Mechline Basix bsx-mhb-x Installation instructions

INSTALLATION&OPERATINGMANUAL REVISION:07/2020|page1of16

CONTENTS:

ChapterDescriptionPage

1. Introduction .......................................................... 1

2. ModelsandSpecifications .................................... 3

3. ProductSafety ...................................................... 4

4. Structure ............................................................... 5

5. LocationAdvice ..................................................... 5



8. GeneralMaintenance ......................................... 13

9. AfterSalesandServiceSupport ......................... 13

10. Warranty ............................................................. 13

Chapter1.INTRODUCTION

ThankyouforpurchasingMechline’sBaSixTMmobilehandwashstation.Whencorrectlyinstalled,andoperatedin

accordancewiththisOperatorManual,itwillprovidemanyyearsofservice.

Mechline’shygienichand-washingsolutionshelpoperationsmeettheirrequirementstoprovidehand-washfacilities

forstaffandcustomersonsite.Bygivingtoolstomakeiteasierandfaster,goodandsafehabitsaremoreeasily

followedandenforced.

Hands-freetechnologyimproveshealthandsafety,byremovingtheneedformanualcontactandpreventingthe

spreadofgermsbyhand.

Hand-washingisthenumberonepreventionagainstthespreadofviruses,bacteriaandotherpathogens.Goodhand-

washinghabitscanbeencouragedwiththerightequipmentinstalledinthecorrectposition.

Spoutwithwatersavingdiffuser–OurBSX-MHB-Xmodelwillprovideapprox.223handwashcyclesfrom1x12.5L

watercontainer.Ifthealternativeultrawater-savingdiffuserisfittedtothespout,thiswouldprovideapprox.304

handwashcyclesfrom1x12.5Lwatercontainer.OurBSX-MHB-HWCandHWC-Tmodelscanreduceyourwater

consumptiontoaslittleas0.6lpmwhenconnectedtomainswater(testedat3barpressure).

Portable–Allmodelscanbetransportedwitheaseusingthecastorsandgrabhandle.Idealforuseatentrancesto

buildings/operations.Thecastorscanberemovedtoallowflushtowallfittingifdesired.

LEAVE THIS MANUAL WITH THE OPERATOR AFTER INSTALLATION

6. INSTALLATIONINSTRUCTIONS ............................. 6

7. OPERATINGINSTRUCTIONS ................................ 12

INSTALLATION &

OPERATING MANUAL

MODELS:

BSX-MHB-X

/

BSX-MHB-HCW

/

BSX-MHB-HCW-T

Mobile Hand Wash Station

REVISION:07/2020|page2of16INSTALLATION&OPERATINGMANUAL



Mobile Hand Wash Station

INSTALLATION&OPERATINGMANUALREVISION:07/2020|page3of16

Chapter2.MODELSandSPECIFICATIONS

Modelnumbers BSX-MHB-X BSX-MHB-HCWBSX-MHB-HCW-T

RegionUK/International

MODELFEATURES

Standard•2xremovablecastors

•Splashbackwith

integratedgrabhandle

•Fronthingeddoor,with

¼turnthumblatch,to

accessstoredcontainers

•Built-inslotsinside

panelsforhangingbin

andtoweldispenser

options

•2x12.5Lcontainersfor

waterfeedandwaste

watercollection

•ReinforcedPVCwater

hoses

•Flexiblewasteconnection

•Manualfootpumpvalve

•Spoutfittedwith

water-savingdiffuser

•Alternativeultra

water-savingspout

diffusersupplied



•2xremovablecastors

•Splashbackwith

integratedgrabhandle

•Fronthingeddoor,with

¼turnthumblatch,to

accessservicesand

internallowerstorage

shelf

•Built-inslotsinside

panelsforhangingbin

andtoweldispenser

options

•Built-incut-outswith

removablecoverstothe

rearandsidepanels-for

wasteandwaterservices

connection

•Timeflowfootvalve

•Manualmixervalve

•Spoutfittedwith

water-savingdiffuser

•2xremovablecastors

•Splashbackwith

integratedgrabhandle

•Fronthingeddoor,with

¼turnthumblatch,to

accessservicesand

internallowerstorage

shelf

•Built-inslotsinside

panelsforhangingbin

andtoweldispenser

options

•Built-incut-outswith

removablecoverstothe

rearandsidepanels-for

wasteandwaterservices

connection

•Timeflowfootvalve

•Thermostaticmixervalve

•Spoutfittedwith

water-savingdiffuser

Optional

•Deckmountedsoap

dispenser

•Spare12.5Lcontainers

•Hangingbinand/ortowel

dispenser

•Deckmountedsoap

dispenser

•Hangingbinand/ortowel

dispenser

•Deckmountedsoap

dispenser

•Hangingbinand/ortowel

dispenser

SITE&INSTALLREQUIREMENTS

Site

NOwater/waste

connectionorelectricity

required.

