NuTone IS-515 Series User manual

READ & SAVE THESE INSTRUCTIONS!
INSTALLATION INSTRUCTIONS
FIGURE 1
DATA
SELECTOR
SWITCH
INTERCOM
AUDIO
RED
RED/WHT
BLK/WHT
BLK
ORN
ORN/WHT
5" Indoor Speaker
MODEL: IS-515 Series
5" Patio Speaker
MODEL: IS-519
For use with NuTone IM-5000 or IM-5006 Intercom Systems.
ROUGH-IN FRAME MOUNTING
The speakers are mounted to the IR-50 Rough-ln Frame.
New Construction
NOTE: Refer to the instructions packaged with the rough-in.
The Rough-ln Frame is mounted to a wall stud during rough-
in construction. The wiring is ran to the speaker location.
The speaker is mounted to the rough-in frame once the wall
is in place.
Existing Construction
NOTE: Refer to the instructions packaged with the
rough-in.
The Rough-ln Frame requires a cutout to the finished wall.
The Frame may be mounted either directly to a wall stud or
between the wall studs. The wiring is installed through the
existing walls.
WIRING
RATING: INPUT 19vDC, 40mA
OUTPUT 60mW
Refer to Figure 1. Connect the color-coded wires from the
Master Station to the matching terminal screws on the
speakers printed circuit board.
SETTING THE SELECTOR SWITCH
IMPORTANT: Be certain the system has been
disconnected at the main power source prior to setting
the selector switch. Powering the system up will allow
the station identification to be effective.
IMPORTANT: The Master Station has been preset as
Station #1. The remotes will be station 02 through 21 on the
IM-5000 master and 02 through 25 on the IM-5006 master.
Do not exceed 21 when using the IM-5000 or the IM-
5000/401T power transformer will be damaged.
1. Refer to Figure 2. Locate the Selector Switch on the
back of the remote control unit.
2. Refer to Figure 3. As indicated in Figure 3, set the
Selector Switch in the ON and OFF positions.
OFF
POSITION
ON
POSITION
OFF
12345
FIGURE 2

FIGURE 4
IR-50
IW-6
MOUNTING
Refer to Figure 4.
1. Carefully place wires inside wall.
2. IMPORTANT: Outdoor models must be caulked with a
waterproofing compound (Silicone Rubber, RTV or
equivalent - not supplied by NuTone). Caulk across the
top and both sides of the unit only; the bottom of the unit
should not be caulked.
3. Using two mounting holes in the sides of the speaker
body, secure the speaker to the frame with two (2)
provided screws.
For operating instructions, refer to the
Radio-lntercom system’s Operator’s Manual. If Operator’s
Manual has been misplaced, write to: NuTone, 4820 Red
Bank Road, Cincinnati, Ohio 45227.
FIGURE 3
IF THE REMOTE UNIT IS TO
BE THE STATION NUMBER:
THESE NUMBERS ON THE
SELECTOR SWITCH MUST BE
IN THE ON POSITION
02 2
1 & 2
3
1 & 3
2 & 3
1, 2 & 3
4
1 & 4
2 & 4
1, 2 & 4
3 & 4
1, 3 & 4
2, 3 & 4
1, 2, 3 & 4
5
1 & 5
2 & 5
1, 2 & 5
3 & 5
1, 3 & 5
2, 3 & 5
1, 2, 3 & 5
4 & 5
1, 4 & 5
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
NOTE: Shaded area is for IM-5006 only.
Product specifications subject to change without notice.
Printed in China, Rev. 3/2002, Part No. 43964
Two Year Limited Warranty
WARRANTY OWNER: NuTone warrants to the original consumer purchaser of its products that
such products will be free from defects in materials or workmanship for a period of two (2)) years
from the date of original purchase. THERE ARE NO OTHER WARRANTIES, EXPRESS OR
IMPLIED, INCLUDING, BUT NOT LIMITED TO, IMPLIED WARRANTIES OF MERCHANTABILITY
OR FITNESS FOR A PARTICULAR PURPOSE.
During this two year period, NuTone will, at its option, repair or replace, without charge, any
product or part which is found to be defective under normal use and service. THIS WARRANTY
DOES NOT EXTEND TO FLUORESCENT LAMP STARTERS OR TUBES. This warranty does not
cover (a) normal maintenance and service or (b) any products or parts which have been subject to
misuse, negligence, accident, improper maintenance or repair (other than by NuTone), faulty
installation or installation contrary to recommended installation instructions.
The duration of any implied warranty is limited to the two year period as specified for the express
warranty. Some states do not allow limitation on how long an implied warranty lasts, so the above
limitation may not apply to you.
NUTONE’S OBLIGATION TO REPAIR OR REPLACE, AT NUTONE’S OPTION, SHALL BE THE
PURCHASER’S SOLE AND EXCLUSIVE REMEDY UNDER THIS WARRANTY. NUTONE SHALL
NOT BE LIABLE FOR INCIDENTAL, CONSEQUENTIAL OR SPECIAL DAMAGES ARISING OUT
OF OR IN CONNECTION WITH PRODUCT USE OR PERFORMANCE. Some states do not allow
the exclusion or limitation of incidental or consequential damages, so the above limitation or
exclusion may not apply to you. This warranty gives you specific legal rights, and you may also have
other rights, which vary from state to state. This warranty supersedes all prior warranties.
WARRANTY SERVICE: To qualify for warranty service, you must (a) notify NuTone at the
address stated below or telephone [phone], (b) give the model number and part
identification and (c) describe the nature of any defect in the product or part. At the time of
requesting warranty service, you must present evidence of the original purchase date.
Date of Installation Builder or Installer
Model No. and Product Description
IF YOU NEED ASSISTANCE OR SERVICE:
For the location of your nearest NuTone Independent Authorized Service Center:
Residents of the contiguous United States Dial Free 1-800-543-8687
Please be prepared to provide:
Product model number • Date and Proof of purchase • The nature of the difficulty
Residents of Alaska or Hawaii should write to: NuTone Inc. Attn: Department of National Field
Service, 4820 Red Bank Road, Cincinnati Ohio 45227-1599.
Residents of Canada should write to: Broan-NuTone Canada, 1140 Tristar Drive,
Mississauga, Ontario, Canada L5T 1H9.
Rev. 03/2001