Jayco Eagle FW 2021 User manual

Owner’s Manual
0283662.2021
2021
Fifth Wheel Towables
FW, FW HT
A subsidiary of Thor Industries, Inc.

Table of Contents

Factory Tours 9
Options and Equipment 9
Dealer Responsibility 9
Customer Relations 9
To Contact Us 11
About This Manual 11
Warranty Packet 12
Safety Alerts 12
Reporting Safety Defects 13
Customer Responsibility 14
Change Of Address/Ownership 14
Suggestions For Obtaining Service 14
Obtaining Service For Separately Warranted Items 15
Obtaining Service At Our Customer Service Facility 15
Parts and Accessories 15

Secondary Means of Escape (Exit Window) 23
Exit Window Label
Fire Safety 24
Fire Extinguisher 24
Smoke Alarm 25
Combination Carbon Monoxide /Propane Alarm 26
Carbon monoxide/propane alarm (alarm may vary from model(s) shown)
Formaldehyde 30
Extended Or Full Time Usage 30
Cold Weather Usage 30
Condensation 31

Tow Vehicle 33
Vehicle Labels 33
Weight Terms 33
Weight and Capacity Labels 33
OCCC Label (yellow)
Federal Certication Label
Tire and Loading Information
Loading Your Recreation Vehicle 35
Cargo CarryingAccessory Receiver (if so equipped) 35
Rear Bumper 36
Fifth Wheel Pin Box (customer supplied) 36
Fifth Wheel Pin Box 37
Fifth Wheel Pin Box Height 37
Fifth Wheel Hitching Procedure 37
Wire Harness/Connector Plug 38
Weighing Your Tow Vehicle and RV 38

Towing 41
RV Brake System 42
Electric Brakes 42
Brake Controller (customer supplied) 43
Travel Trailer Breakaway Switch 43
Hydraulic Brakes (if so equipped) 43
Disc Brakes (if so equipped) 43
Towing Behind Your RV 44
2021 Jayco Eagle FW

Table of Contents
Factory Installed Hitch Reciever (if so equipped) 44
Entrance Door Step(s) 46
Stowable Entrance Door Step (if so equipped) 46
Entrance Door 47
Rear Backup Camera Prep 48
Campsite Hook-Up 48
LCI 3.0 Leveling System (if so equipped) 49
Auto Leveling Touch Pad 50
OneControl Touch Panel 51
OneControl Touch Panel
Linc Remote
Linc Remote Control 52
Troubleshooting 52
Stabilizer Jacks 53
Manual Stabilizer Jacks (if so equipped) 53
Electric Stabilizer Jacks (if so equipped) 53
Emergency Stopping 54
Emergency Towing 54
Wheel Lugs 55
Wheel Lug Nut Diagrams 55
Wheel Lug Nut Torque Values 56
Tires 57
Changing A Tire 59
Spare Tire Carrier (if so equipped) 60
Hoist Mount 60
Bracket Mount Travel Position
Hoist Mount Travel Position
Bumper Mount
Crank Access Port
Bumper Mount: 61
Setting Up Your Recreation Vehicle 62
Travel Trailer Set Up 62
Fifth Wheel Set Up 62
Awnings (if so equipped) 62
Awning Care 63
Electric Patio Awning With Remote Control 63
In Motion Detector (if so equipped) 63

Electric Slide Room(s) (if so equipped) 64
General Slideout Operation 64
Slideout Overlap-Outside
General Slideout Troubleshooting Checklist 65
Flush Floor Slideout 65
Schwintek In-Wall Slideout System 67
Norco Slideout System 70
Power Gear Slideout System 71
Fig.1 Slideout Controller
Power Gear Slim Rack Slideout System 73
Power Gear Ram Slideout System 78

The Electrical System 80
In Case Of An Electrical Fire 80

Table of Contents
Command Center 81
Command Center Panel
Command Center Panel w/Switch Modules
GFCI Receptacle 82
LCI One Control® System(if so equipped) 82
LCI One Control® App(If So Equipped) 85
Testing the Campsite Power Connection 87
Connecting the Power Cord 88
Inverter (if so equipped) 89
BMPro RVMASTER SYSTEM (If So Equipped) 91
Power Converter 98
Converter with Charge Wizard (if so equipped) 100
12-Volt DC System 100
12-Volt Fuse Panel 100
Auxiliary Battery (customer supplied) 101
Replacing a Fuse 101
12-Volt DC Outlet 101
Dry Camping 102
Replacement and Maintenance 102
Battery Isolator For Your Tow Vehicle (customer supplied) 102
Battery Disconnect Switch (if so equipped) 102
Load Center 103
120-Volt Circuit Breakers 103
Battery Disconnect Switches
Approximate Electrical Load Ratings 105
120-Volt (30 AMP) AC System (if so equipped) 106
30-amp Power Cord (if so equipped) 106
120-Volt (50 AMP) AC System (if so equipped) 107
Calculating 30 AMP Electrical Load (if so equipped) 107
50-AMP Power Cord: 108
Calculating 50 AMP Electrical Load (if so equipped) 108
Solar Prep (if so equipped) 109
Replacing Light Bulbs 109
Solar Plug

