Philips 32PFL3406D/78 User manual

Published by ER/JY 1166 BU TV Consumer Care Printed in the Netherlands Subject to modification EN 3122 785 19131
2011-Jun-24
©
Copyright 2011 Koninklijke Philips Electronics N.V.
All rights reserved. No part of this publication may be reproduced, stored in a
retrieval system or transmitted, in any form or by any means, electronic, mechanical,
photocopying, or otherwise without the prior permission of Philips.
Color Television Chassis
L11M1.1L
LA
19080_000_110301.eps
110329
Contents Page
1. Revision List 2
2. Technical Specifications and Connections 2
3. Precautions, Notes, and Abbreviation List 6
4. Mechanical Instructions 10
5. Service Modes, Error Codes, and Fault Finding 19
6. Alignments 25
7. Circuit Descriptions 28
8. IC Data Sheets 36
9. Block Diagrams
Wiring Diagram 32" (Thriller) 45
Wiring Diagram 40" (Thriller) 46
Wiring Diagram 32" (Berlinale) 47
Wiring Diagram 40" (Berlinale) 48
Block Diagram Video 3939 123 65052 49
Block Diagram Audio 3939 123 65052 50
Block Diagram Control & Clock Signals 3939 123
65052 51
Block Diagram I2C 3939 123 65052 52
Supply Lines Overview 3939 123 65052 53
Block Diagram Video 3939 123 65231 54
Block Diagram Audio 3939 123 65231 55
Block Diagram Control & Clock Signals 3939 123
65231 56
Block Diagram I2C 3939 123 65231 57
Supply Lines Overview 3939 123 65231 58
10. Circuit Diagrams and PWB Layouts
B01 313912365052 59
B02 313912365052 60
B03 313912365052 62
B04 313912365052 63
B05 313912365052 67
B06 313912365052 69
B07 313912365052 73
313912365052 SSB Layout 74
B01 313912365231 76
B02 313912365231 77
B03 313912365231 79
B04 313912365231 80
B05 313912365231 84
B06 313912365231 86
B07 313912365231 90
313912365231 SSB Layout 91
E 272217190347 Leading Edge Module 93
E 272217190276 KEYBOARD 95
J 272217190275 IR/LED 96
T01 313912365071 98
313912365071 TCON Layout 104
11. Styling Sheets
Styling Sheet Thriller 32" 105
Styling Sheet Thriller 40" 106
Styling Sheet Berlinale 32" 107
Styling Sheet Berlinale 40" 108