NB:COLDwateroperation

onlyviastoredcontainers

Hotandcoldwater

(minimum1.5bar)and

wasteconnection

Hotandcoldwater

(minimum1.5bar)and

wasteconnection

Installation!Freestanding

!Wallfixing-optional

MATERIALS

Mainbody430stainlesssteel

Basinbowl304stainlesssteel

FootplateReinforced,heavy-dutystainlesssteel

DIMENSIONS&WEIGHTS

Dimensions1222mm(H)X382mm(W)X360mm(D)

Netweight15.5kg15.6kg15.6kg

Mobile Hand Wash Station

REVISION:07/2020|page4of16INSTALLATION&OPERATINGMANUAL

Chapter3.PRODUCTSAFETY

3.1SYMBOLS

MEANING/DESCRIPTIONSYMBOL

UsePPE

TheuseofsuitablePPE,suchasgloves,isrecommendedwhen

cleaningormaintainingthisproduct.

Warning/Caution

Anappropriatesafetyinstructionshouldbefollowedorcaution

toapotentialhazardexists.

RefertoManual

Refertotherelevantinstructionsdetailedwithintheproduct

manual.

 

Beforeoperatingtheunit,readtheseinstructionscarefully.Correctinstallationandoperationwillprovideoptimum

performanceandalongerlife.



3.2SAFETYINSTRUCTIONS

3.3PRODUCTCONFORMITY

3.3.1Themobilehandwashstationrangeissuppliedtothemarketplacehavingbeenproducedunderthe

controlofourcomprehensiveBSIISO9001:2015QualityManagementSystem(certificateFS616985).



3.2.1Childrenshouldbesupervisedwhileusingthemobilehandwashrange.

3.2.2Unitsshouldbeusedasintendedandnotbetamperedwithoralteredasthesafetyoftheunitmaybe

compromised.

3.2.3TheBSX-MHB-Xversionisdesignedtobeusedindoorsandoutdoors.Werecommendstorageindoors

whenproductisnotinuse.



Mobile Hand Wash Station

INSTALLATION&OPERATINGMANUALREVISION:07/2020|page5of16

Chapter4.STRUCTURE



Chapter5.LOCATIONADVICE

•TheBSX-MHB-Xmodelisdesignedtobeused

indoorsandoutdoors.Werecommendstorage

indoorswhenproductisnotinuse.

•Modelscanbefreestandingorwallfixed.



BSX-MHB-X BSX-MHB-HCWBSX-MHB-HCW-T

A

Splashback

B

Grabhandle

C Spout

D

Water-savingdiffuser

E Built-insideslotsonbothsides

-foroptionalhangingbinand/ortoweldispenser

F 

Built-inhatchesonbothsideswith

removablepanels-forwasteandwater

servicesconnection

G

Door

H

¼turnthumblatch

I

Internalshelf

forwater/waste

containers

Internalstorageshelf

J

Protectiveedgetrim

K 2xCastors

L Reinforced

PVCHosesStainlesssteelbraidedhose

M Manualfoot

pumpvalveTimeflowfootvalve

N Barbedhose

connection

Manual

mixingvalve

Thermostatic

mixingvalve

O Reinforced,stainlesssteelfootplate

P

Wastewater

container

(storedleft)



Q

Freshwater

container

(storedright)



R Flexiblewaste

connection

S Optionaldeckmountedsoapdispenser

A

C

B

N

D

E

G

H

G

H

I

J

K

L

M

BSX-MHB-HCW

BSX-MHB-HCW-T

BSX-MHB-X

O

E

S

R

P

Q

J

A

B

C

D

F

K

N

Mobile Hand Wash Station

REVISION:07/2020|page6of16INSTALLATION&OPERATINGMANUAL

Chapter6.INSTALLATIONINSTRUCTIONS

6.1Equipmentneeded:



6.2 Installspout-usespannertotighten.



6.3 Laysplashbackonaflatsurface.Removescrewsandputaside.



Mobile Hand Wash Station

INSTALLATION&OPERATINGMANUALREVISION:07/2020|page7of16

6.4 Slideframestoaligntop2holeswithsplashbackholes.Withholesaligned,fitscrews.



6.5 Splashbackisnowreadytobefittedontothemainbody.



Mobile Hand Wash Station

REVISION:07/2020|page8of16INSTALLATION&OPERATINGMANUAL

6.6 Slidefittedsplashbackontomainbodyasshown.Ensurebowlsplashbacksitsbehindmainbodysplashback.

Oncethesplashbackisplacedintopositionandholesalign,fitscrews.



Splashbackisnowinstalled.



6.7 Ifneeded,fitcastors.



Bowlsplashback

Mobile Hand Wash Station

INSTALLATION&OPERATINGMANUALREVISION:07/2020|page9of16

6.8 Ifneeded,removecoverplatestorunwaterandwasteservices,asappropriate.



6.9 Modelsaresuppliedwithawater-savingdiffuserreadyfittedinthespout.FormodelsBSX-MHB-HCWand

BSX-MHB-HCW-Tthewater-savingdiffusercanbeswappedfortheSTANDARDdiffuser.FortheBSX-MHB-X

modelthewater-savingdiffusercanbeswappedfortheULTRAwater-savingdiffuser.

HOWTOREPLACEDIFFUSER:Manuallyunscrewthediffuser,removethewasherandtheinsert(diffuser).

Replacewiththealternativediffuser,ensuringthattheexistingwasherisre-usedwhenfitting.



 



6.10FormodelsBSX-MHB-HCWandBSX-MHB-HCW-Tfinalconnectionstomainswaterfeedandwaste(1¼inch)

tobecompletedbytheinstaller.

6.11 ForinstallingandoperatingmixingvalvesforBSX-MHB-HCWandBSX-MHB-HCW-Tseesections6.12or6.13.

Washer

Mobile Hand Wash Station

REVISION:07/2020|page10of16INSTALLATION&OPERATINGMANUAL

6.12 MANUALMIXINGVALVE

–

suppliedwithmodelBSX-MHB-HCW

6.12.1Technicalfeatures

•Balancedwaterpressuresuppliesrequired.Pressurerange1.5-3Bar.Holdandcoldpressureshouldbe

nomorethan1barflowdifferential.

•JointsealstobemadeusingPTFEtapeONLY.

•NOJOINTINGCOMPOUNDStobeusedunderanycircumstances.

•Thepreferredlocationforthemanualmixingvalveisnexttothetimeflowfootvalve.However,if

desired,thiscanbeinstalledattheinletendofthewatersupply.



6.12.2 Installation

NOTE:Installmanualmixingvalvewithadjustablevalvesfacingtheinstaller.

•Recommendedpressurerange1.5-3Bar.

•ConnectthecoldwatersupplytotheinletontheLHSasviewedfromtheviewinpictureabove.

•ConnectthehotwatersupplytotheinletontheRHSasviewedfromtheviewinpictureabove.

6.12.3 Calibratingthetemperature

Afterinstallationturntheadjustmentsscrewsusinga3mmAllenkeyuntilthedesiredwatertemperature

deliverytothespoutisachieved.Turnclock-wisetoclosethevalveandanti-clockwisetoopenthevalve.



INPUT

COLD

INPUT

HOT

Adjustmentscrews

Mobile Hand Wash Station

INSTALLATION&OPERATINGMANUALREVISION:07/2020|page11of16

6.13 THERMOSTATICMIXINGVALVE

–

suppliedwithmodelBSX-MHB-HCW-T

6.13.1Technicalfeatures

•Integratednon-returnvalvesandfilters.

•Pre-setat38°C(CWandHWpressure3bar).

•Minimummixedwatertemperature:34°C.

•Anti-scaldingfail-safeactivatesif:

othemixedwatertemperatureexceeds42°C.

othedifferencebetweentheHWandCWisgreaterthan15°C.

NOTE:Responsetime~2seconds.

