Kenwood KDC-2092RYA User manual

© 2001-12 PRINTED IN JAPAN
B51-7872-00 (N)1937
CD RECEIVER
KDC-2092RYA/RYG
KDC-3021A/G/YA/YG
KDC-306A/G/YA/YG
SERVICE MANUAL
COMPACT
DIGITAL AUDIO
RDMLOUD REPSCAN
OFF
KDC-XXXX
PTY
VOL. ADJ
TI
MENUCLK
AUD
50Wx4
COMPACT
DIGITAL AUDIO
RDMLOUD REPSCAN
OFF
KDC-2092R
PTY
VOL. ADJ
TI
MENUCLK
AUD
50Wx4
Panel assy
(A64-2563-02): KDC-2092RYA/RYG
DC cord
(E30-4790-05)
Lever
(D10-4589-04)x2
Escutcheon
(B07-3054-02)
The CD mechanism infomation is not in this sarvice manual.
Please, refer to sarvice manual X92-4030-0x (B51-7867-00).
Panel assy
(A64-2553-02): KDC-3021A/G/YA/YG
(A64-2565-02): KDC-306A/G/YA/YG Escutcheon
(B07-3054-02)
Plastic cabinet assy
(A02-1486-13)
Mounting hardware assy
(J21-9641-13)
WIDE BAND
Antenna adaptor
(T90-0523-05)
CD mechanism extension cord : W05-0618-00

KDC-2092RYA/RYG,3021A/G/YA/YG, 306A/G/YA/YG
2
BLOCK DIAGRAM
CD
IC4
IC12
IC1
POWER IC
TUNER FM+B
AM+B
SW5V
BU5V
A8V
SERVO
CH
BACK UP
E-VOL & MPX
u-COM
BU5V
TEL-MUTE
ACC DET.
BU DET.
BUFF
DECODER
RDS
IC6 ('E)
IC2
SW5V
SW5V
E2PROM
SW5V
SERVO SW14V
IC7
IC2
IC1
PRE OUT
SP-OUT
ACC
TEL-MUTE
BACK-UP
P-CON
ANT-CONT
POWER SUPPLY
MUTE
PRE MUTE
DSIBU5V
REMOTE SW5V
PAN DET.
PAN5V
PAN5V
LCD DRIVER
KEY MATRIX
With
ILLUM SW
A8V
CONTROL
BU5V MARINE CN.
ANT-CON DET.
P-CON DET.
FM DET OUT
AM DET OUT
REQUEST
LO/DX
PLL-CLK
PLL-CE
S-METER
PLL-DATA
SD
MSDA
MSCLK
SW2
SW1
SW3
M MUTE
RST
STOP
LO/EJ
MO SW
RST
CH-CON
MUTE
DATA C
REQ H
DATA H
CLK
REQ C
FM
AM
CD
CH
AFS
NOISE DET
LEVEL
RDCK
DATAS
MUTE
RDDA
LO/DX
QUAL
PLL-DATA
PLL-CLK
AFS
NOISE
S-METER
SCL
SD
SDA
PLL-CE
EN2
EN3
EN1
PC DET
PA DET
CLK
DATAL
CE
REMO
PANEL
DSI
RES
SDA
SCL
P-CON
P.ANT
FM+B
VP2
AM+B
AUDIO
ILLUM
BU5V
SW1
SW2
203mV
170mV
1200mV
1200mV
382mVK:
E:
382mVJ:
(K)
FM
(E)
(K)
(J)
(J)AM
(E)
: 1605mV
: 1276mV
: 561mV
: 1700mV
: 561mV
: 792mV
: 3529mVCD.CH
LCD

KDC-2092RYA/RYG,3021A/G/YA/YG,
306A/G/YA/YG
3
MICROCOMPUTER’STERMINAL DESCRIPTION
SYSTEM MICROCOMPUTER µPD780058GC-XXX (IC1 : X25)
Pin No. Pin Name I/O Purpose Processing in STBY Mode
1 PANEL I Panel detection Hi-Z
2 8EJE SW *1 I 8 cm disk eject end detection switch L, L when the 8 cm CD compatibility is not provided.
3 NC O Not used L
4 AVss - GND potential (for A/D and D/A) -
5 L-RST O LCD driver reset H, L when the panel is detached or with 7-segment output.
6 L-CE O LCD driver chip enable L, L is output when the panel is detached.
7 AVREF1 I 5V power supply (D/A converter reference voltage) -
8 NC I Not used Hi-Z
9 PLL-DATA I/O F/E (IC3) communication data L
10 PLL-CLK O F/R (IC3) communication clock L
11 L-DATAL I LCD driver communication data (LCD) Hi-Z
12 L-DATAS O LCD driver communication data (SYSTEM) L, L is output when the panel is detached.
13 L-CLK O LCD driver communication clock H, L is output when the panel is detached.
14 R-DATA I RDS DATA Hi-Z, L when RDS is not available.
15 R-QUAL I RDS QUAL Hi-Z, L when RDS is not available.
16 CH-DATAC I 5-wire communication data (CH) Hi-Z, L when CH is not available.
17 CH-DATAH O 5-wire communication data (HEAD) L, L when CH is not available.
18 CH-CLK I/O 5-wire communication clock Hi-Z, L when CH is not available.
19 CH-REQH O 5-wire CH request (HEAD) H, L when CH is not available.
20 PLL-CE O F/E chip enable L
21 AFS O Noise detection time constant switching L
22 LO/DX O Local seek switching L
23~26 NC O Not used L
27 SD I Station detection Hi-Z
28 CH-CONT O 5-wire communication CH ON output L, L when CH is not available.
29 TYPE REF O Destination type and servicing setting 5V output L
30 TYPE2 I Destination type setting Hi-Z
31 TYPE1 I Destination type setting Hi-Z
32 TYPE0 I Destination type setting Hi-Z
33 Vss1 - GND potential (for other parts than ports and analog circuitry) -
34 IC2TYPE1 I Servicing pin (SEL1), normally “L” Hi-Z
35 IC2TYPE0 I Servicing pin (SEL0), normally “L” Hi-Z
36 DATA I/O IC2, CD mechanism and F/E communication data L
37 CLK O IC2, CD mechanism and F/E communication clock L
38 MUTE O Muting control output L, 15 sec. after power OFF.
39 P-MUTE O PWR IC muting output H, 15 sec. after power OFF.
40 SVR O SVR control output L
41 P-STBY O PWR IC standby output L
42 SW5V O SW5 control output “H” in 10 sec.after power OFF.
43 B.U-DET I B.U. detection Hi-Z
44 ACC-DET I ACC detection Hi-Z
45,46 NC O Not used L
47~49 PS1-0~PS1-2 O Power supply IC AUD/P.CON/P.ANT SW L
50 BEEP O Buzzer output L
51,52 PS2-0,PS2-1 O Power supply IC ILL/AM/FM SW L
53 DSI O DSI control output L, H/L when panel is detached. FIX output is L.

KDC-2092RYA/RYG,3021A/G/YA/YG,
306A/G/YA/YG
4
MICROCOMPUTER’STERMINAL DESCRIPTION / ADJUSTMENT
Pin No. Pin Name I/O Purpose Processing in STBY Mode
54 LOE/LIM SW I CD mechanism Down & Limit detection Hi-Z
55 MOSW O CD mechanism motor switching L
56 LO/EJ I/O Lo/Ej switching Hi-Z
57 M-STOP O Mechanism COM stop output L
58 M-RST O Mechanism COM reset output H
59 M-MUTE I Mechanism COM mute input Hi-Z
60 RESET I System reset input Hi-Z
61 REMO I Remote control input Hi-Z
62 R-CLK I RDS CLOCK Hi-Z, L when RDS is not available.
63 CH-REQC I 5-wire CH request (CH) Hi-Z, L when CH is not available.
64 LOS SW I Loading SW detection Hi-Z
65 KEY-REQ I Key input detection Hi-Z
66 12EJE SW I 12 cm disc detection Hi-Z
67 Vss0 - GND potential (for ports) -
68 VDD1 - Positive power supply (for other parts than ports and analog circuitry) -
69 X2 - Main system clock oscillation -
70 X1 I Main system clock oscillation -
71 IC - Flash uCOM write -
72 XT2 - Not used -
73 XT1 - Not used (Connected to 5V power supply) -
74 VDD0 - Positive power supply (for ports) -
75 AVREF0 I 5V power supply (A/D converter reference voltage) -
76 S-METER I S-meter input Hi-Z
77 PHONE I Navigation muting 2.5V or more, Telephone muting 1V or less . Hi-Z, L when TEL is not available.
78 NOISE I FM noise detection Hi-Z, L when RDS is not available.
79 NC O Not used L
80 AVCONT O A/D reference voltage control L
No. ITEM INPUT SETTINGS TUNER (RECEIVER) ALIGNMENT ALIGN FOR
SETTINGS POINTS
FM SECTION
98.1MHz TEST MODE : ON While holding preset “1”key, press and
1SD 0dev FM Preset “1”key, and hold preset “6”key for a few seconds.