Revision List
EN 2 L11M1.1L LA1.
2011-Jun-24 back to
div. table
1. Revision List
Manual xxxx xxx xxxx.0
• First release.
Manual xxxx xxx xxxx.1
•Chapter 2: Table 2-1 updated (added Berlinale CTNs).
•Chapter 4: added wiring diagrams; see section 4.1.
•Chapter 6: added white tone alignment data, see section
6.3.
•Chapter 7: added Berlinale architecture diagrams; see
section 7.1.
2. Technical Specifications and Connections
Index of this chapter:
2.1 Technical Specifications
2.2 Directions for Use
2.3 Connections
Notes:
• Figures can deviate due to the different set executions.
• Specifications are indicative (subject to change).
2.1 Technical Specifications
For on-line product support please use the links in Table 2-1.
Here is product information available, as well as getting started,
user manuals, frequently asked questions and software &
drivers.
Table 2-1 Described Model Numbers and Diversity
2.2 Directions for Use
You can download this information from the following websites:
http://www.philips.com/support
http://www.p4c.philips.com
CTN Styling
SSB 2 4 9 10
3139 123 xxxxx Connection Overview
Mechanics Block Diagrams Schematics
Wire Dressing Assembly Removal LCD Removal Wiring Diagram Video Audio Control & Clock I2C Supply lines B01 (DC-DC) B02 (Tuner & Dig. Dem.) B03 (Class D & mute) B04 (Power, DDR, LVDS) B05 (HDMI, USB) B06 (analog I/O, VGA) B07 (Hospitality) E (Keyboard/Leading Edge) J (IR/LED) T01 (LVDS Display, TCON
32PFL3406D/78 Thriller
11-1
65052 2-1 4-1 4.3 4.3.2 9-1 9-5 9-6 9-7 9-8 9-9 10-1 10-2 10-3 10-4 10-5 10-6 10-7 10-18 10-19 -
32PFL3606D/78 Thriller
11-1
65052 2-1 4-1 4.3 4.3.2 9-1 9-5 9-6 9-7 9-8 9-9 10-1 10-2 10-3 10-4 10-5 10-6 10-7 10-18 10-19 -
32PFL5606D/77 Berlinale
11-3
65231 2-2 4-3 4.4 4.4.8 9-3 9-10 9-11 9-12 9-13 9-14 10-9 10-10 10-11 10-12 10-13 10-14 10-15 10-17 - -
32PFL5606D/78 Berlinale
11-3
65231 2-2 4-3 4.4 4.4.8 9-3 9-10 9-11 9-12 9-13 9-14 10-9 10-10 10-11 10-12 10-13 10-14 10-15 10-17 - -
40PFL3606D/78 Thriller
11-2
65052 2-1 4-2 4.3 4.3.2 9-2 9-5 9-6 9-7 9-8 9-9 10-1 10-2 10-3 10-4 10-5 10-6 10-7 10-18 10-19 10-20
10-21
40PFL5606D/77 Berlinale
11-4
65231 2-2 4-4 4.4 4.4.8 9-4 9-10 9-11 9-12 9-13 9-14 10-9 10-10 10-11 10-12 10-13 10-14 10-15 10-17 - -
40PFL5606D/78 Berlinale
11-4
65231 2-2 4-4 4.4 4.4.8 9-4 9-10 9-11 9-12 9-13 9-14 10-9 10-10 10-11 10-12 10-13 10-14 10-15 10-17 - -

Technical Specifications and Connections EN 3L11M1.1L LA 2.
2011-Jun-24
back to
div. table
2.3 Connections
Figure 2-1 Connection overview Thriller (xxPFL3x06/xx)
Figure 2-2 Connection overview Berlinale (xxPFL5x06/xx)
SROTCENNOCEDISSROTCENNOCRAER
DIGITAL
AUDIO OUT
AUDIO IN
DVI/VGA
SERV.U
R L Pr Pb Y
CVI 1
BOTTOM REAR CONNECTORS
VGA
HDMI 1
(ARC)
R L Pr Pb Y
CVI 2
ANTENNA
19130_001_110421.eps
110421
1
3
2
4 5 6 7
8 9 10 11
SIDE CONNECTORS
BOTTOM REAR CONNECTORS
REAR CONNECTORS
19131_021_110623.eps
110623
1
3
2
4 56 7
8 912 10 11

