HEAT GLO RED60 User manual

eat  l • D • 1- e.  • /1 1
M odels:
RED60
• DO NOT stre r use gasline r ther am-
mable ars and liuids in the icinit f this
r an ther aliance.
• Whattodoifyousmellgas
- DO NOT tr t light an aliance.
- DO NOT tuch an electrical switch. DO
NOT use an hne in ur building.
- Immediatel call ur gas sulier frm a
neighbrs hne. llw the gas suliers
instructins.
- If u cannt reach ur gas sulier call
the re deartment.
• Installatin and serice must be erfrmed
b a ualied installer serice agenc r the
gas sulier.
WARNING:Iftheinformationinthese
instructionsisnotfollowedexactly,are
orexplosionmayresultcausingproperty
damage,personalinjury,ordeath.
Owner’sManual
InstallationandOperation
DONOTDISCARDTHISMANUAL
NOTICE
his aliance ma be installed as an  installatin in
manufactured hme  nl r mbile hme and must be
installed in accrdance with the manufacturers instructins
and the manufactured hme cnstructin and safet standard
T itle 2 4 C FR , Part 3 2 8 0 or Standard f or Installation in M ob ile
H om es, C A N / C SA Z 2 4 0 M H , in C anada.
T his appliance is only f or use with the type(s) of g as indicated
on the rating plate.
Installatin and serice f this aliance shuld be
erfrmed b ualied ersnnel. earth  me
echnlgies suggests I certied r factr trained
rfessinals r technicians suerised b an I
certied rfessinal.
• eae this manual with
art resnsible fr use
and eratin.
DO NOT
DISCARD
WARNING
• Imrtant erating
and maintenance
instructins included.
• ead understand and fllw
these instructins fr safe
installatin and eratin.
In the mmnwealth f assachusetts installatin must be
erfrmed b a licensed lumber r gas tter.
ee able f ntents fr lcatin f additinal mmnwealth
f assachusetts reuirements.
This appliance has been supplied with an integral barrier
to prevent direct contact with the xed glass panel. DO
NOT operate the appliance with the barrier removed.
ntact ur dealer r earth  me echnlgies if the
barrier is nt resent r hel is needed t rerl install ne.
HOTSURFACES!
lass and ther surfaces are ht during
eratin D cl dwn.
Hotglasswillcauseburns.
• DO NOT tuch glass until it is cled
• V allw children t tuch glass
• ee children awa
•  PVI children in same rm as
relace.
• lert children and adults t haards f high temeratures.
Hightemperaturesmayigniteclothingorotherammable
materials.
• ee clthing furniture draeries and ther ammable
materials awa.

eat  l • D • 1- e.  • /1
ListingLabelInformation/Location
del ame ___________________________________________ Date urchased/installed__________________
erial umber__________________________________________ catin n relace _____________________
Dealershi urchased frm _______________________________ Dealer Phne __________________________
tes _______________________________________________________________________________________
_____________________________________________________________________________________________
A. Congratulations
ngratulatins n selecting a eat  l gas relace an
elegant and clean alternatie t wd burning relaces.
he eat  l gas relace u hae selected is designed
t ride the utmst in safet reliabilit and efcienc.
s the wner f a new relace ull want t read and
carefull fllw all f the instructins cntained in this
wners manual. Pa secial attentin t all cautins and
warnings.
This wners manual shuld be retained fr future
reference. e suggest that u kee it with ur ther
imrtant dcuments and rduct manuals.
he infrmatin cntained in this wners manual unless
nted therwise alies t all mdels and gas cntrl
sstems.
ur new eat  l gas relace will gie u ears f
durable use and truble-free enment. elcme t the
eat  l famil f relace rducts
W e recom m end that you record the f ollowing pertinent
information about your replace.
as and lectric
Infrmatin
erial umber
e f as
he mdel infrmatin regarding ur secic relace can be fund n
the rating late usuall lcated in the cntrl area f the relace.
HomeownerReferenceInformation
del umber
N otN ot forfor useuse withwith solidsolid fuel.fuel.
((N eN e doitdoit paspas entreentre utiliseutilise av ecav ec unun com b ustib lecom b ustib le solide).solide).
ThisThis applianceappliance mustmust bebe installedinstalled inin accordanceaccordance withwith locallocal codes,codes, ifif any;any; ifif not,not, followfollow A N SIA N SI Z 223.1Z223.1
ininthetheUSAUSA ororC A N / C G AC A N / C G A B 149B 149installationinstallationcodes.codes.(Installer(Installerl’ appareill’ appareilselonselonleslescodescodesououreg lem entsreg lem ents
locauxlocaux ou,ou, enen l’ ab sencel’ ab sence dede telstels reg lem ents,reg lem ents, selonselon lesles codescodes d’ installationd’ installation C A N / C G A - B 1 4 9 .)C A N / C G A - B 1 4 9 .)
TypeType ofof G asG as (Sorte(Sorte DeDe G az )G az )::
NNAATURALTURAL G ASG AS
M ADEM ADE ININ USAUSA
M inimumM inimum P ermissibleP ermissible G asG as SupplySupply forfor P urposesP urposes ofof I nputI nput A dj ustment.A dj ustment.
A pprovedA pprovedM inimumM inimum(De(DeG az )G az )A cceptableA cceptable0.00.0 inin w.c.w.c. (Po.(Po.C ol.C ol.d’ eau)d’ eau)
M ax imumM ax imum P ressureP ressure(Pression)(Pression) 0.00.0 inin w.c.w.c. (Po.(Po.C ol.C ol.d’ eau)d’ eau)
M ax imumM ax imumM anifoldM anifoldP ressureP ressure(Pression)(Pression) 0.00.0 inin w.c.w.c. (Po.(Po.C ol.C ol.d’ eau)d’ eau)
M inimumM inimumM anifoldM anifold P ressureP ressure(Pression)(Pression) 0.00.0 inin w.c.w.c. (Po.(Po.C ol.C ol.d’ eau)d’ eau)
M odel:M odel:
( M odele) :( M odele) :
SerialSerial
( S erie) :( S erie) :
ANSIANSI Z21X X-XXXXZ21X X-XXXX ·· CSACSA 2.X X -M X X2.X X -M X X ·· UL307BUL307B
XXXXXXXXXXXXXXXX
I NI N C A N A D AC A N A D A
A L TI TUD E :A L TI TUD E :0-00000-0000 F T.F T.0000-0000F T.0000-0000F T.
M A X .M A X .I N P UTI N P UTB TUH :B TUH : 00,00000,000 00,00000,000
M I N .M I N . I N P UTI N P UT B TUH :B TUH : 00,00000,000 00,00000,000
O R I F I C EO R I F I C E SI Z E :SI Z E : #XXXXX#XXXXX #XXXXX#XXXXX XXXXXXXXXXXXXXXX
TotalTotal E lectricalE lectrical R eq uirements:R eq uirements: 000V ac,000V ac, 00H z .,00H z ., lessless thanthan 0000 A mperesA mperes
Heat & G lo, a b rand of Hearth & Home Technologies, Inc.
7571 215th Street West, Lakeville, M N 55044
ead this manual befre installing r erating this aliance.
Please retain this wners manual fr future reference.

