Kenwood KID60S10 Service manual

Dishwasher
KID60S10
installation / instructions manual
KID60S10_IB_110426.indd 1 4/27/11 5:46 PM

KID60S10_IB_110426.indd 2 4/27/11 5:46 PM

contents
unpacking............................................................................................................................ 5
Installation........................................................................................................................... 6
location ............................................................................................................................ 6
product overview.............................................................................................................. 12
front view ....................................................................................................................... 12
upper basket.................................................................................................................. 12
internal view .................................................................................................................. 12
lower basket .................................................................................................................. 12
rear view........................................................................................................................ 12
cutlery basket ................................................................................................................ 12
control panel.................................................................................................................. 13
wash cycle table ............................................................................................................... 14
before operating ............................................................................................................... 15
to open the door ............................................................................................................ 15
to close the door............................................................................................................ 15
items not suitable for use in the dishwasher ................................................................. 15
adding detergent power or tablet.................................................................................... 16
adding rinse aid................................................................................................................ 17
adjusting the rinse aid reservoir .................................................................................... 17
adding salt ..................................................................................................................... 18
Adjusting Salt Consumption .......................................................................................... 19
loading the dishwasher.................................................................................................... 20
before loading the dishwasher ...................................................................................... 20
upper basket.................................................................................................................. 21
- adjusting the upper basket ...................................................................................... 21
- loading the upper basket for 12 place settings........................................................ 21
- hinged cup rack....................................................................................................... 22
lower basket .................................................................................................................. 22
- hinged spikes .......................................................................................................... 22
- loading the lower basket for 12 place settings ........................................................ 23
cutlery basket ................................................................................................................ 23
starting a wash cycle ....................................................................................................... 24
changing a programme.................................................................................................... 24
at the end of a programme .............................................................................................. 24
switching off the unit ....................................................................................................... 25
KID60S10_IB_110426.indd 3 4/27/11 5:46 PM

unloading the dishwasher ............................................................................................... 25
delay start.......................................................................................................................... 25
half load............................................................................................................................. 25
cleaning after use............................................................................................................. 26
external care.................................................................................................................. 26
- the door and the door seal ...................................................................................... 26
- the control panel...................................................................................................... 26
internal care................................................................................................................... 26
- ltering system ........................................................................................................ 26
- spray arms............................................................................................................... 27
frost precaution ................................................................................................................ 27
moving the dishwasher.................................................................................................... 27
maintenance after a prolonged period of non-operation.............................................. 27
hints and tips .................................................................................................................... 28
fault code....................................................................................................................... 28
technical problems ........................................................................................................ 28
disposal of the dishwasher ............................................................................................. 30
disposal of packing material ........................................................................................... 30
specications.................................................................................................................... 31
safety warnings ................................................................................................................ 32
KID60S10_IB_110426.indd 4 4/27/11 5:46 PM

5
Thank you for purchasing your new Kenwood Dishwasher.
These operating instructions will help you use it properly and safely.
We recommend that you spend some time reading this installation/instruction
manual in order that you fully understand all the operational features it offers.
Read all the safety instructions carefully before use and keep this installation/
instruction manual for future reference.
unpacking
Remove all packaging from the unit. Retain the packaging. If you dispose of it please do so
according to local regulations.
The following items are included:
the main unit
lower hook X 2
P.N.: 672000200103
detergent measuring spoon X 1
1 full spoon = 20g (approx.)
P.N.: 673002200079
instruction manual x 1
P.N.: KID60B10-002
door template x 1
P.N.: 675001800313
ST4 screws X 10
P.N.: 672000900040
ST3.9x13 screws (white) X 2
P.N.: 672000900078
4x18 screws X 2
P.N.: 672000900039
4x20 screws X 2
P.N.: 672000900036
condensation strip X 1
P.N.: 675001300716
ST3.9x13 screws (black) X 2
P.N.: 672000900079
3.5x25 screws X 2
P.N.: 672000900041
U-shape hose holder X 1
P.N.: 673006200003
salt funnel X 1
P.N.: 673002200043
hop hook X 2
P.N.: 672000200023
measuring cup X 1
60ml (approx.)
P.N.: 673006200004
water supply hose X 1
P.N.: 673000900060
cutlery basket
P.N.: 673002200099
This product has been wet tested to ensure correct operation. As a result some water
may remain inside the unit. This is normal and safe. Remove any water droplets from the
exterior if necessary.
If items are missing, or damaged please contact Partmaster (UK only).
Tel: [phone] for assistance.
KID60S10_IB_110426.indd 5 4/27/11 5:47 PM