Technical Specifications and Connections
EN 4 L11M1.1L LA2.
2011-Jun-24 back to
div. table
Note: The following connector color abbreviations are used
(according to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green,
Gy= Grey, Rd= Red, Wh= White, Ye= Yellow.
2.3.1 Side Connections
1 - USB2.0
Figure 2-3 USB (type A)
1-+5V k
2 - Data (-) jk
3 - Data (+) jk
4 - Ground Gnd H
2 - AV IN: Cinch: Video CVBS - In, Audio - In
Ye - Video CVBS 1 VPP / 75 ohm jq
Wh - Audio L 0.5 VRMS / 10 kohm jq
Rd - Audio R 0.5 VRMS / 10 kohm jq
3 - HDMI: Digital Video, Digital Audio - In
Figure 2-4 HDMI (type A) connector
1 - D2+ Data channel j
2 - Shield Gnd H
3 - D2- Data channel j
4 - D1+ Data channel j
5 - Shield Gnd H
6 - D1- Data channel j
7 - D0+ Data channel j
8 - Shield Gnd H
9 - D0- Data channel j
10 - CLK+ Data channel j
11 - Shield Gnd H
12 - CLK- Data channel j
13 - Easylink Control channel/CEC jk
14 - n.c.
15 - DDC_SCL DDC clock j
16 - DDC_SDA DDC data jk
17 - Ground Gnd H
18 - +5V j
19 - HPD Hot Plug Detect j
20 - Ground Gnd H
2.3.2 Rear Connections
4 - CVI-1: Cinch: Video YPbPr - In, Audio - In
Wh - Audio - L 0.5 VRMS / 10 kjq
Rd - Audio - R 0.5 VRMS / 10 kjq
Rd - Video Pr 0.7 VPP / 75 jq
Bu - Video Pb 0.7 VPP / 75 jq
Gn - Video Y 1 VPP / 75 jq
5 - Cinch: Digital Audio - Out
Bk - Coaxial 0.4 - 0.6VPP / 75 ohm kq
6 - Service Connector (UART)
1 - Ground Gnd H
2 - UART_TX Transmit k
3 - UART_RX Receive j
7 - Mini Jack: Audio - In DVI/VGA
Bk - Audio 0.5 VRMS / 10 kjo
2.3.3 Bottom Connections
8 - CVI-2: Cinch: Video YPbPr - In, Audio - In
Wh - Audio - L 0.5 VRMS / 10 kjq
Rd - Audio - R 0.5 VRMS / 10 kjq
Rd - Video Pr 0.7 VPP / 75 jq
Bu - Video Pb 0.7 VPP / 75 jq
Gn - Video Y 1 VPP / 75 jq
9 - HDMI1 Audio Return Channel: Digital Video, Digital
Audio - In
Figure 2-5 HDMI (type A) connector
1 - D2+ Data channel j
2 - Shield Gnd H
3 - D2- Data channel j
4 - D1+ Data channel j
5 - Shield Gnd H
6 - D1- Data channel j
7 - D0+ Data channel j
8 - Shield Gnd H
9 - D0- Data channel j
10 - CLK+ Data channel j
11 - Shield Gnd H
12 - CLK- Data channel j
13 - Easylink Control channel/CEC jk
14 - ARC Audio Return Channel j
15 - DDC_SCL DDC clock j
16 - DDC_SDA DDC data jk
17 - Ground Gnd H
18 - +5V j
19 - HPD Hot Plug Detect j
20 - Ground Gnd H
10 - Aerial - In
- - F-type Coax, 75 D
11 - VGA: Video RGB - In
Figure 2-6 VGA Connector
1 - Video Red 0.7 VPP / 75 j
2 - Video Green 0.7 VPP / 75 j
3 - Video Blue 0.7 VPP / 75 j
4-n.c.
5 - Ground Gnd H
6 - Ground Red Gnd H
7 - Ground Green Gnd H
8 - Ground Blue Gnd H
9-+5V
DC +5 V j
10 - Ground Sync Gnd H
11 - n.c.
12 - DDC_SDA DDC data j
13 - H-sync 0 - 5 V j
14 - V-sync 0 - 5 V j
15 - DDC_SCL DDC clock j
12 - HDMI2: Digital Video, Digital Audio - In (optional)
Figure 2-7 HDMI (type A) connector
1 2 34
10000_022_090121.eps
090121
10000_017_090121.eps
090428
19 1
182
10000_017_090121.eps
090428
19 1
182
1
610
11
5
15
10000_002_090121.eps
090127
10000_017_090121.eps
090428
19 1
182

Technical Specifications and Connections EN 5L11M1.1L LA 2.
2011-Jun-24
back to
div. table
1 - D2+ Data channel j
2-Shield Gnd H
3 - D2- Data channel j
4 - D1+ Data channel j
5-Shield Gnd H
6 - D1- Data channel j
7 - D0+ Data channel j
8-Shield Gnd H
9 - D0- Data channel j
10 - CLK+ Data channel j
11 - Shield Gnd H
12 - CLK- Data channel j
13 - Easylink Control channel/CEC jk
14 - n.c.
15 - DDC_SCL DDC clock j
16 - DDC_SDA DDC data jk
17 - Ground Gnd H
18 - +5V j
19 - HPD Hot Plug Detect j
20 - Ground Gnd H