35dBµ(ANT input) 98.1MHz preset “6”key “ADJ OK”is good.
“ADJ NG”is not good.
AM SECTION
990kHz TEST MODE : ON While holding preset “1”key, press and
(1) SD 0% mod AM Preset “1”key, and hold preset “6”key for a few seconds.
35dBµ(ANT input) 990kHz preset “6”key “ADJ OK”is good.
“ADJ NG”is not good.
TEST MODE : ON While holding the FM key and preset “6”key, reset the unit.
TEST MODE : OFF Reset the unit.
ADJUSTMENT

ABCDEFGHIJ
1
2
3
4
5
6
7
65
PC BOARD
(COMPONENT SIDE VIEW)
Refer to the schematic diagram for the values of resistors and capacitors.
IC1
D267
D264
D268
D13
D11
Q20
Q201
IC2
IC6
Q102
Q224Q223
Q222
Q251
Q51
Q50
Q221
Q101
Q53
IC8
IC11
IC12
D102
Q40
Q10
Q70
J1
X25-9142-7x (J74-1368-12)
CN3
CN1
CN2
J2
J3
A1
D108
Q55 D1
D403
D265
D266
D263
D261
D262
D14 D12
D110
D251
D101
D103
D104
D253
D252
D109
D106 D107
J5
P1
D30
D202
D201
D10
D50
D20
D404
D402
D401
D407
D411
D410
D409
IC4
J4
D111
D70
D51
IC7
D40
X25-9120-xx/913x-xx (J74-1290-12)
R56
W157
R123
C211
W160
C208
C104
C62
W156
C225
R139
C307
W163
W164
C226
W167
W168
C59
R57
W166
C356C355
TH1
R127
R126
R128
R130
R129
R125
R122
R138
R137
R143
R144
R132
R131
R133
R140
R134
R119
R104
R103
R105 R107
R106
R102
R136
R135
C207
R67
R115
R114
R116
R118
R117
R113
R108 R110
R112
R111
R261
R260/W178
R263
R255
R254/W176
R256
R258
R257
R413
R412
R414
R415
C30
C21
R202
R201
R203
R205
R204
C103
C202
C206
C142
C106
C102
R251/W177
R222
R221
R223
R224
C354
R12
R23
R22
C404
R11
C305
C303
C302
R10
R52
R58
R51
R31
C209
C210
R32
W179
CP3
C352
W162W161
R53
C64
C310
R54 C60
R55
C61
CP1
W151
W158
C40
W152
C309
W165
R264
CP2
W159
C105
R121
W155
W150
C500
R71
R72
C228
R73
W169
W171
W172
W173
W174
C501
R142
C311
C312
C313
80
61
40
21
1
20
41
60
21
43
17
814
14
58
114
1528
1
16
8
9
EB
EB
EBE
EEB
BE
BE
EB BE
EB
EB
EB
EB
EB
EBEB
W53
W54
W142
W66
W79
C58
W38
C1
W82
L1
W108
W119
W85
W112
W132
W81
W137
W58 W44
W55 W37
R404
R402
R408
R411
R409
R410
R407 R405
R406
R403
R401
R231
R232
W91
W1
R227
R228
W3
W47
W14
W87
W120
C403 C402
W61
C253
W39
C252 C254 C251
W83
C401
R253
W50
R252
W86
W90
W93
W124
R301
C63
W114
W84
R28 R25
R21
R20
R30
R165
R166
R167
R101
R163
R164
R168
R172
R229
R230
R169
R170
R171
X1
X2
W41
W129
R145
W56
R352
R351
R259
R353
R226
R225
W17
R50
L4
L305
L306
L304
L101
L303
L201
C222
C221 C223
C51
C52
C53
C55
C56
C54
C205 C204
C353
C257
C351
C224
C258
C203
C255
C101
C304
C201
C256
C57
C301
C306
W6
W5
W51
W57
W60
W45
W48
W25
W35
W31
W23
W30
W27
W22
W28
W40
W42
W43
W13
W15
C50
W67
W115
W102
W133
W122
W136
W135
W113
W125
W134
W111
W104
W103
W88 W89
W70
W74
W65
W68
W80
W19
W46
W75
W52
W49
W96
W92
W101
W71
W69
W18
W12
W29
W2
W20
W4
W10
W11
W7
W21
W9
W100
W72
W32
W26
W95
W121
W73
W77
W76
W59
W24
W33
W34
W36
W138
W105
W62
W64
W78
W130
W128
W131
W94
W99
W116
W117
W98
W97
W106
W110
W127
W107
W63
W139
L2
W140
W141
W143
R173
R141
W16
916
81
25 1
2
24 2348 9
12 11 13
106157
2
1
1
3
1
24
15
1142
1
21
22 2
1
12
B
E
(FOIL SIDEVIEW)
D19
D20
D5
D6
D7
D4
D1
D2
D3
D8
D12
D17
D18
D9
D10
D11
ED1
D13
X16-1482-7x (J74-1288-12)
X16-1472-7x/
IC2 KI1
KI3 KI4 KI5
KS2
KS3
KS4
KS5
VOL
SRC
ATT
123456
RST CLK TI AUD
AM FM
156
KI2
4 3
1
2
Q1
J1
IC1
D22
D23
D24
X16-1482-7x (J74-1288-12)
X16-1472-7x/
C9
C6
C7
R21
R22
R12
R10
R13
R15
R14
R2
R1
R3
R5
R4
R16
R20
C5
R17
R19
C4
C3
C1
C2
R8
R7
R6
R18
LRES
KS4
KS5
KI1 KI2
KI3
KI4
KI5
KS2
KS3
IGND
DGND
SW5V
WL+B
DATAS
L-CLK
L-CE
DATAL
PAN5V
RES
REMO
DGND
ESDGND
142
115
180
24
41 64 6540
25 BE
X16-1472-7x
X16-1482-7x
IC Q Address
14D
14D
IC Q Address
15F
24H
42H
65I
73E
IC Q Address
84G
11 5E
12 4H
10 3F
20 3G
IC Q Address
40 3I
50 4G
51 3E
55 2E
70 3F
IC Q Address
101 6E
102 6F
201 4I
223 2I
224 2I
IC Q Address
251 3G
X25-9132-7x/9142-7x

ABCDEFGHIJ
1
2
3
4
5
6
7
47K
10K
10K
47K
4.7K 4.7K
22K
22K
ILL+B
ILL+B
ILL+B
ILL+B
ILL+B
BU5V
SW5V
SW5V
SW5V
SW5V
SW5V
SW5V
SW5V
SW5V
SW5V
SW5VSW5V
SW5V
+5V +5V
+5V+5V+5V
+5V
+5V
+5V
+5V
+5V
+5V
ILL+B
ILL+B
ILL+B
BU5V BU5V
BU5V
BU5VBU5VBU5V
BU5V
BU5V
BU5V
AUDIO+B
AUDIO+B
SW5V
FM+B
AM+B
FM+B
AM+B
FM+B
AM+B
AUDIO+B
AUDIO+B
AUDIO+B
AUDIO+B
AUDIO+B AUDIO+B
AUDIO+B
AM+B
FM+B
AM+B
FM+B
+B
+B
+B
+B
+B
+B+B
+B
+B
+B
+B
+B
+B
60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
1
2
3
4
5 6
7
8 9
10
11
12
13
14
15 16
17
18 19 20
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
RESET
M-MUTE
M-RST
M-STOP
LO/EJ
MO SW
LOE/LIM SW
DSI
PS2-1
PS2-0
BEEP
PS1-2
PS1-1
PS1-0
N.C N.C
ACC-DET
B.U-DET
SW 5V
P-STBY
SVR
P-MUTE
MUTE
CLK
DATA
IC2 TYPE0
IC2 TYPE1
VSS 1
TYPE0
TYPE1
TYPE2
TYPE REF
CH-CON
SD
N.C
N.C
N.C
N.C
LO/DX
AFS
PANEL 8EJE SW N.C A VSS L-RST(ONLY 14seg) L-CE AVREF1 N.C PLL-DATA PLL-CLK L-DATAL L-DATAS L-CLK R-DATA R-QUAL CH-DATAC CH-DATAH CH-CLK CH-REQH PLL-CE
REMO
R-CLK
CH-REQC
LO/S SW
KEY-REQ
12EJE SW
VSS 0
VDD 1
X2
X1
IC
XT2
XT1
VDD 0
AVREF0
S-METER
PHONE
NOISE
N.C
AV CONT
1
3 5
7
9
11
13 15
17
19
21
23 25
TAB OUT2- OUT2+ OUT1- OUT1+ IN 1 S GND IN 3 OUT3+ OUT3- OUT4+ OUT4- CD
2 4 6 8 10 12 14 16 18 20 22 24
P GND
STBY
VCC 2
P GND
SVR
IN 2
IN 4
AC GND
P GND
VCC 1
MUTE
P GND
1
2
3
4
5
6
7
8
QUAL
RDDA
VREF
MPX
OSEL
GND
ARI
FI 1 OUT
16
15
14
13
12
11
10
9
RDCL
T57
OSCO
OSCI
VCC
EXTRES
TM
F SEL
1
2
3
4VSS
8
7
6
5
VCC
WP
SCL
SDA
16 15 14 13 12 11 10 9
REAR Lch+
REAR Lch-
REAR Rch-
REAR Rch+
NC
PHONE
NC
B.U.
