Harman Trident SF160 Installation instructions
3-90-70742R11_05/13
Portland
Trident Boilers: SF160, SF260, SF360
SAFETY NOTICE
PLEASE READ THIS ENTIRE MANUAL BEFORE YOU INSTALL AND/OR USE YOUR NEW BOILER. FAILURE TO
FOLLOW INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE, BODILY INJURY, OR EVEN DEATH.
IF THIS HARMAN BOILER IS NOT PROPERLY INSTALLED, A HOUSE FIRE MAY RESULT. FOR YOUR SAFETY,
FOLLOW INSTALLATION DIRECTIONS.
CONTACT LOCAL BUILDING OR FIRE OFFICIALS ABOUT RESTRICTIONS AND INSTALLATION INSPECTION
REQUIREMENTS IN YOUR AREA.
CONTACT YOUR LOCAL AUTHORITY (SUCH AS MUNICIPAL BUILDING DEPARTMENT, FIRE DEPARTMENT, FIRE
PREVENTION BUREAU, ETC.) TO DETERMINE THE NEED FOR A PERMIT.
SAVE THESE INSTRUCTIONS
Installation & Operating Manual
“Ce manuel est disponible en Français sur demande”
33-90-70742R11_05/13
Congratulations,
Introduction
Maintenance 13
= Contains updated information
Harman® Central Heating Appliances are built and tested to be complete Home Heating solutions. As with any
Central Heat system, a backup heating system may be required in the event of power outages or during appliance
service or maintenance.
3-90-70742R11_05/13
Packing List
Items needed for assembly and installation.
Please notify your Harman® Dealer if you are missing any items.
Included with Boiler:
Items In Boiler Kit # 1-00-01020: (Sold Separately)
Notice:
The Aquastat controls supplied with the Boiler Kit
are designed only to maintain water temperature
within the boiler. The actual heating system is
controlled separately by your thermostat(s) opening
zone valves or energizing circulation pump(s).
Do not attach a thermostat to the supplied controls.
Appliance Certication.
Model:
Test Lab:
Report #:
Type:
Standard(s):
3-90-70742R11_05/13
Installation
Getting Started
NOTE: The sheet metal top holds the sides in place,
thus, no bolts or screws are needed.
CAUTION: BOILER SHOULD NOT BE INSTALLED
CLOSER THAN 36 INCHES (915 MM) TO ANY
COMBUSTIBLE MATERIAL
Locating Boiler
Assembly
NOTE: Use Teon tape to seal the threads on all ttings.
Any unused ttings must be plugged
FIG. 2
Well
FIG. 1
63-90-70742R11_05/13
Aquastat Installation
(See optional items, page 7)
Installation
Wiring Diagram
FIG. 3
3-90-70742R11_05/13
Wiring and Electrical
Setting The Aquastat
Optional Items
Venting
Installation
FIG. 4
3-90-70742R11_05/13
Installation
Plumbing
FIG. 5
Air Valve
Notice:
The Aquastat controls supplied with the Trident Boiler
are designed only to maintain water temperature
within the boiler. The actual heating system is
controlled separately by your thermostat(s) opening
zone valves or energizing circulation pump(s).
Do not attach a thermostat to the supplied controls.
NOTE
U.S. Canada,
DO NOT CONNECT THIS UNIT TO A CHIMNEY FLUE
THAT IS SERVING ANOTHER APPLIANCE.
FIG. 6
3-90-70742R11_05/13
Installation
FIG. 7
10 3-90-70742R11_05/13
Operation
Automatic Draft Control
FIG. 9
Starting a Wood Fire
Never start a re without water in the system. An
explosion will occur.
Do not leave the boiler unattended with any door open.
FIG. 8
11 3-90-70742R11_05/13
Operation
Starting a Coal Fire
Never start a re without water in the system. An
explosion will occur.
Loading
Shaking the Grates
Ashes and Ash Removal
DO NOT LEAVE THE BOILER UNATTENDED WITH
ANY DOOR OPEN.