6
installation
1. Please ensure the dishwasher is installed
by a qualified technician. Refer to the tools
required.
location
When selecting a position for your dishwasher
you should make sure the installation surface
is flat and firm, and the room is well ventilated.
Avoid locating your dishwasher near a heat
source, e.g. cooker, boiler or radiator. Extreme
cold ambient temperatures may also cause
the appliance not to perform properly. This
dishwasher is not designed for use in a garage
or outdoor installation.
Do not drape the dishwasher with any covering.
When installing, ensure that free space is left at
the sides.
2. Ensure there is clearance each side of the
unit to allow slight sideways movement for
servicing when required. Good levelling is
essential for correct closure and sealing of
the door. When the unit is correctly levelled,
the door should not catch the inner liner on
either side of the cabinet. The adjustable
feet may be loosened or tightened in order to
obtain the optimum levelling of the unit.
level
level
level level
screw
cone
gear
level
Installation
All parts removed must be saved to do
the reinstallation in the future. Ensure
the dishwasher is unplugged and empty.
We recommend that 2 people handle
the dishwasher during installation.
The supplied door template also
contains installation steps which will
assist installation.
KID60S10_IB_110426.indd 6 4/27/11 5:47 PM

7
installation
3. The height of the unit is 820 mm. The figure
outlines the minimum dimensions required
to accommodate the dishwasher within fitted
kitchen furniture units.
820
600
560
595
540
820
unit in mm
4. Do not connect the unit to the mains socket
before installation. Ensure you are not
installing the unit right in front of the mains
socket. This is to avoid potential damage to
the back of the unit.
5. The condensation strip must be fitted to
the underside of the worktop above your
dishwasher to protect it against any moisture.
Its purpose is to protect your worktop’s
underside from steam rising from the
dishwasher.
Remove the backing paper from the
condensation strip.
Leave some space
Stick the Condensation
Strip under the worktop,
where you want to
install the dishwasher.
6. Stick the condensation strip to the underside
of the worktop.
Ensure the surface is clean prior to
sticking the condensation strip to
the underside of the worktop.
Failure to attach the condensation
strip could result in damage to the
underside of your worktop!
KID60S10_IB_110426.indd 7 4/27/11 5:47 PM

8
installation
7. Position the dishwasher next to a water tap
and a drain. Ensure the water inlet and drain
hoses are not kinked or squashed. The unit
must not stand on the mains cable.
<6.5kg
8. To secure the dishwasher under the table top,
tighten the screws through the top sides of
the unit onto the table top.
9. Tape the supplied Door Template to the
dishwasher door. Make sure the top of
the template is at the top of the door. Drill
the required holes following the depth and
diametre shown on the Door Template.
KID60S10_IB_110426.indd 8 4/27/11 5:47 PM

9
installation
10. Install the Aesthetic Panel onto the dishwasher door. Ensure the aesthetic panel weight is a
minimum of 3kg and a maximum of 6kg. After the aesthetic panel is installed, the tension of
the dishwasher door spring can be adjusted by rotating the adjusting bolt. If the tension is
right, the door will remain horizontal in the fully open position.
4 X 18 screw
Cover
Spacer for
aesthetic
panel
Hook for
aesthetic panel
Aesthetic panel
Outer door of
dishwasher
Lower hook
Hop hook
ST4 countersunk
head screw
11. Ensure to tighten the screws on both sides
of the dishwasher door and to secure the
Aesthetic Panel.
Rubber cover
Screw
4*14 screw
Loosen
12. Adjust the bolt to loosen or tighten the
tension of the dishwasher door.
KID60S10_IB_110426.indd 9 4/27/11 5:47 PM