FRONT Lch+
FRONT Lch-
FRONT Rch-
FRONT Rch+
P-ANT
P-CON
ACC
GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
D OUT
12EJE SW
LO/S SW
MS CLK
MSDA
8EJE SW
N.C
BU 5V
D GND
M MUTE
N.C
M RST
M STOP
AUDIO +B
Lch
GND
Rch
LO/EJ
MO SW
SERVO +B
SERVO GND
LOE/LIM SW
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
RF GND
FM ANT
AM ANT
FM +B
AM +B
AM LO/DX
FM LO/DX
IF SELECT
RDS OUT
REQUEST
K2I-VTH
VCO GND
FM SD OUT
FSD OUT
FM DET OUT
AM DET OUT
COMMON +B
IF GND
HI UPADJ
PLL CE
PLL DATA
PLL CLK
P-ON 5V
DIG GND
4
BU 5V
ILLUM
SW 2
SW 1
11
12
10
9
VCC
AUDIO +B
AM +B
FM +B
8
7
6
5
P-ANT
P-CON
GND
2
3
1
V BU
1 2345678 FUSE
L1
FL+
FL-
RL+
RL-
RR-
FR-
RR+
FR+
3300u16
+
C1
82K
R71
36K
R72
100K
R73
30K
R10
10K
R11
1K
2.2K
R104
R105 470
R121 2.2K R107 2.2K
∗R413
∗R412
R106 100K
R108 2.2K
R58
R110
∗R135 ∗R136
∗R137 ∗R138
∗R139 ∗R140
R113 47K
R115 1K R116 10K
R118 10KR117 1K
R259
R119 47K
38
R114 47K
47K47K
47K 47K
47K47K
4.7K
VSS
4
32
VCC 1
10K
CP1
C103 0.1
R125 1K
CP3
1K 2.2K
CP2
R122 100
R67 10K
R255 33K
47K
100K
R126
R127
R128
R129
R130
15P
C104
6.8K
R131
15P
C105 X1
2.2M
2.2K
R123
1K
2.2K
2.2K
4.19MHz
22K
R134
59
54 57
58 55 56
52
47
41
64
66
63
61
1
5
6
9
10
15
14
11
12
13
20
22
21
27
40
39
2.2K
R353
10P
C356
10P
C355
4.332MHz
C352 330P
10u6.3
+
C351
2.2K
R351
2.2K
R352
X2
+
C353
10u6.3
0.01
C354
14
15
RL+
RL-
FL-
FL+
FR+
RR+
FR-
RR-
C253
0.22u50
4.7K
∗
R253
4.7K
∗
R252
1K
R256
C252
0.22u50
∗
R263
∗
R261
∗
R260
750
∗
R258
3.6K
R257
TH1
4.7K
∗
R254
0.22u50
C254
0.22u50
∗
R251
C251 4.7K
∗
C256
+
1u50
C255
Q251
+
RL
RR
FR
50
FL
39
CH CON
B.U
DATA C
REQ H
MUTE
GND
RST
Rch
A GND
8412
6 A. GND
4
5 MUTE
CH-CON
12 Lch
CLK13
DATA C
DATA H
10
11
2
3B.U
GND
1REQ H Rch
REQ C
8
9
RST7
7311
6210
519
DATA H
REQ C
CLK
Lch
1113
13
1096
12 3
75
24
1
8
R404 100
R405 4.7K R406 4.7K R407 4.7K
4.7
10
R403
R402
R409 4.7K
R401 10
R410 100 R411 100
R408 4.7K
100u10
+
1u50
+
1u50
+
7
5
19
28
16
63
18
17
10u16
C224
+270
R224
100
R232
30K
R228
100
R231
30K
R227
10u16
C223
+270
R223
RL
RR
3
4
2
1
12 11
VDD 13
14
VSS
6 5
7
9 10 8
100K
R415
0.01
∗C404
C40
0.01
R264
10u16
C53
C57 220u16
+
10u25
+
C55 100u16
+
C58
10u50
C56
+
10u16
+
C54
10u16
+
+
C52
10u25
+
C50
22K
47
4.7K
R28
W166
∗
W143
∗
W179
∗
W177
∗
W141
∗
W176
∗
W178
∗
W140
3.3K
R20
10K
R22
33K
R21
1/2W
0.01
C21
100K
R23
100K
R12
47K
R51
5.6K
R50
52
4.7uH
L101
L2
C102 0.01
+
C101
100u6.3
1.5K
R57
+
C63
22u16
47K
R31
0.01
C30
22K
R32 10K
R30
4.7K
R143
4.7K
R141
66
55
SDA
SCL
64
59 58
57
56
54
100K
R144
4 3
2.2K
R145
0.1
C142
0.01
C225
40
41
52mH
L4
L303 4.7uH
L304 4.7uH
0.01
C302
100u10
+
C301
0.01
C303
AM
FM
22
27
76
L305
0.01
C305
+
C304
100u10
R301
2.2
9
20
10
L306
4.7uH
4.7uH
38
60
4.7K
19 18
17
16
28
6
53
42
50
42
76
4
∗
R168 1K
PANEL
ESD-G
L-DATAL
L-DATAS
REMO
SW 5V
L-CE
L-CLK R165 470
R166 1K
R167 100
∗R170 1K
R164 470
∗R171 47
R172 1K
14
15 11
12
13
8
9
10
12
61
11
13
6
LAMP +B
LED +B
RST
L-RES
PAN 5V
ILL-GND
D-GND
R169 1K
4
5
6
7
2
3
10
R163
1
1
5
60
4
32.2u50
0.1
4.7K
R203
AM
FM
4.7K
R202
2.7K
∗W21
4
3
SDA SDA
AFS
15 14
MP OUT
0.1
OUT L
LEVEL
MP IN 13
12
C207
0.015
11
AM
MPX
10
S MUTE
16 QUAL
OUT R
17
18 SCL
19
SCL
CD GND 77
8
9
PH-
CDL 6
5
6
CDR 5
20
22
21
VDD
GND
42.2u50
+
R
C204
+
L
OUT RL
OUT RR
23
26
25
24 OUT FR
OUT FL
RL
RR
FR
FL
VREF
CREF
1C203
2.2u50
C205
2+
28 AC OUT L
AC OUT R
27
0.01
C202
C201
47u10
+
SCL
SDA
21
18
43
44
77
77 43
44
L201
4.7uH
0.47
C206 R201
R101
240
53
R204
1K
R205
4.7K
17
+
C257
1u50
1u50
+
C258
2.2K
R103
C208
C210 0.033
C211 150P
C209
+
C306
10u10
C307
0.01
C309
0.01
100K
100K
∗
R102
C228 0.01
C402
C403
C401
100K
∗R414
R132
C106
4700P
R133
160K
2.2K
18
17
KEY
KEY
+B+B
D12
D11
4.7K
R25
0V
5V
0V
5V
0V
5V
5V
0V 0V
5V
0V
5V 0V
5V 0V
5V
5.0V
0V
5V
0V
0V
5V
5.0V
0V
0V
5V
0V
0V
5V
5.0V
0V or 5.0V
0V or 5.0V
0V or 5.0V
0V
5V
5V
0V
5V
0V
5.0V
0V
0V or 5.0V
0V
5V
0V
5V
5V
0V
5V
0V
5V
0V
0V
5V
0V
5V
0V
5.0V
0V
5.0V
5V
0V
0-4.0V
0.6-4.1V
2.2-4.5V
5V
0V
5V
0V
2.4V
0V
5.0V
7.4V
7.3V
7.2V
7.2V
0V
0V
0V
0V
0V
0V
5.0V
5.0V
0V
0V
0V
0V
0V
0V
5.0V
0V
5.0V
0V
3VDD
1
4
VDD
1357
10.3V
5.0V
14.3V
8.1V
7.9V
8.1V
14.0V
14.0V
0V
7.3V
0V
4.9V
14.4V
0V
7.2V
7.2V
0V
7.2V
7.2V
7.3V
7.3V 0V
7.3V 14.4V
3.4V or 4.1V
0V
7.4V
7.4V
1.0V
4.7V
0V
5.0V
0V
3.5V
8.2V
0V
4.0V
4.1V
4.1V
5.0V
0V
5V
0V
5V
5.0V
0V
or 0V
0V
∗
IC1
∗
IC4
IC6
IC12
∗
A1
IC7
IC11
IC8
IC2
(X25-91XX-XX)
KDC-4021/V/Y/YV (1/2)
KDC-3020R (1/2)
KDC-3021A/G/YA/YG (1/2)
KDC-306A/G/YA/YG (1/2)
KDC-2092RYA/RYG (1/2)
KDC-2021SA/SG (1/2)
∗
C
J2
CN1
Q70 D70
D10
Q10
RESET
D101
RDS DECODER
∗
D267
∗
D261
∗
D265
∗
D263
∗
D268
∗
D264
∗
D262
∗
D266
D252
D253
Q251
J4
D404
Q223 Q224
∗
E
Q40
D40
D50
D14
D13
D20
Q20
Q50
Q51
D51
Q55
SW14V
D30
P1
D103
D104
J5
REAR
POWER
J1
J3
D106 D109
D110
D107
D108
Q102
D201
D202
D102
Q101
SUPPLY
F/E
Q201
D251
D1
POWER
D403
D402
D409 D407
D401
D410
D411
to CD MECHANISM
(BOTTOM VIEW)
PRE OUT
MUTE
DRIVER
Q223,224
PRE OUT
MUTE
POWER IC
SVR SW
MUTE GATE
Q201
NOISE
BUFFER
PANEL
5V SW
SYSTEM
u-COM
E2P ROM
DSI SW
E.VOL & N.C MPX
BU DETECT
ACC DETECT
SURGE
DETECT
SW5V
TEL
MUTE
SERVO
+B AVR

KLMNOPQRST
CAUTION : For continued safety, replace safety critical components only with manufacturer's recommended parts (refer to parts list).
