Kenwood KDW60S12 Service manual

Freestanding Dishwasher
KDW60S12
installation / instructions manual
ON
OFF

contents
Safety Warnings ................................................................................................................. 5
unpacking............................................................................................................................ 8
installation........................................................................................................................... 9
location ............................................................................................................................ 9
product overview.............................................................................................................. 13
front view ....................................................................................................................... 13
rear view........................................................................................................................ 13
upper basket.................................................................................................................. 14
lower basket .................................................................................................................. 14
internal view .................................................................................................................. 14
control panel ﹠ display window ..................................................................................... 15
wash cycle table ............................................................................................................... 16
before operating ............................................................................................................... 17
to open the door ............................................................................................................ 17
to close the door............................................................................................................ 17
items not suitable for use in the dishwasher ................................................................. 17
adding detergent or detergent tablet.............................................................................. 18
adding rinse aid................................................................................................................ 19
adjusting the rinse aid reservoir..................................................................................... 19
adding salt ..................................................................................................................... 20
adjusting salt consumption ............................................................................................ 21
loading the dishwasher.................................................................................................... 22
before loading the dishwasher ...................................................................................... 22
upper basket.................................................................................................................. 23
adjusting the upper basket ............................................................................................ 23
loading the upper basket for 12 place settings.............................................................. 23
hinged cup rack ............................................................................................................. 24
lower basket .................................................................................................................. 24
hinged spikes ................................................................................................................ 24
loading the lower basket................................................................................................ 25
cutlery basket ................................................................................................................ 25
loading the cutlery basket.............................................................................................. 25
starting a wash cycle ....................................................................................................... 26
changing a programme.................................................................................................... 26
at the end of a programme .............................................................................................. 26
switching off the unit ....................................................................................................... 27
unloading the dishwasher ............................................................................................... 27
delay start.......................................................................................................................... 27

half load............................................................................................................................. 27
cleaning after use............................................................................................................. 28
external care.................................................................................................................. 28
the door and the door seal ............................................................................................ 28
the control panel............................................................................................................ 28
internal care................................................................................................................... 28
ltering system .............................................................................................................. 28
spray arms..................................................................................................................... 29
frost precaution ................................................................................................................ 29
moving the dishwasher.................................................................................................... 29
maintenance after a prolonged period of non-operation.............................................. 29
hints and tips .................................................................................................................... 30
fault code....................................................................................................................... 30
technical problems ........................................................................................................ 30
disposal of the dishwasher ............................................................................................. 32
disposal of packing material ........................................................................................... 32
specications.................................................................................................................... 33

5
Safety Warnings
For your continued safety and to reduce the risk of injury or electric shock,
please follow all the safety precautions listed below.
• Read all instructions carefully before using the dishwasher and keep them
for future reference.
• Retain the manual. If you pass the dishwasher onto a third party, make sure
to include this manual.
• Keep ventilation openings in the dishwasher enclosure clear of obstructions.
• Choose a location for your dishwasher away from heat sources such as
radiators or fires.
• Young children should be supervised to ensure that they do not play with
the dishwasher.
• Keep mains cable out of reach of children.
• This appliance can be used by children aged from 8 years and above
and persons with reduced physical, sensory or mental capabilities or
lack of experience and knowledge if they have been given supervision or
instruction concerning use of the appliance in a safe way and understand
the hazards involved. Children shall not play with the appliance. Cleaning
and user maintenance shall not be made by children without supervision.
• Keep the appliance and its cord out of reach of children less than 8 years
old.
• Keep children away from detergents and rinse aids. These may cause
chemical burns in the mouth, throat and eyes or asphyxiation.
• Keep children away from the dishwasher when the door is open.
• Switch off water and power and unplug before fitting or removing tools/
attachments, after use and before cleaning.
• Keep your fingers away from moving parts and fitted attachments.
• Never use a damaged machine.
• If the mains cable is damaged, it must be replaced by the manufacturer, its
service agent or a qualified technician in order to avoid a hazard.
• Keep the power unit, mains cable and plug away from water.
• Never exceed the maximum capacities.
• 2 people are required to lift this dishwasher.
• Only use the dishwasher for its intended domestic use.

