Master cook SRGG41126 User manual

Model No. SRGG41126
SAFETY INSTRUCTIONS TESTED INACCORDANCE WITH BS EN498:2012 STANDARD
Manufactured by:
SHINERICH INDUSTRIAL LTD.
8/F, NOBLE CENTER NO.1006, 3RD FUZHONG RD.,
FUTIAN DISTRICT, SHENZHEN, CHINA
0359
4 + 2 Burner Gas Grill User Manual
1

PRIOR TO USE:
Read the instructions before using the
appliance.
Use outdoors only.
Do not move the appliance during use
Do not modify the appliance.
Parts sealed by the manufacturer or his
agent must not be altered by the user.
DANGER:
If you smell gas:
1. Shut off gas supply to appliance.
2. Extinguish any open flame, avoid using any
electrical appliance.
3. Open lid and ventilate the area.
4. Check gas connections with soap solution.
5. If odor still exists, immediately contact
your gas supplier or fire department.
IMPORTANT:
Hazardous fire or explosion may result if these
instructions are ignored.
It is the user’s responsibility to see that this
barbecue is properly assembled, installed, and
taken care of. Failure to follow instructions in
this manual could result in serious bodily injury
and/or property damage.
Any modification of the appliance, misuse, or
failure to follow the instructions may be
dangerous and will invalidate your warranty.
WARNING:
Accessible parts may be very hot. Keep
young children away.
This appliance must be kept away from
flammable materials during use.
Please keep this manual for future reference
2

Table of Contents
1. Information.................................................................................................................4
2. Safety instructions......................................................................................................5
3. Explode view & Hardware.........................................................................................6
4. Assembly instructions................................................................................................8
5. Installing with gas supply system..............................................................................21
6. Operating instructions.......................................................................................…….22
7. Cleaning and maintenance ....................................................................................... 25
8. Troubleshooting ........................................................................................................26
9. Limited Warranty…………………………………………………………….……..27
3

1. Information
PIN Number 359CL1089 ∑Qn
∑Qn
17.7kW (1276 g/h)
Main burners ∑Qn :
Side burner ∑Qn : 10 kW (717g/h)
2.8kW (203g/h)
Main infrared burner
∑Qn
Back burner
2.45
2.45
kW (178g/h)
kW (178g/h)
Country Category Injector Size
(Main Burner)
Injector Size
(Main Infrared
Burner)
Injector Size Injector Size
(Side Burner) (Back Burner) Gas & Pressure
□AT □CH □DE □SK I3B/P(50) 0.80 mm 0.68 mm 0.68 mm
0.79 mm
0.79 mm
0.79 mm
0.79 mm
0.74 mm G30 Butane and
G31 Propane at
50mbar
□BE □CY □DK □EE
□FR □FI □HU □IT
□LT □NL □NO □SE
□SI □SK □RO □HR
□TR □BG □IS □LU
□MT
I3B/P(30) 0.90 mm 0.83 mm G30
Propane at
30mbar
□BE □CH □CY □CZ
□ES □FR □GB
□GB
□GR
□IE □IT □LT □LU
□LV □PT □SK □SI
I3+(28-30/37) 0.90 mm 0.83 mm G30 Butane
Butane
and G31
Propane at
37mbar
CAUTION :
USE OUTDOORS ONLY. If stored indoors, detach and leave cylinder outdoors.
Read the instructions before using the appliance.
Minimum clearance from side and back of unit to combustible construction: 100cm.
WARNING: Accessible parts may be very hot. Keep young children away.
MADE IN CHINA
SUPPLIED BY: Shinerich Industrial Ltd.
Product Name 4 + 2 BURNER GAS GRILL Model No. SRGG41126
8/F, Noble Center No.1006, 3rd Fuzhong Road
Futian District, Shenzhen, China
at 28-30 mbar
and G31
4