!Indicates safety critical components. To reduce the risk of electric shock, leakage-current or resistance measurements shall be carried out
(exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.
• DC voltages are as measured with a high impedance voltmeter. Values may vary slightly due to variations between individual instruments
or/and units.
+B
RR+
ANT CONT/
GND
RL-
FR+
FR-
FL-
FL+
P. CONT
GRN
VIOL
VIOL/BLK
GRN/BLK
WHT
GRY
GRY/BLK
WHT/BLK
BLU/WHT
RED
BLU/WHT
BLK
6
5
8
7
ACC
PCON
FR-
6
57
8
FL+
RL+
FL-
2
1
4
3
2
1
4
3
FR+
RR+
RR-
98
10
11
7
6
125
134
143
15
16
2
1
TEL MUTE
BUP
A
B
YEL
BRN
RL+
RL-
RR-
RR+
ANT CONT/
GND
RL-
FR+
FR-
FL-
FL+
P. CONT
GRN
VIOL
VIOL/BLK
GRN/BLK
WHT
GRY
GRY/BLK
WHT/BLK
BLU/WHT
RED
BLU/WHT
BLK
6
5
8
7
ACC
PCON
FR-
6
57
8
FL+
RL+
FL-
2
1
4
3
2
1
4
3
FR+
RR+
RR-
98
10
11
7
6
125
134
143
15
16
2
1
TEL MUTE
BUP
A
B
YEL
BRN
RL+
RL-
RR-
KDC-3020R (M)
KDC-4021 (E)
KDC-4021Y (E)
KDC-4021YV (E)
KDC-4021V (E)
427
427
427
MODEL NAME
32-70
42-71
UNIT
42-70
No.
30-21
32-71 33u50
C256
33u50
33u50
TDA7560
TDA7560
TDA7560
E58-0879
E58-0879
E58-0879
KDC-306G (E)
KDC-2092RYA (E)
KDC-3021A (E)
KDC-306A (E)
KDC-3021G (E) 42-75
32-74
42-73
42-74
42-72
NO
NO
NO
33u50
33u50
33u50
TDA7560
TDA7560
TDA7560428
427
427
E58-0879
E58-0879
E58-0879
KDC-3021YA (E) 32-72
KDC-3021YG (E) 32-73
KDC-2092RYG (E) 32-75 NO 33u50 TDA7560428 E58-0879
KDC-306YA (E)
KDC-306YG (E)
KDC-2021SA (E)
KDC-2021SG (E) 42-76 100u50 TDA7386429 E58-0879NO
YES
YES
YES
YES
YES
YES
YES
YES
YES
YES
NO NO
C404
YES
YES
YES
NO
NO
NO
NO
NO
(UPD780058GCXXX)
D261-268 IC1 IC4 J3
YES
YES
YES
YES
YES
YES
YES
CE
32-70
42-71
UNIT
42-70
No.
30-21
32-71 NOYES
YES
YESNO
NO
R138R137
10 4.3K
10
10 4.3K
4.3K
R261 R263
X86-3512-70
X86-3512-70
X86-3512-70
A1 (F/E)
42-75
32-74
42-73
42-74
42-72
X86-3512-70
X86-3512-70
X86-3512-72
10
10
10
4.3K
4.3K
4.3K
32-72
32-73
32-75 X86-3512-72 10 4.3K YES
NO
YES
NO
NO
YES
NO
YES
42-76 YES X86-3522-71 430
220
220
220
220
220
220
220
100 180KNO YES
NO
NO
NO
NO
YES
YES
YES
YES
YES
YES
YES
R139,170,
NO
NO
NO
NO
NO
R140 R258
NO
NO
NO
YES
YES
YES
YES
YES
R251-254,
260
NO
NO
NO
NO
NO
NO
NO
YES
YES
W21,140,
141,176-178
YES
YES
YES
YES
YES
NO
W143
NO
NO
NO
NO
YES
W179
YES
YES
YES
171,412-414
NO
NO
YES
R135
YES
YES
NO
R136
YES
YES
NO
NO
YES
NO
NO YES
R102,
YES
YES
YES
YES
YES
YES
YES
NO NO YES
168
A
(E30-4790-05)
KDC-4021/Y/3021A/G/YA/YG/306A/G/YA/YG/
3020R/2021SA/SG/2092RYA/RYG
DC CORD
(E30-4791-05)
KDC-4021V/YV
DC CORD
(X25-91XX-XX)
: D1F60
D11,13,264,267,268
:
IC1 :
IC4
IC2
∗
TDA7407D
IC8
IC11 HD74HC27FP S-80835ANNP
IC7
IC6 BA4911-V4 TDA7479D
D10,20,70,201,202,401,402
D12,14,261-263,265,266
D30
MA4068(N)-M
1SS133
D1
IC12
1N5393G-M6
BR24C01AF
:
:
:
:
:
::
:
:
:
: AM01Z or
Q10,20,70,201 : 2SC4081 or
Q51
Q50
Q40
UMC2N:2SA1036K:
: DTA124EUA or
: 2SD2375 or
Q55
Q251
Q223,224
Q102
DTC114YUA or:
DTC143TUA or:
: DTA114YUA or
UN5214
UN5216
UN5114
2SD2396
UN5112
2SD1819A
DSM1SD2 or
ERA15-02
∗
2/2
X13-
J1
D40,50,101,103,104,251-253
D102
D51
D106-109,403,404,407,409-411
B30-1567-05:
MA4062-L:
: MA4082(N)-L or
: HZS12A2
D110
HZS9A1L
MA4047-M or
HZS5B1
B LINE
SIGNAL LINE
ISO CONNECTOR
CONNECTOR
MOLEX
ISO CONNECTOR
CONNECTOR
MOLEX
10K
10K
5.0V
3.0V
1.5V
0V
5V
0V
3.9V
0V
0V 5V
ILL-GND
D-GND
L-RES
SW5V
LAMP+B
LED+B
L-DATAS
L-CLK
L-CE
L-DATAL
PAN 5V
RST
PANEL SW
ESD-GND
64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
1
2
3
4
5 6
7
8 9
10
11
12
13
14
15 16
17
18 19 20
21
22
23
24
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
KS6 KS5
KS4
KS3
KS2
S56
COM3
COM2
COM1
S55
S54
S53
S52
S51
S50 S49 S48
S47
S46 S45
S44
S43
S42
S41
S40
S39
S38
S37
S36
S35
S34
S33
S32
S31
S30
S29
S28
S27
S26
S25
GREEN RED KEY S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S17 S18 S19 S20 S21 S22 S23 S24
KI1
KI2
KI3
KI4
KI5
VDD
VDD1
VDD2
VSS
TEST
OSC
L-RES
L-DATA L
L-CE
L-CLK
L-DATA S
KI1
KI2
KI4
KI3
C3 0.047
C1
C2 0.047
R8 56K
0.01
4.7
4.7K
79
80
78
76
77
80
79
77
78
R1 1K
R2 470
R4 470
R5 1K
R3 470
76
KS5
S25
S4
S5 S6
S7
S8 S9
S10
S11
S12
S13
S14
S15 S16
S17
S18 S19 S20
S21
S22
S23
S24
S26
S27
S28
S29
S30
S31
S32
S33
S34
S35
S36
S37
S38
S39
S40
KS4
KS3
KS2
C3
C2
C1
S55
S54
S53
S52
S51
S50 S49 S48
S47
S46 S45
S44
S43
S42
S41
R20
510
R18
510
R17
R16
510
R14
330
R15
330
KI1
KI2
KI3
KI4
KI5
1
2
3
45
6
7
8
9
10
11
12
13
14
15
S56
KS2
KS3
KS4
KS5
KI5
R19
0.01
C9
220
R21 220 R22
KDC-3021A (E)
MODEL NAME
X16-1482-72
X16-1472-72
X16-1482-73
UNIT No.
