Poulan Pro PO14542B Use and care manual

27
REPAIR PARTS
TRACTOR - - MODEL NUMBER PO14542B
SCHEMATIC
BATTERY
FUSE
IGNITION
SWITCH
RED RED
RED BLACK
IGNITION
UNIT
HEADLIGHTS
REMOVABLE
CONNECTIONS
BLACK
BLACK BLACK
WHITE
WHITE
WHITE
RED
BLACK
ORANGE
BLACK
BROWN
BLACK
BLACK
BLACK
STARTER
M
SEAT SWITCH
(NOT OCCUPIED)
GROUNDING
CONNECTOR
ATT'MENT CLUTCH
(CLUTCH OFF)
CLUTCH / BRAKE
(PEDAL UP)
SOLENOID
BLACK
LIGHTING SYSTEM OUTPUT
5 AMP AC @ 3600 RPM
ALTERNATOR
14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF)
DIODE
28 VOLTS AC MIN. @ 3600 RPM
(CHARGING SYSTEM DISCONNECTED)
CHARGING SYSTEM OUTPUT
3 AMP DC @ 3600 RPM
NOTE
YOUR TRACTOR IS
EQUIPPED WITH A SPECIAL
ALTERNATOR SYSTEM.
THE LIGHTS ARE NOT
CONNECTED TO THE
BATTERY, BUT HAVE THEIR
OWN ELECTRICAL SOURCE.
BECAUSE OF THIS, THE
BRIGHTNESS OF THE LIGHTS
WILL CHANGE WITH ENGINE
SPEED. AT IDLE THE LIGHTS
WILL DIM. AS THE ENGINE IS
SPEEDED UP, THE LIGHTS
WILL BECOME THEIR BRIGHTEST.
WIRING INSULATED CLIPS
NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR
SERVICING OF UNIT, THEY SHOULD BE REPLACED TO
PROPERLY SECURE YOUR WIRING.
A
AMMETER
RED
G
BSM
A1
A2
L
HOUR
METER
(OPTIONAL)
(OPTIONAL)
SPARK
PLUG
GAP
(2 PLUGS ON
TWIN CYL. ENGINES)
IGNITION SWITCH
CIRCUITPOSITION
OFF
B+A1RUN/LIGHT
B + S + A1START
M+G+A1
B+A1RUN
“MAKE”
A2+L
NONE
NONE
NONE
(IF SO EQUIPPED)
NON-REMOVABLE
CONNECTIONS
BLUE
FUEL SHUT-OFF SOLENOID
FUEL
LINE

28
REPAIR PARTS
TRACTOR - - MODEL NUMBER PO14542B
ELECTRICAL
28
29
26
24
42
43
27
27
25
41
27
27
40
33
30
8
2
1
27
16
16
52
D.C. AMPERES
45
2221

29
REPAIR PARTS
TRACTOR - - MODEL NUMBER PO14542B
ELECTRICAL
1 144925 Battery 12 Volt 25 Amp
2 74760412 Bolt Hex Hd 1/4-20unc X 3/4
8 156417 Case Battery
16 153664 Switch Interlock Push -In
21 166181 Harness Asm Light W/4152J
22 4152J Bulb Light #1156
24 4799J Cable Battery 6 Ga 11"red
25 146147 Cable Battery 6 Ga w/16 wire,red
26 175158 Fuse 20 AMP
27 73510400 Nut Keps Hex 1/4-20 unc
28 4207J Cable Ground 6 Ga 12" black
29 121305X Switch Plunger Nc Gray
30 175566 Switch Ign
33 140401 Key Ign
40 170217 Harness Ign
41 71110408 Bolt Blk Fin Hex 1/4-20 X 1/2
42 131563 Cover Terminal Red
43 175141 Solenoid
45 121433X Ammeter
52 141940 Protection Wire Loop
KEY PART
NO. NO. DESCRIPTION
NOTE: All component dimensions give in U.S. inches
1 inch = 25.4 mm.

30
REPAIR PARTS
TRACTOR - - MODEL NUMBER PO14542B
CHASSIS AND ENCLOSURES
3
235
3
26
35
3
26
33 10
34
1
208 11
17
29
28
208
13
12
51
57
53
52
54
55
24
26 25
26 25
3
31
24
30
209
8
209
6
16
9
15
209
209
5
5
58
145
37
37
18
206
3
3
38
38
212

