Lake Lite LL-SPL-DOWN-8 User manual

Solar Piling Down Light
MODEL: LL-SPL-DOWN-8
Solar Underglow: Model: LL
-SDL-UG-X
Description
Lake Lite Inc.
105 W. Simon St.
Laotto, IN 46763
Phone: [phone]
Fax: [phone]
E-mail [email protected]
www.lakelite.com
www.solarmarinelites.com
LIGHT CHARACTERISTICS
Light Source 1-Ultra-High intensity Cree Brand LED
Lumens output 40/75/100/125 Lumens *Varies with Color &
Settings & Power Setting
Available LED Colors White, Sea Turtle Amber
Light Mode Options Constant
Visible Range 300m-500m+ Depending on Settings
Horizontal Output (degrees) 160 Deg.
Vertical Divergence (degrees) NA
LED Life Expectancy (hours) > 100,000 hrs
ELECTRICAL CHARACTERISTICS
Circuit Protection Integrated
Nominal Voltage (v) 3.2v
Autonomy (hours) 16-20hrs *On full Charge
Temperature Range -10 to 70 C
SOLAR CHARACTERISTICS
Solar Module Type Multicrystalline or Monocrystalline
Power (watts) 2.4w
Solar Module Efficiency (%) 16-17%
POWER SUPPLY
Battery Type High Capacity LiFePo4
Battery Size 2pcs Parallel LiFePo4
Battery Capacity (mAh) 2800mA
Nominal Voltage (v) 3.2v
Battery Service Life 3-6 years (Varies with local Environment)
Battery Service Access Yes: User Changeable / Replaceable
PHYSICAL CHARACTERISTICS
Body Material Marine Grade Aluminum + Powder Coat
Lens Material NA –No Lens
External Lens Design NA –No Lens
Internal Lens design NA –No Lens
Water Proof Rating IP 68
Mounting Fits on Pilings or flat surfaces 8” diameter
and Larger
Height 42mm
Width / Diameter 204mm
Weight 4 lbs
OPTIONS
Custom Options, Sizes, & Colors Please Contact
Custom Hardware & Mounting Please Contact
* Informationsubject tochange without notice

CAUTION: PLEASE KEEP OUR ENVIORNMENT CLEAN! BATTERIES MUST BE RECYCLED OR DISPOSED OF PROPERLY.
Installing Batteries & Cover
PO BOX 414
105 W. Simon St.
Laotto, IN 46763
Phone: [phone]
Fax: [phone]
E-mail [email protected]
www.lakelite.com
www.solarpilinglites.com
Mounting Hardware Suggestions –Not Included
Mount
Type
Hardware
Stainless Steel Recommended
No Through Hole #14 OVAL HEAD Screws x Desired Length
No Through Hole 5/16” Lag Bolts x Necessary Length with
5/16” Washers
No Through Hole 3/8” Lag Bolts x necessary Length with
3/8” Washers
Through Hole 5/16” Bolts X Necessary Length with
5/16” Washers & 5/16” Nuts
LiFePo4 Type Battery:
Volts: 3.2v Cell Size: 18650 Capacity: 2800mA
DO NOT USE: standard 1.2v NiMh or NiCd type Rechargeable
batteries or they will be damaged!
Caution! When plugging battery connectors
together, align notches before connecting both
connectors. Failure to do so could result in
permanent damage to the light.
Battery Information
BATTERY MAINTENANCE
For prolonged storage when not using the product please follow these procedures.
1. Charge Batteries inside product on sunny day
2. Before Nightfall open your light and FULLY Disconnect the battery from the product
3. Store Battery and Product in warm/dry location.
4. Note: Batteries can be damaged from sub-zero temperatures when not in use.
SOLAR PILING LITE –8”
MODEL: LL-SPL-8-X-X