eat  l • D • 1- e.  • /1 3
SafetyAlertKey:
• DANGER! Indicates a haza rdous situation which, if not avo ided will result in death or serious inj ury.
• WARNING! Indicates a haza rdous situation which, if not avo ided could result in death or serious inj ury.
• CAUTION! Indicates a haza rdous situation which, if not avo ided, could result in m inor or m oderate inj ury.
• NOTICE: U sed to address practices not related to personal inj ury.
TableofContents
. ngratulatins .................................
. imited ifetime arrant ..........................
1ListingandCodeApprovals
. liance erticatin ............................7
. lass ecicatins ..............................7
.  ecicatins ...............................7
D. igh ltitude Installatins .......................... 7
. n-mbustible aterials ecicatin. . . . . . . . . . . . . . 7
. mbustible aterials ecicatin ................. 7
. lectrical des .................................7
. euirements fr the mmnwealth f assachusetts . . 8
User Guide
2OperatingInstructions
. as irelace afet .............................
. ur irelace ..................................
. lear ace ....................................
D. Decratie Drs and rnts ......................1
. ixed lass ssembl ...........................1
. ntrl dule eratin ........................1
. efre ighting irelace .........................1
. ighting Instructins IPI ......................... 11
I. fter irelace is it .............................1
. reuentl sked uestins ......................1
3MaintenanceandService
. aintenance asks-mewner ...................1
. aintenance asks-ualied erice echnician ...... 14
Installer Guide
4GettingStarted
. ical liance stem. . . . . . . . . . . . . . . . . . . . . . . . . 1
. Design and Installatin nsideratins ..............1
. ls and ulies eeded .......................1
D. Insect liance and mnents ................. 1
5FramingandClearances
. electing liance catin ...................... 17
. nstructing the liance hase ..................1
. learances ....................................1
D. antel and all Prectins ....................... 1
6TerminationLocations
. Vent erminatin inimum learances ..............
7VentInformationandDiagrams 
. red Pie .................................
. Vent able e .................................
. se f lbws .................................
D. easuring tandards ............................
. Vent Infrmatin ................................
. Installatin Instructins and Venting Infrmatin
- PVI-DVP ....................................
. erating Instructins ...........................
. aintenance ..................................
I. Vent Diagrams .................................
. Installatin Instructins and Venting Infrmatin
- PV- fr D del .......................38
8VentClearancesandFraming 
. Pie learances t mbustibles ..................4
. all Penetratin raming .........................4
. Install the eiling irest ........................4
D. Install ttic Insulatin hield ....................... 
9AppliancePreparation 
.  Vent ......................................1
. ecuring and eeling the liance ................
. ctie nectin echnlg ..................... 
10InstallingVentPipe(DVPPipe) 
. ssemble Vent ectins. . . . . . . . . . . . . . . . . . . . . . . . . . 4
. ssemble li ectins ..........................
. ecure he Vent ectins ........................
D. Disassemble Vent ectins ....................... 
. Install Decratie eiling mnents ..............
. Install etal f lashing ........................7
. ssemble and Install trm llar ..................7
. Install Vertical erminatin a ....................
I. eat hield euirements fr rintal erminatin ...
. Install rintal erminatin a ..................
11GasInformation 
. uel nersin ................................
. as Pressure ..................................
. as nnectin ................................
D. igh ltitude Installatins ......................... 
12ElectricalInformation 
. iring euirements ............................1
. Intelliire Plus Ignitin stem iring .............. 1
. tinal nguratin euirements ...............1
D. tinal D ighting ircuit ......................


eat  l • D • 1- e.  • /14
  ntains udated infrmatin.
. lectrical erice and eair ......................4
. unctin x Installatin. . . . . . . . . . . . . . . . . . . . . . . . . . 4
. ctie nectin lwer elacement .............4
13Finishing
. latter uard .................................
. raming and inishing Instructins .................
. antel and all Prectins ....................... 
D. acing aterial .................................
. esh rnts ...................................7
14ApplianceSetup
. eme ixed lass ssembl ....................71
. eme the hiing aterials ....................71
. lean the liance .............................71
D. ccessries ...................................71
. ck edia Instructins ..........................71
. Prcelain Instructins ............................73
. ranite Instructins .............................78
. heet etal efractr Instructins .................4
I. ixed lass ssembl ...........................
. Install the esh ................................
. ir hutter etting ..............................
15Troubleshooting
. Intelliire Plus Ignitin stem ...................87
. PVI-DVP rubleshting ........................ 88
16ReferenceMaterials
. liance Dimensin Diagram .....................
. Vent mnents Diagrams ...................... 
. erice Parts ..................................4
D. ntact Infrmatin .............................

eat  l • D • 1- e.  • /1 
B. LimitedLifetimeWarranty
4021-645C 12-29-10 P age 1 of 2
Hearth & Home Technologies Inc.
LIM ITED LIFETIM E WARRANTY
H earth & H ome Technologies I nc., on behalf of its hearth brands (” H H T” ), ex tends the following warranty for
H H T gas, wood, pellet, coal and electric hearth appliances that are purchased from an H H T authoriz ed dealer.
WARRANTY COVERAG E:
H H T warrants to the original owner of the H H T appliance at the site of installation, and to any transferee tak ing ownership
of the appliance at the site of installation within two years following the date of original purchase, that the H H T appliance
will be free from defects in materials and work manship at the time of manufacture. A fter installation, if covered compo-
nents manufactured by H H T are found to be defective in materials or work manship during the applicable warranty period,
H H T will, at its option, repair or replace the covered components. H H T, at its own discretion, may fully discharge all of its
obligations under such warranties by replacing the product itself or refunding the verified purchase price of the product
itself. The max imum amount recoverable under this warranty is limited to the purchase price of the product. This warranty
is subj ect to conditions, ex clusions and limitations as described below.
WARRANTY PERIOD:
W arranty coverage begins on the date of original purchase. I n the case of new home construction, warranty coverage
begins on the date of first occupancy of the dwelling or six months after the sale of the product by an independent,
authoriz ed H H T dealer/ distributor, whichever occurs earlier. The warranty shall commence no later than 24 months
following the date of product shipment from H H T, regardless of the installation or occupancy date. The warranty period for
parts and labor for covered components is produced in the following table.
The term “ L imited L ifetime” in the table below is defined as: 20 years from the beginning date of warranty coverage for
gas appliances, and 10 years from the beginning date of warranty coverage for wood, pellet, and coal appliances. These
time periods reflect the minimum ex pected useful lives of the designated components under normal operating conditions.
See conditions, ex clusions, and limitations on nex t page.
P arts L abor G as W ood P ellet EPA
W ood
C oal E lectric V enting
XXXXXXX
A ll parts and material ex cept as
covered by C onditions,
E x clusions, and L imitations
listed
XXX I gniters, electronic components,
and glass
X X X X X F actory-installed blowers
X M olded refractory panels
X F irepots and burnpots
5 years 1 year X X C astings and baffles
7 years 3 years X X X M anifold tubes,
H H T chimney and termination
10
years
1 year X B urners, logs and refractory
L imited
L ifetime
3 years X X X X X F irebox and heat ex changer
XXXXXXX A ll replacement parts
beyond warranty period
W arranty P eriod H H T M anufactured A ppliances and V enting
1 Y ear
C omponents C overed
3 years
2 years
90 D ays

