Ski-Daddler 5813-0000 Quick start guide

CR UISER 22
MODEL
5813·0000
PARTS AND SERVICE
M ANUAL
~
AMERICAN MACHINE & FDUNDRY CDMPANY
F
CONSUMER PRODUCT S SALES DIVISION
PARTS & SERVICE DEPARTMENT
Whiteford Road, York, Pennsylvania 17402· Area Code 717 848-1177
PART NO. 37950

TABLE OF CONTENTS
Page
WARRAN TY. . . . . . . . . . . . . . . . . . . . .. 1
TABLE OF CONTENTS ........... 2
SER VICE INSTR UCTIONS .•..•..... 2
BODY PAR TS .................... 4
BODY PARTS LIST ................ 5
STEERING, SKIS, AND UPPER
DRIVE ELEMENTS ................ 6
STEERING, SKIS, AND UPPER
DRIVE ELEMENTS PAR TS LI ST. . .. 7
DRIVE BELT AND LOWER DRIVE
ELEMENTS. " ...........•....... 8
DRIVE BELT AND LOWER DRIVE
ELEMENTS PARTS LIST .•..•..... 9
ENGINE, ELECTRICAL, AND
FUEL ......•........•.......•.... 10
ENGINE, ELECTRICAL, AND
FUEL PAR TS LIST ................ II
Page
CHAIN CASE COMPLETE AND
PAR TS LIST ...................... 12
WIRING DIAGRAM ................ 13
BLOCK AND HOOD ............... 14
BLOCK AND HOOD PARTS LIST .... 15
FLY WHEEL, MAGNETO DIAGRAM
AND PARTS LIST .................. 16
CRANKSHAFT DIAGRAM AND PAR TS
LIST ..................... ....... 17
GENERATOR, SOLENOID DIA-
GRAM AND PARTS LIST ..•.•..... 18
MANIFOLD, MUFFLER DIAGRAM
AND PARTS LIST .•..•.•••..•....•. 19
CARB URETOR AND PAR TS LIST. .. 20
ENGINE OPERATING IN -
STRUCTIONS ..••.•.•.••..•...••.• 21
All information in the preceding section relative to Models 5811 and 5812 apply to
Model 5813 except the information under POWER TRAIN on pages 7 & 8, "Brake Ad-
justmen t" and "To Remove Drive Sprockets" on page 11. New copy for t he latter is
below.
TOR E MOVE DRIVE SPR OCKETS
1. Remove the battery from the sled.
A . Re move cables from battery termi -
nals.
B. Remove battery hold-dow n fasteners.
2. Place rear of sled on kick-stand.
3. Release track tension by removing both
right hand and left hand adjuster plates. R e-
move all fasteners holding adjuster plates
to t he frame (See Figure 1) .
4. Remove track tension springs by push-
ing the extended top end toward the center
and pulling down. Use same procedure on
both sides (See Figure 2) .
5. Remove the three screw s, lock washers,
1.nd nuts that hold the bearing retainer to the
right side of the sled (See Figure 3) .
6.
Turn sled up on its right side. With th e
sle d on its right side, the grease in the gear
case will not run out as much as it would if
the sl ed wer e on its left side.
7. R emo ve lacer pins from the drive track
by ben ding t he ends s tr aight a nd pulling them
ou t.
8. Pull belt to one si de sa you c an gai n
ac c es s to the dr i ve sp rocket s .
9. Remove the set s crew in the collar at
both ends of the drive shaft. There is a notch
- 2 -
FASTENERS
ADJUSTER PLATE
Figure 1
Figure 2

c
•
DRIVE SPR OCKETS
COLLAR
SET SCREW
BEARING RETAINER
Figure 3
in each collar. Insert a punch into the notch.
Tap the punch lightly to loosen the collar
(See Figure 3).
10. Remove the three screws which secure
the chain case cover ( See Figure 3).
11. Remove the bolt and washer from the
end of the drive shaft (See Figure 4). Tap
on the drive sprockets with a hammer. Tap
them to the right side. This will free the
drive shaft from the gear shaft.
12. Loosen set screws which hold the drive
sprockets in place. Slide them off the left end
of the drive shaft.