2. Safety instructions
Leak test all connections after each tank refilled or first use after a long period, by which the
method is described in the “Installing with gas supply system” part.
This Barbecue is NOT for commercial use.
Never use an LP gas tank with damaged body, valve, collar, or footing.
Do not store a spare LP gas tank under or near this appliance.
The use of alcohol, prescription or non-prescription drugs may impair the ability to properly
assemble or safely operate the appliance.
Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene, or alcohol within this product.
Do not store or use gasoline or other flammable liquids or vapors within 25 feet (7.6m) from
this appliance.
Do not use this appliance under overhead combustible surface.
Do not use the barbecue unless it’s completely assembled and all parts are securely fastened
and tightened.
This barbecue should be thoroughly cleaned and inspected on a regular basis, clean and inspect
the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts or leaks, the
hose must be replaced prior to the appliance being operated.
Use only factory authorized parts. The use of any part that is not factory authorized is
dangerous. This may also void your warranty.
When cooking, fire extinguishing materials shall be readily accessible. In the event of an oil
grease fire, do not attempt to extinguish with water. Use type B or type C dry chemical fire
extinguisher or smother with dirt, sand or baking soda.
Operate on solid ground only, do not install or use in/on boats or recreational vehicles.
Do not leave a lit barbecue unattended, especially keep children and pets away from barbecue
at all times.
Do not move the appliance during use.
Always open barbecue lid carefully and slowly as heat and steam trapped within barbecue can
severely burn you.
Move gas hoses as far away as possible from hot surface and dripping hot grease.
Keep all electrical cords away from a hot barbecue.
Turn off the gas supply at the gas cylinder after use.
Never cover the entire cooking area.
Never obstruct the ventilation openings of the container compartment.
When handling particularly hot components, protective gloves should be used.
The type of regulator to be used shall comply with the relevant EN standard.
The type of flexible tube to be used shall comply with the requirement of the national conditions.
5

3. Explode view & Hardware
19-A 19-B 19-C
Optional:
19-A: Cast iron cooking grates 2pcs
19-B: Cast iron cooking grate 1pc
Cast iron cooking plate 1pc
19-C: Cast iron cooking grates 2pcs
Infrared burner cast iron grate 1pc
1
2
5
67
4
9
10
11
16
15
12
17 18
25
28
26
36
35
24
22
23
20
21
13
14
33
32
31 30
29
34 27
3
19
8
6

44CC M5 x 10
Hardware List
Part #
AA M6 x 12 18
16BB M6 x 10
Dimensions Picture Qty (pcs) Part #
DD M5 x 12 4
2
2
EE
FF
M4 x 10
M4 x 12
Dimensions Picture Qty (pcs)
Part List
1
18 4
2
1
1
1
1
1
1
1
1
1
1
1
2
2
2
2
3
3
19*
* Note: #19 Cooking grate may stand for cooking grate or cooking plate according to different models.
21
20
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
2
3
4
5
6
7
8
9
10
11
12 5
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
5
13
14
15
16
17
Part # Picture
Qty (pcs) Part # Picture Qty (pcs)
7

8
4. Assembly instructions
Please read these instructions carefully before assembly and use.
Find a large, clean area to assemble your barbecue. Please refer to the parts list and assembly
diagram as necessary. Assembly of the barbecue involves many large components; it is
advisable to have two people assemble the unit.
Please use protective gloves when assembling this product.
To avoid losing any small component or hardware, assemble your product on a hard level
surface that does not have cracks or openings.
To avoid damage to soft floor or carpet, do not assemble or move the appliance on soft floor or
carpet.
Follow all steps in order to properly assemble your product.
Make sure all the plastic protection rip off before assembling.
Do not force parts together as this can result in personal injury or damage to the product.
When applicable, tighten all hardware connections by hand first, once the step is completed, go
back and full tighten all hardware.
Caution: Whilst every effort has made in manufacture of your barbecue to remove any sharp edge,
you should handle all components with care to avoid accidental injury.
STEP 1
BBx16 M6x10
23
22
24
BB

STEP 2
STEP 3
24
FFx2 M4x12
CCx3 M5x10
FF
CC
9
25

STEP 4
STEP 5
CCx8 M5x10
CCx3 M5x10
29
18
CC
17
24
CC
10

STEP 6
STEP 7
CCx8 M5x10
CCx7 M5x10
CC
29 17
16
24
18 CC
17
11

15
26
21
STEP 8
STEP 9
DD
DDx4 M5x12
CCx4 M5x10
DD
CC
24
26
21
12

3
9
CC X 4
1
STEP 10
STEP 11
CCx4 M5x10
CCx4 M5x10 9
18
CC X 4
13

STEP 12
CCx3 M5x10
14
31
32
cc

STEP 13
AAx9 M6x12
AA X 2
32
9
1
32 31
9
AA X 4
31
AA X 3
9
15

STEP 14
AAx9 M6x12
8
9
AA X 4
1
8
9
1
AA X 2 8
AA X 3
9
16

15PETS
EEx2 M4x10
17
10
EE X 2
10
12
8
EE X 2
10
12
8
10
8
13
10

STEP 16a
18
7 6
10
Ignition wire

STEP 16b
STEP 17
5
2
19
34
1
9
8
19

STEP 18
STEP 19
AA
not included
20
+ -
+ -
Battery