PO BOX 414
105 W. Simon St.
Laotto, IN 46763
Phone: [phone]
Fax: [phone]
E-mail [email protected]
Use the provided wrench to remove the battery
cover from the bottom of the light
The battery is not connected when shipped.
Connect Battery: Caution! Align notches before joining
both connectors. Forcing or connecting backwards may
damage the light or the connector.
MALE NOTCH
FEMALE NOTCH
Power Level + OFF Button Power
Setting
* Run
Times
100% 6-8 hrs
80% 7-9 hrs
65% 10-12 hrs
50% 13-14 hrs
35% 15-17hrs
20% 17-22 hrs
OFF OFF
1 2
3
SOLAR PILING LITE –8”
MODEL: LL-SPL-8-X-X
www.lakelite.com
www.solarpilinglites.com
NEW MAGNET
SWITCH OPERATION
CHANGING BRIGHTNESS LEVELS
Wave the magnet over the solar
panel at night until you find the
activation area which changes
the brightness level
Make a quick up & down motion
over this area to change between
brightness levels & OFF
NOTE: moving too
slowly may activate the
magnet switch multiple
times going through
multiple levels at once.
A quick motion will help!
•Turn the light over or cover the solar panel. The LED will turn on. If not, then push the button, and select brightness level.
•Run times will vary significantly based on factors such as; Sun Exposure, Season, Angle of Sunlight, Geographic Location, Shading,
Installed Location/Position, Battery Condition, and most importantly the Brightness Setting in comparison to the season.
•The following run times should only be used as a general reference and are not guaranteed. Consider your local environment
•Lower brightness settings use less power and leave more reserve power for cloudy days where less recharging takes place.
NOTE: RUN TIMES ARE BASED ON A FULL CHARGE: MANY FACTORS MAY PREVENT A FULL CHARGE SEE BELOW

Place light onto piling and mark holes. Drill small pilot holes
in piling with drill bit. Use screwdriver to secure the light to
your piling with mounting screws –Not Included
Mount the Top unit to the dock Piling with screws.
Mount the Down Light at the desired height on the side of
the piling. The Higher the down light is off the dock surface
the wider the light pattern will be on the dock surface.
6 7
Connect the Down light: NOTE make sure to align the
connector notches and that the o-ring is in place. Tighten
the nut to ensure the connector is water proof.
PO BOX 414
105 W. Simon St.
Laotto, IN 46763
Phone: [phone]
Fax: [phone]
E-mail [email protected]
Use Provided wrench and top screws to assembly your
light together. NOTE: The seal must be in the correct
position before tightening down the top to the base.
4 5
Mounting Screws
Screwdriver
Piling
SOLAR PILING LITE –8”
MODEL: LL-SPL-8-X-X
www.lakelite.com
www.solarpilinglites.com
Piling
Align the Wire Notch
in the direction of the
down light before
mounting the top
Wrap Excess wire
under the base
before mounting
Note you can disconnect the down light for
installation if necessary. The extra wire can be
wrapped around the inside during installation.
Make sure to fully
tighten all screws
to ensure a water
proof seal
MALE NOTCH
FEMALE NOTCH

Owner Registration Card
Please fill out and affix proper postage and return this owner
registration card within 10 days to insure that your new Solar Piling
Lite is covered by the limited warranty.
Purchaser’s Name .
Address .
State . Zip .
Purchase Date: . Number of Lights: .
Where Purchased (Store Name): .
Model No LL-SPDL-8-X
UPC No. Varies On Different Models
Lake Lite Inc.
P.O. Box 414, Laotto, IN 46763
Lake Lite Inc. 1-Year Limited Warranty
The retailer warrants the Solar Lites to be free from defects in workmanship and material present
at time of shipment from the factory for a period of one year after the date of purchase by the
original purchaser. We agree to correct such defects without charge or at our option replace with a
comparable or superior model if the product is returned to the retailer. To obtain warranty service,
you must present a copy of the receipt as proof of purchase. All costs of removing and reinstalling
the product are you responsibility. Damage to any part such as by accident or misuse or improper
installation or by affixing any accessories, is not covered by this warranty. There is no other
express warranty. The retailer hereby disclaims any and all warranties, including but not limited
to, those of merchantability and fitness for a particular purpose to the extent permitted by law. The
duration of any implied warranty, which cannot be disclaimed, is limited to the time period as
specified in the express warranty. Some states do no allow limitation on how long an implied
warranty lasts, so the above limitation may not apply to you. The retailer shall not be liable for
incidental, consequential, or special damages arising out of or in connection with product use or
performanceexcept as may otherwise be accorded by law. Some states do not allow the exclusion
of incidental or consequential damage, so the above exclusion or limitation may apply to you.
This warranty gives specific legal rights, and you may also have other rights, which vary from
state to state. This warranty supersedes all prior warranties.
Dimensions = mm
Lake Lite Inc.
105 W. Simon St.
Laotto, IN 46763
Phone: [phone]
Fax: [phone]
E-mail [email protected]
www.lakelite.com
www.solarmarinelites.com
Solar Piling Down Light
MODEL: LL-SPL-DOWN-8
42mm
150mm
204mm
88mm
88mm
12mm
45mm
65mm