Kajak Sport KS-footrest User manual

Assembly and installation instruction
ITEM: KS-footrest
Dated 10.2.2012
PAGE 1/4
The Kajak-Sport footrest system is one of the most innovative footrests available in the
world. With the KS-footrest you always have solid support for your feet which is the basic
rule for efcient paddling. The footrest consist of a solid rail and an innovative pedal part
with self pivoting system for adjusting and soft grip material in the middle of the pedal.
The adjusting of the footrest is smart and simple. It can be done only with feet. The po-
sition of the pedals can be adjusted while seated.
The Footrest can be xed to the kayak simply with screws through the hull or by laminating
into the kayak hull with special KS-fasteners (#501117) for footrest.
40 mm
408 mm
Attachement point: 374 mm
Attachement screw tolerance: 17 mm
22 mm
Attachment screw tolerance: 17 mm
Attachment point: 374 mm

Assembly and installation instruction
ITEM: KS-footrest
Dated 10.2.2012
PAGE 2/4
Name  Code Qty
1. KS-plasticpedal 501111 2
2. KS-rail  501112 2
3. KS-pedallock 501114 2
4. KS-railend  501113 4
5. Foamwasher 501116 4
6. PT-torxscrew 475622 4
(1)(1)
(2)
(2)
(3)
(3)
(4)
(4)
(4)
(4)
(6)(6)
(6) (6)
(5)(5)
(5) (5)


Assemblingthepedallocktothefootrestpedal
A) Slidethehingemechanismplateofthepedalinside
 thepedallockpart.Pushitasfarasthepedal
 lockfrontendcanturnupinthetrackonthepedal.
B) Pullthepedallockbackwards,sothatthefrontendof
 thepedallockwillstayinthetrack
C) Liftthepedallockrearendtoequallevelwiththefrontend.
 Nowtrythatthepedallockcanfreelyslidefrontandbackonthepedaltrack.
Assemblingthefootrest:
1) Slidethepedaltotherail.Considertherailfrontendtobetheonewithovalshaped
 attachmenthole.
2) Placethefoamwashersaroundtheattachmentholesatthebacksideoftherailinbothends.
3) Slidetherailendpartstothebothendsoftherail.
4) Fastenthefootrestbyscrewingitthroughthekayakhullfromtheoutside.Noticethat  
 srewsarenotmenttoattachtherailitself,buttheyfastentotherailendpartswhichwilltighten
 thecompletefootrestpackageproperlyagainstthekayakhull.
Assembly and installation instruction
ITEM: KS-footrest
Dated 10.2.2012
PAGE 3/4

Adjustingthepedaldistance
Forwards:
1) Openthepedallockbypullingitbeforeadjustingthepedal.
2) Pressthepedalarmagainsttherailandkeepitpressedwhileadjustingthepedaldistance.
3) Whenpedalisincorrectpositionstoppressingthepedalarmagainsttherailandpush  
 thepedalabitfurtheruntilitlockstothenextfreeslot.
4) Pressthepedallockpartbetweenpedalandrailtolockthesystem.
Backwards:
5) Openthepedallockbypullingitbeforeadjustingthepedal.
6) Placeyourfootbehindthepedalandpullitcloser.Thepedalwillmovefreely
7) Whenpedalisincorrectpositionchangeyourfootinfrontofthepedalandpressitslightlyforward
 untilthepedallockstothenextfreeslot.
8) Pressthepedallockpartbetweenpedalandrailtolockthesystem.
Movepedalforwards
Movepedalbackwards
Unlockthepedalbeforeadjusting Lockthepedalafteradjusting
(1 & 5)
(2) (2) (2) (3)
(4 & 8)
(6)(6)(6)
(7)
Assembly and installation instruction
ITEM: KS-footrest
Dated 10.2.2012
PAGE 4/4