ORVIS Battenkill User manual

THE ORVIS COMPANY | MANCHESTER VERMONT 05254 | www.orvis.com
Orvis Technical Questions: [email protected] or 800-778-4778
INTRODUCTION
Features of your Battenkill Disc reel include:
•The best selling reel of all time, Battenkill Disc reels are designed to be
durable, smooth operating, and attractive.
 •Counterweightedspoolsforvibration-freeoperationathighrevolutions.
 •Anodizedaluminumorstainlesssteelforcompletecorrosionresistance.
 •Spoolshavebronzebushingssothereisnodistortionwhenspinning
against the hard shaft.
 •Allmodelschangefromright-toleft-handretrieveinseconds.
 •One-sidedframepermitsquickandeasyspoolchangeswith
no line pinching.
 •Thespoolrimisexposedforeasypalmingandprecisecontrolof
running fish.
DRAG OPERATION
The Battenkill Disc reels feature a multistage disc drag
system that incorporates stainless steel, Rulon®, and brass
componentstoensuresmoothtrouble-freeperformance.
The drag should be adjusted to meet the fishing
conditions.To adjust the drag, turn the drag adjustment
knobclockwise(+)toincreasethedragandcounter-
clockwise(-)todecreasethedrag.Theminimumdrag
settingshouldneverbelessthanthepressurerequiredto
prevent overrunning of the line on fast runs.
SPOOL REMOVAL
The spool release is located in the middle of the
reel spool.To remove the spool, depress the spool
releasewhilesimultaneouslyliftingthespooloutof
the body.
RETRIEVAL CONVERSION
The Battenkill Disc reels have the drag factory
installedforleft-handwind.Tochangeyourreelto
right-handwind,simplyslidetheratchetgearoffthe
centerspindle,turnitoversothe“R”facestoward
you, and slide the ratchet gear back over the center
spindle.Thereelisnowsetforright-handwind.
ROUTINE MAINTENANCE
YournewBattenkillreelhasbeenproperlylubri-
catedwhenyoureceiveit.However,itshouldbe
cleanedandlubricatedafterextendeduse(perhapstwiceayear)orafter
contactwithdirt,sand,orsalt.Lubricatethehandles,pawls,andratchet
gearshaftwithPennReelLube,whichisavailableinmosttackleshops.
If you can’t find this item in your tackle shops, tubes are available from
Orvisatanominalcharge.
Followingeachuseinsaltwater,thereelshouldberinsedinfreshwater
andallparts,exceptthedragsurfaces,lightlyoiled.Themainframeand
spoolshouldbewipedwithalightlyoiledcloth.Forextendedstorage,
especiallyaftersaltwateruse,itisrecommendedthatthelineandbacking
be removed and the drag loosened.
GUARANTEE
Your reel is unconditionally guaranteed against defects in materials and
workmanship.
If you have any problems, simply send your reel and a $10 check to
thefollowingaddress:
By USPS Mail: Orvis;OverhaulServices;178ConservationWay;
Sunderland,VT05250.
By FedEx or UPS:Orvis;OverhaulServices;4182MainSt.;
Manchester,VT05254.
Ifthereelisinanywaydefectiveinmaterialsorworkmanship,your
$10repaircheckwillbereturnedtoyouatonce.
Yourreelwillbecompletelyserviced(cleaned,lubricated,andeturned
toyoupostpaid)forafeeof$10,pluscostofparts.
Damagedreelscanberepairedonanindividualbasisandrepairwork
willbebilledatthehourlyshoprate,plusparts.Wewillprovideawrit-
tenestimateuponreceiptofthereelpriortoanyworkbeingdone.
QUESTIONS?
Ifyouhaveanyquestionsabouttheoperationandmaintenanceof
yournewreel,OrvisTechnicalAdvisorsarealwaysavailable.
Email:[e-mail].Phone:1-800-778-4778.
Original Battenkill®Disc Reel

THE ORVIS COMPANY | MANCHESTER VERMONT 05254 | www.orvis.com
Orvis Technical Questions: [e-mail] or 800-778-4778
Original Battenkill®Disc Reel
REEL ASSEMBLY
1 DragKnobScrew
2Drag Knob
3 ClickSpring
4 ClickBall
5Nut
6 DiscSpring
7 LogoLabel
8Body
9 FootScrews
10 Foot
11 SpindleWasher
12 CenterSpindle
13 ClickerPawlSpring
14 ClickerPawl
15 ClickerRetainingScrew
16 DriveGearAssembly
17 SpoolGearing
18 RearSpool
19 FrontSpool
20 O-Ring
21 CounterWeight
22 Q/RSpring
23 Q/RLever
24 CoverPad
25 Q/RCover
26 Q/RCoverScrews
27 KnobScrew
28 HandleKnob
29 DragSpindle
30 DragWasher
31 Drag Gear Bearing
32 Drag Gear
33 LineGuardScrew
34 LineGuard
1
1
2
2
3
3
4
4
6
6
7
7
5
5
1
0
10
8
8
9
9
1
1
11 1
2
12
34
34
3333
3
2
32
3
131
30
30 2
9
29
28
28
1
4
14
1
5
15
1
6
16
1
8
18
20
20
22
22
21
21
23
23
1
9
19
2
424
25
25
26
26
27
27
1
3
1
1
13
1
7
17
WF3100
WF475
WF550 100
WF675 125*
WF750 100*
WF8 75*
LINE WEIGHT
ORIGINAL BATTENKILL DISC REELS
Capacity Chart
3/4 5/6 7/8
Battenkill Fly Reel Specifications
3/4 Reel|weight:4.2oz.|27⁄8 inches
5/6 Reel|weight:4.7oz.|31⁄8inches
7/8 Reel|weight:5.8oz.|33⁄8 inches
Capacity in Yards
StatedcapacitiesarebasedonOrvis20-lbDacron®backinganda100-foot
weight-forwardfloatingflyline.*30-lbDacronbacking.