Livoo DOC276 User manual

Instruction manual
WWW.LIVOO.FR
Reference : DOC276
Version : 1.4
Language : English
lancha gaz 2 burners

Instruction manual
1
You have purchased a product LIVOO brand and we thank you. We take great care in design, ergonomics
and ease of use of our products. We hope that this product will give you complete satisfaction.
This instruction manual is available too on our website www.livoo.fr
Model. DOC276
CS Number CS - - - - - - ( = “CS” + our order N° - ex: CS117584)
Description: PLANCHA GAZ 2 BRULEURS
Max power 5,6kW
(408g/h)
2531 20
Pin:
2531
DL
-
00
4
4
Category of gaz : I
3+(28-30/37)
I
3B/P(30)
I
3B/P(50)
I
3B/P(37)
Types of gas :
Butane
(
408
g/h)
Propane
(400 g/h)
LPG GAS MIXTURES ( 408 g/h)
Gas pressure : 28-30 mbar 37 mbar 30 mbar 50mbar 37 mbar
Injector size : 0.76 mm 0.76 mm 0.66 mm 0.70 mm
Number and code OL6301-35
To be used only outs de the prem ses
Consult the nstruct ons before use
Caut on: access ble parts can be very hot, keep away from young ch ldren
Th s appl ance must be kept away from flammable mater als dur ng use
Do not move the appl ance dur ng use
Close the gas conta ner valve after use. Do not mod fy the appl ance
DESTINATION LAND
I
3+(28-30/37)
：
BE, CH, CY, CZ, ES, FR, GB, GR, IE, IT, LT, LU, LV, PT, SK, SI.
I
3B/P(30)
：
BE, CY, DK, EE, FI,FR, HU, IT, LT, NL, NO, SE, SI, SK, RO, HR, TR, BG, IS, LU, MT.
I
3B/P(50)
：
AT, CH, DE, SK
I
3B/P(37)
：
PL
DELTA - BP61071 - 67452 Mundolsheim - FRANCE

Instruction manual
2
SAFETY ADVICES
1. LEASE READ THE FOLLOWING INSTRUCTIONS CAREFULLY
BEFORE USING THE A LIANCE AND KEE THEM FOR
FUTURE
2. CAUTION: Th s appl ance w ll become very hot. Do
not move t dur ng use.
3. Do not move the un t wh le n use.
4. CAUTION: Do not leave the appl ance w th n the
reach of ch ldren and pets.
5. Never leave the appliance unattended during use.
6. Do not allow children to use or play with the appliance.
7. Use the appliance only for its intended purpose.
8. WARNING! Do not use n closed or conf ned spaces.
Make sure t s placed n a well vent lated area.
9. The appl ance s ntended for outdoor use only and n
accordance w th local regulat ons.
10. Incorrect use or action and non-compliance with the safety
instructions in this manual can result in serious injury or
death.
11. Incorrect use or action and failure to observe the safety
instructions in this manual may result in fire or explosion,

Instruction manual
3
causing serious material damage.
12. Carry out a leak test every year and whenever the gas
cyl nder s changed or d sconnected. Check that the gas
hose connect ons are t ght and n good cond t on.
13. The appl ance must be nstalled on a flat, level, stable and
heat-res stant surface or floor before and dur ng use.
14. Do not obstruct the ventilation openings of the barbecue/
plancha
15. Do not use near flammable materials or substances. Do not
store unplugged gas cylinders or aerosol cans near this
appliance. Do not use within 1.5 metres of combustible
material.
16. No ignition products should be used with this appliance.
17. Do not lean over the appliance during lighting or cooking.
18. This appliance is for private use only. Do not use at events
or in public places.
19. Do not modify the appliance. This gas grill must be
assembled according to the assembly instructions provided.
If the appliance has been assembled in a shop, make sure
that the assembly has been carried out correctly and carry
out a leak test before using the grill. Incorrect assembly of
the appliance can be dangerous.
20. Do not use the barbecue / plancha in strong winds.
21. Do not use the barbecue / plancha if all parts are not in
place. Be sure to follow the assembly instructions to