B30-1567-05
B30-1533-05
D1-13,
X16-1472-73
B30-1567-05
B30-1533-05
1000P
+B
+B
+5V
+5V
TP35
TP32
TP31
TP30
TP29
TP27
TP28
TP26
TP24
TP23
TP22
TP21
TP5
TP4
TP3
TP1
TP2
TP9 TP8 TP6TP7
TP15
TP14
TP13
TP12
TP11
TP16 TP17 TP18 TP19
R6 47K
TP34
510
510
KDC-306YA (E)
KDC-3021G (E)
KDC-306G (E)
KDC-306YG (E)
+B
R10
C4
R7
17,18,20
KDC-306A (E)
KDC-2092RYA (E)
KDC-2092RYG (E)
KDC-3021YG (E)
KDC-3021YA (E) (RED)
(GREEN)
(RED)
(GREEN)
S42
14
S12
S10
S8 S9
15 16
S11
17 18
S14
S13
19 20
S15
21 22
S45
S47
S16
S17
23 24
S48
25 26
S44
S46
27 28
S41
29 30
S27
S19
S37
S39 S40
31 32
S38
33 34
S35 S36
35 36
S18
37 38
S23
S21
S20
39 40
S22
41 42
S25
S24
43 44
S26
45 46
S29 S28
47 48
S30
49 50 51 S31
S32
52 S33 54 55 56 1 2S51
S43
6 4 3 5 7 8
S55 S56 S53
S52
S54
S49
10 9 11 13 12
S4
S50
S5 S6
S7
S34
53
14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 1 2 6 4 3 5 7 8 10 9 11 13 12 53
56 55 54
C2
C1
C3
IC1
SWITCH UNIT (X16-14XX-XX)
KDC-3021A/G/YA/YG/306A/G/YA/YG/2092RYA/RYG (2/2)
A
ED1 (SEGMENT)ED1 (COMMON)
J1 Q1
:
∗
D1-13,17,18.20
Q1 : DTA114EUA
IC1 : LC75883E
J3
X14-
1/2
KEY DETECT
SW
RST
D22
LCD DRIVER
VOL+
VOL-
SRC
AUD
TI
CLK
ATT
1
2
43
5
6FM
AM
: MA3062WA
: B30-1633-05
D22
D19
D19
S3
S4
S5
S6
S2
S1
S7
S8
S21
S20
S19
S18
S9
S10
S11
S12
S16
S15
S14 S13
S26
S22
S27
S23
S25
S24
S17
B LINE
GND LINE
∗
D18
∗
D17
∗
D7
∗
D8
∗
D2
∗
D1
∗
D3
∗
D6
∗
D5
∗
D4
∗
D20
∗
D9
∗
D12
∗
D13
∗
D11
∗
D10
2SD2396 DTC114YUA
DTC143TUA
UN5111
UN5114
UN5214
UN5216
2SA1036K
2SD1819A
2SC4081 DTA114EUA
DTA124EUA UMC2N DTA114YUA BR24C01AF BR24C01AF-W TDA7479D

11
EXPLODED VIEW
Parts with the exploded numbers larger than 700 are not supplied.
KDC-2092RYA/RYG,3021A/G/YA/YG,
306A/G/YA/YG
AB
1
2
3
ED1
(X25)
J2
J5
J1
A1
J3
Dx2
Fx2
F
A
A
E
E
D
D
G
D
D
C
H
C
C
C
D
B
B
DME1
PA1
KDC-2021SA/3021A
A
B
C
D
E
F
G
H
M3x8
φ2x6
φ2x8 (BLK)
φ3x5
φ3x10
φ3x20
φ2.6x6
φ1.5 RING
: N30-3008-46
: N80-2006-46
: N80-2008-45
: N83-3005-46
: N80-3010-46
: N83-3020-46
: N86-2606-46
: N29-0205-04
FC1
755
753
206
F1
210
702
722
717
743
229
215x2
DC1
201
242
708
728
751 742
X16
704
236
237
235
232 226
233
249 245
246
250
248 218
234
211
238
(X16)
205
216
213 224
203
214
225

12
KDC-2092RYA/RYG,3021A/G/YA/YG,
306A/G/YA/YG
!
Indicates safety critical components.
✽New parts
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert.
Ref. No. A
d
d
N
e
wParts No. Description Desti-
nation Ref. No. A
d
d
N
e
wParts No. Description Desti-
nation
E0 : KDC-3021A E4 :KDC-2092RYA E6 : KDC-306A
E1 : KDC-3021G E5 :KDC-2092RYG E7 : KDC-306G
E2 : KDC-3021YA E8 : KDC-306YA
E3 : KDC-3021YG E9 : KDC-306YG
201 1A A02-1486-13 PLASTIC CABINET ASSY
203 1A A22-2863-03 SUB PANEL ASSY
205 2A ✽ A46-1750-01 REAR COVER
206 1B ✽ A52-0804-02 TOP PLATE
PA1 3A ✽ A64-2553-02 PANEL ASSY E0E1
PA1 3A ✽ A64-2553-02 PANEL ASSY E2E3
PA1 3A ✽ A64-2563-02 PANEL ASSY E4E5
PA1 3A ✽ A64-2565-02 PANEL ASSY E6E7
PA1 3A ✽ A64-2565-02 PANEL ASSY E8E9
210 3B B07-3054-02 ESCUTCHEON
211 3A ✽ B10-4139-01 FRONT GLASS E0E1
211 3A ✽ B10-4139-01 FRONT GLASS E2E3
211 3A ✽ B10-4140-01 FRONT GLASS E4E5
211 3A ✽ B10-4142-01 FRONT GLASS E6E7
211 3A ✽ B10-4142-01 FRONT GLASS E8E9
- B46-0100-50 WARRANTY CARD E0E1
- B46-0100-50 WARRANTY CARD E6E7
- B46-0182-14 ID CARD E0E1
- B46-0182-14 ID CARD E6E7
- B46-0606-04 ID CARD E2E3E4
- B46-0606-04 ID CARD E5E8E9
- B58-1365-04 CAUTION CARD
- ✽ B64-2112-00 INSTRUCTION MANUAL (ENGLISH) E0E1
- ✽ B64-2112-00 INSTRUCTION MANUAL (ENGLISH) E6E7
- ✽ B64-2113-00 INSTRUC.MANUAL (FRE.GER.ITA.) E0E1
- ✽ B64-2113-00 INSTRUC.MANUAL (FRE.GER.ITA.) E6E7
- ✽ B64-2119-00 INSTRUC. MANUAL (ENG.RUS.POL.) E2E3E4
- ✽ B64-2119-00 INSTRUC. MANUAL (ENG.RUS.POL.) E5E8E9
- ✽ B64-2120-00 INSTRUC. MANUAL (CZE.HUN.CRO.) E2E3E4
- ✽ B64-2120-00 INSTRUC. MANUAL (CZE.HUN.CRO.) E5E8E9
- ✽ B64-2121-00 INSTRUCTION MANUAL (SWE.FIN.) E2E3E4
- ✽ B64-2121-00 INSTRUCTION MANUAL (SWE.FIN.) E5E8E9
- ✽ B64-2231-00 INSTRUC. MANUAL (DUT.SPA.POR.) E0E1
- ✽ B64-2231-00 INSTRUC. MANUAL (DUT.SPA.POR.) E6E7
213 1A D10-4446-03 LEVER
214 2A D10-4447-03 LEVER
215 1A D10-4589-04 LEVER
216 1A D21-2329-04 SHAFT
218 2A ✽ E29-1872-02 CONDUCTIVE RUBBER
DC1 1A E30-4790-05 DC CORD
FC1 2A E39-0343-05 FLAT CABLE
F1 2B F52-0006-05 FUSE (MINI BLADETYPE)
224 1A ✽ G01-2987-04 TORSION COIL SPRING
225 1A ✽ G01-3096-04 EXTENSION SPRING
226 3A ✽ G01-3149-04 COMPRESSION SPRING
- ✽ H10-4800-02 POLYSTYRENE FOAMED FIXTURE E0E1
- ✽ H10-4800-02 POLYSTYRENE FOAMED FIXTURE E6E7
- ✽ H10-4801-02 POLYSTYRENE FOAMED FIXTURE E2E3E4
- ✽ H10-4801-02 POLYSTYRENE FOAMED FIXTURE E5E8E9
- H25-0329-04 PROTECTION BAG (280X450X0.03) E2E3E4
- H25-0329-04 PROTECTION BAG (280X450X0.03) E5E8E9
- H25-0337-04 PROTECTION BAG (180X300X0.03)
- H25-1111-04 PROTECTION BAG (280X450X0.03) E0E1
- H25-1111-04 PROTECTION BAG (280X450X0.03) E6E7
- ✽ H54-2280-03 ITEM CARTON CASE E2
- ✽ H54-2281-03 ITEM CARTON CASE E3
- ✽ H54-2282-03 ITEM CARTON CASE E4
- ✽ H54-2287-03 ITEM CARTON CASE E0
- ✽ H54-2288-03 ITEM CARTON CASE E1
- ✽ H54-2305-03 ITEM CARTON CASE E6
- ✽ H54-2350-03 ITEM CARTON CASE E5
- ✽ H54-2430-03 ITEM CARTON CASE E7
- ✽ H54-2485-03 ITEM CARTON CASE E8
- ✽ H54-2486-03 ITEM CARTON CASE E9
229 1A J21-9641-13 MOUNTING HARDWARE ASSY
232 3A ✽ K24-3822-04 KNOB (RELEASE)
233 3A ✽ K24-3823-04 KNOB (SRC)
234 3A ✽ K24-3824-04 KNOB (AUD)
235 3A ✽ K24-3825-03 KNOB (VOL)
236 3A ✽ K24-3826-04 KNOB (EJECT)
237 3A ✽ K25-1396-03 KNOB (PRE1-6,ATT,RESET)
238 3A ✽ K25-1397-03 KNOB (AUTO,CLK,FM,AM)
A 3B N30-3008-46 PAN HEAD MACHINE SCREW
