Local Motors Olli User manual

Owner’s
Manual
V1.0 - 2020
Everything you need to know about Olli

Congratulations and thank you for choosing
Olli. We are pleased to welcome you to the
growing number of organizations who use
Olli. We are very proud of the advanced
engineering, autonomy and high-quality
construction of each Olli we create. This
manual will introduce you to Olli’s features,
safety, infrastructure needs, maintenance
and other useful information. To become
familiar with your new Olli and fully enjoy
the experience, please read carefully.
Olli will need an Onboard Steward when
driving in manual mode and for regular
maintenance. The Onboard Steward will
be provided to you either by LMI or an
approved channel partner/fleet operator
organization. Any service related activities
must be performed only by the service team
from LMI or from an approved organization.
All information in this manual is current
at the time of publication. However, LMI
reserves the right to make changes at
any time so that our policy of continual
product improvement may be carried out.
For any questions about the operation,
maintenance, service or other topics
not covered in this manual, please
contact Local Motors Service Department
at 1.888.256.2028.
Introduction

Contents
Information in this document considered of
importance is distinguished by the following
icons and notations. Please be familiar with
these icons as they will appear throughout.
Caution
This symbol indicates a hazardous situation
which, if not avoided, could result in minor or
moderate injury to people.
Warning
This symbol indicates a hazardous situation
which, if not avoided, could result in death or
serious injury to people.
Electric Shock
This symbol indicates a hazardous situation
which, if not avoided, could result in death or
serious injury due to electricity.
Notice
This symbol indicates a situation which, if not
avoided, could result in vehicle damage.
Important Labels
Recognizing Olli
Pg. 22-23
2.0
Vehicle Overview
Pg. 08-09 |About Olli
1.0
Pg. 10-15 |Vehicle Features
Pg. 16-17 |Operator Controls
Pg. 18-19 |Vehicle Technical Specifications
Safety
Pg. 26-27 |Safety Systems
5.0
Pg. 28-29 |Egress Procedure
Pg. 30-31 |Electrical Safety
Pg. 32-35 |Hazardous Materials
Infrastructure
Pg. 38-39 |Garage Requirements
3.0
Pg. 40-41 |RTK Base Station
Pg. 42 |Laptop & Cables
Pg. 42 |Internet Requirements
Pg. 43 | Power & Charging Requirements
Shipping Procedures
7.0
Wrapping Olli
Pg. 64-65
8.0
Warranty
Pg. 68-69
9.0
Additional Notes
Pg. 72-78
10.0
Information Technology
Pg. 54-55 |GDPR Requirements
6.0
Pg. 56-57 |Cybersecurity Information
General Maintenance
Pg. 46 |Charging Olli
4.0
Pg. 47-48 |Cleaning Olli
Pg. 49 |Tire Maintenance
Pg. 50-51 |Towing
Pg. 61 |Vehicle Lift Points
Pg. 60-61 |Shipping Procedures

Vehicle
Overview
Page .07

Page .09
Olli Owner’s Manual:
Vehicle Overview
About
Olli
Meet Olli, your friendly neighborhood mobility solution
and the world’s first co-created, self-driving, electric
and cognitive shuttle. Olli is ready to change the way we
view transportation. From neighborhoods to campuses
to urban city centers, learn how Olli is the smart, safe,
sustainable option for getting around.
Olli is a low speed electric powered passenger carrier
vehicle designed for use in light occupancy transit.
Olli can transport one Onboard Steward and up to eight
seated occupants. Olli has an air ride automatic leveling
suspension system to adjust ride height and provide
smooth performance.
Each Olli shuttle has an electronically activated door,
eight passenger seats with seatbelts and cabin climate
control. Olli is a drive-by-wire system using electronic
servo motors to actuate steering and braking controls
via joystick input command.