10
installation
• Do not bend your drain hose.
14. Make sure your plumbing is suitable for
use with the dishwasher. If in doubt contact
a qualified plumber. This unit MUST BE
connected to COLD WATER MAINS using
the new water inlet hose. OLD HOSE SETS
MUST NOT BE RE-USED. The water
pressure from the water mains needs to be at
a minimum of 0.04 MPa and a maximum of
1.00MPa.
• Connect one end of the safety water
supply hose to your dishwasher, and then
connect the other end of the hose to your
water mains. Please ensure the black
rubber seal is in place.
• After connecting the hose, turn on your
water mains and check for leaks.
• Connect the dishwasher to the mains
socket.
water mains
water supply hose
Y-Adaptor
(not included)
Connect to
another
appliance
if required.
You may use a Y-Adaptor (not included)
for an additional water feed for another
appliance, for example a washing
machine. This is only applicable for cold
water mains. A Y-Adaptor is available
from most DIY stores.
screw
cone
gear
level
13. Adjust the adjustable feet again to obtain the
optimum levelling of the unit.
KID60S10_IB_110426.indd 10 4/27/11 5:47 PM

11
installation
water drain
hose
U-shaped drain
hose holder
• You may use the U-shaped drain hose
holder to secure your drain hose and to
avoid bending it.
• Secure the water drain hose to the waste
pipe to avoid it coming off during the
washing process.
• The waste pipe must only be
connected to the foul drains and not
the surface water drainage system.
• The water drain hose should be
placed between 40 cm and 100 cm
from the floor level and must not be
extended, otherwise the unit may
not be able to expel the waste water
properly.
KID60S10_IB_110426.indd 11 4/27/11 5:47 PM

12
product overview
front view
upper basket
internal view
rear view
lower basket cutlery basket
door handle
control panel
water inlet
(connect to
supply hose)
drain hose
mains cable
(connect to
mains socket)
cup racks spikes
spray arms
cutlery basket
ltering system
rinse aid
dispenser
spray arms
salt reservoir
detergent
dispenser
KID60S10_IB_110426.indd 12 4/27/11 5:48 PM

13
control panel
3 in 1 intensive normal economy rinse glass rapid 1/2delay
on/off
3 4 51 2 6
1. programme button
• press this button to select the washing programme.
programme indicator light
• illuminates when the selected washing programme is running.
2. salt refill warning light
• illuminates when the salt reservoir needs refilling.
rinse aid refill warning light
• illuminates when the rinse aid dispenser needs refilling.
3 display window
• displays selected programme, delay start time and fault codes etc.
4. delay start button
• to preset the wash timer and delay the starting time by up to 24 hours.
• each press of this button increases the delay start time by 1 hour intervals.
5. half load washing button
• press this button to select the half load washing cycle.
• illuminates when the half load washing cycle is selected.
• only the upper spray arms will be in function.
• load the soiled dishes in the upper basket.
6. on/off button
• to turn the dishwasher on and off.
• the LED light illuminates when the dishwasher is on.
KID60S10_IB_110426.indd 13 4/27/11 5:48 PM

14
wash cycle table
programme cycle selection
information process detergent
running
time
(min.)
energy
consumption
(kwh)
water
consumption
(l)
rinse
aid
3 in 1 • Pots, plates,
glasses and
lightly soiled
pans.
• Normally soiled.
• pre-wash
(50°C)
• wash (50°C)
• rinse (70°C)
• drying
• 3 in 1 155 1.2 16
intensive • Pots, pans,
casserole
dishes. Dishes
that have been
sitting with dried
food on them
for a while.
• pre-wash
(50°C)
• pre-wash
• wash (65°C)
• rinse (55°C)
• drying
• pre-wash
(5g)
• main wash
(25g)
130 1.4 22
normal • Pots, plates,
glasses and
lightly soiled
pans.
• Normally soiled.
• pre-wash
(50°C)
• wash (50°C)
• rinse (65°C)
• drying
• pre-wash
(5g)
• main wash
(25g)
160 1.2 16
economy*
(EN50242)
• Plates, glasses,
bowls.
• Lightly soiled.
• pre-wash
• wash (55°C)
• rinse (65°C)
• drying
• pre-wash
(5g)
• main wash
(25g)
155 1.05 13
rinse • For dishes that
need to be
rinsed and dried
only.
• wash (40°C)
• rinse (70°C)
• drying
• n/a 80 0.8 8
glass • Glasses, crystal
and fine china.
• A shorter wash
for lightly soiled
loads.
• pre-wash
• wash (40°C)
• rinse (60°C)
• drying
• main wash
(20g)
95 0.8 15
rapid • A shorter wash
for lightly soiled
loads that do
not need drying.
• wash (40°C)
• rinse (45°C)
• main wash
(20g)
30 0.45 12
* To comply with Standards of Performance, i.e. EN50242, please ensure to use economy washing
cycle for the test.
Condensing dry technology
• Energy is saved by drying the dishes using the remaining heat after the last rinse cycle.
• Wash cycle times are extended due to this drying method.
• Some wash programmes do not have a drying function, please refer to the Wash Cycle
Table for more details.
KID60S10_IB_110426.indd 14 4/27/11 5:48 PM