Instruction manual
4
properly assemble this barbecue. Incorrect assembly can
be dangerous.
22. Use appropriate heat-resistant barbecue utensils to handle
cooking food. Wear protective gloves when using the
barbecue to avoid burns. Some accessible parts can be very
hot.
23. Do not cover the cooking grate with foil, dish or container
to avoid heat build-up. Do not cook in foil.
24. If your appliance has a lid, be careful when opening it. Hot
steam may be released from the inside.
25. DO NOT cook with the lid (if fitted) down when the valves
are on high heat, otherwise your appliance may be
damaged.
26. Allow the barbecue / plancha, the ashes and its accessories
or parts to cool down completely before cleaning and
storing it. It is recommended to empty the ashes 24 hours
after using the barbecue.
27. Always allow to cool before storing or cleaning.
28. Clean the appliance and its accessories after each use to
avoid the accumulation of grease (risk of fire).
29. lease store the appliance in a dry and sheltered place.
30. For details on how to clean food contact surfaces, refer to
the following paragraph of the manual.
31. If you detect a smell of gas:
- Turn off the gas supply to the appliance

Instruction manual
5
- Open the lid if the model has one
- Extinguish any open flame
- If the smell persists, stop using the appliance, move away
from the appliance and contact your dealer or the fire
brigade immediately.
A gas leak may cause a f re or explos on wh ch could result
n ser ous njury or death or damage to property.
32. Always close the gas cylinder when you are not using your
barbecue / plancha.
33. lease purchase gas connection accessories (hose,
regulator and gasket) that comply with the national
regulations in force in the country of destination. These
components must be replaced periodically, according to
the date indicated on the body of each of them, or
according to the national regulations in force in the country
of destination.
34. The gas supply pipe (not provided) must be installed so that
it does not come into contact with the hot surfaces of the
grill during operation or during storage and travel.
35. Never attempt to disconnect the pressure regulator or any
gas connection while using the barbecue.
36. Follow the instructions for connecting the regulator for
your gas barbecue.
37. Inspect the gas supply hose before each use. If it is
excessively cracked, worn or cut, it must be replaced with

Instruction manual
6
a pressure regulator and hose assembly specified by the
manufacturer before using the grill hose with a
replacement assembly specified by the manufacturer
before using the grill.
38. Do not overtighten connections. Do not use Teflon tape or
sealing fluids on connections.
39. Warn ng. Never connect your appl ance to town gas
(natural gas). The gas c rcu t s des gned exclus vely for
butane/propane gas (G30/G31).
40. Ensure that the gas cylinder is placed outside the appliance
during use.
41. Gas cylinders must never be used or stored lying down
42. After each use, ensure that all control levers are in the off
position and that the gas cylinder supply is closed.
Although this appliance has been manufactured to avoid sharp edges, care should be taken when
handling all parts to avoid the risk of injury.
Remove all protective packaging and keep it away from children. Read the safety instructions carefully
before you start using your barbecue.
Refer to the parts list and assembly diagrams to assemble your barbecue. Make sure that no parts or
pieces are missing or damaged/broken, which could impair the proper functioning of the appliance. The
guarantee for this appliance cannot be applied for abnormal conditions of use, incorrect storage
conditions, lack of maintenance, modification of the product, use for professional purposes, etc.
IGNITION
Make sure that the appliance is positioned on a stable, flat surface.
Wear protective gloves and open the vents wide (if the model has them) so that the air can flow in and
accelerate the combustion.

Instruction manual
7
CAUTION: Th s barbecue w ll become very hot. Do not move t dur ng use.
This product is intended for use with bottled gas only.
A regulator in accordance with EN16129 of 28 mbar must be used for butane gas or 37 mbar for propane
gas.
Never use an adjustable regulator with the product.
Make sure that the regulator is correctly set so that the supply pipe and valves are filled with gas.
Otherwise, the burners will not have enough power and will not light or will cut out regularly.
If you need to replace the gas cylinder, make sure that the appliance is switched off and that there is no
source of ignition nearby (spark, cigarette, open flame, etc.).
Make sure that the gas hose is not twisted, stretched, bent or kinked to allow free flow of gas.
•Use only spare parts supplied by your distributor. The failure to respect the modifications or the
replacements of spare parts would pull the cancellation of the guarantee.
•Never connect your appliance directly on your gas cylinder; use a regulator and a NF typical pipe.
•Never cover the device before it is not completely cooled.
•Use no spray near your device.
•Use no product of ignition while you light the device.
Informat on :
- Think of controlling the state of the burner before any use, especially if you do not use your device
frequently.
- Before the first use, clean your appliance with a clean wet cloth, let it dry completely.
Make warm your outdoor appliance during at least 10 minutes. This can release a light smell during a
few moments.

