Pinnacle PRO Series User manual

KEY LOCKABLE
394,700 CUBIC CM
STORAGE
CAPACITY
2 X GAS STRUTS
DOUBLE WALL
STEEL FRAME
1.5mm 2 X POWER
ENTRY HOLES
USER INSTRUCTIONS:
Model Number: GOS207
635mm
DEPTH
1855mm
WIDTH
460mm
HEIGHT
73”OVERHEAD CABINET
METAL HANDLES

IMPORTANT SAFETY INSTRUCTIONS:
CONNECT WITH US!
PINNACLE.NET.AU
When using your garage equipment, basic
safety precautions should always be
followed, including the following:
1. Read all instructions
2. Do not operate equipment with a damaged
cord or if the equipment has been dropped or
damaged until it has been examined by a
qualified service person.
3. Do not let a cord hand over the edge of the
table, bench or counter or contact with hot
manifolds or moving fan blades.
4. If an extension cord is necessary, a cord with
a current rating equal to or more than that of
the equipment should be used. Cords rated
for less current than the equipment may
overheat. Care should be taken to arrange the
cord so that it will not be tripped over or pulled.
5. Always unplug equipment from electrical
outlet when not in use. Never use the cord to
pull the plug from the outlet. Grasp plug and
pull to disconnect.
6. Loop cord loosely around equipment when
storing.
7. To reduce the risk of fire, do not operate
equipment in the vicinity of open containers
of flammable liquids (petrol).
8. Adequate ventilation should be provided when
working on operating internal combustion
engines.
9. Keep hair, loose clothing, fingers, and all
parts of body away from moving parts.
10. To reduce the risk of electric shock, do not
use on wet surfaces or expose to rain.
11. Use only as described in this manual. Use only
manufacturer’s recommended attachments.
12. Always use safety glasses, Everyday glasses
only have impact resistant lenses, they are
not safety glasses.
13. To reduce the risk of injury, close supervision
is necessary when this product will be used
around children.
14. To reduce the risk of injury, never overload the
drawers. Refer to loading instructions.
15. To reduce the risk of electric shock or fire,
never overload receptacles. Refer to markings
for the proper load on receptacles.
16. TO PREVENT SERIOUS INJURY AND DEATH
FROM TIPPING: DO NOT SIT, STAND OR CLIMB
ON THIS ITEM.
17. This product is not a toy nor a toy chest. Do not
allow children to play with or near this item.
18. Assemble only according to these instructions.
Improper assembly can create hazards.
19. Keep assembly area clean and well lit.
20. Weight capacity and other product capabilities
apply to properly and completely assembled
product only.
21. Do not have more than one Drawer open at a
time.
22. Do not lift using handle(s). Do not move or lift
while loaded.
23. Lock Swivel Casters after moving.
24. Do not mount on truck bed or any other
moving object.
25. Inspect before every use; do not use if parts
are loose or damaged.

ASSEMBLY INSTRUCTIONS:
1. Bolt handles to each end of the housing using the two M8 handle bolts for each handle.
PARTS LIST:
Handle1 2
M8 x 65mm Handle Bolt2 4
Trim End Cap6 2
Pinnacle Badge7 1
M8 x 20mm Bolt41 4
Vertical Trim44 2
Door45 1
1Door Trim46
Wiring Grommet53 4
Gas Strut Bolt52 2
Gas Strut Bolt51 4
Gas Strut50 2
Cushion Rubber49 2
Lock Bar48 1
1
Lock47
2
1
50
48
41
51
52
49
46
45
67
53
44
47

WARRANTY CONDITIONS:
This product comes with a lifetime warranty*. To make a claim under this warranty, take the product (with
proof of purchase) to any Bunnings store (for AUS customers see www.bunnings.com.au and for NZ
customers see www.bunnings.co.nz for store locations).
Pinnacle Hardware bears reasonable, direct expenses of claiming under the warranty. You may submit details
and proof of purchase to our support centre for consideration. The warranty covers manufacturer defects in
materials, workmanship and finish under normal use.
This warranty is provided in addition to other rights and remedies you may have under law: Our goods come
with guarantees that cannot be excluded under the Australian consumer law or Consumer Guarantees Act
1993 (NZ).
You are entitled to a replacement or refund for a major failure and compensation for any other reasonably
foreseeable loss or damage. You are also entitled to have the goods repaired or replaced if the goods fail to
be of acceptable quality and the failure does not amount to a major failure.
*This warranty excludes damage resulting from product misuse or product neglect, any modifications,
additions or alterations to the product including the addition of extra shelves. Additions or modifications can
compromise the structure and safety of the product. The warranty covers domestic use only and does not
apply to commercial applications.
This warranty is given by Pinnacle Hardware, ABN 87 614 496 196, 45-49 Whitfield Boulevard, Cranbourne
West VIC 3977, 1800 349 776, Email: [email protected].
Products sold in New Zealand are imported by Bunnings New Zealand.
‘Pinnacle’ is a trademark. © Pinnacle Hardware.
Suitable for model number GOS207.
MAINTENANCE AND SERVICING:
To prevent serious injury from tool failure: Do not use damaged equipment.
If any part becomes damaged, have the problem corrected before further use.
To prevent serious injury from electric shock:
Disconnect the power cord from the cabinet before maintenance and servicing.
1. Periodically, inspect the general condition of the trolley. Check for:
- Loose hardware,
- Misalignment or binding of moving parts,
- brake operation,
- Castor swivel function and movement,
- Cracked or broken parts,
- Any other condition that may aect its safe operation.
2. Wipe external surfaces of the trolley with a clean cloth.