eat  l • D • 1- e.  • /1
4021-645C 12-29-10 P age 2 of 2
WARRANTY CONDITIONS:
• his warrant nl cers  aliances that are urchased thrugh an  authried dealer r distributr.  list f
 authried dealers is aailable n the  branded websites.
• his warrant is nl alid while the  aliance remains at the site f riginal installatin.
• ntact ur installing dealer fr warrant serice. If the installing dealer is unable t ride necessar arts cntact
the nearest  authried dealer r sulier. dditinal serice fees ma al if u are seeking warrant serice
frm a dealer ther than the dealer frm whm u riginall urchased the rduct.
• heck with ur dealer in adance fr an csts t u when arranging a warrant call. rael and shiing charges
fr arts are nt cered b this warrant.
This warranty is void if:
• he aliance has been er-fired r erated in atmsheres cntaminated b chlrine flurine r ther damaging
chemicals. er-firing can be identified b but nt limited t wared lates r tubes rust clred cast irn bubbling
cracking and disclratin f steel r enamel finishes.
• he aliance is subected t rlnged erids f damness r cndensatin.
• here is an damage t the aliance r ther cmnents due t water r weather damage which is the result f but
nt limited t imrer chimne r enting installatin.
LIM ITATIONS OF LIABILITY :
• he wners exclusie remed and s sle bligatin under this warrant under an ther warrant exress r
imlied r in cntract trt r therwise shall be limited t relacement reair r refund as secified abe. In n
eent will  be liable fr an incidental r cnseuential damages caused b defects in the aliance. me states
d nt allw exclusins r limitatin f incidental r cnseuential damages s these limitatins ma nt al t u.
his warrant gies u secific rights u ma als hae ther rights which ar frm state t state. P 
  PVIDD      P I    
PIID I.  DI   IPID  I IID  DI  
PD  PIID V.
WARRANTY EX CLUSIONS:
his warrant des nt cer the fllwing
• hanges in surface finishes as a result f nrmal use. s a heating aliance sme changes in clr f interir and
exterir surface finishes ma ccur. his is nt a flaw and is nt cered under warrant.
• Damage t rinted lated r enameled surfaces caused b fingerrints accidents misuse scratches melted items
r ther external surces and residues left n the lated surfaces frm the use f abrasie cleaners r lishes.
• eair r relacement f arts that are subect t nrmal wear and tear during the warrant erid. hese arts
include aint wd ellet and cal gaskets firebricks grates flame guides light bulbs batteries and the disclr-
atin f glass.
• inr exansin cntractin r mement f certain arts causing nise. hese cnditins are nrmal and cm-
laints related t this nise are nt cered b this warrant.
• Damages resulting frm 1 failure t install erate r maintain the aliance in accrdance with the installatin
instructins erating instructins and listing agent identificatin label furnished with the aliance  failure t
install the aliance in accrdance with lcal building cdes  shiing r imrer handling 4 imrer era-
tin abuse misuse cntinued eratin with damaged crrded r failed cmnents accident r imrerl/
incrrectl erfrmed reairs  enirnmental cnditins inadeuate entilatin negatie ressure r drafting
caused b tightl sealed cnstructins insufficient make-u air sul r handling deices such as exhaust fans r
frced air furnaces r ther such causes  use f fuels ther than thse secified in the erating instructins 7
installatin r use f cmnents nt sulied with the aliance r an ther cmnents nt exressl authried
and ared b   mdificatin f the aliance nt exressl authried and ared b  in writing
and/r  interrutins r fluctuatins f electrical wer sul t the aliance.
• n- enting cmnents hearth cmnents r ther accessries used in cnunctin with the aliance.
• n art f a re-existing firelace sstem in which an insert r a decratie gas aliance is installed.
• s bligatin under this warrant des nt extend t the aliances caabilit t heat the desired sace. Infrma-
tin is rided t assist the cnsumer and the dealer in selecting the rer aliance fr the alicatin. nsider-
atin must be gien t aliance lcatin and cnfiguratin enirnmental cnditins insulatin and air tightness f
the structure.
B. LimitedLifetimeWarranty( continued)

eat  l • D • 1- e.  • /1 7
C. BTUSpecications
MODEL: RED60
LABORATORY: UnderwritersLaboratories,Inc.(UL)
TYPE: VentedGasFireplaceHeater
STANDARD:ANSIZ21.88b-2008CSA2.33a-2008
VentedGasFireplaceHeaters
his rduct is listed t I standards fr Vented as
irelace eaters and alicable sectins f as urn-
ing eating liances fr anufactured mes and
ecreatinal Vehicles and as ired liances fr
se at igh ltitudes.
M odels
(U .S. or C anada) Maximum
InputBTU/h
Minimum
Input
BTU/h
Orice
Size
(DMS)
RED60
(NG)
U S
(0 - 2 0 0 0 FT ) 44 1 
C A N A DA
(2 0 0 0 - 4 5 0 0 FT )   
RED60
(LP)
U S
(0 - 2 0 0 0 FT ) 4  47
C A N A DA
(2 0 0 0 - 4 5 0 0 FT )  1 4
E. Non-CombustibleMaterialsSpecication
aterial which will nt ignite and burn. uch materials are
thse cnsisting entirel f steel irn brick tile cncrete
slate glass r lasters r an cmbinatin theref.
aterials that are rerted as assing ASTM E 136,
StandardTestMethodforBehaviorofMaterialsina
Vertical Tube Furnace at 750 ºC and UL763 shall be
cnsidered nn-cmbustible materials.
F. CombustibleMaterialsSpecication
aterials made f r surfaced with wd cmressed a-
er lant bers lastics r ther material that can ignite
and burn whether ame rfed r nt r lastered r
unlastered shall be cnsidered cmbustible materials.
G. ElectricalCodes
NOTICE: T his appliance m ust b e electrically wired and
g roundedinaccordance with localcodes or, intheab sence
of local codes, with NationalElectricCodeANSI/NFPA
70-latest edition or the Canadian Electric Code CSA
C22.1.
•  11-1 V circuit fr this rduct must be rtected
with grund-fault circuit-interruter rtectin in cmliance
with the alicable electrical cdes when it is installed in
lcatins such as in bathrms r near sinks.
NOTINTENDEDFORUSEASAPRIMARYHEATSOURCE.
his aliance is tested and ared as either sulemen-
tal rm heat r as a decratie aliance. It shuld nt be
factred as rimar heat in residential heating calculatins.
D. HighAltitudeInstallations
NOTICE: If the heating v alue of theg ashas b eenreduced,
these rules do not apply. C heck with your local g as utility
or authorities havi ng j urisdiction.
hen installing abe  feet eleatin
• In the  educe inut rate 4 fr each 1 feet
abe  feet.
• In D educe inut rate 1 fr eleatins
between  feet and 4 feet. be 4 feet
cnsult lcal gas utilit.
heck with ur lcal gas utilit t determine rer
rice sie.
NOTICE: T his installation m ust conf orm with local codes.
In the ab sence of local codes you m ust com ply with the
N ational Fuel G as C ode, A N SI Z 2 2 3 .1 - latest edition in
the U .S.A . and the C A N / C G A B 1 4 9 Installation C odes in
C anada.
1 ListingandCodeApprovals 
A. ApplianceCertication
B. GlassSpecications
earth  me echnlgies aliances manufactured
with temered glass ma be installed in haardus lca-
tins such as bathtub enclsures as dened b the n-
sumer Prduct afet mmissin P. he temered
glass has been tested and certied t the reuirements
f ANSIZ97.1 and CPSC16CFR1202afet laing
erticatin uncil SGCC#1595 and 1597. rchitectur-
al esting Inc. erts 02-31919.01 and 02-31917.01.
his statement is in cmliance with CPSC16CFRSec-
tion 1201.5 erticatin and labeling reuirements
which refers t 15 .. de (USC)2063stating uch
certicate shall accman the rduct r shall therwise
be furnished t an distributr r retailer t whm the
rduct is deliered.
me lcal building cdes reuire the use f temered
glass with ermanent marking in such lcatins. lass
meeting this reuirement is aailable frm the factr.
Please cntact ur dealer r distributr t rder.