Instruction manual
8
ASSEMBLY
LPG GAS MIXTURES

Instruction manual
9
INSTRUCTIONS FOR USE
Follow these instructions carefully to avoid seriously damaging your barbecue and causing injury to
yourself and to property.
1. Assemble the barbecue following the assembly instructions carefully.
2. Connect the gas hose to the barbecue. Connect the regulator to the hose.
3. Connect the regulator to the cylinder valve following the regulator instructions supplied with the
regulator.
4. Turn all of the control knobs to the ‘OFF’ position before turning on the gas supply to the appliance.
5. Operate the regulator in accordance with the instructions supplied with the regulator.
LIGHTING INSTRUCTIONS: MAIN BURNERS
1. Connect the gas cylinder to the barbecue following the instructions supplied with the regulator.
2. Turn all the control knobs to the ‘OFF’ position.
3. Turn ‘ON’ the gas supply at the cylinder or regulator switch following the regulator connection and
operating instructions. Check the cylinder to regulator connection and hose to barbecue hose inlet

Instruction manual
10
connection for leakage using soapy water. Any leakage will show as bubbles in the area of the leak. If
leak is found, do not use the barbecue and turn off the gas supply. Consult your gas or barbecue
supplier for advice.
4. ush down and turn on the burner, at the same time, press on the red button of ignition, an audible
click will be heard and then the burners will be light.
5. If the burner has not lit after two attempts, turn ‘OFF’ the gas tap and wait 5 minutes before retrying
the ignition sequence.
6. When the burner has lit, the burner rate can be adjusted by turning the knob anticlockwise to any
position between the full and low rate positions.
7. Light the remaining burners from left to right in sequence.
8. To switch off the plancha, cut the gas inlet by turning the button of the valve or the regulator in position
"Stop", by following the instructions supplied with the regulator. Turn the buttons of all the burners in
the directions of watch hands, in position "Stop" switched off,(faded), when flames are switched off.
Warn ng: If any burner fails to ignite, turn the control knob off (clockwise) and also turn the cylinder valve
off. Wait five minutes before attempting to relight with ignition sequence.
After use, close the gas supply by either turning ‘OFF’ the switch on the regulator or turning ‘OFF’ the
cylinder valve.
In the event of light back whilst the appliance is in use. Turn all the controls, cylinder valve and regulator
switch to the ‘OFF’ position. Wait 5 minutes before attempting to relight the appliance. If the problem
persists after relighting, consult your gas dealer, or the store where you purchased the barbecue, or a
qualified gas engineer for assistance or repair. Never try to rectify the problem yourself as this could result
in serious injury and/or property damage.
Clean the appliance of excess fat, before storage, with a damp cloth using a mild detergent solution as the
cleaning agent.
Store the appliance in a clean dry environment.
Do not store your gas cylinder indoors. Store in a well ventilated area away from direct sunlight.
CONNECTING THE GAS CYLINDER TO THE APPLIANCE
This appliance is only suitable for use with low-pressure butane, propane or their mixture gas and used with the
appropriate low-pressure regulator via a flexible hose. The hose should be secured to the regulator and the
appliance with hose clips.
- Using 28mbar regulator with category I3+ for butane gas and a 37mbar regulator with category I3+ for
propane gas;
- Using a 30mbar regulator with category I3B/ (30);
- Using a 37mbar regulator with category I3B/ (37);
- Using a 50mbar regulator with category I3B/ (50);
Use a suitable regulator certified to BSEN 12864:2001.
lease consult your L G dealer for information regarding a suitable regulator for the gas cylinder.
BEFORE USE PLEASE CHECK FOR LEAKS
Never check for leaks with a naked flame, always use a soapy water solution