6
• This appliance is intended for indoor household use and similar applications
such as:
- farm houses and by clients in hotels, motels and other residential type
environment;
- bed and breakfast type environment;
- catering and similar non-retail applications.
WARNING
IT IS HAZARDOUS FOR ANYONE OTHER THAN AUTHORISED
SERVICE PERSONNEL TO CARRY OUT SERVICING OF REPAIRS
WHICH INVOLVE THE REMOVAL OF COVERS.
TO AVOID THE RISK OF AN ELECTRICAL SHOCK DO NOT
ATTEMPT REPAIRS YOURSELF.
• Do not sit or stand on the door or dish rack.
• Do not move your dishwasher by holding the door or its edges. Hold the
dishwasher around its sides or base when moving it.
• Do not touch the heating element during or immediately after use.
• Do not operate your dishwasher unless all enclosure panels are properly in
place. Open the door very carefully when there is a programme running, as
there is a risk of hot water spraying out of the appliance.
• Do not place any heavy objects on the open door. The appliance could tip.
• When loading items to be washed:
• Locate sharp items so that they will not damage the door seal;
• Warning: Knives and other utensils with sharp points must be loaded in the
basket with the points downwards or placed horizontally.
• Do not allow plastic items to come into contact with heating element.
• Check that the detergent receptacle is empty after completion of the wash
cycle.
• Do not wash plastic items unless they are marked dishwasher safe or
equivalent.
• Use only detergent and rinse aids designed for an automatic dishwasher.
• Other means for disconnection from the supply must be incorporated in the
fixed wiring with at least 3mm contact separation in all poles.
• The door should not be left in the open position since this could present a
tripping hazard.

7
• For energy saving, always remember to switch the dishwasher off when you
have finished using it. The dishwasher should not be left unattended when
in use.
• Remove the door to the washing compartment when removing an old
dishwasher from service or discarding it.
• During installation, the power supply cord must not be excessively or
dangerously bent or flattened.
• Do not tamper with controls.
• The appliance is to be connected to the water mains using new hose sets.
• The maximum number of place settings to be washed is 12.
• The maximum permissible inlet water pressure is 1Mpa, and the minimum
permissible inlet water pressure is 0.04Mpa.
earthing instructions
WARNING: THIS APPLIANCE MUST BE EARTHED.
• This appliance is equipped with a mains cable having an equipment-
earthing conductor and an earthing plug.
• The plug must be plugged into an appropriate mains socket that
is installed and earthed in accordance with local standards and
requirements.
Improper connection of the equipment-earthing conductor could result in
a risk of electric shock.
• The wires in the cord are coloured as follows:
Green and Yellow = Earth,
Blue = Neutral,
Brown = Live.
• Check with a qualified electrician or service representative if you are in
doubt whether the appliance is properly earthed or the plug does not
fit correctly.
• Never modify the plug provided with the appliance.

8
This product has been wet tested to ensure correct
operation. As a result some water may remain
inside the unit. This is normal and safe. Remove
any water droplets from the exterior if necessary.
unpacking
Remove all items from the packaging. Retain the packaging. If you dispose of it please do so
according to local regulations.
The following items are included:
The Main Unit
Detergent Measuring Spoon x 1
1 full spoon = 20g (approx.)
Instruction Manual X 1U-shape Hose Holder X 1Salt Funnel X 1
Condensation Strip X 1Measuring Cup X 1
60ml (approx)
Water Supply Hose X 1
Cutlery Basket
ON
OFF
Thank you for purchasing your new Kenwood Dishwasher.
These operating instructions will help you use it properly and safely.
We recommend that you spend some time reading this installation/instruction
manual in order that you fully understand all the operational features it offers.
Read all the safety instructions carefully before use and keep this installation/
instruction manual for future reference.
If items are missing or damaged please contact Partmaster (UK only).
Tel: [phone] for assistance.
Instruction
Manual