31
REPAIR PARTS
TRACTOR - - MODEL NUMBER PO14542B
CHASSIS AND ENCLOSURES
1 169831 Chassis
2 169061 Drawbar
3 17060612 Screw 3/8-16 x 3/4
5 155272 Bumper Hood/Dash
6155924X012 Saddle Slkscr Flat Lt 6 Sp
8 155138 Clip Retainer Slide-On
9 168348X012 Dash
10 72140608 Bolt RdHd Sqnk. 3/8-16 Unc x 1
11 155927 Panel Asm. Dash Lh
12 145660 Clip Tinnerman Grile P/L
13 172107X010 Panel Dash Rh
15 74180512 Screw Mach Trhd 5/16-18 Unc x 3/4
16 73510500 Nut Keps 5/16-18 Unc
17 159639X428 Hood
18 126938X Bumper Hood
24 74780616 Bolt Fin Hex 3/8-16 Unc x 1 Gr. 5
25 19131312 Washer 13/32 x 13/16 x 12 Ga.
26 73800600 Nut Lock Hex w/Insert 3/8-16 UNC
28 140434 Grill/Lens Asm
29 140273X599 Lens Grille Private label
30 169465X428 Fender Asm
31 136619 Bracket Fender
33 145244X428 Footrest
34 145243X428 Footrest
35 72110606 Bolt RdHd Sht. Sqnk. 3/8-16 x 3/4
37 17490508 Screw Thdrol 5/16-18 x 1/2 Tyt
38 169834 Bracket Asm. Pivot Mower Rear
51 73800400 Nut Lock Hex W/Ins. 1/4-20
52 19091416 Washer 9/32 x 7/8 x 16 Ga.
53 144697 Bracket Grille LH
54 161464 Screw Hex Wshd 8-18 x 7/8
55 144696 Bracket, Grille RH
57 74780412 Bolt Fin Hex 1/4-20 x .75
58 150127 Air Duct Private Label
145 156524 Rod Pivot Chassis/Hood
206 170165 Bolt shoulder 5/16-18
208 17670608 Screw Thdrol 3/8-16 x 1/2
209 17000612 Screw Hex Wsh Thdrol 3/8-16
212 156229 Insert Lens Reflector
- - 5479J Plug Btn Blk
KEY PART
NO. NO. DESCRIPTION
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm

32
REPAIR PARTS
TRACTOR - - MODEL NUMBER PO14542B
DRIVE
29
28
117
89
57
90
74
75
76
78
77
1
25
19 24
253
46
45
44
35
34
37
36 35
27
19
48
62
36
49
47
26 50
45
59
55
77
42
61
61
115
31
58
22 27
26
61
5
6
5
6
61
85
51
54
30
110
110 111
51
110
11
85
80 4
3
13
88 87 86
81
84 83
82
86
88
87
15
96
26
79
8
21
10
51
19
38
41
26
40
26
39
56
42
42
19
9
23
33
63
17
65
20
43
52
60
56
68
52

33
REPAIR PARTS
TRACTOR - - MODEL NUMBER PO14542B
DRIVE
KEY PART
NO. NO. DESCRIPTION
KEY PART
NO. NO. DESCRIPTION
1 - - - - - - Transaxle Peerless Model 206-545C
(Order Parts From Transaxle
Manufacturer)
2 146682 Spring Extension Brake
3 123666X Pulley Transaxle 18" tires
4 12000028 Ring Retainer # 5100-62
5 121520X Strap Torque Rh Pnt Blk
6 17060512 Screw 5/16-18 X 3/4
7 162240 Bracket T/A Saddle Shift
8 131679 Rod Shifter Black(dana)
10 76020416 Pin
11 105701X Washer Plate Shf 388 Sq Hole
12 19151216 Washer 15/32 X 3/4 X 16ga
13 74550412 Bolt 1/4-28 UNF Gr. 8 W/Patch
14 10040400 Washer
18 74780616 Bolt Fin Hex 3/8-16 UNC x 1 Gr. 5
19 73800600 Nut
21 106933X Knob Rd 1/2-13 Plstc Thds Blk
22 130804 Rod Brake Lt
24 73350600 Nut
25 106888X Spring Rod Brake 2 00 Zinc
26 19131316 Washer
27 76020412 Pin
28 145204 Rod Brake Parking Lt/Yt
29 71673 Cap Parking Brake
30 174973 Bracket Transmission
32 74760512 Bolt
34 155071 Shaft Asm Pedal Foot
35 120183X Bearing Nylon Blk 629 Id
36 19211616 Washer
37 1572H Roll Pin
38 131494 Pulley Idler Flat
39 74760644 Bolt Fin Hex 3/8-16 Unc x 2-3/4
40 4470J Spacer Split 395 X 59 Bzp
41 165838 Keeper Belt Idler
42 19131312 Washer 13/32 X 13/16 X 12 Ga
47 127783 Pulley Idler V Groove Plastic
48 154407 Bellcrank Clutch
49 123205X Retainer Belt Style Spring
50 74760624 Bolt
51 73680600 Nut
52 73680500 Nut
53 105710X Link Clutch 7 66
55 105709X Spring Return Clutch 6 75
56 74760620 Bolt
57 130801 V-belt Ground Drive 95
59 169691 Keeper Belt Chassis Span Ctr.
61 17060612 Screw 3/8-16x3/4
62 8883R Cover Pedal Blk Round
63 140186 Pulley Engine
64 71170764 Bolt, Hex 7/16-20 x 4 Grade 5
65 10040700 Washer, Lock, Hvy Hlcl Spring 7/16
66 154778 Keeper Belt Engine Flproof
70 134683 Guide Belt Dr Mower Rh
72 19132012 Washer 13/32 X 1-1/4 X 12 Ga
74 137057 Spacer Axle
75 121749X Washer 25/32 X 1 1/4 X 16 Ga
76 12000001 E Ring
77 123583X Key Square 2 0 X 1845/ 1865
78 121748X Washer 25/32 X 1 5/8 X 16ga
79 2228M Key Woodruff
96 4497H Retainer Spring 1”
112 19091210 Washer 9/32 X 3/4 X 10 Ga
113 127285X Strap Torque Lh
116 72110610 Bolt, Rdhd Sqnk 3/8-16 x 1.25
145 74490540 Bolt Hex Flghd 5/16-18 x Gr. 5
150 165850 Bushing Bellcrank
151 19133210 Washer 13/32 x 2 x 10 Ga.
170 173898 Keeper Belt
202 72110612 Bolt Carr. Sh. 3/8-16 x 1-1/2 Gr. 5
204 17060516 Screw 5/16-18 x 1
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm

