Lefroy Brooks M2-2400 User manual

INSTALLATION INSTRUCTIONS
M2-2400
CROSS HANDLE 3-HOLE BATH FILLER TRIM ONLY, TO SUIT R1-4017 ROUGH
M2-2401
LEVER 3-HOLE BATH FILLER TRIM ONLY, TO SUIT R1-4018 ROUGH
M2-2401M2-2400

Dimensions in Inches (& Millimetres)
Whilst every effort is made to ensure accuracy, design and dimensions are subject to
change without notice as part of the company’s product development process.
M2-2400
8"
2 11/16"
3 1/4"
9 3/16"
3 1/16"
3-Ø2 3/8"
11/16"
Ø1"
5°
9 11/16"
(203mm)
(68mm)
(83mm)
(234mm)
(77mm)
(3-Ø60mm)
(17mm)
(Ø25.4mm)
(246mm)
2

Dimensions in Inches (& Millimetres)
Whilst every effort is made to ensure accuracy, design and dimensions are subject to
change without notice as part of the company’s product development process.
M2-2401
3 1/4"
Ø1"
5˚
(83mm)
3 1/8"
(80mm)
9 11/16"
(246mm)
3 1/16"
(77mm)
8"
(203mm)
9 3/16"
(234mm)
(Ø25.4mm)
3-Ø2 3/8"
(3-Ø60mm)
11/16"
(17mm)
3

What you need to know
Adjustable Wrench
Groove Joint Pliers
Hacksaw
Phillips Screwdriver
Pipe Tape
Spatula
Spirit Level
Your new bathroom faucet is designed for years
of trouble-free performance.
Keep it looking new by cleaning it periodically with
a soft cloth. Avoid abrasive cleaners, wire wool and
harsh chemicals as these will dull the finish and
void your warranty.
If you are soldering during faucet installation,
remove cartridges, seats, gaskets and washers
prior to applying flame, otherwise you will void
the warranty.
Cover drain openings to avoid losing small parts.
When cutting or soldering pipe, use safety glasses
to protect your eyes.
Correct installation may vary depending on previous faucet installation. All necessary supplies required for
faucet installation are not included, but may be found where plumbing supplies are sold. It is suggested that
IAPMO and/or CSA approved plumbing supplies are used during installation.
Prior to beginning installation. turn off the cold and
hot water lines and open the old faucet to release
built-up pressure.
Overtightening nuts may cause damage.
Wrap all threaded connections with pipe tape
available at your local plumbing supply store.
Always wrap in a clockwise direction. The fittings
should be installed by a state-licenced plumber.
Tools: Maintenance
SafetyTips
ThingsYouMayNeed
ImportantPoints
IAPMO/cUPC Listed
Meets A112.18.1
Standards
4

Steps 1-4
InstallationProcedure
Lefroy Brooks always recommends that plumbing products be installed by a licensed professional.
Shut off main water supply before installation.
21
3
Once the front wall is finished, take off the
protective caps for installing the trim.
Install the spout and then fix the central
canopy with the spout by fixing the grub
screw.
Disassemble central canopy and spout by
loosing the grub screw.
3
1 2
A
A
2:1
5

Steps 5-7
InstallationProcedure
Lefroy Brooks always recommends that plumbing products be installed by a licensed professional.
Shut off main water supply before installation.
45
Install the handle by fixing the screw with
stem extension.
After installation, turn on valve to do water
checking.
5 6
6

7
Exploded View
PartsList
M2-2400
M2-2401
14
15
19
17
16
18
11
12
13
7
3
4
6
5
1
20
2
21
8
10
9
1 Handle ( H ) (069826H)
2 Set screw (292598)
3 Canopy (018014)
4 Adaptor (067773)
5 Clip (012242)
6 Adaptor (057507)
7 Escutcheon (071325)
8 O-ring (004640N)
9 Screw (008115)
10 Stem extension (110413)
11 Aerator housing (305037)
12 Aerator insert (114237R)
13 Oil-seal (010899)
14 Spout (139657)
15 Set screw (292505)
16 O-ring (004094N)
17 Canopy (000114)
18 O-ring (004617)
19 Nut (009618)
20 Handle ( C ) (069826C)
21 Allen Key (031000)
1 Cross handle (029685H)
2 Set screw (292598)
3 Canopy (018014)
4 Clip (012242)
5 Stem extension (067773)
6 Adaptor (057507)
7 Escutcheon (071325)
8 O-ring (004640N)
9 Screw (008115)
10 Stem extension (110413)
11 Oil seal (010899)
12 Aerator insert (114237R)
13 Adrator housing (305037)
14 Spout (139657)
15 Set screw (292505)
16 O-ring (004094N)
17 Canopy (000114)
18 O-ring (004617)
19 Nut (009618)
20 Cross handle (029685C)
21 Allen key (031000)
14
13
11
12
15
19
17
16
18
7
3
4
5
6
1
20
2
21
8
10
9

For additional assistance or service call
718-302-5292
9am to 5pm EST Monday to Friday
LEFROY BROOKS INC, 1828 TROUTMAN STREET, RIDGEWOOD, NY, 11385
TELEPHONE: [phone]. FAX: [phone]
The use of trademarks, product design and artwork is subject to licence or agreement with LBIP Ltd. The design
registrations, trademark registrations and copyrights are protected by law and the use or reproduction outside the terms of an agreement is prohibited.
The right to modify designs and dimensions is reserved. Christo Lefroy Brooks is a member of ACID (Anti Copying in Design).
© LBIP LTD 2012
www.lefroybrooks.com