13. Replace or repair sprockets.
14. Reassemble in opposite order.
15. When replacing the drive shaft into the
gear case, align the large sprocket and the
spacer behind it with your finger before in -
serting the drive shaft (See Figure 5). Insert
shaft and align notches on the end of the drive
sha ft with those on the sprocket in the gear
case.
-3 -
BOLT AND WASHER
Figure 4
Figure 5

.l>-
I
AMF SKI-DADDLER SNOWMOBILE
BODY PARTS
22
For Parts List - See Page 5
ALL UNNUMBERED
~~~ 34
~ d 3~
PARTS INTER·CHANGEABLE
WITH OPPOS IT E SIDE
~/ I 88 "","""
72 52 /J.J 49 35
41 5t l-J 28 68
44 46'a
37 / 40 43 0
45 l- '- ' ~ 'lila eJ
I . Vl) \42
IF> \)= m... If" 00 _ -
\)= 39 38
2~ ~ ~"'-29' ! ~22
12 .;:.;: Q ~ ~ 26~"It-10
~ I d i 860 '~o ~ 9 ~-64
G;
/ ~ 2 54 48 51 l-
I- » •• • I I J -30
;:1. ~. 1":--. ~O ~
29 --13 ~ 64
IO r:e
31
1)=,8
" I»m> B -.
II
~~ .. (D..~
I - .
19 17
II
J
26 - ~
'l
15
-----
~~
-
~
o 0
11
84
57 J 'I'§)
0 '61 ~
~ 83 - 1'9>
• 63 '"
~1~"'-- t 60 ., "'"
62 ._____<P' -A -· , ---------- 66 65 )2 81
~~. 18~ ~~~ ITY6 ~
ry. ~~- - .
o O~"
18
-
~
~ 69 tiS
u • •

AMF SKI-DADDLER SNOWMOB IL E
ALWAY S GIVE THE FOLLOWING INFORMATION WHEN ORDER ING REPAIR PARTS:
•
l. THE PART NUMBER 2. THE PART NAM E 3. QUANTITY DESIRED 4. THE MODEL NUMBER -58130000
c
SEND PART OR DER S TO ATTENTION OF: PARTS DEPARTMENT, P. O. BOX 377, DES MOINES, I OWA 50302
..
Your Unit is Right Hand (R.H.) or Left Hand (L.H.) as you stand behind it.
DO NOT US E KEY NUMBERS WHEN ORDERING REP AIR PARTS, ALWAYS USE P ART NUMBERS.
BODY PARTS
FIGURE 1 PARTS LIST FOR MODEL 58130000
Key Key
No. Port
No.
D escription
No. Part No.
Descr ip tion
1
304 18
Windshield
45
134186
*No. 6-32 x 1" Ova l Hd. Sc.
2
30295
Rubber Spacer
46
271482
No. 6-32 Lock Nut
3 30555 Rubber Bumper Strip 47 30581
Glove Box L id
4
30529
Alu mi num Trim Strip 48 30218 Head Lamp Assy.
5
30376
End Cap Trim- R.H.
49 30630
Windshie ld Trim St rip R.H .
6 30377
End Cap Tr im -L.H .
50
16615 Light Switch
Deca l
7
30394
Kick St and Tube 51 134244
*N o. 8-32 x 11/4 II Ova l Hd. Sc .
8
30395
Hand Rail Tube 52
996907
*No. 10 -32 Keps Nut
9
30396
Hood Access Lid 53
4575 14
*No. 8-32 Loc k N ut
10 30397 Tote Pouch 54 30283 Spon
ge Pad
11
30398 Seat Back 55
30219
Latch
12
30399
Seat 56 16634 I
gn it ion Decal
13 30233
Snap-Male Half
57 30417 Hood
14
30245
Spri ng- Latch H oo k 58
31450
Fue l Tank
15
30246 Latch
Hook
59
30229
Gas Line--Long
16 2251 7/
32" x 3/
4" Washer
60
30263 Gas Tank Inlet Fitting
17 8728 Formed Washer
61
30264
Gas Tank Outlet Fi tting
18
121913 *
1/4" -2 0 X 11/4" Hex Hd. Sc. 62 30265
Fue l Fi lter
19 121926 *
1/4" -20 X 11/2 II Hex Hd. Sc.