B 3A N80-2006-46 PAN HEAD TAPTITE SCREW
C 2A N80-2008-45 PAN HEAD TAPTITE SCREW
D 1B N83-3005-46 PAN HEAD TAPTITE SCREW
H 1A N29-0205-04 RETAINING RING (1.5)
242 1A T90-0523-05 ANTENNA ADAPTOR
DME1 1B ✽ X92-4030-00 MECHANISM ASSY E2E3E4
DME1 1B ✽ X92-4030-00 MECHANISM ASSY E5E8E9
DME1 1B ✽ X92-4030-01 MECHANISM ASSY E0E1
DME1 1B ✽ X92-4030-01 MECHANISM ASSY E6E7
245 2A ✽ B11-1358-04 OPTICAL DIFFUSER
246 2A ✽ B11-1359-04 REFLECTION SHEET
248 2A ✽ B19-2130-03 LIGHTING BOARD
D1-13 B30-1533-05 LED (1608,PG) E1E7
D1-13 B30-1533-05 LED (1608,PG) E3E5E9
D1-13 B30-1567-05 LED (1608,RED) E0E6
D1-13 B30-1567-05 LED (1608,RED) E2E4E8
D17,18 B30-1533-05 LED (1608,PG) E1E7
D17,18 B30-1533-05 LED (1608,PG) E3E5E9
D17,18 B30-1567-05 LED (1608,RED) E0E6
D17,18 B30-1567-05 LED (1608,RED) E2E4E8
D19 B30-1633-05 LED (WHITE)
D20 B30-1533-05 LED (1608,PG) E1E7
D20 B30-1533-05 LED (1608,PG) E3E5E9
D20 B30-1567-05 LED (1608,RED) E0E6
D20 B30-1567-05 LED (1608,RED) E2E4E8
ED1 ✽ B38-1083-05 LIQUID CRYSTAL
C1 CK73GB1H102K CHIP C 1000PF K
C2,3 CK73GB1E473K CHIP C 0.047UF K
C2,3 CK73GB1H473K CHIP C 0.047UF K
KDC-2092RYA/RYG,3021A/G/YA/YG, 306A/G/YA/YG
SWITCH UNIT (X16-1472-7x/1482-7x)
PARTS LIST
!
!

KDC-2092RYA/RYG,3021A/G/YA/YG,
306A/G/YA/YG
13
PARTS LIST
SWITCH UNIT (X16-1472-7x/1482-7x)
!
Indicates safety critical components.
Ref. No. A
d
d
N
e
wParts No. Description Desti-
nation Ref. No. A
d
d
N
e
wParts No. Description Desti-
nation
E0 : KDC-3021A E4 :KDC-2092RYA E6 : KDC-306A
E1 : KDC-3021G E5 :KDC-2092RYG E7 : KDC-306G
E2 : KDC-3021YA E8 : KDC-306YA
E3 : KDC-3021YG E9 : KDC-306YG
✽New parts
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert.
C4 CK73GB1H103K CHIP C 0.010UF K
C9 CK73GB1H103K CHIP C 0.010UF K
249 2A E29-1829-04 CONDUCTIVE RUBBER
250 2A E29-1834-04 CONDUCTIVE RUBBER
J1 E59-0828-05 RECTANGULAR PLUG
- ✽ J19-5130-04 HOLDER (LED)
R1 RK73GB2A102J CHIP R 1.0K J 1/10W
R2-4 RK73GB2A471J CHIP R 470 J 1/10W
R5 RK73GB2A102J CHIP R 1.0K J 1/10W
R6 RK73GB2A473J CHIP R 47K J 1/10W
R7 RK73GB2A472J CHIP R 4.7K J 1/10W
R8 RK73GB2A563J CHIP R 56K J 1/10W
R10 RK73GB2A4R7J CHIP R 4.7 J 1/10W
R14,15 RK73FB2B331J CHIP R 330 J 1/8W
R16-20 RK73FB2B511J CHIP R 510 J 1/8W
R21,22 RK73FB2B221J CHIP R 220 J 1/8W
D22 MA3062WA ZENER DIODE
IC1 LC75883E MOS-IC
Q1 DTA114EUA DIGITAL TRANSISTOR
Q1 UN5111 DIGITAL TRANSISTOR
D102 B30-1567-05 LED (1608,RED)
C1 C90-5242-05 ELECTRO 3300UF 16WV
C21 CK73GB1H103K CHIP C 0.010UF K
C30 CK73GB1H103K CHIP C 0.010UF K
C40 CK73GB1H103K CHIP C 0.010UF K
C50 CE04NW1E100M ELECTRO 10UF 25WV
C52-54 CE04NW1C100M ELECTRO 10UF 16WV
C55 CE04NW1E100M ELECTRO 10UF 25WV
C56 CE04CW1H100M ELECTRO 10UF 50WV
C57 C90-2980-05 ELECTRO 220UF 16WV
C58 C90-2962-05 ELECTRO 100UF 16WV
C63 CE04NW1C220M ELECTRO 22UF 16WV
C101 CE04NW0J101M ELECTRO 100UF 6.3WV
C102 CK73GB1H103K CHIP C 0.010UF K
C103 CK73GB1C104K CHIP C 0.10UF K
C103 CK73GB1H104K CHIP C 0.10UF K
C104,105 CC73GCH1H150J CHIP C 15PF J
C106 CK73GB1H472K CHIP C 4700PF K
C142 CK73GB1C104K CHIP C 0.10UF K
C142 CK73GB1H104K CHIP C 0.10UF K
C201 CE04NW1A470M ELECTRO 47UF 10WV
C202 CK73GB1H103K CHIP C 0.010UF K
C203-205 CE04NW1H2R2M ELECTRO 2.2UF 50WV
C206 CK73GB1H153K CHIP C 0.015UF K
C207 CK73GB1A474K CHIP C 0.47UF K
C208,209 CK73GB1C104K CHIP C 0.10UF K
C208,209 CK73GB1H104K CHIP C 0.10UF K
C210 CK73GB1E333K CHIP C 0.033UF K
C210 CK73GB1H333K CHIP C 0.033UF K
C211 CC73GCH1H151J CHIP C 150PF J
C223,224 C90-2597-05 ELECTRO 10UF 16WV
C225 CK73GB1H103K CHIP C 0.010UF K
C228 CK73GB1H103K CHIP C 0.010UF K
C251-254 C90-5296-05 NP-ELECT 0.22UF 50WV
C255 CE04NW1H010M ELECTRO 1.0UF 50WV
C256 CE04NW1A330M ELECTRO 33UF 10WV
C257 CE04NW1H010M ELECTRO 1.0UF 50WV
C258 C90-2935-05 ELECTRO 1.0UF 50WV
C301 CE04NW1A101M ELECTRO 100UF 10WV
C302,303 CK73GB1H103K CHIP C 0.010UF K
C304 CE04CW1A101M ELECTRO 100UF 10WV
C305 CK73GB1H103K CHIP C 0.010UF K
C306 C90-2594-05 ELECTRO 10UF 10WV
C307 CK73GB1H103K CHIP C 0.010UF K
C309 CK73GB1H103K CHIP C 0.010UF K E2E3E8
C309 CK73GB1H103K CHIP C 0.010UF K E6E7
C309 CK73GB1H103K CHIP C 0.010UF K E9E0E1
C309,310 CK73GB1H103K CHIP C 0.010UF K E4E5
C351 C90-2592-05 ELECTRO 10UF 6.3WV
C352 CC73GCH1H331J CHIP C 330PF J
C353 C90-2592-05 ELECTRO 10UF 6.3WV
C354 CK73GB1H103K CHIP C 0.010UF K
C355,356 CC73GCH1H100D CHIP C 10PF D
CN1 E40-9550-05 FLAT CABLE CONNECTOR
J1 E04-0312-05 RF COAXIAL CABLE RECEPTACLE
J2 E58-0863-15 RECTANGULAR RECEPTACLE
J3 E58-0879-05 RECTANGULAR RECEPTACLE
J5 E63-0852-05 PIN JACK
L1 L33-1170-05 CHOKE COIL ASSY
L2 L33-1807-05 CHOKE COIL
L4 L33-1123-05 LINE FILTER COIL
L101 L40-4795-91 SMALL FIXED INDUCTOR (4.7UH,J)
L201 L40-4795-91 SMALL FIXED INDUCTOR (4.7UH,J)
L303-306 L40-4795-91 SMALL FIXED INDUCTOR (4.7UH,J)
X1 L77-1167-05 CRYSTAL RESONATOR (4.19M)
X2 L77-2002-05 CRYSTAL RESONATOR
D 2B N83-3005-46 PAN HEAD TAPTITE SCREW
E 2B N80-3010-46 PAN HEAD TAPTITE SCREW
F 2B N83-3020-46 PAN HEAD TAPTITE SCREW
G 2B N86-2606-46 BINDING HEAD TAPTITE SCREW
CP1 R90-1056-05 MULTIPLE RESISTOR
CP2 R90-1047-05 MULTIPLE RESISTOR
CP3 R90-1046-05 MULTIPLE RESISTOR
R10 RK73FB2B303J CHIP R 30K J 1/8W
R11 RK73GB2A103J CHIP R 10K J 1/10W
R12 RK73GB2A104J CHIP R 100K J 1/10W
R20 RD14DB2H332J SMALL-RD 3.3K J 1/2W
R22 RK73GB2A103J CHIP R 10K J 1/10W
R23 RK73GB2A104J CHIP R 100K J 1/10W
R31 RK73GB2A473J CHIP R 47K J 1/10W
R32 RK73GB2A223J CHIP R 22K J 1/10W
R51 RK73GB2A473J CHIP R 47K J 1/10W
R57 RK73FB2B152J CHIP R 1.5K J 1/8W
R58 RK73GB2A472J CHIP R 4.7K J 1/10W
R67 RK73GB2A103J CHIP R 10K J 1/10W
!
