Johnson Outdoors Eureka! SPRK+ Camp Stove 2572201 User manual

210MM
142MM
426MM
• NEVER install or remove butane canister while outdoor stove is lighted,
near flame, pilot lights, other ignition sources or while outdoor stove is
hot to touch.
FOR OUTDOOR USE ONLY.
ANS Z21.72 CSA 11.2-2016 Camp Stove
Model 2572201
Instruction Manual
Read and comply with all instructions and warnings in this manual
before using this Product. Keep these instructions for future reference.
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space such as a camper,
tent, car or home.
DANGER
Drip Pan
Electrode
Levelling Feet Control / Ignition Knob
Canister locking lever
Canister Cover
Pan Supporter
Burner Head
Windshield High / low control knob
with piezo-ignition
• NEVER store butane near high heat, open flames, pilot lights, direct sunlight,
other ignition sources or where temperatures exceed 120 degrees F (49 C ).
Do not connect to a remote gas supply.
WARNING: Provide ample ventilation when using this appliance. This appliance consumes
oxygen. To avoid endangering your life, do not use this appliance in unventilated structures.
Provide additional ventilation for any additional burning products or additional occupants.
Failure to comply with the precautions and instructions provided with these stoves can result
in death, serious bodily injury and property loss or damage from hazards of fire, explosion,
burn, asphyxiation, and / or carbon monoxide poisoning. Only persons who can understand
and follow the instructions should use or service this stove.
If you need assistance or information such as an instruction manual or labels, contact you seller.
• EXPLOSION - FIRE HAZARD
• During operation, this product can be a source of ignition. NEVER use the
stove in spaces that contain or may contain volatile or airborne combustibles,
or products such as gasoline, solvents, paint thinner, dust particles or unknown
chemicals. Minimum clearances from combustible materials: 1m / 3ft.
• Provide adequate clearances around air openings into the combustion chamber.
• Butane canisters must be stored outdoors, in a well ventilanted space, out of the reach of children,
and must not be stored in a buliding, garage, or any other enclosed area.
Do not store or use gasoline or other liquids with flammable vapor in the
vicinity of this or any other appliance.
FOR YOUR SAFETY
If you smell gas:
1. Do not attempt to light appliance.
2. Extinguish any open flame.
3. Disconnect from fuel supply.
4. Evacuate immediately.
5. Allow gas to dissipate 5 minutes before relighting the appliance.
Failure to follow these instructions could result in fire or explosion, which
could cause property damage, personal injury, or death.
WARNING
!
DANGER
This appliance is only intended for use with butane canisters that are
designed for vapor withdrawal only. This is done by lining up the notch
in the collar of the canister with the safety guide on the regulator. They
must fit together or the canister will not lock into place.
• Do not dispose of empty gas canister into fire, risk of explosion may occur.
• The butane fuel canister shall comply with DOT 2P or 2Q requirements
and shall be listed to the Standard for Non-refillable (Disposable) Type
Metal Canister. Assemblies for Butane, UL 147B.
• Avoid any strong shock or impact to the fuel canister.
Keep canisters upright for storage.
Remove canister from stove before storing.
• Use only butane set up for vapor withdrawal.
Safety guide Notch
• Never leave the stove unattended when hot or when in use.
• Keep out of reach of children at all times.
• Keep the stove area clear and free of combustible materials, gasoline and other flammable
vapors and liquids.
• Do not obstruct the flow of ventilation or combustion air around the appliance.
• Use a soft cloth to clean greasy parts of the stove with soap and
water.
• Keep the electrode and the burner gap free from debris for easy
lighting.
• Clean stove frequently to avoid grease build up and as necessary.
• Burner flame should be blue with hint of yellow tip.
Blue
Yellow
GOOD BAD
Yellow
Blue
Holes in Burner
PRECAUTIONS FOR FUEL USE
MAINTENANCE AND CAUTIONS
BUTANE INFORMATION AND STORAGE
• Performance may be suboptimal if used in extreme conditions
(cold, hot, wind, altitude).
Johnson Outdoors Gear,Inc.
625 Conklin Road,
Binghamton,NY13903
T:1.800.847.1460
Johnson Outdoors Gear,Inc.
4180 Harvester Rd,
Burlington, ON L7L 0C1 Canada
T: +1.905.634.0023
• Keep your stove clean using a stiff brush to clean the burner head.
In a home or residence, the canister must be removed from the stove and the canister must be
stored outdoors in a well ventilated area, out of the reach of children. They shall not be stored in
a building, garage or any other enclosed area.
The stove may be stored indoors but only if the canister is removed.
When the stove is not in use or in storage, always remove the fuel canister.
Only gas canisters marked with the fuel type approves for the appliance must be used.

210MM
142MM
426MM
• Turn the control knob to " " position.
• Make sure Lever is in the " " (UNLOCK) position (otherwise canister
cannot be installed). (Fig.3)
PORTABLE BUTANE GAS STOVE
(Fig.8)
Clean the burner head with a brush.
Check the igniter tip to see if it has been bent too far away
from the burner cap for a spark to be produced.
Check that the Control Knob is in the OFF position.
Make sure the notch on the canister is lined up with the
safety guide.
Check if the gas canister was inserted and locked in properly.
Check if the gas canister is empty.
Check if the temperature is above 32F.
No Gas Comes Out
No Ignition
Can not lock in
The fuel canister
You smell gas
Check with soapy water for any gas leaks where the canister
and regulator meet If there is a leak and you have inserted
the canister properly, contact customer service.
Do not use.
