Philips Whirlpool AVM 914 AV User manual

~ l; ~~~ [I ~ i; Whirlpool Euro.pe AVM 914~ ConsumerServices
PHILIPS ~~'1
,~'iJ
-~Whirlpool
~i Service Manual
",
'{Ir M icrowave oven
AVM 914 Raised power
Model AVM 914 AV
(' Version 8538 914 01101
Model AVM 914 WH
'Jersion 8538 914 01201
853891412201
Model AVM 914 Blue Line
Version 853891412001
!
Introduction safty !
Technical cIata 481271450022
Wiring diagram 481271470018 1 .r:~;'
;j'l"l'OR,';\3!:.,..." : R:t"'~;:'~
Spare part list 481271480009 .r-j\;;~;l'i
(\ Explodecl view 481271460025
---
'at, ,:':-:I
t.~",gEm3t,"S9";
'.'"'(;)
'; t;.
"")CI;:; .j;U ~,' -,
,,';';:""::'0(''Y,)\',,\
'"."" ~""" _
I""" rl"
"Ij'""" ""'J "
1'11.
.~'J:("
c'i:";,'i<::\:7,
CThis documentalion is only inlended for qualified technicians who are aware of the respective safety re-
gulations.
Date: 07.10 1992
Document-No: 4812714 1002t; Subject to n10dification -Änderungen vorbehalten
Register No.: 2

INTRODUCTION
Before leaving the fa.ctory each oven is carefully checked. 0I
It must however, be Installed and used correctly. ~
Oespite all the steps taken to make the oven safe, the safety is dependent on the correct installation and the fact the user '- -"!
understands how to use and maintain the oven.
The information in this section should be used as areminder that the oven is safe and that anyone who uses it must first
read the instructions tor use in order to be able to use the oven correctly and obtain the best results.
1
SAFETY \
To avoid injury to yourself and damage to the appliance always work to the following rules when servicing an oven.
.Always disconnect the plug from the mains before starting work.
If there is no plug switch-off the electricity supply at the control box.
.When you have finished servicing an oven before you reconnect it to the mains, make sure that:
-all the internat connections are correct
-the wires are insulated and not touching the door or the cabinet or anything sharp
-all the earth connections are electrically and mechanically sound ~
-do not modify or anyway interfere with the safety devices built-in to the oven Ji
-make sure that each replacement part you use conforms to the manufacturer's specifications
.00 not start arepair if you have any doubt as to your ability to complete it.
CAUTION -MICROWAVE RADIATION
PERSONNEL SHOULD NOT BE EXPOSED TO THE MICROWAVE ENERGY WHICH MAY RADIATE FROM THE
MAGNETRON, WAVEGUIDE OR ANTENNA IFTHEY ARE IMPROPERLY USED OR CONNECTED. ALL INPUTAND OUT-
PUT MICROWAVE CONNECTIONS, WAVEGUIDES, FLANGES AND GASKETS MUST BE SECURE.
NEVER OPERATE THE DEVICE WITHOUT A MICROWAVE ENERGY ABSORBING LOAD ATTACHED.
NEVER LOOK INTO AN OPEN WAVEGUIDE OR ANTENNA WHILE THE DEVICE IS ENERGIZED.
NEVER OPERATE AN OVEN WITH CABINET OFF WITHOUT MEASURING THE MICROWAVE LEAKAGE AROUND
MAGNETRON AND VISIBLE MICROWAVE CONNECTIONS (WELDING JOINTS).
')
00 not operate the oven if the following conditions exist:
-The door does not close firmly against the door support because of the door being warped or the hinges damaged.
-The door trims or seals are damaged.
-If there is any visible damage to the oven.
-If the door does not close properly.
Avoid operating the oven if known components in the interlock system, oven door or microwave generating assembly are
known defective. They must be replaced.
,
WARNING -HIGH VOLTAGE
IT IS POSSIBLE TO COME IN CONTACT WITH LETHAL HIGH VaL TAGE WHENWORKING WITH HVTRANSFORMER, HV .
CAPACITOR, AND MAGNETRON.
THEREFORE NEVER TRY TO MEASURE THE HIGH VOLTAGE. ALWAYS TAKE UTMOST CARE WHEN PERFORMING
ELECTRIC MEASUREMENTS INSIDE THE OVEN. J""":1
c;l.
.,;