Instruction manual
11
TO CHECK FOR LEAKS
Make 2-3 fluid ounces of leak detecting solution by mixing one part washing up liquid with 3 parts water.
Ensure the control valve is “OFF”.
Connect the regulator to the cylinder and connect regulator with hose and outdoor gas grill, ensure the
connections are secure then turn ON the gas.
Brush the soapy solution on to the hose and all joints. If bubbles appear you have a leak, which must be
rectified before use.Turn off the gas supply in the event of gas leak.
Retest after fixing the fault. Turn OFF the gas at the cylinder after testing.
If detected leakage cannot be rectified, do not attempt to cure leakage but consult your gas dealer.
REGULATOR AND HOSE
Use only regulators and hose approved for L G at the above pressures (See age 6). The life expectancy
of the regulator is estimated as 10 years. It is recommended that the regulator is changed within 10 years
of the date of manufacture.
The use of the wrong regulator or hose is unsafe; always check that you have the correct items before
operating the barbecue.
The hose used must conform to the relevant standard for the country of use. The length of the hose must
be 1.5 meters (maximum). Worn or damaged hose must be replaced. Ensure that the hose is not
obstructed, kinked, or in contact with any part of the barbecue other than at its connection. Change
the hose when the national conditions require it and/or depending on it validity.
The hose should not be twisted or kinked when attached to the regulator and outdoor gas grill. No part of
the hose should touch any part of the appliance. So site the cylinder out to the left hand side of the
appliance at the maximum distant permitted by the hose length.
STORAGE OF THE A LIANCE
Storage of an appliance indoors is only permissible if the cylinder is disconnected and removed from the
appliance. When the appliance is not to be used for a period of time it should be stored in a dry dust free
environment.
GAS CYLINDER
The appliance can be used with any gas cylinder of weights between 4.5KGS and 15KGS butane and 3.9KGS
to 13KGS propane. The gas cylinder should not be dropped or handled roughly! If the appliance is not in
use, the cylinder must be disconnected. Replace the protective cap on the cylinder after disconnecting the
cylinder from the appliance. The maximum weight of cylinder is 6.75KGS.
Cylinders must be stored outdoors in an upright position and out of the reach of children. The cylinder
must never be stored where temperatures can reach over 50°C. Do not store the cylinder near flames,
pilot lights or other sources of ignition. DO NOT SMOKE.The cylinder should be changed away from any
source of ignition.

Instruction manual
12
CLEANING AND CARE
CAUTION:
All cleaning and maintenance should be carried out when the barbecue is cool and with the fuel supply
turned OFF at the gas cylinder. We would recommend that this gas grill should be serviced by your local
gas retail outlet at least once a year by a competent engineer. Do not attempt to service this appliance
yourself.
CLEANING
“Burning off” the barbecue after every use (for approx 15 minutes) will keep excessive food residue to a minimum.
OUTSIDE SURFACE
Use mild detergent or baking soda and hot water solution. Non-abrasive scouring powder can be used on
stubborn stains, then rinse with water.
If the inside surface of the barbecue lid has the appearance of pealing paint, baked on grease build up has
turned to carbon and is flaking off. Clean thoroughly with strong hot soapy water solution. Rinse with
water and allow to completely dry. Never use oven cleaner.
INTERIOR OF BARBECUE BOTTOM
Remove residue using brush, scraper and/or cleaning pad then wash with a soapy water solution. Rinse
with water and allow dry it.
PLASTIC SURFACES
Wash with a soft cloth and hot soapy water solution. Rinse with water. Do not use abrasive cleaners,
degreasers or a concentrated barbecue cleaner on plastic parts.
COOKING PLATE
Use a mild soapy water solution. Non-abrasive scouring powder can be used on stubborn stains then rinse
with water.
GREASE TRAY
lease do not open the grease tray during use.
When clean the grease tray, take it away.
lease check it on time and take away the oil when 1/3 full.
CLEANING THE BURNER ASSEMBLY
Turn the gas OFF at the control knob and disconnect the cylinder.
Remove cooling grate.
Clean the burner with a soft brush or blow clean with compressed air and wipe with a cloth.
Clean any clogged ports with a pipe cleaner or stiff wire (such as an opened paper clip).

Instruction manual
13
Inspect burner for any damage (cracks or holes). If damage is found, replace with a new burner. Reinstall
the burner, check to ensure that the Gas valve orifices are correctly positioned and secured inside the
burner inlet (venturi).
In some cases your barbecue will light back because of an insect crawling inside the burner venturi or a
spider spinning its web inside the burner. This can be rectified by using a bottle brush inserted through the
burner venturi and pushing it into the burner over the burner length. If condition persists consult your gas
dealer.
SERVICING
Your gas barbecue should be serviced annually by a competent registered person.
Correct d sposal of the un t
(Electr cal and Electron c Equ pment)
(Applicable in the European Union and the rest of Europe that have adopted separate collection systems
countries)
The European Directive 2012/19/EU on Waste Electrical and Electronic Equipment (WEEE), requires that old household
electrical appliances must not be disposed of in the normal household waste stream. Old appliances must be collected
separately in order to optimize the recovery and recycling of the materials they contain and reduce the impact on human
health and the environment. The symbol of the crossed-out dustbin is marked on all products to remind the obligations of
separate collection. Consumers should contact their local authority or retailer for information concerning the correct disposal
of their product.
•hoto no contractual
• Worried about the quality of his products the manufacturer reserves the right to make modifications without advance
notice
LIVOO
BP 61071
67452 Mundolsheim - FRANCE