63
30270
Fuel Pick-Up Tube
20 9
41 7373
*N o. lOx % II Flat Washer 64
24180
Hose Clamp
21
11 2726
* 1/16" x 1f2" Cotter Pin 65 30278
"O"Ring 11/2" O.D.
22 1
25680
* 1/4 II - 20 x % II Truss Hd. Mach. Sc.
66
30279
" 0" Ring 1 1/4 II O.D.
23
120854
* 1/ 4 II - 20 x %" Hex Hd. Sc. 67 120706
*%" - 20 x 1/2" Hex Hd. Sc .
24 30275
3/16" x % II Pop Rivet 68 30810 Hood Gr
ommet
25
457509
No. 10-2 4 Lock Nut
69 31763 Rubber S
trip
26
94 13314
1/4" -2 0 Lock Nut
70 30365 Support
Ang le
27 120691 No.
10 - 24 x 1% II Flat Hd. Sc. 71
30488 Hose Cl
amp
28
995355
1/4" -20 x 1" Truss Hd. Sc.
72
132911
*N .o. 10 -32 x %" Rd. Hd . Sc.
29
30276
1fs II Pop Rivet 73 30635 Clutch
Guard
30
30400
Fuel Inlet Tube Assy.
74
30605 Plastic Hood Trim
31
30409
Seat Back Tube Assy.
75
30272
Hinge
32
30412
Fuel Ta nk Re tainer Plate Assy.
76
30171 J-Bolt
33 30268 Gas Cap
77
122007 *5/16" - 18 x %" Hex Hd. Sc.
34 306
24 Chain
78
9415988 *5 / 16"-18 Lock Nut
35 30269
Fue l Level Indicator
79
122027
*5/16 "- 18 x 11/4" Hex Hd. S c.
36 30414
Main Frame Assy.
80
30633 B
umper
37 29080
Ta il Lamp Door
81 22780
5/ 16"-18 Curved Hd. Bo lt
38 29081 Tail Lamp
Lens
82 120272 5
/1 6"- 18 x 1" Truss Hd. Sc.
39
29266 Rubber Spacer 83
996407
*5 /1 6" Wa sher
40 30363
Ta il Lamp 84
271184
*5/ 16"-18 Lock Nut
41
31151 Seat Back Cover 85 30587 Rear Brake
Mounting Bracket
42 30362 Tail Lamp Ground
Wire
86 30285 Plate (Glove Box Lid)
43 120622
*No. 8-32 Hex Nu t 87 16439
Dec al F.N.R.
44
132764
*No . 8-32 x % II Rd. Hd. Mach Sc. 88 30631
Windshield T rim Tape L.H.
*Standard Hardware Items may be purchased lo ca lly. For Illustration
See Page 4
c
All replacement parts will be supplied in cu rre nt production co lors or in a neutral co lor.
- 5-

37
26 /
43
\
62
AMF SKI-DADDLER SNOWMOBILE
55-, 56
1Pr/
36 ~18
~ -47
32
o 0
41
e COl &>,,43 \ .....-49
48 ru
6i--r' ~43
69 ~"t>,
35
20
J
/
\ /' \
\< \
\ '",- '
\~~ ~
STEERING, SKIS, FRAME AND TOP DRIVE ELEMENTS '.
\ 60
For Parts List -See Page 7
ALL UNNUMBERED
PARTS INTER-CHANGEABLE
WITH OPPOSITE SIDE
1
'3
)9
46 ~ ..
~. 12
~
8 ~JJ
4)3~10 1
9 ~~/4
~
~~I
13 - : ... 19 q
oa ~ - 2
FIGURE 2
- 6 -
)
)

AMF SKI-DADDLER SNOWMOBILE
c
STEERING, SKIS, FRAME AND TOP DRIVE ELEMENTS
FIGURE 2 PARTS LIST FOR MODEL 58130000
Key Key
No. Part
No.
Description No . Part No. Description
1
30247
Bumper Pad 38
120383 *Lock Washer
2 8441 Spring Roller 39
457507 *No. 10-32 Lock Nut
3
28762
Spring Pivot Pin
40
30575 Square Key
4
137185 * Va" X 1" Cotter Pin
41
25188 Swivel Button
5
997314
1/4 "-20 Centerlock Nut
42 121893 * 1/4 "-20 x 7Ja" Hex Hd. Sc .
6 30369
Ski Wear Rod Assy.