•Thepreferredlocationforthethermostaticmixingvalveisnexttothetimeflowfootvalve,underthe

footplate.However,ifdesired,thiscanbeinstalledattheinletendofthewatersupply.



6.13.2 Installation

•Recommendeddynamicpressure:1-5bar.

•HWsupplytemperature:55-85°C.

•CWsupplytemperature:5-20°C.

•BalancetheHW/CWpressure(∆P<1bar).

•PREMIXNANOcanbeinstalledinanyposition.

•Connectthehotwatersupplytotheinletwitharedmarkerandthecoldwatertotheinletwitha

bluemarker.

6.13.3 Calibratingthetemperature

Itispossibletochangethemixedwatertemperatureby:

•Removingthecap

•Turningthescrewwitha5mmAllenkey-clockwisetoreducethetemperatureandanti-clockwiseto

increasethetemperature.

NOTE:Theadjustorscrewturnscontinuouslybelow34°C.

•Oncethedesiredtemperaturehasbeenachieved,replacethecap.



Adjustmentscrews

Cap

Mobile Hand Wash Station

REVISION:07/2020|page12of16INSTALLATION&OPERATINGMANUAL

Chapter7.OPERATINGINSTRUCTIONS

7.1ModelsBSX-MHB-HCWandBSX-MHB-HCW-T

Important!Followinginstallation,thetimeflowvalveneedstobeprimedto

removeairfromthehose.

Actuatetimeflowvalvebycompressingandreleasingbyfoot.At3barwater

pressure,eachactuationwillprovidearuntimeof8to12seconds.Repeat

asnecessary.



7.2 ModelBSX-MHB-X

Important!Followinginstallation,orfollowingwatercontainerrefill,themanual

footpumpneedstobeprimedtoremoveairfromthehose.

Actuatemanualfootpumpbycompressingandreleasing.Eachcompressionwill

deliverwatertothespout.Repeatasnecessary.

7.2.1 Removeemptywaterfeedcontainer.Liftoutfeedhose.

7.2.2 Liftflexiblewastehoseoutofwastecontainer.

7.2.3 Removewastecontainerfromunit.Ensurecontainerscrewcapisreplaced.Disposeofwastewater.

NOTE:Becarefultomanoeuvrethecontainersaroundtheflexiblewastefittingstopreventdamage.

NOTE:Wastewaterisdirtyandmustbedisposedofresponsibly.

7.2.4 EnsureemptywastecontainerisreplacedintotheLHSoftheunitwithneckfacingfrontandscrewcap

removed.Reinsertflexiblewastehoseintoneckofthecontainer.

7.2.5 Oncerefilled,replacewaterhoseintofreshwatercontainerandreinsertintotheRHSoftheunitwiththe

neckofthecontainerfacingtherear.

NOTE:Becarefultomanoeuvrethecontainersaroundtheflexiblewastefittingstopreventdamage.

NOTE:Whentransportingfullwatercontainersensurescrewcapisfitted.

7.2.6 Followingeachwatercontainerrefillmanualfootpumpneedstobeprimedtoremoveairfromthehose.



     



Mobile Hand Wash Station

REVISION:07/2020|page12of16INSTALLATION&OPERATINGMANUAL

Chapter7.OPERATINGINSTRUCTIONS

7.1ModelsBSX-MHB-HCWandBSX-MHB-HCW-T

Important!Followinginstallation,thetimeflowvalveneedstobeprimedto

removeairfromthehose.

Actuatetimeflowvalvebycompressingandreleasingbyfoot.At3barwater

pressure,eachactuationwillprovidearuntimeof8to12seconds.Repeat

asnecessary.



7.2 ModelBSX-MHB-X

Important!Followinginstallation,orfollowingwatercontainerrefill,themanual

footpumpneedstobeprimedtoremoveairfromthehose.

Actuatemanualfootpumpbycompressingandreleasing.Eachcompressionwill

deliverwatertothespout.Repeatasnecessary.

7.2.1 Removeemptywaterfeedcontainer.Liftoutfeedhose.

7.2.2 Liftflexiblewastehoseoutofwastecontainer.

7.2.3 Removewastecontainerfromunit.Ensurecontainerscrewcapisreplaced.Disposeofwastewater.

NOTE:Becarefultomanoeuvrethecontainersaroundtheflexiblewastefittingstopreventdamage.