15
before operating
to open the door
• Pull the door handle.
• If the door is opened during operation all functions are automatically interrupted.
to close the door
• After loading the dishes, push the baskets fully into the dishwasher.
• Lift the door upwards and push until it clicks into position.
• Do not slam the dishwasher door.
items not suitable for use in the dishwasher
When purchasing new crockery and cutlery, please make sure they are dishwasher-proof. Some
items are not suitable for dishwashers.
• Wooden cutlery and crockery or items with wooden parts may discolour and fade. The glue used
in these items is not dishwasher-proof and wooden handles may come loose after being washed
in a dishwasher.
• Craft items, antiques, valuable vases and decorative glassware are also not suitable for
dishwashers.
• Plastic items (e.g. tupperware) which are not heat resistant may melt or loose shape due to the
high temperature in the dishwasher.
• Copper, brass, tin and aluminium items may discolour or become matt.
• Clouding may occur on glasses and delicate glassware after frequent washing. Do not wash
delicate glassware, or glassware containing lead crystal in a dishwasher. Wash delicate
glassware by hand instead.
• Silver and aluminium parts have a tendency to discolour during washing. Residues like egg
white, egg yolk and mustard often cause discolouring and staining on silver. Therefore, please
clean the residues from silver immediately after use.



the following items are not suitable
small plastic items
(milk bottle nipple)
plastic items that
are not dishwasher safe
crystal glasses
silverware
valuable vases
copper pots and pans
cast iron pans
cracked / chipped china
scratched non-stick cookware
towels and sponges
KID60S10_IB_110426.indd 15 4/27/11 5:48 PM

16
adding detergent power or tablet
Only use detergents specifically designed for use in dishwashers. To be more environmentally
friendly, please use no more than the correct amount of detergent. Fill the detergent dispenser with
detergent powder or tablet.
Please follow the steps below to fill the detergent dispenser.
1. Push the button on the lid of the detergent
dispenser in the direction of the arrow until the
flap springs open.
2. Fill the detergent dispenser with detergent
powder or insert the detergent tablet. The
marking indicates the filling level.
Bleach and
Countertop detergent Irritant
pre-wash detergent chamber
main wash detergent chamber
or
3. All programmes with pre-wash need an
additional detergent dosage that must be
placed in the pre-wash detergent chamber
(please refer to the wash cycle table). This
detergent will take effect during the pre-wash
phase.
4. Close the lid firmly so that it clicks into place.
push up from the right side
Keep out of the reach of children
• Irritating to eyes.
• Avoid contact with eyes. In case of contact with eyes, rinse
immediately with plenty of water and seek medical advice.
• If swallowed, seek medical advice immediately.
You can choose to add a detergent
tablet alone or to add detergent powder
to both the main wash detergent
chamber and the pre-wash detergent
chamber for your selected wash cycle.
KID60S10_IB_110426.indd 16 4/27/11 5:48 PM

