Polar Metalli M8 User manual

Installation instructions
and use and care guide

ASSEMBLY INSTRUCTIONS
FOR POLAR GRILL M8/M6/L8
If the grill is placed inside a cabin/hut, take care of ventilation e. g. by assembling ventilation pipes
under the grill. 4 x 150 mm ventilation pipes are recommended.
2
Turn firebox upside down on a
flat surface to prevent the
firebox from being scratched.
Add a cage nut to each square
hole located at the bottom of
the firebox.
1
Take grill base parts and attach
them together with bolts and
cage nuts (see picture).
4
Attach pull knob to the handle
of the regulating plate.
5
Turn the grill firebox upwards
and place the cast iron grid as
shown in the picture (P-logo
should be on the same side as
the pull knob of the regulating
plate). Place sparknet into the
holes on top of the grill.
6
Assemble the gridiron. Place
the holder into the shaft of the
grid iron as shown in the
picture. Attach the shaft to the
gridiron with two bolts.
3
Lift base of the grill on top of
the firebox as shown in the
picture. Handle of the regula-
ting plate should be on the
open side of the grill base.
Attach base to the firebox from
every corner with hex socket
screws.

Assemble the hook for a coffeepot
and small gridiron into the curved
pipe (or the straight pipe if the grill
is equipped with a hood). Assemble
locking rings (with butterfly nuts) as
shown in the picture. Assemble
pipes into the grill.
Assemble metal holders to
the wooden table parts and
place them around the grill
as shown in the picture.
Wooden table parts are
made of non-treated wood
and should be oiled, painted
or lacquered before use.
7
Assemble pipes into the grill.
Hook for coffeepot as well as the
small gridiron should be assemb-
led on the right side and adjus-
table gridiron on the left. Make
sure that the hook*¹ (see picture
4) located on the same side as
the grip comes to the upper side.
*1
89
Assembled grill without hood.
10

1 2 3
4 5 6
Assemble the pipes into the grill.
Make sure that you have
assembled locking rings with
butterfly nuts under the grilling
devices (grid irons, hook for
coffee pot).
Place the straight chimney
pipe on top of the hood.
ASSEMBLY INSTRUCTIONS
FOR M8/M6/L8 HOOD PACKAGE
Turn the hood upside down
and attach the holders with
butterfly nuts as shown in the
picture.
The parts assembled from the
roof: Lengthening with collar is
attached to the chimney and Rain
hat is attached with long butterfly
nut.
Lift the hood into its place.
Attach pipes into the holders.
Place the pleated chimney pipe
on top of the straight chimney,
pleat downwards.

Care Instructions For Polar Grill
Clean the fireplace off combustion residue after use.
After cleaning the fireplace oil it's surfaces with cooking oil.
Empty the fire box regularly to prevent iron grate from burning through prematurely. This way
you will prevent hot coal from dropping on the floor. When emptying the ash box, make sure
the ash has cooled down properly. Always push the ash box all the way through.
If the grill is firmly installed inside a grill hut/pavilion, cover the chimney pipe during winter to
prevent snow from getting inside.
Wooden tables are untreated wood and should be treated with oil, lacquer or paint before
use.
Keep the grill in a dry place.
GUARANTEE
Polar Metalli grants work- and material guarantee according to following conditions:
- Guarantee is valid for a period of one year (12 months) from the date of purchase by the
original end-user purchaser.
- Guarantee covers defects in materials and workmanship under normal use.
- Guarantee provides original receipt indicating the place and date of purchase and product.
GUARANTEE DOES NOT COVER:
- Usual wear and tear of paint or other parts
- Damages resulting from misuse, carelessness, defective maintenance or other external
factors
- Indirect costs such as carriage
PROCEDURE IN CASE OF A DEFECT
Transport damages are to be reported immediately after receiving the goods. Latent defects
are to be reported within five days from receiving the goods.
Polar Metalli Oy will restore the product free of charge.
Guarantee repair does not extend the guarantee of the product or the repaired part.
Buyer is to notify the seller or the manufacturer about the defect in a reasonable time. Reaso-
nable time is usually 14 days from noticing the defect.
This guarantee does not limit the rights the buyer has according to consumer protection
policy.

Instructions for Use
FIRST COOKING
It is recommended to heat up the grill and keep the fuel red hot for at least 30 minutes prior
to the first cooking on the grill. Do not cook before the fuel has a coating of ash.
SAFETY
Do not add lighter fluid or coal imbued with lighter fluid on hot charcoal/firewood.
Always close lighter fluid bottle after use and place it within safe distance from the grill.
Do not use petrol, spirit or comparable fluids för lighting or re-lighting.
Do not leave children or pets unsupervised near fire.
Do not attempt to move a hot grill.
Do not place the grill near flammable materials. Minimum 1,5 m distance from the grill is
recommended.
Do not use the grill until it is fully assembled.
Do not remove ash from the ash basin until all fuel has fully burned out.
When using the grill it is not recommended to wear clothes with slouchy sleeves.
If the grill is in the yard do not use it in heavy wind.
Never touch the grid irons or hook for coffee pot when they're hot.
Always use oven mitts or kettle holders to protect your hands when handling the grill.
Always use proper grilling tools with long, heat-resistant handholders.
LIGHTING THE GRILL
Use charcoal, briquettes or firewood as fuel. Never add more fuel than the height of the
fireplace. Sparknet is not part of the fireplace. When lighting the grill fully open air regulator
and turn grid irons away from the fire.
WOOD
Stack firewood to the center of the fireplace. Firewood should be small enough not to come
out of the fireplace. Light the firewood using birch bark or paper.
CHARCOAL
Stack charcoal/briquettes to the bottom of fireplace and add lighter fluid. Let the lighter fluid
soak in before lighting the grill.
PUTTING OUT FIRE
Let the fire burn out by itself. Do not use water to burn it out as it can damage the grill.