NOTE:Wastewaterisdirtyandmustbedisposedofresponsibly.

7.2.4 EnsureemptywastecontainerisreplacedintotheLHSoftheunitwithneckfacingfrontandscrewcap

removed.Reinsertflexiblewastehoseintoneckofthecontainer.

7.2.5 Oncerefilled,replacewaterhoseintofreshwatercontainerandreinsertintotheRHSoftheunitwiththe

neckofthecontainerfacingtherear.

NOTE:Becarefultomanoeuvrethecontainersaroundtheflexiblewastefittingstopreventdamage.

NOTE:Whentransportingfullwatercontainersensurescrewcapisfitted.

7.2.6 Followingeachwatercontainerrefillmanualfootpumpneedstobeprimedtoremoveairfromthehose.



     



INSTALLATION&OPERATINGMANUALREVISION:07/2020|page13of16

Chapter8.GENERALMAINTENANCE

RefertoChapter3ofthismanual,relatingtosafety.

Thegradeofstainlesssteelusedtomanufacturethisappliance(430ASI)hasbeenchosentoofferenhanced

corrosionprotection.However,allgradesofstainlesssteelcanstainanddiscolourthroughgeneraluse.Inorderto

keepyourBaSixproductingoodcondition,itshouldbekeptascleanaspossible.Withpropercare,yourBaSix

productwillgivemanyyearsofservicelife.

Careshouldbetakenduringinstallationtoensurethatsurfacecontaminationisavoided.Thebestwaytodothisis

toleavetheprotectiveplasticfilminplaceifpossible,duringinstallation,andthenremoveitjustbeforetheproduct

isused.

Forgeneralcleaning,usesoaporamilddetergentandwateronasponge.Rinsewithcleanwaterandwipedryif

necessary.Avoidabrasivecleaningproductssuchasscourers.



Themobilebasinrangemustbeinstalledandoperatedincompliancewiththesuppliedinstructions.



•TheuseofsuitablePPE,suchasgloves,isrecommendedwhencleaningormaintainingthisproduct.

•Donotuseabrasive,chlorineoracid-basedcleaningproducts.Avoidcontactwithconcentratedbleach.

Cleanwithsoapywaterusingaclothorsponge.



Chapter9.AFTERSALESandSERVICESUPPORT

TECHNICALASSISTANCE

Call:+44(0)1908251511andaskfortheTechnicalHelpdesk.

Or,e-mail:technical@mechline.com



Chapter10.WARRANTY

Themobilehandwashstationiscoveredbya12monthpartsonlymanufacturer’swarrantyfromthedateofinvoice,

againstdefectiveworkmanshiporfaultyparts.Termsandconditionsapply.

Pleasecontactyourlocaldistributororvisitwww.mechline.comforsparepartrequests.



Mobile Hand Wash Station

REVISION:07/2020|page14of16INSTALLATION&OPERATINGMANUAL



NOTES..............................................................................................................................................................................

.........................................................................................................................................................................................

Mobile Hand Wash Station

INSTALLATION&OPERATINGMANUALREVISION:07/2020|page15of16



REVISION:07/2020|page14of16INSTALLATION&OPERATINGMANUAL



©2020 All rights reserved. All material on these pages, including and without limitation text, logos, icons, photographs and all other artwork, is copyright material of Mechline Developments Ltd, unless

otherwise stated. Commercial use of this material may only be made with the express, prior, written permission of Mechline. This includes material provided by any third party, including material obtained through links

to other sites from Mechline’s pages or its afﬁliates and commercial associates. Material and information included are correct at time of print. Intending buyers and users must satisfy themselves as to the suitability and

safety of the products for their particular purposes and duties. Dimensions shown in mm unless otherwise stated. Product accreditation may not apply to all products in the relevant range.

Please contact Mechline to

conﬁrm. Unless otherwise stated, all products carry a warranty of twelve (12) months against manufacturing defect or workmanship on parts with no inclusion for labour or site attendance. (MHWB-14) Rev. 07/2020

MECHLINE DEVELOPMENTS LIMITED

|

Telephone: +44 (0)1908 261511

|

Email: [email protected]

|

Web: www.mechline.com

Distributed by:

MECHLINE Basix BSX-MHB-X Installation instructions

Popular Water System manuals by other brands