17
adjusting the rinse aid reservoir
The rinse aid reservoir has six settings. Both the recommended
setting and the factory setting is “4”. If the dishes are not drying
properly or are spotted, adjust the dial to the next higher number
until your dishes are spot-free.
adding rinse aid
Rinse aid helps to ensure water does not cling and leave marks on crockery during the drying phase
and helps crockery dry faster after it has been washed. Only pour rinse aid that is for domestic
dishwashers into the reservoir. This model is designed to use liquid rinse aids only.
Please follow the steps below to pour the rinse aid into the storage reservoir, and the amount will
dispense automatically.
1. Turn the cap and open as indicated.
2. When the cap open marking is aligned, you
may lift the cap up.
3. Pour the rinse aid in until the level indicator
turns completely black in colour and close
the cap.
4. Be careful not to overfill the reservoir. Wipe
up any spills. The approximate volume of
the rinse aid reservoir is 110ml.
open
rinse aid indicator
If the water hardness in your area is soft, you
may not need rinse aid as it may cause white
film to develop on your dishes.
Rinse aid warning light will illuminate when the reservoir
is running out of rinse aid and requires refilling.
Alternatively, you can judge the amount of rinse aid by checking the rinse aid indicator right next
to the reservoir’s cap. When the indicator is black, it means it is full. When it is clear, it means it is
almost empty.
rinse aid
warning light
KID60S10_IB_110426.indd 17 4/27/11 5:48 PM

18
adding salt
If the water in your area is hard, deposits will form on your dishes
and utensils. This appliance contains a salt reservoir for you to
reduce the hardness of the water.
Please follow the steps below to pour the salt into the salt reservoir
and it must be set to correspond to the water hardness level in your
area.
1. Remove the lower basket and unscrew the reservoir cap.
2. Fill the reservoir with approximately 500ml of water (first use
only).
3. Place the funnel provided over the salt reservoir.
4. Pour in approximately 1.2kg of dishwasher salt depending on the
brand used.
5. Clean any excess salt from around the reservoir opening and
then screw the cap on again firmly.
6. Run the “rapid” wash programme immediately (without any
crockery in the dishwasher) to remove any traces of salt from the
compartment.
• The salt warning light will illuminate when the reservoir is
running out of salt and requires re-filling.
• The salt warning light will cease to illuminate within a few
days depending on how quickly the salt dissolves.
OPEN
open
open
open
salt warning
light
KID60S10_IB_110426.indd 18 4/27/11 5:48 PM

19
Adjusting Salt Consumption
Salt consumption must be adjusted to correspond to the water hardness level in your area. If you
don’t know how hard the water in your home is, please ask the company that supplies water in your
area.
It is recommended that adjustments should be made in accordance with the following chart.
water hardness selector
position
salt consumption
(gram/cycle)
number of
cycle / 1.2 kgs
˚dh ˚fh ˚Clark mmol/l
0-8 0-14 0-10 0-1.4 / 0 /
8-22 14-39 10-28 1.4-3.9 - 20 60
22-45 39-80 28-56 3.9-8 Mid 40 30
>45 >80 >56 >8 + 60 20
turn
To optimise and customise the level of salt consumption, please follow the steps below.
1. Remove the lower basket and unscrew the reservoir cap.
2. There is an arrow-shaped indicator in the reservoir, which you can turn. You may turn it to the “-”
or “+” settings based on the water hardness in your area.
1 ˚dh (German degree) = 1.25mmol/l
1 ˚fh (French degree) = 0.178mmol/l
1 ˚Clark (British degree) = 1.78mmol/l
• Do not use everyday table salt or cooking salt as they contain insoluble
substances which could damage the dishwasher.
• Do not pour detergent into the salt container. This will damage the dishwasher.
KID60S10_IB_110426.indd 19 4/27/11 5:48 PM

20
loading the dishwasher
before loading the dishwasher
Please observe the following notes before loading your cutlery and crockery into the basket.
• Remove lipstick stains and any food residues from crockery and dishes. Rinse if necessary.
• Dishes and cutlery must not lay inside one another, or cover each other.
• Load your cutlery and crockery so that water can access all surfaces.
• Ensure all items are securely positioned.
• Hollow items such as cups, glasses, pans, etc. must be placed upside down in the basket.
• Wide based items should be placed at an angle so that water can run off them freely.
• The spray arms must not be blocked by items which are too tall or hang through the baskets. If
in doubt, test for free movement by manually rotating the spray arms.
• Ensure that small items cannot fall through the holders in the baskets.
Do not wash items soiled with ash, sand, wax, lubricating grease or paint in the dishwasher.
Ash does not dissolve and can distribute in the dishwasher. Wax, sand, lubricating grease
and paint can cause damage to the dishwasher.
KID60S10_IB_110426.indd 20 4/27/11 5:48 PM