43 124925 *%" - 24 Jam Nut
7 28764
Spring Plate
44
142443
No. 10-32 x 1 %" Rd. Hd. Sc.
8
28766
Leaf Spring
45
18164 3 *%/1-24 x 11 /2" Hex Hd. Sc.
9 28770
Main Leaf Spring
46 995364 %"-24 x 2%" Hex Hd. Sc.
10
29645
Middle Leaf Spring 47 999101
*No. 10-32 x %" Se lf Tap. Sc.
11
28769
Spr ing Mounting Bracket 48
9413314 * 1/4 " - 20 Lock Nut
12 995365
% "-24 x 11/4/1 Hex Hd. Sc . 49
995339
No. 8-32 x %" Socket Hd. Sc.
13 995224
%" - 24 Slotted Nut
50 30414
Main Frame Assy.
c 14
30799
Ski and Wear Rod Assy.
15
706
Grea' se Fitting
16
21777 Spacer Bushing
51
30579 Steering Handle & Column Assy.
52
181 652 % "-24 x 3" Hex Hd. Sc.
53 9415 106 * %" -30 Lock Nut
17 28416
Hand Grip
54 181650 % /1 -24 X 21 /2" Hex Hd. Sc.
18 28907
Hand Control Assy. 55
424339 *No. 10-32 x 1" Rd. Hd. Sc.
19
121222
*3/32" x %" Cotter Key 56 1
20614
*No. 10-32 Hex Nut
20
30673 Bra ke Sp ring Bracket 57
30060 Spindle Arm
21 2347
Spr ing
58 30403 Tie Rod
22
30117 Spindle Bolt 59 30081
Rod End Bearing
23
120233
*%/1-16 xl/1 Hex Hd. Sc .
60
30124 Spindle Tube Assy.
24
30149 Spr ing (Spindle)
61
180079
5/16/1-18 x 1" Hex Hd. Sc.
25 1
20382 * '%" Lock Washer
62 30228 Foot Pad
26
20202 Throttle Control Cable
63 30561
Drag Link
27
24054
"U" Strap
64 30535
No. 706 Hi- Pro Key
28
302 11 Column Support Plate (Upper) 65
30576 Washer (Disc Brake)
29
30212 Thumb Lever (Throttle Control)
66 8103 Flat Washer
30 30224 Brake Cable 67
30592 Front Brake Mounting Bracket
31 30251 Spacer Bushing 68
30392 Driven Clutch
32
27128 Cable Cl amp
69 28783 Disc Brake
33
120396
*%/1 Washer
70 28784 Disc Brake Hub
34 30282 Housing (Brake Cable)
35
120854
*%/1_20 x %/1 Hex Hd. Sc.
71 30390
Apex Gear Case Comp lete
72
120638
*5/16/1 Lock Washer
36 29032 Cable Ferrule
73
31406 Lever Assy.
37
30284 Cable Housing
*
Standard Hardware It ems May Be Purchased Locally For
Illustration See Page 6
All replacement parts will be supplied in cu rrent production colors or in a neutral color.
-7-

(Xl
I
AMF SKI-DADDLER SNOWMOBI LE
DRIV E BELT AND LOWER DRIVE EL EMEN TS
21
\
27 29 24
\ \
26 ()'"". ~
- ru- -Q- _ :n :((\,
15 \ XJ·~·
~ 15 25 ' '
ff 5
10 13 . ~ )6 3 IV
I
~ \ ~~
~ -- 9) ~ - ~~ - ~
4 8 18
____ ~GII$ -- -----
31
- r\ - _ ~ -® l ·( 28
12 11 i f ~ ~ ~ 35
37 34 33 26
39
15 42
~ @,\
~
...0
51 Q ~
/ @~ 0 ~L\) , 1
(
'V' 'q 36 41
4 49 49 50
@
~
43
FIGURE 3
..
""
- _.'::>
24
"'- '-...'-...
~
'-... '-...
'-.....
45 ~ "'-'-,-
22
~
14
F or Parts List - See Pa ge 9
A LL UN NU MBE R ED
P AR TS I NTER-CHANGEABLE
W IT H OP POSI TE S ID E
u

•
n
()
n
AMF SKI-DADDLER SNOWMOBIL E
DRIVE BE LT AND LOWER DRIVE E LEM EN TS
FIGURE 3 PARTS LIST FOR MODEL 581 30000
Key Key
No. Part N
o.