01 Audio Speakers
02 Grab Handles
03 Seatbelts with Rectractors
04 Forward-Facing Rear Passenger Seating
05 Rear-Facing Front Passenger Seating
06 Information Display Screens
07 Emergency Window Breaker
08 Side-Facing Seating
09 Emergency Stop Button
10 Olli Control Center
Interior
Olli Owner’s Manual:
Vehicle Overview
Vehicle
Features
05
02
04
07
06
09
01
03
08
10
Page .11

02
01
03
04
05
07
12
08
10
11
09
06
01 GPS (Hidden)
02 Rear Upper Camera
03 Rear Light Blades
04 Rear Information
Display Screen
05 Taillights
06 Rear Lower Camera
07 Rear LiDAR
08 Rear Radar
09 Rear Tow Hook
Exterior, Rear
Page .13
02
06
08
04
07
09
03
05
01
01 Front Right Camera
02 Front Windscreen
03 Front Light Blades
04 Headlights
05 Front Lower LiDAR
06 GPS (Hidden)
07 Front Upper LiDAR
08 Front Left Camera
09 Front Information
Display Screen
10 Front Lower Camera
11 Front Radar
12 Front Tow Hook
Exterior, Front
Olli Owner’s Manual:
Vehicle Overview

Page .15
01 Rear Left Window Pane
02 Left Camera
03 Front Left Window Pane
04 Left Center Window Pane
05 Front Left Radar
06 Front Left Reflector
07 Front Left LiDAR
08 Left Bottom Window Pane
09 Rear Left LiDAR
10 Rear Left Reflector
Exterior, Left
02
03
05
06
01
10
08
07
09
04
01 Front Right Window Pane
02 Side Information
Display Screen
03 Right Camera
04 Rear Right Window Pane
05 Door Entry Button (Captron)
06 Vehicle Identification Plate
07 Rear Right LiDAR
08 Rear Right Reflector
09 Wheelchair Ramp
10 Entry Door
11 Emergency Door
Release Button
12 Front Right LiDAR
13 Front Right Radar
14 Front Right Reflector
Exterior, Right
04
07
03
10
12
02 01
08
09
06
05
11 13 14
Olli Owner’s Manual:
Vehicle Overview

01 Steward Display Screen
02 Emergency Stop Button
03 Ignition Switch
04 Hand Brake
05 Air Ride Automatic Control
06 Autonomous/Manual Mode Switch
07 Forward/Reverse Switch
08 Autonomous Engagement Button
09 Autonomous Disengagement Button
10 Driver Controls
Olli Control Center
Olli Owner’s Manual:
Vehicle Overview
Operator
Controls
Page .17
10
02
01
04
0605 07 08 09
03
For safety reasons, we only authorize certified Onboard Stewards
to do the following operations.
• Use Olli’s control center
• Switch on/off procedures
• Drive in manual/autonomous mode
• Park Olli in the garage
• Remove any components from Olli
• Use the laptop provided by Local Motors in the garage
• Other activities related to operating Olli
Detailed instructions on how to operate Olli are covered in the Operator’s
Manual. The Operator’s Manual is provided to certified Onboard Stewards,
channel partners, and fleet operating agencies.
Any identified service related issues must be reported to Local Motors
Service Department at 1.888.256.2028.
Do not attempt to start and/or drive Olli if you are
not a certified Onboard Steward. Operating Olli
without Local Motors’ approval may void the
warranty and may be subject to legal consequences.
Do not attempt servicing any component of
Olli without consulting Local Motors Service
Department. Servicing Olli without Local Motors’
approval may void the warranty and may be
subject to legal consequences.