9
installation
unit in mm level
level
level
level
600
580
850
30
850
600
620
min.100
80
600
580
850
30
850
600
620
min.100
80
ON
OFF
ON
OFF
1. Please ensure the dishwasher is installed
by a qualified technician. Refer to the tools
required.
ON
OFF
location
When selecting a position for your
freestanding dishwasher you should make
sure the installation surface is flat and
firm, and the room is well ventilated. Avoid
locating your dishwasher near a heat source,
eg. cooker, boiler or radiator. Extreme cold
ambient temperatures may also cause the
appliance not to perform properly. This
dishwasher is not designed for use in a garage
or outdoor installation.
Do not drape the dishwasher with any
covering. When installing, ensure that free
space is left at the sides.
2. Ensure there is sufficient clearance
on each side of the unit to allow slight
sideways movement for servicing when
required. Good levelling is essential for
correct closure and sealing of the door.
When the unit is correctly levelled, the door
should not catch the inner liner on either
side of the cabinet. The adjustable feet
may be loosened or tightened in order to
obtain the optimum levelling of the unit.
If required, the worktop of the dishwasher
can be removed. The height without
the worktop is 820 mm, the minimum
dimensions required to accommodate the
dishwasher within fitted kitchen furniture
units.
installation
All parts removed must be saved to do
the reinstallation in the future. Ensure
the dishwasher is unplugged and empty.
We recommend that 2 people handle the
dishwasher during installation.

10
installation
Failure to attach the condensation strip
could result in damage to the underside
of your worktop!
4. The condensation strip must be fitted
to the underside of the worktop above
your dishwasher to help protect it against
and reduce potential liability moisture.
Its purpose is to protect your worktop’s
underside from steam rising from the
dishwasher.
Remove the backing paper from the
condensation strip.
3. Do not connect the unit to the mains socket
before installation. Ensure you are not
installing the unit right in front of the mains
socket. This is to avoid potential damage to
the back of the unit.
6. The worktop can be removed by removing
the fixing screws located at the rear of the
dishwasher. After removing the screws, lift
and push the worktop forward to release
the lugs from the front section of the
dishwasher. The polystyrene block and the
lugs should be saved for future use.
ON
OFF
Ensure the surface is clean prior to
sticking the condensation strip to the
underside of the worktop.
Leave some space
Stick the Condensation Strip
under the worktop, where you
want to install the dishwasher.
Remove
Remove
Unscrew
Remove
5. Stick the condensation strip to the
underside of the worktop.

11
installation
8. Make sure your plumbing is suitable for
use with the dishwasher. If in doubt contact
a qualified plumber. This unit MUST BE
connected to COLD WATER MAINS
using the new water supply hose. OLD
HOSE SETS MUST NOT BE RE-USED.
The water pressure from the water mains
needs to be at a minimum of 0.04 MPa and
a maximum of 1.00MPa.
• Connect one end of the water supply
hose to your dishwasher, and then
connect the other end of the hose to
your water mains. Please ensure the
black rubber seal is in place.
• After connecting the hose, turn on your
water mains and check for leaks.
• Connect the dishwasher to the mains
socket.
• Do not bend your drain hose.
7. Position the dishwasher next to a water
tap and a drain. Ensure the water inlet and
drain hoses are not kinked or squashed.
The unit must not stand on the mains
cable.
ON
OFF
You may use a Y-adaptor (not included)
for an additional water feed for another
appliance, for example a washing
machine. This is only applicable for cold
water mains. A Y-adaptor is available
from most DIY stores.
water mains
Y-Adaptor
(not included)
Connect
to another
appliance
if required.
safety water supply hose

12
installation
• The waste pipe must only be
connected to the foul drains and not
the surface water drainage system.
• The water drain hose should be
placed between 40 cm and 100 cm
from the floor level and must not be
extended, otherwise the unit may
not be able to expel the waste water
properly.
water drain hose
U-shaped drain hose
holder
• You may use the U-shaped drain hose
holder to secure your drain hose and to
avoid bending it.
• Secure the water drain hose to the
waste pipe to avoid it coming off during
the washing process.