Description No. Part No. Oescri
ption
1 706 Grease Fi
tting
26 30080 Ball Bearing
2 2483 Spring Washer 27 120222
*No. 10-24 x %" Mach. Sc .
3 29956 Spacer 28 997316 No. 10-24 Lock Nut
4 29975
Ad justing Block 29 29955 Sprocket Support Plate Assy.
5 30464
Rear To rsfon Spring R.H.
30 30087 Boggie Wheel &Support Assy.
6 30463
Rear Torsion Spring L.H.
31 30402 Boggie Wheel & Support Shaft
7 30145 Retainer Spring
8 28776 5/
16"- 18 x 3" Hex Hd. Sc . 32 29944 Boggie Wheel Spring
33 29942 Boggie Tire
9 122007
*5/16"-18 x %" Hex Hd. Sc.
34 29954 Boggie Wheel Half (Outer)
-0
I 10 122065
*5/ 1 6"- 18 x 2" Hex Hd. Sc.
11 138485
*5/ 16" Lock Washer
12 181595
*5/16"-24 x %" Hex Hd. Sc.
35 29953 Boggie Wh ee l Half (Inner)
36 30560 Bearing Back Up Plate
37 120221
*No. 10-24 x %" Mach. Sc.
13 456145
5/16" Washer 38 31802
Rear Shaft Assy. W/ Plugs
14 30620 Short Hinge Wire
15 9415988
*5/16"- 18 Lock Nut
16 29980 Belt
Ad just. Angle Assy. R. H.
39 31803 Boggie Support Assy. W/ Plugs
40
30577 Drive Sprocket Assy. Consists
of
(24-~7-28-43-44 - 45-46-47 )
17 29981 Belt Adjust.
Angle Assy. L. H.
41 998010 5/
16"-18 x %" Carriage Bolt
18
29984
Rear Support Arm Assy. R.H.
42 120638
*5 / 1 6" Split Lock Washer
19 29985
Rear Support Arm Asy. L.H.
43 30523 Plate
20 30017 No.
40 Sprocket-26 Tooth 44 30524 Hub
21 30100 Traction
Be lt Assy. 45 998503 5/
16" -18 x 5/ 16" Se t Sc.
22 30621 Long Hinge Wire 46
1218 87 * 1
/4"-20 x %" Hex Hd. Sc.
23 30085
Rear Sprocket Complete Consists 47 9413314 * 1/4"-20
Lock Nut
of (24 -25-26-27 - 28-29-38)
48 31073 Link
Be lt Bearing
Not Illus. 49 31074 Link Belt Collar
24 29945 Rubber
Sp r ocket-9 Tooth
50 31075 Link Belt Stamping
25 30079 Grease Seal 51 8288 Snap
Ring
-- - -- - -- -- --
* Standard Hardware Items May Be Purchased Locally
For Illustration See Page 8
All replacement par ts wi ll be supplied in cu rrent production colors or in a neutral co lo r.

AMF SKI-DADDLER SNOWMOBILE
ENGINE, ELECTRICAL AND FUEL ELEMENTS
48
31 ~
46 ~9-\1 00
g \, ,," a
33
39~~
40~ •
9
35-W
36--®
35~
~
9
30
5"e
51--
.....
~ -46
EJ-27
LJ-26
~28
l-47
10
~
18 38
~
~@-.
32
FIGURE 4
-10 -
~12
11
~12
Fo r Parts List - See Page 11
ALL UNNUMBERED
PARTS INTER -CHANGEABLE
WITH OPPOSITE SI DE
4 34 37
~~
o-~
6 20
46 _r
43
~44
41 I
~1~
-~i\
- 16
o
6
•
..
25

(
AMF SKI-DADDLER SNOWMOBILE
ENGINE, ELECTRICAL AND FUEL ELEMENTS
FIGURE 4 PARTS LIST FOR MODEL 58130000
Key K
ey
No. Port No. Des
cr iption No. Pa rt No. Description
1
30556
Rubber Engine Moun ting Pad 26 30176
Air Cleaner Screen
2 29677 Connector 27 30178
Air Cleaner Co ver
3 30557 Exhaust Pipe 28
30180
Air Cleaner Mount Plate
4 30393
Variable Speed Belt 29 30375
Air Cleaner S tud
5
9416107 * % " -16 Lock Nut
30 16635 Kill Button Dec al
6 999701 %
"-20 x %" Hex Hd. Self Tap Sc.