ELECTRIC UNIT (X25-9132-7x/9142-7x)

KDC-2092RYA/RYG,3021A/G/YA/YG,
306A/G/YA/YG
14
PARTS LIST
ELECTRIC UNIT (X25-9132-7x/9142-7x)
!
Indicates safety critical components.
✽New parts
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert.
Ref. No. A
d
d
N
e
wParts No. Description Desti-
nation Ref. No. A
d
d
N
e
wParts No. Description Desti-
nation
E0 : KDC-3021A E4 : KDC-2092RYA E6 : KDC-306A
E1 : KDC-3021G E5 : KDC-2092RYG E7 : KDC-306G
E2 : KDC-3021YA E8 :KDC-306YA
E3 : KDC-3021YG E9 : KDC-306YG
R71 ✽ RK73GB2A823J CHIP R 82K J 1/10W
R72 ✽ RK73GB2A363J CHIP R 36K J 1/10W
R73 RK73GB2A104J CHIP R 100K J 1/10W
R102 RK73GB2A102J CHIP R 1.0K J 1/10W
R103,104 RK73GB2A222J CHIP R 2.2K J 1/10W
R105 RK73GB2A471J CHIP R 470 J 1/10W
R106 RK73GB2A104J CHIP R 100K J 1/10W
R107,108 RK73GB2A222J CHIP R 2.2K J 1/10W
R110 RK73GB2A472J CHIP R 4.7K J 1/10W
R113,114 RK73GB2A473J CHIP R 47K J 1/10W
R115 RK73GB2A102J CHIP R 1.0K J 1/10W
R116 RK73GB2A103J CHIP R 10K J 1/10W
R117 RK73GB2A102J CHIP R 1.0K J 1/10W
R118 RK73GB2A103J CHIP R 10K J 1/10W
R119 RK73GB2A473J CHIP R 47K J 1/10W
R121 RK73GB2A222J CHIP R 2.2K J 1/10W
R122 RK73GB2A101J CHIP R 100 J 1/10W
R123 RK73GB2A102J CHIP R 1.0K J 1/10W
R125 RK73GB2A102J CHIP R 1.0K J 1/10W
R126 RK73GB2A104J CHIP R 100K J 1/10W
R127 RK73GB2A222J CHIP R 2.2K J 1/10W
R128 RK73GB2A225J CHIP R 2.2M J 1/10W
R129,130 RK73GB2A222J CHIP R 2.2K J 1/10W
R131 RK73GB2A682J CHIP R 6.8K J 1/10W
R132 RK73GB2A223J CHIP R 22K J 1/10W
R133 RK73GB2A164J CHIP R 160K J 1/10W
R134 RK73GB2A222J CHIP R 2.2K J 1/10W
R135 RK73GB2A473J CHIP R 47K J 1/10W E0E6
R135 RK73GB2A473J CHIP R 47K J 1/10W E2E4E8
R136 RK73GB2A473J CHIP R 47K J 1/10W E1E7
R136 RK73GB2A473J CHIP R 47K J 1/10W E3E5E9
R138 RK73GB2A473J CHIP R 47K J 1/10W
R140 RK73GB2A473J CHIP R 47K J 1/10W
R143 RK73GB2A472J CHIP R 4.7K J 1/10W
R144 RK73GB2A104J CHIP R 100K J 1/10W
R201 RK73GB2A272J CHIP R 2.7K J 1/10W
R202,203 RK73GB2A472J CHIP R 4.7K J 1/10W
R204 RK73GB2A102J CHIP R 1.0K J 1/10W
R205 RK73GB2A472J CHIP R 4.7K J 1/10W
R223,224 RK73FB2B271J CHIP R 270 J 1/8W
R255 RK73GB2A333J CHIP R 33K J 1/10W
R256 RK73FB2B102J CHIP R 1.0K J 1/8W
R257 ✽ RK73GB2A362J CHIP R 3.6K J 1/10W
R258 ✽ RK73GB2A221J CHIP R 220 J 1/10W
R261 ✽ RK73GB2A100J CHIP R 10 J 1/10W
R263 RK73GB2A432J CHIP R 4.3K J 1/10W
R264 RK73GB2A473J CHIP R 47K J 1/10W
R415 RK73GB2A104J CHIP R 100K J 1/10W
W150 R92-1252-05 CHIP R 0 OHM J 1/16W
W151 R92-2053-05 CHIP R 0 J 1/8W
W152 R92-1252-05 CHIP R 0 OHM J 1/16W
W155 R92-1252-05 CHIP R 0 OHM J 1/16W
W156,157 R92-2053-05 CHIP R 0 J 1/8W
W158,159 R92-1252-05 CHIP R 0 OHM J 1/16W
W160-165 R92-2053-05 CHIP R 0 J 1/8W
W166-169 R92-1252-05 CHIP R 0 OHM J 1/16W
W171-174 R92-1252-05 CHIP R 0 OHM J 1/16W
W176-178 R92-1252-05 CHIP R 0 OHM J 1/16W
W179 R92-2052-05 CHIP R 0 OHM J 1/10W E2E3E8
W179 R92-2052-05 CHIP R 0 OHM J 1/10W E6E7
W179 R92-2052-05 CHIP R 0 OHM J 1/10W E9E0E1
D1 S2V20✽A DIODE
D1 1N5393G-M6 DIODE
D10 MA4068(N)-M ZENER DIODE
D11 D1F60 DIODE
D12 AM01Z DIODE
D12 DSM1SD2 DIODE
D12 ERA15-02 DIODE
D13 D1F60 DIODE
D14 AM01Z DIODE
D14 DSM1SD2 DIODE
D14 ERA15-02 DIODE
D20 MA4068(N)-M ZENER DIODE
D30 HZS5B1 ZENER DIODE E2E3E4
D30 HZS5B1 ZENER DIODE E5E8E9
D30 MA4047-M ZENER DIODE
D40 1SS133 DIODE
D50 1SS133 DIODE
D51 HZS9A1L ZENER DIODE E2E3E4
D51 HZS9A1L ZENER DIODE E5E8E9
D51 MA4082(N)-L ZENER DIODE
D70 MA4068(N)-M ZENER DIODE
D101 1SS133 DIODE
D103,104 1SS133 DIODE
D106-109 HZS6C1 ZENER DIODE E2E3E4
D106-109 HZS6C1 ZENER DIODE E5E8E9
D106-109 MA4062-L ZENER DIODE
D110 ✽ HZS12A2 ZENER DIODE
D201,202 MA4068(N)-M ZENER DIODE
D251-253 1SS133 DIODE
D261-263 AM01Z DIODE
D261-263 DSM1SD2 DIODE
D261-263 ERA15-02 DIODE
D264 D1F60 DIODE E0E1E6
D264 D1F60 DIODE E7
D264 ✽ S1J DIODE
D265,266 AM01Z DIODE
D265,266 DSM1SD2 DIODE
D265,266 ERA15-02 DIODE
D267,268 D1F60 DIODE E0E1E6
D267,268 D1F60 DIODE E7
D267,268 ✽ S1J DIODE
IC1 ✽ UPD780058GC427 MI-COM IC E2E3E8
IC1 ✽ UPD780058GC427 MI-COM IC E6E7
IC1 ✽ UPD780058GC427 MI-COM IC E9E0E1
IC1 UPD780058GC428 MI-COM IC E4E5
IC2 TDA7407D ANALOGUE IC
IC4 ✽ TDA7560 ANALOGUE IC
IC6 TDA7479D ANALOGUE IC

KDC-2092RYA/RYG,3021A/G/YA/YG,
306A/G/YA/YG
15
PARTS LIST
!