34
REPAIR PARTS
TRACTOR - - MODEL NUMBER PO14542B
STEERING ASSEMBLY
62 44
51 54
5
9
5
7
7
9
4
332
43
6
43
8
18
19
22
27
23
40 66
29
25
79
8
10
40
11
8
6
9
46
46
8
6
9
2
47
47
17
26
30
28
1
41
42
37
36
37
38
63
11
39
11
80
68 67
67
67
13
65
85
85
68
15
15
15
29
29 82

35
REPAIR PARTS
TRACTOR - - MODEL NUMBER PO14542B
STEERING ASSEMBLY
1140044X428 Wheel Steering Auto Black
2 154427 Axle Asm Front
3 156483 Spindle Asm Lh
4 157473 Spindle Asm Rh
5 6266H Bearing Race Thrust Harden
6 121748X Washer 25/32 X 1 5/8 X 16ga
7 19272016 Washer 27/32 X 1 1/4 X 16 Ga
8 12000029 Ring Klip #t5304-75
9 3366R Bearing Col Strg Blk
10 169832 Link Drag Extended
11 10040600 Lockwasher
13 136518 Spacer Bearing Axle Front
15 145212 Hex Flange Lock
17 156546 Shaft Asm Strg 5/8 X 15 19 Lt
18 57079 Washer Thrust 515x 750x 033
19 160395 Support Shaft
22 165857 Screw Hex Wsh Hd Torx
23 165851 Shaft Asm Pittman
25 154406 Bracket Steering
26 126847X Bushing Rod Tie Blk Lt
27 136874 Gear Sector
28 19131416 Washer 13/32 X 7/8 X 16ga
29 17060612 Screw 3/8-16x3/4
30 76020412 Pin
32 130465 Rod Tie Wire Form 19 75 Mech
36 155099 Bushing Strg 5/8 Id Dash
37 152927 Screw TT #10-32 x 5 x 3/8 Flange
38 140045X428 Insert Cap Strg
39 19133812 Washer 13/32 x 2-3/8 x 12Ga
40 7810H Locknut Center
41 100711L Adaptor Wheel Strg 640/ 635id
42 145054X428 Boot Dash Steering
43 121749X Washer 25/32 X 1 1/4 X 16 Ga
44 153720 Extension Steering Non-Adjust
46 121232X Cap Spindle Fr Top Blk
47 6855M Fitting Grease
51 73800500 Nut Lock Hex W/Ins.
54 74780520 Bolt Fin Hex 5/16-18 Unc P
62 167902 Kit Steering Assembly Service
63 74780616 Bolt Fin Hex 3/8-16unc x Gr. 5
65 160367 Spacer Brace Axle
66 154404 Bearing Arm Pittman
67 72140618 Bolt Rdhd Sq 3/8-16 Unc x 2-3/4
68 169827 Brace Axle
79 19132012 Washer 13/32 x 1-1/4 x 12 Ga
80 74950612 Bolt Hex Nylon 3/8-16 x 3/4
82 169835 Bracket Susp Chassis Front
85 133835 Fastener Christmas Tree
KEY PART
NO. NO. DESCRIPTION
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm

36
REPAIR PARTS
TRACTOR - - MODEL NUMBER PO14542B
ENGINE
2
1
OPTIONAL EQUIPMENT
Spark Arrester
29
44
46
32
31
33
37
33
40
62
13 4
72
78
81
3
16
78
23
45
14
38