31
30603 Anchor Bracket (Throttle Cable)
7 999101
*No. 10 -32 x %" Self Tap Sc.
32 30610 Clutch Spacer
8
3039 1 Drive Clutch 33 30628 Carbure
tor (Tillotson HR- 3A )
9 26032 Key Switch 34 21970 Washer
10 29073 Light Switch 35 30676 Intake
Manifold Ga'sket
11
30618 Wiring Harn ess
36 30629 In
su la tor Block
12 30389
Wiring Clip
37 30573 Special Screw
13
30612
Lead Wire (Battery to Sol enoid) 38 30574 1/ 4" Square Key
14 30614 Lead
Wire (R e gulator to Grou-nd) 39 119117
*3/32 x %" Cotter Pin
15 30615 Lead
Wir e (R e gulator to Gen.)
40
30642 Carburetor Adapter Arm Assy.
16 30616 Lead
Wire (Solenoid to Regulator)
41
30601 Battery Hold Down Assy.
17 30617 Lead
Wire (R e gular to Generator)
42
30602 Battery Hold Down
Rod
18 135629 *
1/
2" Shakeproof Washer 43 126177 1/4"-20
Wing Nut
19
31470 Voltag e Regulator (Se e
44 120386
1/4" Washer
Engine Manual)
45 Engine See Footnote Below
20 3324
Solenoid 46 120380
1/4" Lock Wa'sher
21 30572 Engine Base Assy. 47 180124
%" -16 x 11/4" Hex Hd. Sc.
22
9415106 * %" -24 Lock Nut
48 30489 Hose Clamp (Carburetor)
23
446363
*%" Washer
49 120382 *
%" Split Lock Wa sher
24 30568 Engine
Mount Plate
50
995246
1/4"-20 Acorn Nut
25 30613 Lead
Wire (Battery to Ground)
51 124829
%" -16 Jam Nut
* Standard Hardwar e Items May Be Purchased Loca lly For Illustration See Page 10
All pri ces s ubj ect to change with out notic e.
All repla ce me nt parts will be supplied in current production colors or in a neutral color.
Replacement engines
and parts ar e obtainable from the Eng ine Manufactur er's auth orized Service Stations who
are also to be co ntacted in regards to the Engine Wa rranty. See your E ngine Manual for location of these stations.
-11 -

AMF SKI-DADDLER SNOWMOBILE
CHAIN CASE COMPLETE
For Parts List See Below
FIGURE 5
CHAIN CASE COMPLETE
FIGURE 5 PARTS LIST FOR MODEL 58130000
Key
Key
No. Part No. Description No. Part No.
De scrip ti on
1 31814 Housing
25 31838 Spring fo r Detent
2 31815 Drive Sprocket & Bushing
26 31839 5/16" Nut
3 31816 Shif ter Shaft
27 31840 Snap Ring
4 31817 Reverse Pinion
28 3184 1 Snap Ring
5 3 1818 Reverse Shaft
29 31842 Seal- Input Shaft
6 31819 Reverse Gear
30 31843 Dust Cap
7 31820 Taper Bearing Bushing
31 31844 Expansion Plug
8 31821 Shift Lever 32 31845
Torrington Bearing
9 31822 Sprocket-.Driven 33
31846
Seal
10 31823 Input Shaft
34
31847 Oilite Bea ring
11 3 182 4 Output Shaft
35 31848 Set Screw
12 31825 Insp ec tion Cover
36 31849 1/8" x 1" Roll Pin
13 31826 Cover Plate 37
31850 Breather
14 31827 Fulcrum & Nut
38 31851 Stud
15 31828 Washer - Axle
39
31852 Lever Ball
16 31829 Gasket for Inspection Cover
40 318 53 Chain (by link) ,
17 31830 Gasket for Cover Plate
41
31854 Bearing & Collar
18 31831 "0" Ring for F lang et
42
3 1855 Flanget
19 31832 Gasket for Flanget
43 31856 Detent Ball
20 31833 Shaft & Bearing
44 31857 5/16/1 Lock Washer
21 31834 Roller
45 31858
%" Bolt
22 31835 Spacer- Output
46
31859 1/8" x 1f2" Roll Pin
23 31836 Collar-Input
47
31860 1/4" Bolt
24 31837 Timken Bearing
* Standard Hardware It ems May Be Purchased Locally For
Illustration See Above
All replacement pa rts will be supplied in cu rrent production colors or in a neutral color.