eat  l • D • 1- e.  • /18
H. Requirementsfor theCommonwealth of
Massachusetts
r all side wall hrintall ented gas fueled euiment
installed in eer dwelling building r structure used in
whle r in art fr residential urses including thse
wned r erated b the mmnwealth and where the
side wall exhaust ent terminatin is less than seen 7
feet abe nished grade in the area f the enting in-
cluding but nt limited t decks and rches the fllwing
reuirements shall be satised
InstallationofCarbonMonoxideDetectors
t the time f installatin f the side wall hrintal ented
gas fueled euiment the installing lumber r gas tter
shall bsere that a hard wired carbn mnxide detectr
with an alarm and batter back-u is installed n the r
leel where the gas euiment is t be installed. In addi-
tin the installing lumber r gas tter shall bsere that
a batter erated r hard wired carbn mnxide detec-
tr with an alarm is installed n each additinal leel f
the dwelling building r structure sered b the side wall
hrintal ented gas fueled euiment. It shall be the
resnsibilit f the rert wner t secure the serices
f ualied licensed rfessinals fr the installatin f
hard wired carbn mnxide detectrs.
In the eent that the side wall hrintall ented gas fu-
eled euiment is installed in a crawl sace r an attic
the hard wired carbn mnxide detectr with alarm and
batter back-u ma be installed n the next adacent
r leel.
In the eent that the reuirements f this subdiisin can
nt be met at the time f cmletin f installatin the
wner shall hae a erid f thirt  das t cml
with the abe reuirements rided hweer that dur-
ing said thirt  da erid a batter erated carbn
mnxide detectr with an alarm shall be installed.
ApprovedCarbonMonoxideDetectors
ach carbn mnxide detectr as reuired in accr-
dance with the abe risins shall cml with P
7 and be I/ 4 listed and I certied.
Signage
 metal r lastic identicatin late shall be ermanent-
l munted t the exterir f the building at a minimum
height f eight  feet abe grade directl in line with the
exhaust ent terminal fr the hrintall ented gas fu-
eled heating aliance r euiment. he sign shall read
in rint sie n less than ne-half 1/ in. in sie “GAS
VENTDIRECTLYBELOW.KEEPCLEAROFALLOB-
STRUCTIONS”.
Inspection
he state r lcal gas insectr f the side wall hrin-
tall ented gas fueled euiment shall nt are the
installatin unless un insectin the insectr b-
seres carbn mnxide detectrs and signage installed
in accrdance with the risins f 4  .a1
thrugh 4.
Exemptions
he fllwing euiment is exemt frm 4 
.a1 thrugh 4
• he euiment listed in hater 1 entitled uiment
t euired  e Vented in the mst current editin
f P 4 as adted b the ard and
• Prduct red side wall hrintall ented gas fu-
eled euiment installed in a rm r structure searate
frm the dwelling building r structure used in whle r
in art fr residential urses.
MANUFACTURERREQUIREMENTS
GasEquipmentVentingSystemProvided
hen the manufacturer f Prduct red side wall
hrintall ented gas euiment rides a enting
sstem design r enting sstem cmnents with the
euiment the instructins rided b the manufacturer
fr installatin f the euiment and the enting sstem
shall include
• Detailed instructins fr the installatin f the enting
sstem design r the enting sstem cmnents and
•  cmlete arts list fr the enting sstem design r
enting sstem.
GasEquipmentVentingSystemNOTProvided
hen the manufacturer f a Prduct red side wall
hrintall ented gas fueled euiment des nt r-
ide the arts fr enting the ue gases but identies
secial enting sstems the fllwing reuirements
shall be satised b the manufacturer
• he referenced secial enting sstem instructins
shall be included with the aliance r euiment in-
stallatin instructins and
• he secial enting sstems shall be Prduct -
red b the ard and the instructins fr that ss-
tem shall include a arts list and detailed installatin
instructins.
 c f all installatin instructins fr all Prduct -
red side wall hrintall ented gas fueled eui-
ment all enting instructins all arts lists fr enting
instructins and/r all enting design instructins shall
remain with the aliance r euiment at the cmletin
f the installatin.
SeeGasConnectionsectionforadditionalCommon-
wealthofMassachusettsrequirements.
Note:he fllwing reuirements reference arius
assachusetts and natinal cdes nt cntained in this
dcument.