12 3-90-70742R11_05/13
Safety Tips
Burning coal produces Carbon Monoxide. If the ue
exit is blocked, the Carbon Monoxide can be forced
out of the boiler, into the room, with possible FATAL
consequences.
Never install a Harman® Trident Boiler into a chimney
with a history of down-drafts.
Keep Children Away - May Cause Serious Burns.
CAUTION: All surfaces of the boiler are hot. Do not
touch. Keep children away. Serious burns will result if
touched. This is a heat producing appliance.
DANGER: Fire Hazard, Do not use chemicals or
ammable liquids to start or “freshen-up” a re. Severe
burns or a house re may result. Do not burn Garbage,
Gasoline, Thinners, Oil, Kerosene Etc. An explosion, a
house re or serious personal injury could result. Keep
all such liquids well away from this boiler.
Chimney Problems
Not Enough Draft -
Down Drafts -
Creosote and condensation -
Excessive Draft -
Operation
13 3-90-70742R11_05/13
Maintenance
Specications SF-160 SF-260 SF-360
130,000
32
Yes Yes Yes
23
6 inch
6
Yes Yes Yes
Yes Yes Yes
Ye s Ye s Yes
Yes Ye s Yes
Yes Yes Yes
30,000 30,000 30,000
3-90-70742R11_05/13
Warranty
Hearth & Home Technologies
LIMITED LIFETIME WARRANTY
WARRANTY COVERAGE:
WARRANTY PERIOD:
Wood
listed
10
1 Year
3-90-70742R11_05/13
Warranty
WARRANTY CONDITIONS:
This warranty is void if:
LIMITATIONS OF LIABILITY:
WARRANTY EXCLUSIONS:
16 3-90-70742R11_05/13
Notes
3-90-70742R11_05/13
Date Of Service Performed By Description Of Service
Service & Maintenance Log
Service Parts SF160
Beginning Manufacturing Date: N/A
Ending Manufacturing Date: Active
Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
1
2
3
4
6
7
8
10
11
5
9
Wood, Coal red Boiler
1-70-03233
Service Parts SF160
Beginning Manufacturing Date: N/A
Ending Manufacturing Date: Active
Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Beginning Manufacturing Date: N/A
Ending Manufacturing Date: Active
Service Parts SF260
Wood, Coal red Boiler Appliance
1-70-03236
Stocked
at Depot
ITEM DESCRIPTION COMMENTS PART NUMBER
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
Y
1
8
2
3
4
6
7
10
9
5
This manual suits for next models
2
Table of contents
Other Harman Boiler manuals
Popular Boiler manuals by other brands
Fröling
Fröling PE1c Pellet 16-22 operating instructions
Kober
Kober Motan BP120L V1 installation manual
Ideal Boilers
Ideal Boilers Mexico Super RS440 Installation and servicing guide
Immergas
Immergas HERCULES SOLAR 26 2 ErP Instruction and recommendation booklet
Immergas
Immergas NIKE Star Instruction booklet and warning
Viessmann
Viessmann VITOCROSSAL 300 Service instructions
Alpha
Alpha E-Tec 15R Installation and servicing instruction
Atmos
Atmos InterSystem HE26 User operating instructions
Kozlusan
Kozlusan Propel 40 owner's manual
Immergas
Immergas ARES 440 TEC ERP Instructions and warnings
Wolf
Wolf CGB-2-14 Replacement instructions
Meco
Meco Pellematic PES 12-20 installation manual
Slant/Fin
Slant/Fin VICTORY II VHS Series Installation and operating instructions
Truma
Truma Ultrastore Rapid GE Operating instructions & installation instructions
NTI
NTI TRX150 manual
Alpha
Alpha Alpha CD24 Installation and servicing instructions
Weil-McLain
Weil-McLain Ultra Electric Water Heater installation guide
Saunier Duval
Saunier Duval EnviroPlus F24e Instructions for use installation and servicing