Leenders WALD User manual

WALD
INSTALLATION EN

WALD LEENDERS
2019.49.002.I.EN
4
4
Installaon opon 1; xing THROUGH ceiling. Installaon opon 2; xing TO ceiling.

WALD LEENDERS
2019.49.002.I.EN
Points for special aenon when installing the Wald
• Installaon opon 1, xing with threaded ends and counter plate is recommended. This provides
the Wald with beer side-collision protecon.
• If the ceiling height exeeds 2750mm, the Wald can only be suspended according to opon 1, with
the counter plate and threaded ends.
• The Wald can only be connected to an insulated double-walled ue.
• This stove appliance must be ed to a ceiling that can easily support the load.
• The weight of the double-walled ue must not be supported by the connecon to the Wald.
Poujoulat Ecience
• Can be connected to the Poujoulat Ecience to draw in fresh air through the ue. A special
connector is required for this and can be supplied with the stove if requested.
Art. nr. ENA15SP49.
• The Poujoulat Ecience duct may be up to 6 metres in length.

WALD LEENDERS
2019.49.002.I.EN
Installaon opon 1; xing THROUGH ceiling.
Fixing with threaded ends and counter plate is recommended.
This provides the Wald with beer side-collision protecon.
1. Posion the counter plate on the ceiling.
3. Secure the ceiling plate to the
threaded ends with 4x coupling
nuts and M8x20 countersunkhead
bolts.
2. Fix the threaded ends tot the counter
plate.
4. Fix both plates with the nuts on
the counterplate.

WALD LEENDERS
2019.49.002.I.EN
Installaon opon 2; xing TO ceiling.
.
1. Mark out het ceiling plate
Use the cardboard template. Face
the atbit to the rear. Mark the 12
holes on the ceiling.
2. Drill holes
Drill 6 holes distributed over the
ceiling plate. Pilot drill with Ø 6, nish
with Ø 14.
Should a posion be dicult to drill
through, use one of the other
marked posions.
3. Securing ceiling plate
Use 6 anchors and M8x55
countersunk head bolts. The bolts
must not protrude form the ceiling
plate.
Please note: the construcon of the ceiling must be appropriate for this
method of aachment.

WALD LEENDERS
2019.49.002.I.EN
Installaon opon 1&2
4. Determine the length of the double-walled inner ue
Use a telescopic, double-walled ue that can be adjusted to t
- L= Length telescopic double-walled ue, excluding the connector
- X = Length mantel pipe Wald
- Y = Length of double-walled ue that protrudes from the ceiling
- L = X - Y - 65mm
5a. Double-walled connector
Install the connector for the double-walled ue
5b. Poujoulat connector (only for use with the Poujoulat Ecience)
Install the connector for the Poujoulat Ecience ue
6. Perparing the mantel pipe
Lay the mantel pipe horizontally. Insert the double-walled ue adjusted to length into the mantel pipe.
Bring the mantel pipe with the double-walled ue inot an upright posion.

WALD LEENDERS
2019.49.002.I.EN
7. Installing the double-walled ue
Li the double-walled ue out of the mantel pipe
and aach this to the secon that is protruding
from the ceiling.
8. Aaching the mantel pipe
Put the mantel pipe on the li. Use the li for
aaching the mantel pipe to the ceiling plate.
Secure the mantel pipe with 6x M8x16
countersunk head bolts.

WALD LEENDERS
2019.49.002.I.EN
9. Levelling the mantel pipe
Check to see if the mantel pipe is haning plumb. Adjust for plumb if necessary using the 3x socket-head
screws. Loosen the 6x M8x16 a lile befor you do this. Aerwards re-ghten the 6x M8x16.
10. Transport the stove with a hand truck
Use protecon between the stove and the hand truck.
Ensure that the wooden transport plate is snug against the
base. Seat the stove with the side against the hand truck.
Never posion the stove with the front against the hand
truck; this can damage the glass.
Never posion the stove with the back against the hand
truck; this can damage the air valve.
11. Swivel lock
If 2x60 ° rotatable, install the swivel lock.

WALD LEENDERS
2019.49.002.I.EN
12. Posion stove on the li
13. Aaching the connector
Elevate the li and rst aach the double-walled ue to the
swivelling ring. Please note: the weight of the double-walled ue
must not be supported by the Wald’s swivelling connector.
14. Securing the stove
Elevate the li more and secure the stove. Use the 6x M8 bolts supplied.

WALD LEENDERS
2019.49.002.I.EN
15. Transport plate
Remove the M6 bolt and with this the wooden
transport plate.
16. Air supply cover plate (only for use with the
Poujoulat Ecience)
Secure the air supply cover plate underneath with
3x M6. Please note: only install the cover plate in
conjuncon with the Poujoulat Ecience.
17. Foot
Secure the foot with M6 threaded end and nut.

WALD LEENDERS
2019.49.002.I.EN
18. Inspecon
Check if the stove is xed securely to the ceiling.
Check if the aeraon pipes are properly connected.
Check that the heat shield is properly seated
underneath.

WALD LEENDERS
2019.49.002.I.EN
General instrucons and regulaons
Installaon
For the validity of the guarantee the Wald must be installed by a professional er employed by a
recognised Leenders dealer. See leenders.nl for a current list of addresses of approved dealers or
contact the factory.
The stove is suscepble to scratching: cauon is recommended. Stoke the stove following the
instrucons in the manual.
Use
• All local regulaons, including those reering to naonal and European standards must be
observed when ng the appliance.
• ensure ample venlaon/air supply in the room where the stove is installed. Air extracon, such
as an extractor hood, can cause problems in the form of ue gases escaping from the stove into
the room.
• The appliance is suitable for use with a chimney venlator.
• The appliance is suitable for sharing a ue.
• This appliance must be ed to a ceiling that can easily support the load.
• Ensure there is ample access for cleaning the appliance, the ue gas connecon and the chimney.
Safety regulaons
• For maers of general safety, we refer you to the VCA guidelines.
• Glass is very fragile and broken glass is very sharp. Take sucient safety precauons.
• Please note that aer installaon no combusble and/or materials with a danger of exploding
should be placed in the stove, like spray cans, packaging materials and such like.
Safe distance for Wald from combusble materials
• Rear wall: 15 cm.
• Side wall: 80 cm.
• Front: 110 cm.
Wald specicaons
• Nominal capacity = 7,9 kWh
• Heat emisson capacity = 7,9 kWh
• Flue gas mass ow = 7.5 g/s
• Mass appliance = 145kg
• Minimum chimney draught = 0.12mbar
• Flue gas temperature directly above the stove = 209 °C
• Energy Eciency 82,9%, class A+, 111,4 index