Exhaust Gas Fumes 110
Propane Gas System 110
Propane Gas Container 111
Servicing or Filling 112
“Use propane only” Label (Canada only)
“Shut o for re-fueling” Label
(label appearance may not be exact)
“Do not ll to more than 80%” Label
(label appearance may not be exact)
LP Gas Container Overll 113
Maintenance 113
Propane Cylinder Recertication 113
Hoses, Pipes, Tubes and Fittings 113
Propane Regulator 114
Propane Use and Safety 115
Propane Leak Test 115
Using the Propane System 115
Propane System Label
Cooking With Propane Gas 116

Table of Contents
Calculating Propane Gas Usage 116
Ensure a supply of fresh air (Canada units only)
Cooking / Comfort Heating Label
Traveling With Propane 117
Installing Propane Cylinder(s) 117
Refueling Warning Label
Single Cylinder
Main Supply Hose
Double Cylinder
Two Propane Cylinders

Plumbing System 120
Plumbing System Maintenance 120
Monitor Panel 120
Monitor Panel
Command Center
Fresh Water System 122
Water Pressure Regulator (customer supplied) 122
Fresh Water Holding Tank 122
Draining the Fresh Water System 123
Exterior Fresh Water Drain
Low Point Drains
12-Volt Water Pump and Switch 123
Utility Center – 2 Valves (6 In 1) 124
Sanitizing the Plumbing System 128
Winterizing (with Utility Center) 131
Air Pressure Method 132
Winterizing with Antifreeze Method 133
Nautilus P2.5 Uni-Dock Utility Center 135
Winterizing the Plumbing System 142
Winterize with Air Pressure 143
Winterize the Black Tank Flush 144
Draining the Spray Port (If So Equipped) 145
Winterizing the Spray Port with Antifreeze (If So Equipped) 145
Winterize with Antifreeze Method 145
Water Heater 148
Gas/Electric DSI Tank (Storage) Water Heater System (if so equipped) 148
Anode Rod Replacement Chart
Outside Shower (if so equipped) 152
Faucets 153
Bathroom Tub / Shower 153
Black/Grey Water System and Tanks 154
Black and Grey Tank Drains 155
Black/Grey Tank Drain and Valves
Macerator Pump System (if so equipped) 156
Black Tank Flush (if so equipped) 158
Tank Flush Inlet
Black Tank Flush (if so equipped) 159
Tank Heaters (if so equipped) 159
Toilet (If So Equipped) 160
Spray Port (if so equipped) 161

Table of Contents

Air Conditioner 162
Roof Mount (if so equipped) 162
Wall Mount (if so equipped) 162
Heat Pump Operation (if so equipped) 162
Power Roof Vent (if so equipped) 162
Attic Fan Control
Ceiling Fan (if so equipped) 163
Furnace 163
Fireplace (if so equipped) 164

Microwave 166
Cooking Safety 166
In Case Of a Grease Fire 166
Cooktops: Range and Oven (if so equipped) 167
Electric Drop-In Cooktops (if so equipped) 167
Cooking with Propane (if so equipped) 167
Gas Drop-In Cooktops (if so equipped) 168
Kitchen Range and Oven (if so equipped) 168
Oven (if so equipped) 168
Gas BBQ Grill (if so equipped) 169
Attaching the “Quick Coupler” Connection 170
Quick Connect Coupler
Gas Grill and Mounting
Bracket on Support Rail
Range Hood (if so equipped) 171
Refrigerator 171
Cleaning the Interior 172
Cleaning the Exterior 173
Washer/Dryer Prep (if so equipped) 173
Vacuum Systems (if so equipped) 173
Dryer Vent Label
Water Heater – See Plumbing Section 174
Outside Kitchen (if so equipped) 174
Quick Connect Coupler
Exterior Refrigerator 175
LP Gas Grill (if so equipped) 175

Winegard Air 360 Plus System (If So Equipped) 178
Opening the Router Box 179

Cleaning The Interior 182
Window Treatments 182
Cabinetry and Tables 183
Interior Wall Panel 183
Quik Panel Wall Panels (if so equipped) 183
ABS Plastics 184
Sofa and Dinette 184
Hide-A-Bed Sofa or Sofa Sleeper 184
Jack Knife Sofa 184
Trifold Sofa 184
Cube Sofa 185

Booth Dinette (if so equipped) 185
Free-Standing Table and Chairs (if so equipped) 185
Pantry or Hutch (if so equipped) 186
Countertops 186
Laminate Countertops (if so equipped) 186
Solid Surface Countertops (if so equipped) 186
Flooring 187
Carpet 187
Vinyl Flooring 187
Murphy Bed (if so equipped) 187
Bed Storage 190
Prop Rod (if so equipped) 190
Loft Sleeping Area (if so equipped) 191
Gas Struts (if so equipped) 191

Cleaning the Exterior 194
Frame 196
E-Z Lube or Super-LubeAxle (if so equipped) 196
Exterior Roof and Sidewall Vents 197
Windows 197
Exterior Ladder (if so equipped) 197
Sealants 198
Fifth Wheels - Sealant Diagram 199

Travel Checklist 200
RV Storage 201

Featured Components Quick Reference Chart 204
Vehicle Maintenance Record 206
Ownership Notication 207


7
         

This manual has been provided by your recreational vehicle manufacturer for the sole pur-
pose of providing instructions concerning the operation and maintenance of this recreational
vehicle. Nothing in this manual creates any warranty, either expressed or implied.

Please review the limited warranty and the limited warranties that apply
to specic components oered with this vehicle.
Instructions are included in the manual for operating various components which are optional
on some RV’s or may not be available on your particular model. 

 In addition, the owner should refer to individual manufac-
turer’s operating instructions contained in the owner’s packet.


8