Olli Owner’s Manual:
Vehicle Overview
Vehicle Technical
Specifications
A Overall Length 162.8 in (4136 mm)
B Overall Width 79.6 in (2022 mm)
C Overall Height 102.7 in (2610 mm)
D Wheel Base 101 in (2567.7 mm)
E Ground Clearance 4.8 in (122 mm)
F Ride Kneeling +/- 2.65 in (67.5 mm)
G Overhang, Front 30.8 in (783.3 mm)
H Overhang, Rear 31 in (787.4 mm)
I Track, Front & Rear 70.9 in (1800 mm)
Exterior Dimensions
Curb Weight 4900 lbs (2222 kg)
Max Load 1600 lbs (726 kg)
Max Gross Weight 6500 lbs (2948 kg)
Weight
Front 4-Piston Disk Brake
Rear Single Piston Disk Brake
Integrated Parking Brake
12V Battery Type Lead Acid
EV Battery Type Li-ion
EV Battery Nominal Energy 18.5 kWh
EV Battery Voltage Range 300-400V
Vehicle Operating
Temperature Range 32°F/0°C to 115°F/ 46°C
Brakes
Battery
Model Rear Wheel Hub Motor x 2
Peak Power 215 hp (160 kW)
Continuous Power 163 hp (120kW)
Max Speed 25 mph (40 kph)
Motor Weight 79 lb (36 kg)
Peak Torque 1844 ft-lb (2500 Nm)
Motors
I
C
E
B
D
G
H
A
Page .19

Recognizing
Olli
Page .21

Olli Owner’s Manual:
Recognizing Olli
Recognizing
Olli
Page .23Page .23
The photos in this document as well as the following
listed identification markers will help identify Olli
among other on-road vehicles.
01 Hoop shaped A-pillars on the corners
02 Large curved glass pane on the front and rear
03 Door located on right hand side
04 Large vertical display screen near the door
05 Horizontal front and rear fascia display screens
06 Olli is visually front and rear symmetrical, with only slight
differences in her lights, LiDAR and radar placement
Recognition Markers
01
02
05
03
04

Safety
Page .25

Olli Owner’s Manual:
Safety
Safety Systems
Page .27
Autonomous Safety Systems
Built-In Standard Safety Systems
• LiDAR and radar sensors act as redundant systems to detect a
number of similar objects
• Auto Drive, which slows down or brings Olli to a full stop, as it
detects static or moving objects that are, or may come into her
path. It ensures Olli maintains a safe distance from all objects
• An Onboard Steward continuously monitors any irregularity in
auto drive and is fully trained to overtake and manually control
at any time, if needed
• Seamless, instantaneous switch-over capability from
autonomous to manual mode
• Real-time data collection for continuous improvement
Handrails (Top Two)
Seat Belts (Bottom)
Roadside
Safety Kit
First Aid Kit
and Flashlight
• Paravan brake-by-wire and steer-by-wire
ensures smooth and reliable braking,
with redundant power system
• Manual Parking Mechanical Brake
• Emergency stop button
• Multiple emergency door release buttons
• Eight seat belts
• Handrails
• ADA compliant manual wheelchair
restraint system
• ADA compliant wheelchair ramp
• Front and rear bumper sensors
• Tempered and laminated glass windows
• Exterior lighting with side markers
and direction indicators
• Egress lighting
• Interior lighting
• Safety Kit
• Fire extinguisher
• Emergency glass breaker
• Vertical Grab Handle
• Horizontal Grab Handle
• Display screen for Onboard Steward
displaying forward and side road views
• Front and rear fascia screens with
operational alerts
• No-slip floor
• Horn

Page .29Page .29
Olli Owner’s Manual:
Safety
Egress Procedure
Breakable Glass Pane
Emergency Egress Overview
In an event of an emergency, the door should be used as the
first point of exit. There are two emergency door release buttons
which override the electronic push button, as well as allow manual
movement of the sliding door.
In the event of a malfunction or the need to open door, locate and
push one of the red emergency buttons. One button is located on
the exterior right side of the vehicle and the other is located inside
at the base of the rear seat.
Window Egress Overview
Window egress should be used if the vehicle:
• Is disabled and the door is unable to operate either electronically
or by manual override
• Is turned on its side, fully upside-down, has entered a body
of water, is pinned against an object, or any other scenario in
which the door cannot be used
Pointed Tip of
Window Breaker
Using the Window Breaker
Step 01
Remove the Window Breaker attached to Olli’s left B-pillar.
Step 02
With the Pointed Tip, strike the center of the glass pane.
Step 03
If the vehicle has overturned and is resting with the door side on the
ground, it will be impossible to egress from the door side. In such a
case, break the center glass above side seats (opposite the door)
and use the bench seats and railings to climb up and out of the vehicle.
When shattering glass, all persons onboard
must protect their eyes and face.