Indicates safety critical components.
✽New parts
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert.
Ref. No. A
d
d
N
e
wParts No. Description Desti-
nation Ref. No. A
d
d
N
e
wParts No. Description Desti-
nation
E0 : KDC-3021A E4 :KDC-2092RYA E6 : KDC-306A
E1 : KDC-3021G E5 :KDC-2092RYG E7 : KDC-306G
E2 : KDC-3021YA E8 : KDC-306YA
E3 : KDC-3021YG E9 : KDC-306YG
IC7 BA4911-V4 ANALOGUE IC
IC8 HD74HC27FP MOS-IC
IC11 S-80835ANNP MOS-IC
IC12 BR24C01AF MEMORY IC
IC12 BR24C01AF-W MEMORY IC E2E3E4
IC12 BR24C01AF-W MEMORY IC E5E8E9
IC12 M24C01-WMN6T MEMORY IC
IC12 S-24C01B MEMORY IC
Q10 2SC4081 TRANSISTOR
Q10 2SD1819A TRANSISTOR E2E3E4
Q10 2SD1819A TRANSISTOR E5E8E9
Q20 2SC4081 TRANSISTOR
Q20 2SD1819A TRANSISTOR E2E3E4
Q20 2SD1819A TRANSISTOR E5E8E9
Q40 DTA124EUA DIGITAL TRANSISTOR
Q40 UN5112 DIGITAL TRANSISTOR E2E3E4
Q40 UN5112 DIGITAL TRANSISTOR E5E8E9
Q50 2SA1036K TRANSISTOR
Q51 UMC2N TRANSISTOR
Q55 2SD2375 TRANSISTOR
Q55 2SD2396 TRANSISTOR
Q70 2SC4081 TRANSISTOR
Q70 2SD1819A TRANSISTOR E2E3E4
Q70 2SD1819A TRANSISTOR E5E8E9
Q101 2SC4081 TRANSISTOR
Q101 2SD1819A TRANSISTOR E2E3E4
Q101 2SD1819A TRANSISTOR E5E8E9
Q102 DTA114YUA DIGITAL TRANSISTOR
Q102 UN5114 DIGITAL TRANSISTOR E2E3E4
Q102 UN5114 DIGITAL TRANSISTOR E5E8E9
Q201 2SC4081 TRANSISTOR
Q201 2SD1819A TRANSISTOR E2E3E4
Q201 2SD1819A TRANSISTOR E5E8E9
Q223,224 DTC143TUA DIGITAL TRANSISTOR
Q223,224 UN5216 DIGITAL TRANSISTOR E2E3E4
Q223,224 UN5216 DIGITAL TRANSISTOR E5E8E9
Q251 DTC114YUA DIGITAL TRANSISTOR
Q251 UN5214 DIGITAL TRANSISTOR E2E3E4
Q251 UN5214 DIGITAL TRANSISTOR E5E8E9
TH1 PTH9C42BE471Q POSITIVE RESISTOR
A1 ✽ X86-3512-70 FRONT-END UNIT E2E3E8
A1 ✽ X86-3512-70 FRONT-END UNIT E9
A1 ✽ X86-3512-72 FRONT-END UNIT E4E5
A1 X86-3522-71 FRONT-END UNIT E0E1E6
A1 X86-3522-71 FRONT-END UNIT E7
ELECTRIC UNIT (X25-9132-7x/9142-7x)

KDC-2092RYA/RYG,3021A/G/YA/YG,
306A/G/YA/YG SPECIFICATIONS
KENWOOD CORPORATION
14-6, Dogenzaka 1-chome, Shibuya-ku, Tokyo 150-8501 Japan
KDC-3021A/G/YA/YG, KDC-306A/G/YA/YG
KDC-2092RYA/RYG
FM
Frequency Range ................................................ 65MHz~74MHz
Frequency step ................................................................... 30kHz
Frequency Range ........................................ 87.5MHz~108.0MHz
Frequency step ................................................................... 50kHz
Usable Sensitivity (S/N 26dB)
65MHz~74MHz ....................................................... 1.4µV/75Ω
87.5MHz~108.0MHz............................................... 0.7µV/75Ω
Quieting Sensitivity (S/N 46dB)
65MHz~74MHz ....................................................... 1.4µV/75Ω
87.5MHz~108.0MHz............................................... 1.6µV/75Ω
Frequency Response (±3.0dB) ............................... 30Hz~15kHz
S/N (dB) ................................................................. 65dB (MONO)
Selectivity (DIN) (dB)........................................ ≥80dB (±400kHz)
Stereo Separation
65MHz~74MHz ....................................................not specified
87.5MHz~108.0MHz............................................ 35dB (1kHz)
MW
Frequency Range (kHz) .................................. 531kHz~1611kHz
(Frequency step) (9kHz)
Usable Sensitivity (S/N 20dB) .............................................. 25µv
LW
Frequency Range (kHz) .....................................153kHz~281kHz
Usable Sensitivity (S/N 20dB) .............................................. 45µv
CD
Laser Diode ................................................... GaAlAs (λ=780nm)
Digital Filter (D/A) .................................... 8 times Over Sampling
D/A Converter ........................................................................ 1 Bit
Spindle Speed ...................................................... 500~200 (CLV)
Wow & Flutter ...........................................Below Mesurable Limit
Frequency Respons.......................................... 10~20kHz (±1dB)
THD......................................................................... 0.01% (1kHz)
S/N Ratio (dB)........................................................... 96dB (1kHz)
Dynamic Range .................................................................... 93dB
Channel Speparation............................................................ 85dB
Preout Level (mV)/Load .......................1800mV/10kΩ(CD/CD-CH)
Preout Impedance (Ω)............................................................≤600Ω
AMP
Maximum Power ................................................................. 50wx4
Power (DIN 45324, +B=14.4V) ........................................... 30wx4
TONE
Bass ......................................................................... 100Hz±10dB
Middle .........................................................................1kHz±10dB
Treble ........................................................................10kHz±10dB
GENERAL
Operating voltage (11~16v allowable)................................. 14.4V
Current Consumption ............................................................. 10A
Installation Size (Width) ............................182mm (7-3/16 inch)
(Height) .............................53mm (2-1/16 inch)
(Depth)............................157mm (6-3/16 inch)
Weight .................................................................... 3.1 lbs (1.4kg)
FM
Frequency Range ........................................ 87.5MHz~108.0MHz
Frequency step ................................................................... 50kHz
Usable Sensitivity (S/N 26dB) ..................................... 0.7µV/75Ω
Quieting Sensitivity (S/N 46dB) ................................... 1.6µV/75Ω
Frequency Response (±3.0dB) ............................... 30Hz~15kHz
S/N (dB) ................................................................. 65dB (MONO)
Selectivity (DIN) (dB) ........................................ ≥80dB (±400kHz)
Stereo Separation..................................................... 35dB (1kHz)
MW
Frequency Range (kHz) .................................. 531kHz~1611kHz
(Frequency step) (9kHz)
Usable Sensitivity (S/N 20dB) .............................................. 25µv
LW
Frequency Range (kHz) .....................................153kHz~281kHz
Usable Sensitivity (S/N 20dB) .............................................. 45µv
CD
Laser Diode ................................................... GaAlAs (λ=780nm)
Digital Filter (D/A) .................................... 8 times Over Sampling
D/A Converter ........................................................................ 1 Bit
Spindle Speed ...................................................... 500~200 (CLV)
Wow & Flutter ...........................................Below Mesurable Limit
Frequency Respons..........................................10~20kHz (±1dB)
THD......................................................................... 0.01% (1kHz)
S/N Ratio (dB)........................................................... 96dB (1kHz)
Dynamic Range .................................................................... 93dB
Channel Speparation ............................................................85dB
Preout Level (mV)/Load ................................... 1800mV/10kΩ(CD)
Preout Impedance (Ω) ............................................................≤600Ω
AMP
Maximum Power ................................................................. 50wx4
Power (DIN 45324, +B=14.4V)........................................... 30wx4
TONE
Bass ......................................................................... 100Hz±10dB
Middle .........................................................................1kHz±10dB
Treble ........................................................................10kHz±10dB
GENERAL
Operating voltage (11~16v allowable)................................. 14.4V
Current Consumption ............................................................. 10A
Installation Size (Width) ............................182mm (7-3/16 inch)
(Height).............................53mm (2-1/16 inch)
(Depth)............................157mm (6-3/16 inch)
Weight .................................................................... 3.1 lbs (1.4kg)
follows a policy of continuous advancements in development. For this reason specifications may be changed without notice.