eat  l • D • 1- e.  • /1 
Figure2.1GeneralOperatingParts/ClearSpace.
B. YourFireplace
WARNING! DO NOT operate replace before read-
ing and understanding operating instructions. Failure
to operate replace according to operating instructions
could cause re or injury.
If u exect that small children r ulnerable adults ma
cme int cntact with this relace the fllwing recau-
tins are recmmended
• Install a hsical barrier such as
-  decratie rescreen.
- dustable safet gate.
A. GasFireplaceSafety
WARNING
This appliance has been supplied with an integral barrier
to prevent direct contact with the xed glass panel. DO
NOT operate the appliance with the barrier removed.
ntact ur dealer r earth  me echnlgies if the
barrier is nt resent r hel is needed t rerl install ne.
HOTSURFACES!
lass and ther surfaces are ht during
eratin D cl dwn.
Hotglasswillcauseburns.
• DO NOT tuch glass until it is cled
• V allw children t tuch glass
• ee children awa
•  PVI children in same rm as
relace.
• lert children and adults t haards f high temeratures.
Hightemperaturesmayigniteclothingorother
ammablematerials.
• ee clthing furniture draeries and ther ammable
materials awa.
• Install a switch lck r a wall/remte cntrl with child
rtectin lckut feature.
• eer leae children alne near a ht relace whether
erating r cling dwn.
• each children t V tuch the relace.
• nsider nt using the relace when children will be
resent.
ntact ur dealer fr mre infrmatin r isit www.
hba.rg/safet-infrmatin.
 reent unintended eratin when nt using ur re-
lace fr an extended erid f time summer mnths
acatins tris etc
• urn ff wall cntrls.
• nlug transfrmer.
2 OperatingInstructions 
User Guide
CLEAR SPACE
SECTION 2.C.
DECORATIVE DOORS
SECTION 2.D.
FIX ED G LASS ASSEM BLY
SECTION 14.H.
CLEAR SPACE
3 FT. IN FRONT
OF FIREPLACE
C. ClearSpace
WARNING! DO NOT place com b ustib le ob jects in f ront
of the replace. High temperatures may start a re. See
Fig ure 2 .1 .
id lacing candles and ther heat-sensitie bects n
mantel r hearth. eat ma damage these bects.
WARNING! Choking Hazard! K eep rock m edia out of
reach of children.

eat  l • D • 1- e.  • /11
E. FixedGlassAssembly
ee ectin 14..
D. DecorativeDoorsandFronts
WARNING! Risk of Fire! Install O N L Y doors or f ronts
approve d b y H earth & H om e T echnolog ies. U napprove d
doors or fronts may cause replace to overheat.
This appliance has been supplied with an integral
barrier to prevent direct contact with the xed glass
panel. DO NOT operate the replace with the barrier
removed.
ntact ur dealer r earth  me echnlgies if
the barrier is nt resent r hel is needed t rerl
install ne.
r mre infrmatin refer t the instructins sulied with
ur decratie dr r frnt.
G. BeforeLightingFireplace
efre erating this relace fr the rst time have a
qualiedservicetechnician
• Verif all shiing materials hae been remed frm
inside and/r underneath the rebx.
• eiew rer lacement f media refractr kits and/r
ther decratie materials.
• heck the wiring.
• heck the air shutter adustment.
• nsure that there are n gas leaks.
• nsure that the glass is sealed and in the rer sitin
and that the integral barrier is in lace.
WARNING! Risk of Fire or Asphyxiation! DO NOT op-
erate replace with xed glass assembly removed.
F. ControlModuleOperation
1. he cntrl mdule has an // selectr
switch that must be set. ee igure ..
 Psitin liance will ignre all wer inuts and
will nt resnd t an cmmands frm a wall switch r
remte. he unit shuld be in the  sitin during
installatin serice batter installatin fuel cnersin
and in the eent that the cntrl ges int -
mde as a result f an errr cde.
 Psitin liance will ignite and run cntinuusl
in the I ame setting with n adustment in ame
utut. his mde f eratin is used in this
installatin.
 Psitin t used with this aliance.
. he cntrl mdule has a safet feature that autmaticall
shuts dwn the relace after  hurs f cntinuus
eratin.
Figure2.2ControlModule
NG /LP SETTING
STATUS INDICATOR LED
SELECTOR
SWITCH
FLAM E HI/LO SWITCH
. ModuleReset
his mdule ma lck-ut under certain cnditins.
hen this ccurs the aliance will nt ignite r
resnd t cmmands. he mdule will g int lck-ut
mde b emitting three audible bees then cntinuusl
dislaing a D/ errr cde at its status
indicatr D.
• cate the mdule selectr switch. ee igure ..
• et the mdule selectr switch t the  sitin.
• ait e  minutes t allw ssible accumulated gas
t clear.
• et the mdule selectr switch t  sitin.
• tart the aliance.
WARNING! Risk of Explosion! DO NOT reset the m od-
ule more than one time within a ve minute time period.
Gas may accumulate in rebox. Call a qualied service
technician.
NineHourSafetyShutdownFeature
his aliance will autmaticall shut dwn after nine
hurs f cntinuus eratin.

eat  l • D • 1- e.  • /1 11
H. LightingInstructions(IPI)
1. his aliance is euied with an ignitin
deice which autmaticall lights the burner.
DO NOT tr t light the burner b hand.
2. ait e  minutes t clear ut an gas.
hen smell fr gas including near the r. If
u smell gas P llw  in the afet
Infrmatin lcated n the left side f this la-
bel. If u d nt smell gas g t next ste.
3.  light the burner
uied with wall switch urn / switch
t .
uied with remte r wall cntrl Press
 r  buttn.
uied with thermstat et temerature t
desired setting.
4. If the aliance des nt light after three tries
call ur serice technician r gas sulier.
LIGHTING
INSTRUCTIONS(IPI)
TOTURNOFF
GASTOAPPLIANCE
1. uied with wall switch urn / switch
t .
uied with remte r wall cntrl Press
 buttn.
uied with thermstat et temerature t
lwest setting.
2. erice technician shuld turn ff electric
wer t the cntrl when erfrming serice.
FORYOURSAFETY
READBEFORELIGHTING
WARNING:If u d nt fllw these instructins exactl a re r exlsin
ma result causing rert damage ersnal inur r lss f life.
CAUTION:
NOTFORUSE
WITHSOLIDFUEL
WARNING:
-1
GAS
VALVE
r additinal infrmatin n erating ur
earth  me echnlgies relace lease refer t www.relaces.cm.
A. his aliance is euied with an
intermittent ilt ignitin IPI deice
which autmaticall lights the burn-
er. DO NOT tr t light the burner b
hand.
B. BEFORELIGHTING, smell all arund
the aliance area fr gas. e sure t
smell next t the r because sme
gas is heaier than air and will settle
n the r.
WHATTODOIFYOUSMELLGAS
• DO NOT tr t light an aliance.
• DO NOT tuch an electric switch d
nt use an hne in ur building.
DONOTCONNECTLINEVOLT-
AGE(110/120VACOR220/240
VAC)TOTHECONTROLVALVE.
Imrer installatin adustment al-
teratin serice r maintenance can
cause inur r rert damage. e-
fer t the wners infrmatin manual
rided with this aliance.
his aliance needs fresh air fr
safe eratin and must be installed
s there are risins fr adeuate
cmbustin and entilatin air.
If nt installed erated and main-
tained in accrdance with the manufac-
turers instructins this rduct culd
exse u t substances in fuel r
fuel cmbustin which are knwn t the
tate f alifrnia t cause cancer birth
defects r ther rerductie harm.
ee burner and cntrl cmartment
clean. ee installatin and erating
instructins accmaning aliance.
t while in eratin. DO NOT tuch.
ee children clthing furniture gas-
line and ther liuids haing ammable
ars awa.
DO NOT erate the aliance with
xed glass assembl remed cracked
r brken. elacement f the xed
glass assembl shuld be dne b a
licensed r ualied serice ersn.
• Immediatel call ur gas sulier
frm a neighbrs hne. llw the
gas suliers instructins.
• If u cannt reach ur gas su-
lier call the re deartment.
C.DONOT use this aliance if an
art has been under water. Imme-
diatel call a ualied serice tech-
nician t insect the aliance and
t relace an art f the cntrl
sstem and an gas cntrl which
has been under water.
r use with natural gas and rane.
 cnersin kit as sulied b the
manufacturer shall be used t cnert
this aliance t the alternate fuel.
Also Certied for Installation in a
BedroomoraBedsittingRoom.
r assistance r additinal infrma-
tin cnsult a ualied installer ser-
ice agenc r the gas sulier.
Finalinspectionby