Problem Possible Solutions
CAUTION: Butane is heavier than air and will seek the lowest point in a room. Ventilate the
room and do not turn on any source of ignition, such as lights or appliance until room has
been well ventilated. If gas odor is strong, evacuate the building and seek professional
assistance.
(Fig.7)
LIGHTING THE STOVE
The stove must not be exposed to flammable vapors or liquids during lighting.
(Fig.5)
(Fig.6)
• Turn Control Knob clockwise to " " (OFF) position. (Fig.3)
• Do not use a pan larger than 11" as this will cover the fuel
compartment and cause the canister to overheat. (Fig.2)
• Never use ceramic cookware.
• Do not use this stove below shelves or where there is a danger of falling objects.
• Avoid direct sunlight or other heat sources that could exceed 120F.
• Do not use in windy conditions as the flame may be extinguished.
Gas will continue to flow creating a hazardous condition.
• Never use the stove near flammable materials or combusible vapors.
• Do not use two or more stoves covered by a single pan or
metal sheet.
• Never use aluminum foil as a cooking container on the stove.
• Never heat an empty pan.
(Fig.4)
NOTE: Check for leaks using soapy water, Never use a flame. Bubbles indicate a leak.
• To connect a gas canister, locate the notch on its collar, lift up the
safety guide inside at the stove connection and insert canister so
safety guide is inside canister collar notch.
• Push down the canister lever to " " (LOCK) position. (Fig.4)
CAUTION: When replacing fuel canister, be sure no external sources
of ignition are present.
(Fig.3)
• Open the canister compartment cover.
SETTING UP THE STOVE
CAUTION: Use only the gas pressure regulator supplied with this appliance. This regulator is set for
an outiet pressure of 1.25psi.
If you can not locate a supplier in you area, please contact Eureka!
at www.eurekacamping.com for location information.
Contact your local dealer, distributer, or Eureka! for parts and / or service.
• Do not use grill plates or pans that extend over the canister compartment.
Notch
Safety guide
The recommended maintenance frequency is one time a year.
NOTE: This portable gas stove shall be used with 227g (8 Oz.) non-rellable fuel gas canisters that
are designed with a notch for vapor withdrawal only (refer to "PRECAUTIONS FOR FUEL USE"
section in these Instructions)
TROUBLE SHOOTING
SPECIFICATIONS
SAFETY PRECAUTIONS
• Do not carry the unit while it is burning.
• Do not touch the unit while in use or just after use.
• Do not overheat the stove.
• Do not use two or more stoves adjacent to each other. (Fig.1)
• Do not use as a heater.
• Never use the stove without the pan support.
(Fig.1)
(Fig.2)
SAFETY PRECAUTIONS
• Adjust levelling feet and check stability prior to use.
• Do not operate stove if levelling feet are missing or removed.
• Always place the stove on a horizontal, stable and heat resistant surface.
2572201
Piezo-Electric
3.1 lbs (1.4 kg)
Butane
253 g/h
11,500 Btu/Hr
227 Grams (8 Oz.) DOT-2P/2Q (RVR)Model Number
Type of lgnition
Dimension
Weight
Fuel canister/Nt. Wt
Type of gas
Fuel consumption
Input rating
13.0” x 11.5” x 3.6”
For additional diagrams and FAQs, visit: www.eurekacamping.com
This product is covered by a 1 year limited warranty.
Visit www.eurekacamping.com for additional information.
NOTE: Close the Canister Cover before lighting. Not closing the Cover properly may cause canister
to overheat.
Failure to follow these procedures to properly install the canister and close the door can
result in a gas leak.
• After three failed attempts, turn the gas supply off by turning the Control
Knob clock wise to " " position and return the Canister lever to " " position.
• If the stove does not light, turn the Control Knob back to " " position
and repeat previous step. (Fig.3)
• Push and turn the Control Knob counter clock wise until you hear a click
indicating that a spark has been produced. (Fig.5)
• Open canister cover, remove canister and shake to verify that it is not empty.
• If empty, replace canister following the " Setting up the stove " section.
• CAUTION: When canister needs to be replaced: if stove in use, do not touch
the hot stove or any items that are on stove until they have cooled.
• If canister is not empty, contact Customer Service.
Match Light:
• Turn Control knob clockwise to " " position. (Fig.3)
• Push down the canister lever to " " position. (Fig.4)
• Hold lighted match next to Burner and turn Control Knob counter clockwise slowly.
• Adjust flame to desired heat lever. (Fig.6)
• Flame should be blue with hint of yellow tip.
• If burner does not light and Control / Ignition Knob is not completely in " " position, gas is
escaping and could cause an accident.
• Check Lever on stove to be sure it is in the " " position.
• Turn Control Knob clockwise to " " (AUTO-EJECT) position.
• Alternatively, turn Control Knob clockwise to " " position and return
lever to the " " position. (Fig. 7 & Fig. 8)
• Remove butane canister.
• Store butane canister consistent with instructions and warnings on
the canister.
• Use a soft cloth and clean greasy parts of the stove with soap and water
or a nonabrasive detergent.
• Fuel canister must be disconnected when the stove is in storage.
• Store stove in a cool, dry and well-ventilated area, out of the reach of children.
• Allow stove to cool for 10-15 minutes.
TURNING OFF AND STORING THE STOVE
The appliance is equipped with a safety device which stops the flow of gas if the pressure in the
canister, e.g. because of overheating, becomes too high.
To continue usage...
• Follow the procedure for "SETTING UP THE STOVE" with a cooled canister.
HANDLING SAFETY DEVICE
• Return the canister lever to " " position and take the canister out.
• Adjust flame with Control Knob to desired heat.
Reference " " (HIGH) and " " (LOW) flame indicators. (Fig. 6)