13
product overview
front view
rear view
1. control panel
2. door handle
ON
OFF
2
3
1
5
4
3. drain hose
4. water inlet
(connect to supply hose)
5. mains cable
(connect to electrical mains outlet)

14
upper basket
internal view
lower basket
8. spray arms (1 x under
upper basket and
1 x under lower
basket)
9. salt reservoir
10. detergent dispenser
(dual compartment)
11. cutlery basket
12. filtering system
13. rinse aid dispenser
6
7
6
7
6. cup racks 7. spikes
11
12
13
8
9
10

15
1. ON/OFF button
• to turn the dishwasher on and off.
• the LED light illuminates when the
dishwasher is on.
2. start button
• press this button to start washing
programme.
3. pause button
• press this button to pause washing
programme.
4. half load washing button
• press this button to select the half load
washing cycle.
5. pause indicator light
• illuminates when pause is selected.
half load indicator light
• illuminates when the half load washing
cycle is selected.
ON
OFF
control panel ﹠ display window
1 2
10
3 4 5 76 8 9
6. display window
• displays programme selected, programme
time, delay start time and fault codes etc.
7. rinse aid refill warning light
• illuminates when the rinse aid dispenser
needs refilling.
salt refill warning light
• illuminates when the salt reservoir needs
refilling.
8. delay start button
• press to preset the wash timer and delay
the start time by up to 24 hours.
• each press of this button increases or
decreases the delay start time by 1 hour
intervals.
9. P programme button
• press to select your required washing
programme.
10. programme indicator light
• illuminates when the program is selected.

16
Condensing dry technology
• Energy is saved by drying the dishes using the remaining heat after the last rinse cycle.
• Wash cycle times are extended due to this drying method.
• Some wash programmes do not have a drying function, please refer to the Wash Cycle
Table for more details.
wash cycle table
programme cycle
cycle
selection
information
process
detergent
amount
(pre-wash/ main
wash)
running
time
(min.)
energy
consumption
(kwh)
water
consumption
(i)
rinse
aid
intensive For heaviest
soiled
crockery,
and normally
soiled pots,
pans, dishes
etc with dried
on soiling.
• pre-wash
(50°C)
• wash (65°C)
• rinse
• rinse
• rinse (55°C)
• drying
• pre-wash
(5g)
• main wash
(25g)
125 1.36 19.5
normal For normally
soiled loads,
such as
pots, plates,
glasses and
lightly soiled
pans.
• pre-wash
(50°C)
• wash (55°C)
• rinse
• rinse (65°C)
• drying
• pre-wash
(5g)
• main wash
(25g)
160 1.30 16
eco*
(EN50242)
Standard
daily cycle
for normally
soiled loads,
such as
pots, plates,
glasses.
• pre-wash
• wash (50°C)
• rinse (65°C)
• drying
• pre-wash
(5g)
• main wash
(25g)
165 1.02 12
glass For lightly
soiled
crockery and
glass.
• pre-wash
• wash (40°C)
• rinse
• rinse (60°C)
• drying
• main wash
(20g)
95 0.90 16
1 hour For lightly
soiled loads
that do not
need excellent
drying
efficiency.
• wash (60°C)
• rinse
• rinse (50°C)
• drying
• main wash
(20g)
60 0.95 12
rapid A shorter
wash for
lightly soiled
loads and
quick wash.
• wash (40°C)
• rinse
• rinse (40°C)
• main wash
(20g)
30 0.50 11
soak To rinse
dishes that
you plan to
wash later
that day.
• pre-wash 8 0.01 4
* To comply with Standards of Performance, i.e. EN50242, please ensure to use economy washing
cycle for the test.

17
before operating
to open the door
• Pull the door handle.
• If the door is opened during operation all functions are automatically interrupted.
to close the door
• After loading the dishes, push the baskets fully into the dishwasher.
• Lift the door upwards and push until it clicks into position.
• Do not slam the dishwasher door.
items not suitable for use in the dishwasher
When purchasing new crockery and cutlery, please make sure they are dishwasher-proof. Some
items are not suitable for dishwashers.
• Wooden cutlery and crockery or items with wooden parts may discolour and fade. The glue used
in these items is not dishwasher-proof and wooden handles may come loose after being washed
in a dishwasher.
• Craft items, antiques, valuable vases and decorative glassware are also not suitable for
dishwashers.
• Plastic items (e.g. tupperware) which are not heat resistant may melt or loose shape due to the
high temperature in the dishwasher.
• Copper, brass, tin and aluminium items may discolour or become matt.
• Clouding may occur on glasses and delicate glassware after frequent washing. Do not wash
delicate glassware or glassware containing lead crystal, in a dishwasher. Wash delicate
glassware by hand instead.
• Silver and aluminium parts have a tendency to discolour during washing. Residues like egg
white, egg yolk and mustard often cause discolouring and staining on silver. Therefore, please
clean the residues from silver immediately after use.