eat  l • D • 1- e.  • /11
InitialBreak-inProcedure
• he firelace shuld be run three t fur hurs
cntinuusl n high.
• urn the relace ff and allw it t cmletel cl.
• eme xed glass assembl. ee ectin 14..
• lean xed glass assembl. ee ectin .
• elace the xed glass assembl and run cntinuusl
n high an additinal 1 hurs.
his cures the materials used t manufacture the re-
lace.
NOTICE! Open windows for air circulation during re-
place break-in.
• Some people may be sensitive to smoke and odors.
• Smoke detectors may activate.
I. AfterFireplaceisLit
J. FrequentlyAskedQuestions
ISSUE SOLUTIONS
ndensatin n the glass his is a result f gas cmbustin and temerature ariatins. s the relace warms this cnden-
satin will disaear.
lue ames his is a result f nrmal eratin and the ames will begin t ellw as the relace is allwed t
burn fr  t 4 minutes.
dr frm relace
hen rst erated this relace ma release an dr fr the rst seeral hurs. his is caused
b the curing f materials frm manufacturing. dr ma als be released frm nishing materials
and adhesies used near the relace. hese circumstances ma reuire additinal curing related
t the installatin enirnment.
ilm n the glass his is a nrmal result f the curing rcess f the aint. lass shuld be cleaned within  t 4
hurs f initial burning.  nn-abrasie cleaner such as gas aliance glass cleaner ma be nec-
essar. ee ur dealer.
etallic nise
ise is caused b metal exanding and cntracting as it heats u and cls dwn similar t the
sund rduced b a furnace r heating duct. his nise des nt affect the eratin r lngeit
f the relace.
ck nise
here ma be sme cracking nise cming frm the relace during the rst few heating and
cling ccles. his nise is assciated with settling rck and sme minr cracking f larger
ieces f rck. his will lessen er time as the glass rck is cnditined t the heating and cl-
ing temerature changes.
cks falling thrugh basean It is exected that a few small ieces f rck ma fall thrugh the basean and cme t rest n the
relace bttm. his has n affect n relace erfrmance.
all abe aliance feels ht t
the tuch.
 actin necessar. his aliance shis with a nn-cmbustible material attached. ecica-
tins f the attached nn-cmbustible material are listed in ectin 1..

eat  l • D • 1- e.  • /1 1
GlassCleaning
Frequency: easnall
By:mewner
Tools Needed Prtectie gles glass cleaner dr
clth and a stable wrk surface.
CAUTION! Handle xed glass assembly with care.
G lass is b reaka b le.
• Avoid striking, scratching or slamming glass
• Avoid abrasive cleaners
• DO NOT clean g lass while it is hot
•Preare a wrk area large enugh t accmmdate xed
glass assembl and dr frame b lacing a dr clth
n a at stable surface.
Note ixed glass assembl and gasketing ma hae res-
idue that can stain careting r r surfaces.
• eme dr r decratie frnt frm relace and set
aside n wrk surface.
• ee ectin 14. fr instructins t reme xed glass
assembl.
• lean glass with a nn-abrasie cmmerciall aailable
cleaner.
- ight desits se a sft clth with sa and water
-ea desits se cmmercial firelace glass
cleaner cnsult with ur dealer
• efer t ectin 14. fr glass remal and relacement
instructins.
• einstall dr r decratie frnt.
3 MaintenanceandService 
A. MaintenanceTasks-Homeowner
he fllwing tasks ma be erfrmed annuall b the
hmewner. If u are uncmfrtable erfrming an f
the listed tasks lease call ur dealer fr a serice a-
intment.
re freuent cleaning ma be reuired due t lint frm
careting r ther factrs. ntrl cmartment burner
and circulating air assagewa f the relace must be
ket clean.
CAUTION! Risk of Burns! The replace should be turned
of f and cooled b ef ore servi cing .
hen rerl maintained ur relace will gie u
man ears f truble-free serice. e recmmend an-
nual serice b a ualied serice technician.
Doors,Surrounds,Fronts
Frequency:nnuall
By:mewner
Tools needed Prtectie gles stable wrk surface
• ssess cnditin f screen and relace as necessar.
• Insect fr scratches dents r ther damage and reair
as necessar.
•heck that luers are nt blcked.
•Vacuum and dust surfaces.
n safet screen r guard remed fr sericing must be
relaced rir t erating the relace.
Installatin and reair shuld be dne b a ualied serice
technician nl. he relace shuld be insected befre
use and at least annuall b a rfessinal serice ersn.

eat  l • D • 1- e.  • /114
Venting
Frequency:easnall
By:mewner
Tools needed: Prtectie gles and safet glasses.
• Insect enting and terminatin ca fr blckage r
bstructin such lants bird nests leaes snw debris
etc.
• Verif terminatin ca clearance t subseuent cnstruc-
tin building additins decks fences r sheds. ee
ectin .
• Insect fr crrsin r searatin.
• Verif weather striing sealing and ashing remains
intact.
• Insect draft shield t erif it is nt damaged r missing.
B. MaintenanceTasks-QualiedService
Technician
The fllwing tasks must be erfrmed b a ualied ser-
ice technician.
GasketSealandGlassAssemblyInspection
Frequency:nnuall
By:ualied erice echnician
Tools needed: Prtectie gles dr clth and a stable
wrk surface.
• Insect gasket seal and its cnditin.
• Insect xed glass assembl fr scratches and nicks that
can lead t breakage when exsed t heat.
• nrm there is n damage t glass r glass frame.
elace as necessar.
• Verif that xed glass assembl is rerl retained and
attachment cmnents are intact and nt damaged.
elace as necessar.
Firebox
Frequency:nnuall
By:ualied erice echnician
Tools needed: Prtectie gles sandaer steel wl
clths mineral sirits rimer and tuch-u aint.
• Insect fr aint cnditin wared surfaces crrsin
r erfratin. and and reaint as necessar.
• elace relace if rebx has been erfrated.
ControlCompartmentandFireboxTop
Frequency:nnuall
By:ualied erice echnician
Tools needed: Prtectie gles acuum cleaner dust
clths
• Vacuum and wie ut dust cbwebs debris r et hair.
se cautin when cleaning these areas. crew tis that
hae enetrated the sheet metal are shar and shuld
be aided.
• eme all freign bects.
• Verif unbstructed air circulatin.
BurnerIgnitionandOperation
Frequency:nnuall
By:ualied erice echnician
Tools needed: Prtectie gles acuum cleaner whisk
brm ashlight ltmeter indexed drill bit set and a
manmeter.
• Verif burner is rerl secured and aligned with ilt
r igniter.
• lean ff burner t insect fr lugged rts crrsin
r deteriratin. elace burner if necessar.
• heck fr smth lighting and ignitin carrer t all
rts. Verif that there is n ignitin dela.
• Insect fr lifting r ther ame rblems.
• Verif air shutter setting is crrect. ee ectin 14. fr
reuired air shutter setting. Verif air shutter is clear f
dust and debris.
• Insect rice fr st dirt and crrsin. Verif rice
sie is crrect. ee erice Parts ist fr rer rice
siing.
• Verif manifld and inlet ressures. dust regulatr as
reuired.
• Insect ilt ame attern and strength. ee igure .1
fr rer ilt ame attern. lean r relace rice
sud as necessar.
• Insect IPI ame-sensing rd fr st crrsin and
deteriratin. Plish with ne steel wl r relace as
reuired.
• Verif IPI millilt utut. elace as necessar.
• Verif that there is nt a shrt in ame sense circuit
b checking cntinuit between ilt hd and ame-
sensing rd. elace ilt as necessar.
Figure3.1IPIPilot