r~ i- ,:.;'1LY~ ii ~ :Whirlpool Europe ~".
~~ !~ i~~ ...~ lJ ~ Consumer Services '\llirlp()ol 4812 71450022
1. Technical Data AVM 914 Raised power
1.1. Dimensions of cabinet
~Height 332 mm
r Width 548 mm
Depth 398 mm
1.2. Dimensions of cavity
Heig~t 225 mm
Width 346 mm
C Depth 341 mm
1.3. Weight
Net 22 Kg
Packed 24 Kg
1.4. Electrical
Volta gel frequency 230-240 I 50 V I Hz
Power consumption 2700 W
Current consumption 13,4 A
1.5. Power
c:'- Different food classes (7), weight setting and auto defrost,
CCcc
;~ automatically calculation of a tailor..made program
Output power 1000 W
Microwave frequency 2450 MHz
1.6 Grill
Output grill 1100 W
~ 1.7 Cavity volume 26,55 I
.Turntable diameter 320 mm
1.8. Timer 90 min
C

---'~~&'.K~- -:::;1:-_0__. .Whirlpool Europe PH!lIP~ -, <~.
Consumer Services -: ~~ 48127145002~ .
"\
1.9. Accessories
Built in kif (optional)
Crisp plate (optional) j.
LO~f grill grid (optional)
1
" ..-
Operation panel :",.{tf;'
r%~i;
'. .
'. ...:..,
: A Digital display
L:=J 8 Clock set
0
C Timer with start setting
000 D Power level buttons with detrost setting
and jet setting
E Functions tor
00DG~IICnsp
Stop
H Door release buttonL--

~~-~~~~~~-
~
j
Date 06.10.92 Soare part list
tor MICROWA'vE OVEN RAISED POW
Spare part list No. 4812 714 80009
Model AVM 914 AV AVM 914 WH AVM 914 BL
Type 1 2 3 ~',tl,
Pos. No. Spare Part No. Denomina~~ Type:-
000 1 4819 453 49205 Recipe guide not shown option al 1,2
0002 481946418111 Chassis air guide not shown 1,2
0020 481944059112 Wrapping WH 2
0020 481944059113 Wrapping AV 1
002 1 481949268579 Clip 1,2
0022 481946698624 Cover 1,2
0030 481940478252 Bracket 1,2
0130 481946279423 Foot 1,2
1000 4819440 59169 Door of oven cpl. WH 2,3
1000 4819440 59171 Door of oven cpl. AV 1
120 1 481944059111 Door inner part 1,2 ~
1300 481927618194 Switch holder 1,2
130 1 481946688919 Block small 1,2
1410 481945069332 Door outer gl ass 1,2
1410 481945069525 Doorouter glass Blue Une 3
1430 48194594&481 Door frame WH 2
143 0 4813 459 48483 Door frame AV 1
1430 4819459 48556 Door frame Blue Une 3
1431 481953598394 Pin 1,2
2450 481945819802 Grid high 1,2
2450 4819458 19857 Grid lower 1,2
2460 481946688922 Plate 1,2
246 1 4819 418 78841 Cover not shown or>tional 1,2
2550 4819466 78186 Turn table 1,2
2640 481953578131 Turn table bearing 1,2 ,
,
301 0 4819410 28492 Push button unit WH 2 '
.,., 1
301 0 4819410 28494 Push button unit AV 1 1:),
3020 481940478253 Holder 1,2 ~ ,
302 1 4819325 18027 Insulation 1,2 ,(. , n""
...
(' I
~
320 0 4819453 49347 Control panel WH 2?'
3200 481945349348 Control panel A\! 1 I
5'
:i) ,
332 0 4819410 28493 Push button AV 1'" ,
3320 481941028496 Push button \NH 2 g :
332 1 4819 492 58108 Spring 1,2
3340 4819413 58777 Knob WH 2
3340 4819413 58778 Knob AV 1
3341 481941338126 Knob for rotacode 1,2
3520 481913038058 Display 1,2
354 0 4813 130 38055 Led 1,2
354 0 481';; 13038059 Led 1,2
3550 481928018019 Buzzer 1,2 ~
4021 481946688918 Lid for TT-Motor 1,2
4040 4819131 58019 Magnetron 1,2
4041 481940478269 Bracket 1,2 ~
4042 4819462 38617 Wave guide 1,2
4043 481946238616 Guide 1,2
4060 481936118292 Motor 1,2
406 1 4819 532 68666 Rubber rirlg 1,2
4062 481953268665 Rubber seal 1,2 ~
4120 481914578147 HT Transformer 1,2
4121 481946238615 Guide 1,2
4200 481912148016 Capacitor 1,2
t Subjecl 10 modificationL