The following items are not suitable
Towels and sponges
Small plastic items
(Milk bottle nipple)
Plastic items that are
not dishwasher safe
Cast iron pans
Scratched non-stick cookware
Copper pots and pans
Crystal glasses
Silverware
Valuable vases
Cracked / chipped china

18
Please follow the steps below to fill the detergent dispenser.
1. Push the button on the lid of the detergent
dispenser in the direction of the arrow until the
flap springs open.
adding detergent or detergent tablet
Only use detergents specifically designed for use in dishwashers. To be more environmentally
friendly, please use no more than the correct amount of detergent.
2. Fill the detergent dispenser with detergent
powder or insert the detergent tablet. The
marking indicates the filling level.
Bleach and
Countertop detergent Irritant
3. Close the lid firmly so that it clicks into place.
push up from the right side
pre-wash detergent chamber
main wash detergent chamber
or
• Keep detergents and bleaches out of the reach of children.
• Irritating to eyes.
• Avoid contact with eyes. In case of contact with eyes, rinse
immediately with plenty of water and seek medical advice.
• If swallowed, seek medical advice immediately.
You can choose to add a detergent tablet
alone or to add detergent powder to both
the main wash detergent chamber and
the pre-wash detergent chamber for your
selected wash cycle. All programmes
with pre-wash need an additional
detergent dosage that must be placed
in the pre-wash detergent chamber
(please refer to the wash cycle table).
This detergent will take effect during the
pre-wash phase.
* All images are for reference only; please refer to your individual unit for actual item.

19
• Rinse aid warning light will illuminate when the reservoir is
running out of rinse aid and requires refilling.
• Alternatively, you can judge the amount of rinse aid by
checking the rinse aid indicator right next to the reservoir’s
cap. When the indicator is black, it means it is full. When it is
clear, it means it is almost empty.
adjusting the rinse aid reservoir
The rinse aid reservoir has six settings. Both the recommended
setting and the factory setting is “4.” If the dishes are not drying
properly or are spotted, adjust the dial to the next higher number
until your dishes are spot-free.
adding rinse aid
Rinse aid helps to ensure water does not cling and leave marks on crockery during the drying phase
and helps crockery dry faster after it has been washed. Only pour rinse aid that is for domestic
dishwashers into the reservoir. This model is designed to use liquid rinse aids only.
Please follow the steps below to pour the rinse aid into the storage reservoir. The amount will
dispense automatically.
1. Turn the cap and open as indicated.
2. When the cap open marking is aligned, you
may lift the cap up.
3. Pour the rinse aid in until the level indicator
turns completely black in colour. Close the
cap.
4. Be careful not to overfill the reservoir. Wipe
up any spills. The approximate volume of
the rinse aid reservoir is 110ml.
open
rinse aid indicator
• If the water hardness in your area is soft, you
may not need rinse aid as it may cause white
film to develop on your dishes.
rinse aid
warning
light
* All images are for reference only; please refer to your individual unit for actual item.

20
4. Pour in approximately 1.2kg of dishwasher salt depending on the
brand used.
5. Clean any excess salt from around the reservoir opening and
then screw the cap on again firmly.
6. Run the “rapid” wash programme immediately (without any
crockery in the dishwasher) to remove any traces of salt from the
compartment.
• The salt warning light will illuminate when the reservoir is
running out of salt and requires re-filling.
• After filling, the salt warning light will cease to illuminate within a
few days depending on how quickly the salt dissolves.
adding salt
If the water in your area is hard, deposits will form on your dishes and utensils. This appliance
contains a salt reservoir for you to reduce the hardness of the water.
Please follow the steps below to pour the salt into the salt reservoir. It must be set to correspond to
the water hardness level in your area.
1. Remove the lower basket and unscrew the reservoir cap.
2. Fill the reservoir with approximately 500ml of water (first use
only).
3. Place the funnel provided over the salt reservoir.
OPEN
open
open
open
If you decide to use a detergent tablet, you do not need
to add rinse aid to the rinse aid reservoir.
salt
warning
light
* All images are for reference only; please refer to your individual unit for actual item.