eat  l • D • 1- e.  • /1 1
A. TypicalApplianceSystem
NOTICE: Illustrations and photos reect typical installations and are for design purposes only. Illustrations/diagrams are not
drawn to scale. A ctual product m ay va ry f rom pictures in m anual
Figure4.1 TypicalSystem
4 GettingStarted 
Installer Guide
STORM COLLAR
(SECTION 10.G )
WALL SWITCH
FRAM ING HEADED
OFF IN CEILING
J OISTS (SECTION 8.C)
ATTIC INSULATION SHIELD (NOT SHOWN)
M UST BE USED HERE TO KEEP INSULA-
TION AWAY FROM VENT PIPE IF ATTIC IS
INSULATED. (SECTION 8.D)
VENT PIPE PENETRATES ROOF
PREFERABLY WITHOUT AFFECTING
ROOF RAFTERS (SECTION 8.C)
NON-COM BUSTIBLE ROOF FLASHING
M AINTAINS M INIM UM CLEARANCE
AROUND PIPE
(SECTION 10)
VENTING
(SECTIONS 7 and 8)
CEILING FIRESTOP ON
FLOOR OF ATTIC
(SECTION 8.C)
FRAM ING /HEADER
(SECTION 5)
STANDARD G AS
LINE CONNECTION
(SECTION 11)
VERTICAL TERM INATION CAP
(SECTION 10.H)
REQ UIRED ACTIVE
CONVECTION AND
CONVECTION
DUCTING
(SECTION 9.C)
HORIZONTAL TERM INATION REFERENCES
WALL PENETRATION
FRAM ING
(SECTION 8.B)
HORIZONTAL
TERM INATION CAP
(SECTION 10.J )

eat  l • D • 1- e.  • /11
B. DesignandInstallationConsiderations
eat  l direct ent gas aliances are designed t
erate with all cmbustin air sihned frm utside f
the building and all exhaust gases exelled t the utside.
 additinal utside air surce is reuired.
Installatin  cml with lcal reginal state and
natinal cdes and regulatins. nsult insurance carrier
lcal building insectr re fcials r authrities haing
urisdictin er restrictins installatin insectin and
ermits.
NOTICE: T he b lower m otor present in this appliance
will g enerate sound during operation. T he ef f ects of the
increased sound lev el can b e m inim iz ed with caref ul
planning during installation of the system . L ocating the
conv ectionintak eg rill inanarearem ote of im m ediateliv ing
spacewillreduce theef f ects of theaddedsound g enerated
during operation.
efre installing determine the fllwing
• here the aliance is t be installed.
• he ent sstem cnguratin t be used.
• as sul iing.
• lectrical wiring reuirements.
• raming and nishing details.
• here wall switch is t be lcated.
D. InspectApplianceandComponents
• arefull reme the aliance and cmnents frm
the ackaging.
• he ent sstem cmnents and decratie drs and
frnts ma be shied in searate ackages.
• If ackaged searatel the media and/r refractr kits
must be installed.
• ert t ur dealer an arts damaged in shiment
articularl the cnditin f the glass.
• Readalloftheinstructionsbeforestartingtheinstal-
lation.Followtheseinstructionscarefullyduringthe
installationtoensuremaximumsafetyandbenet.
WARNING! Risk of Fire or Explosion! Dam ag ed parts
could im pair saf e operation. DO NOT install dam ag ed, in-
com plete or sub stitute com ponents. K eep appliance dry.
C. ToolsandSuppliesNeeded
efre beginning the installatin be sure that the fllwing
tls and building sulies are aailable.
ae measure raming material
Pliers n-crrsie leak check slutin
ammer Phillis screwdrier magnetic
les raming suare
Vltmeter lectric drill and bits 1/4 in. magnetic
Plumb line afet glasses
eel ecircating saw
anmeter lat blade screwdrier
1/ - /4 in. length  r  elf-drilling screws
aulking material  minimum cntinuus exsure
rating
ne 1/4 in. female cnnectin fr tinal blwer.
earth  me echnlgies disclaims an resnsibilit fr
and the warrant will be ided b the fllwing actins
• Installatin and use f an damaged aliance r ent
sstem cmnent.
• dicatin f the aliance r ent sstem.
• Installatin ther than as instructed b earth  me
echnlgies.
• Imrer sitining f the gas lgs r the glass dr.
• Installatin and/r use f an cmnent art nt ared
b earth  me echnlgies.
Anysuchactionmaycausearehazard.
WARNING! Risk of Fire, Explosion or Electric Shock!
DO NOT use this appliance if any part has b een under
water. Call a qualied service technician to inspect the
appliance and to replace any part of the control system
and/ or g as control which has b een under water.
Imrer installatin adustment alteratin serice r
maintenance can cause inur r rert damage. r
assistance r additinal infrmatin cnsult a ualied
serice technician serice agenc r ur dealer.