Page .31Page .31
Olli Owner’s Manual:
Safety
Electrical Safety
Olli is a fully electric vehicle and contains
significantly more electronic components
and electric wiring compared to
traditional combustion engine vehicles.
There are two main voltage systems
inside Olli:
• High voltage system
• Low voltage system
Neither the high voltage nor the low
voltage system has any serviceable
components that need the attention of
Olli’s owner or Onboard Steward. In case
of issues, these components must be
only accessed by the Olli service team.
Low Voltage System: Olli has two 12vdc sealed batteries.
The low voltage electrical system is safe from electrical shocks provided all
safety guidelines are followed, as with any other type of passenger vehicle
using a 12vdc system.
Olli is equipped with a master 12vdc disconnect switch that disables the
electrical path from ground.
01 High Voltage Battery
02 High Voltage Cabling
03 High Voltage Distribution Box (HVDU)
04 Hub Motor
05 Charge Port
06 Cabin Heater
01 Break Out Box
02 Air Conditioning Compressor
03 DC/DC Converter
04 Onboard Charger
05 Hub Motor
High Voltage System: High voltage cables are typically colored in orange. Never
disassemble, remove or replace high voltage components, connectors or cables. In
the unlikely event that a fire occurs, immediately contact your local fire emergency
responders.
High voltage system is
extremely dangerous and could
result in serious injury or death.
03
04
02
11
10
09
01
05
06
07
08
11
09
10
08
07
02
01
03
01 DC/DC Converter
02 12v Lithium Ion
03 12v SLA Battery

Page .33
Hazardous
Materials
Olli Owner’s Manual:
Safety
The following is a list of potentially harmful materials
on Olli that one should be aware of when
maintaining/ shipping the vehicle. For your safety,
always read and follow the instructions printed on
fluid containers. In case of battery rupture, major
leakage or explosion, evacuate all passengers and
quarantine the contaminated area.
Some fluids (battery acid, battery coolant, brake
fluid, windshield washer additives, etc.) used in Olli
are poisonous and should not be inhaled, swallowed
or brought into contact with open wounds.
High Voltage
Lithium-Ion
Battery
INHALATION: Provide good ventilation to clear out any fumes, gases or pungent odors.
EYE CONTACT: Rinse eyes with plenty of water for 15 minutes.
SKIN CONTACT: Rinse affected skin area with plenty of water and soap or take a shower for 15 minutes.
INGESTION: Expose those affected to fresh air and use artificial respiration, if needed. Consult a
physician or local poison control center immediately, if any fluid was ingested.
Seek medical attention, as needed.
INHALATION: Move those affected into fresh air and keep them calm under observation. Get medical
attention if any discomfort continues. In the case of exposure to contents of an open or damaged
battery, immediately flush with plenty of water for at least 15 minutes while removing contaminated
clothing and shoes. Get medical attention if irritation develops and persists.
EYE CONTACT: Flush thoroughly with water for at least 15 minutes. Hold eyelids open during flushing.
If irritation persists, repeat flushing. Get medical attention if irritation develops and persists.
INGESTION: Rinse mouth thoroughly with water. DO NOT induce vomiting because of danger of aspirating
liquid into lungs. Get medical attention immediately.
Under normal conditions of processing and use, exposure to the chemical constituents in this product is
unlikely. The battery should not be opened or burned. Exposure to the ingredients contained within or
their combustion products could be harmful.
Low Voltage
Sealed Lead
Acid Battery