0 0 ., N
-.~ 0..-00..- -Q -0
,. M N ;..n ~
~ ~ ~ .r:. .-~ ~ 0 0 It) It) CD N
"~ \ f--g-CD
., ~
-
r--
N
QQ ~
--00 ~
~ NQCO)
-CO) CO)
~-CD
-
Q
~ ~
Q
~
\ /
,
.-Q ,
Q -,'
QO- N ~! r ,
I I
t ,.~~~~ C:<:) I Ii
~ L~!..::.Ei I :
" ( ) J
\'.~ I I
I
I J
\ .I I
\ e
~ ~~ I --N r;: N 1
\ r NO c.o r-r-NI
\ r
.I\ I
\ I
\ I
\\ :
\ I
\ I
; \)
Q
.Y~ \
(' G \
00 000 NO 0 ..-0 ~.I
Nal') c.oal')~ N..- O~NN M
:n~ ~al')c.o 00 NMr->M M
..~N NNN al')c-:> ""'MMc-:> ,-,'ibo",",'
.'.:~;~;;'c.~~ti

Model AVM 914 AV AVM 914 WH AVM 914 Bl
Type 1 2 3 ~
Pos. No. Spare Part No. Denomination Type
-
4201 481940118678 Clamp 1,2
421 0 4819121 18162 Mainsfilter 1,2
4261 481921838038 Diode 1,2
4420 481936118291 Motor fan 1,2 t
442 1 4819 404 78251 Bracket 1,2
4430 481951528197 Fan wheel 1,2
4431 481946238614 Guide 1,2 "
4520 481925928664 Grill element 1,2
4850 481932128074 Cable ht 1,2
4851 481932028011 Cable ht 1,2
4852 481946698742 Spacer paper not shown 1,2
4900 4819321 18129 Cable mains not SIIQv.'n 1,2 -" J\
5021 481920988028 Microprocessor 1,2 /\
5022 481946678187 Display glass: 1,2 \
502 3 4819 101 48072 potentiom~ter 1,2 I\~521 0 481921478378 Control umt 1,2\~
521 1 481911388001 Resistor 1,2 \
521 2 481928018018 Resonator not shown 1,2 ~;
521 3 4819 14868059 Transformer not shown 1,2 , ';
.,
\ '
561 0 4819 282 48205 Thermostat 1,2 '1~ \,
5640 481928228533 Protection motor 1,2 ~i"., ,
5660 481928248217 Thermostat grill 1,2' !
,
6170 481928068295 Relay 1,2!
6220 4819271 38115 Switch 1,2
633 0 481~ 271 38106 Microswitch 1,2
6510 481913488151 Lamp 1,2
9010 481940118512 Cable clam r 1,2
9020 481946688921 Plate 1.2
9710 481925338019 FuseT8A .1,2
9720 481925338006 Fuse 100mA 1,2 ,"
'()
., ,
..
~
-.
Subjecl 10 modification .

..-
-0 0 ., N
'..". O~OO~ -Q -0
(W)C'?N
N
-
QC =
~OO ~
,!' NO~
-~~
~-=
-
=
~ ~
QQ .I(~-
ON N =-
-..". = fD' = N
1:')0==00
=..".~..."...".
/
,
-0 '
0 -,'
N ,."., I
QQ- -_. r ,
I I
L~?!J~~C :;<::) 1 I
() ',;:- ~~ I I
.;: = = ,
I I
II
\ I I
\ I I\ . :t V: I -N r;: N '
\ I NO CD !"-!"-NI
\ J
\ I
\ I
\ I
\ I
\ J
\ I
\ I
\ I
\)
Q
.§
'j~ \
,,(' G \
00 000 NO 0 ~O ..".
N~ =~..". N~ O,.".,NN M
:n..,- ""~CD 00 NC'?r"')C') M
~N NNN 1nC') MMMM