eat  l • D • 1- e.  • /1 17
5 FramingandClearances 
A. SelectingApplianceLocation
hen selecting a lcatin fr the aliance it is imrtant t
cnsider the reuired clearances t walls see igure .1.
WARNING! Risk of Fire or Burns! Provide adequate
clearance around air opening s and f or servi ce access.
Due to high temperatures, the appliance should be locat-
ed out of trafc and away from furniture and draperies.
NOTICE: Illustrations reect typical installations and are
FO R DE SIG N PU R PO SE S O N L Y . Illustrations/ diag ram s
are not drawn to scale.A ctual installation m ay va ry due to
indivi dual desig n pref erence.
1 IN.
45°
1 IN.
A
E
ABC
TOP VENT
ONE 90° ELBOW
ALCOVE
INSTALLATION
B
TOP VENT
ONE 90° ELBOW
F
D
B
ABCD E F
Inches 7-1/1 7-/ 17-/ ee ectin D.
igure .  .7
1-7/ 1-/4
illimeters 1 17 77 1 47
It is imrtant t fllw the framing and nishing instruc-
tins ste b ste t ensure rer lacement f relace
in the surrunding framing/nishing materials. r addi-
tinal infrmatin and cnsideratins fr the actie cn-
ectin technlg in regards t aliance lcatin and
framing see ectin .
Note: nsider installatin f the actie cn-
ectin blwer when determining aliance
lcatin. ee ectin . fr mre detailed
infrmatin.
Figure5.1ApplianceLocationsRED60

eat  l • D • 1- e.  • /11
B. ConstructingtheApplianceChase
 chase is a ertical bx-like structure built t enclse the
gas aliance and/r its ent sstem. In cler climates
the ent shuld be enclsed inside the chase.
NOTICE: Treatment of ceiling restops and wall shield
restops and construction of the chase may vary with the
type of b uilding . T hese instructions are not sub stitutes
for the requirements of local building codes. Therefore,
you M U ST check local b uilding codes to determ ine the
requirements to these steps.
hases shuld be cnstructed in the manner f all ut-
side walls f the hme t reent cld air drafting rb-
lems. he chase shuld nt break the utside building
enele in an manner.
alls ceiling base late and cantileer r f the chase
shuld be insulated. Var and air inltratin barriers
shuld be installed in the chase as er reginal cdes fr
the rest f the hme. dditinall in regins where cld
air inltratin ma be an issue the inside surfaces ma be
sheetrcked and taed fr maximum air tightness.
 further reent drafts the wall shield and ceiling re-
sts shuld be caulked with caulk with a minimum f
 cntinuus exsure rating t seal gas. as line
hles and ther enings shuld be caulked with caulk
with a minimum f  cntinuus exsure rating r
C. Clearances
NOTICE: Installapplianceon hardm etal orwoodsurf aces
extending full width and depth. DO NOT install directly
on carpeting , vi nyl, tile or any com b ustib le m aterial other
than wood.
WARNING! Risk of Fire! Maintain specied air space
clearances to appliance and ve nt pipe:
• Insulatin and ther materials must be secured t reent
accidental cntact.
• he chase must be rerl blcked t reent blwn
insulatin r ther cmbustibles frm entering and
making cntact with relace r chimne.
• ailure t maintain airsace ma cause erheating and
re.
Note: igure . and igure . shw the relace installed
n the r. weer this relace can be eleated ff
the r rided that the relace is rerl surted
b framing materials and the ceiling clearances are
maintained.
C
B
D
A
Figure5.2.ClearancestoCombustibles-RED60
MINIMUMFRAMINGDIMENSIONS*
ABCD E F G H I J
ugh
ening
Vent Pie
ugh
ening
eight
ugh
ening
Deth
ugh
ening
idth
learance
t eiling
mbustible
lr
mbustible
lring
ehind
liance
ides f
liance
rnt f
liance
Inches 1 1 1-1/4 7-/ 4   1 1 
illimeters 4 1 44 17 1     14
H
E
M EASURE FROM TOP OF
FIREPLACE OPENING
I
G
J
F
stuffed with unfaced insulatin. If the aliance is being
installed n a cement surface a laer f lwd ma be
laced underneath t reent cnducting cld u int the
rm.

eat  l • D • 1- e.  • /1 1
NAILING TABS
BOTH SIDES
Figure5.3NailingTabLocations
D. MantelandWallProjections
WARNING! Risk of Fire! C om ply with all m inim um clear-
ances to combustibles as specied. Framing or nishing
m aterial closer than the m inim um s listed m ust b e construct-
ed entirely of noncom b ustib le m aterials (i.e., steel studs,
concrete b oard, etc).
CombustibleMantels
Figure5.4 MinimumVerticalandMaximumHorizontal
DimensionsofCombustibles
M EASUREM ENTS FROM
TOP EDG E OF THE OPENING
78
910 11 12 13
43
TO CEILING
91011 12
8
7
6
25
18
Note: ll
measurements
in inches.
Note: r nn-cmbustible relace nish material marble
stne etc secicatins refer t ectin 1.
Non-CombustibleMantels
Figure5.5MinimumVerticalandMaximumHorizontal
 DimensionsofNon-Combustibles
M EASUREM ENTS FROM TOP EDG E OF THE
FIRESCREEN DOOR ASSEM BLY
8
9
10
16
7
6
5
4123456
12
43
M AX .
M IN.
TO CEILING
1/2
Note: ll
measurements
in inches.
Figure5.6 MantelLegorWallProjections
(Acceptable on both sides of opening)
Mantel Legs Or Wall Projections Extending
PastTheFaceOfTheFireplace
UNLIM ITED
6 IN. M IN.
2 IN.
M IN.
FIREPLACE
OPENING
TOP VIEW
4 IN.
M AX .
= ACCEPTABLE
NON-COM BUSTIBLE
M ANTEL LEG
ZONE

eat  l • D • 1- e.  • /1
A. VentTerminationMinimumClearances
RoofPitch H(Min.)Ft.
lat t /1...........................................................1.
er /1 t 7/1 .................................................1.
er 7/1 t /1 .................................................1.
er /1 t /1 ..................................................
er /1 t 1/1 ................................................
er 1/1 t 11/1 ..............................................
er 11/1 t 1/1 .............................................4.
er 1/1 t 14/1 ..............................................
er 14/1 t 1/1 ..............................................
er 1/1 t 1/1 .............................................7.
er 1/1 t /1 .............................................7.
er /1 t 1/1 ..............................................
Figure6.1 MinimumHeightFromRoofToLowestDischarge
 Opening
  ft minimum in snw regins
HORIZONTAL
OVERHANG
VERTICAL
WALL
G AS DIRECT VENT
TERM INATION CAP
12
X
ROOF PITCH
IS X / 12
LOWEST
DISCHARG E
OPENING
2 FT.
M IN.
20 INCHES M IN.
H (M IN.) - M INIM UM HEIG HT FROM ROOF
TO LOWEST DISCHARG E OPENING
6 TerminationLocations 
ire isk.
aintain ent clearance t cmbustibles as
secied.
• DO NOT ack air sace with insulatin r ther
materials.
ailure t kee insulatin r ther materials awa
frm ent ie ma cause erheating and re.
WARNING
G as, W ood or F uel O il
Termination C ap
B
G as
Termination
C ap * *
A *
*I f using decorative cap cover(s), this distance may need to be
increased. R efer to the installation instructions supplied with the
decorative cap cover.
* *
A B
6 in. (minimum) up to 20 in.
1 5 2 m m / 5 0 8 m m 18 in. minimum 4 5 7 m m
20 in. and over 0 in. minimum
I n a staggered installation with both gas and wood or fuel oil
terminations, the wood or fuel oil termination cap must be
higher than the gas termination cap.
Figure6.2 StaggeredTerminationCaps