Page .35
Olli Owner’s Manual:
Safety
R134a
Refrigerant
EYE CONTACT: Rapid evaporation of liquid in contact with the eye will damage it. Hold eyelids apart
and flush eyes with plenty of water for at least 15 minutes. Get medical attention.
SKIN CONTACT: Rapid evaporation of liquid may cause frostbite. Take off all contaminated clothing
immediately if not stuck to the skin. Flush area with lukewarm water. Do not use hot water.
INHALATION: Rapid evaporation of the liquid may cause frostbite. Vapor is heavier than air and can
cause suffocation. Remove from exposure, move to fresh air, and lie down. Keep patient warm and
at rest. Artificial respiration and/or oxygen may be necessary. Consult a physician.
INGESTION: Toxic or fatal, if ingested. For diethylene glycol, a component of this mixture, a lethal dose
can be as little as two ounces. Symptoms of diethylene glycol poisoning include severe abdominal
cramping, diarrhea, vomiting, sweating, confusion, cardiac abnormalities, neurological abnormalities,
infrequent urination, intoxication or CNS depression. If left untreated, product will metabolize to cause
metabolic acidosis, renal failure, hyperkalemia, hyponatremia, paralysis, cardiac failure or death. Seek
medical attention immediately for poisoning. If ingested, DO NOT wait for symptoms to develop before
getting treatment. Read and observe the instructions provided by the manufacturer of the product.
DOT 4
Brake Fluid
Antifreeze
Coolant
EYE CONTACT: May cause slight eye irritation. May cause slight corneal injury.
SKIN CONTACT: Brief contact is essentially non-irritating to skin.
INHALATION: At room temperature, exposure to vapor is minimal due to low volatility. Mist may cause
irritation of the upper respiratory tract.
INGESTION: Toxic or fatal, if ingested. For diethylene glycol, a component of this mixture, a lethal dose
can be as little as two ounces. Symptoms of diethylene glycol poisoning include severe abdominal
cramping, diarrhea, vomiting, sweating, confusion, cardiac abnormalities, neurological abnormalities,
infrequent urination, intoxication or CNS depression. If left untreated, product will metabolize to cause
metabolic acidosis, renal failure, hyperkalemia, hyponatremia, paralysis, cardiac failure or death. Seek
medical attention immediately for poisoning. If ingested, DO NOT wait for symptoms to develop before
getting treatment. Read and observe the instructions provided by the manufacturer of the product.
EYE CONTACT: May cause slight eye irritation. May cause slight corneal injury.
SKIN CONTACT: Irritating to skin. Wash with plenty of soap and water.
INHALATION: At room temperature, exposure to vapor is minimal due to low volatility. Mist may cause
irritation of the upper respiratory tract.
INGESTION: Toxic or fatal if ingested. For diethylene glycol, a component of this mixture, a lethal dose
can be as little as two ounces. Symptoms of diethylene glycol poisoning include severe abdominal
cramping, diarrhea, vomiting, sweating, confusion, cardiac abnormalities, neurological abnormalities,
infrequent urination, intoxication or CNS depression. If left untreated, product will metabolize to cause
metabolic acidosis, renal failure, hyperkalemia, hyponatremia, paralysis, cardiac failure or death. Seek
medical attention immediately for poisoning. If ingested, DO NOT wait for symptoms to develop before
getting treatment. Read and observe the instructions provided by the manufacturer of the product.

Infrastructure
Page .37

Page .39Page .39
Olli Owner’s Manual:
Infrastructure
Garage
Requirements
To ensure optimal functionality and longevity of your Olli, it is
recommended to have a properly equipped garage or storage
facility. This is to allow proper clearance for comfortable repair
and maintenance procedures. It is beneficial to have the parking
location be within range (3.5ft/1m) of a charging station.
Parking areas should be protected against weather effects
and safety equipment must be available.
Regulations require personal protective equipment (PPE) be
readily accessible in the storage facility:
• Proper marking kit to denote EV storage warnings
• Protective gloves
• Facial protective screen/safety glasses
• Safety shoes
• Power-checker
• First aid kit
• Fire extinguisher
The list below summarizes the technical prerequisites
for Olli’s storage and recharging system.
• The minimum recommended ceiling height is 15ft (4.5 m)
• The minimum recommended width is 10ft (3m)
• The minimum recommended depth is 20ft (6m)
• The temperature for storage area must be between
52°F (11°C) and 88°F (31°C)
• A well-controlled ventilation system