-12-
,
T

)
c
REPA IR MAN'S REFERENCE WIRING DIAGRAM
:z:
u
....
~
'"
....
:I:
g :I:
u
....
~
Z
o
;::
liE
~
The wIring diagram shown here is a te chnical ex-
planation of the circuitry on this unit . It is intended for
use by repairman or owners capable of readin g and
us ing wiring diagrams.
The various component parts have been lab eled. See
your Servi ce De aler for part numbers, price and o rdering
1I01Vln9311 39"1101\
~
Z
o
w
U
~
w
!!?
w
'"
~
'"
'"
Z
'"
«
:I:
o
o
o
:I:
information. Also see your Service Dealer for ava ilable
Service Manual.
We recommend th at unle ss you are fully qualified
to make repairs on the electr.ical syst em on this unit,
you take it to a competen t re pairman for such work or
adjustments.
- 13-

~ll
5
6
7
8
9
10
12---
13- --
BLOCK AND HOOD
~- 38
--=----41
37
lIi
t~
-14 -
36
35
i'-
39 40
34
28
a----27
~--13
--- 14
y
18
)

BLOCK AND HOOD PAR TS LIST
ENGINE TYPE 2054-SRB x 18 (AMF)
C
ITEM NOS .
QUANTITIES DESIGNATION
549x398
Cover for air shro ud
EAZI02B
Connection clamp for grounding w ire
884x7
Insul a tin g washe r
4
DIN84 -5S M3xl5
Screw for connection clamp
549x399
Shield for cylinder
836x43
Terminal for ignitio n cable
SOx39
Spark plug BOSCH M 225 - T
1712x142
Cylinder head
759xl81
Gasket for Cylinder head
10
205xl78
Cylinder
II
759x183
Gask et for cylinde r base
12
DIN931 - 5S M8x65
Screw for c rank case
13
DINI37 A8
Lockwasher
14
DIN934 - 5S M8
Nut for crankcase
15
DIN 835 -5S MIOx22
Stud for cylinder
16
9244x159
Crankcase assembly
17
343x135
Roll pin
18
318x340
Impulse tub e
19 7
3x2 1S
"0" ring seal for crankcase
20
DIN8 35-5S MIOx70
Stud for crankcase
21
DINI37 AIO
10
Lockwash e r
(
22
DIN934 - 5S MIO 10
Nut for c rank case and cylinder
23 DIN7603 A8xll, 5 Washer for drainage plug
24 DIN933- 5D M8xl58SZ Plug for c r ankcase drainage
25
954x87 4 Stud for mounting crankcase
26 22Zx366 Straight fittin g for fuel pump
27 DIN93 1- 5S M8x60 Screw for crankcase
28 582x33 Main bearing plate fly wheel end
29
DINI37 A8 4 Lockwasher
30 DIN931-5D M8x20 Screw for main bearing plate
31 73x219 110" ring seal for crankcase
32 73x217 "0" ring seal for crankcase
33 DIN931-5S MIOxl60 Screw for crankcase
34 549x 385 Air guidance tin
35 DINI25 10,5 Pla in washer for mounting cylinde r
head
36 DIN931-8G M IOx45 Screw for mountin g cylinder head
37
819x77 Screw for mount in g cylinder head and
cover for air shroud
38
DIN84- ·5S M6xl0
Screw for fixing cover for air shroud
39
SI3x62
Rubber nipple for ground i ng wire
40 813- H
Rubber nip pl e fo r ignition cable
41
DIN433-St 6,4 Plain washe r
c
-15 -

FLY WHEEL AND MAGNETO
~ ~
l}-34
)
~
~ 35
33
\ \
19
6 \ ,
~i>
,
,
2:7-,-
,
28 ~ - 30
- ,\1
25
~ \, - 31
23
29
22
11
FLY WHEEL AND MAGNETO PARTS LIST
ENGINE TYPE 2054-SRB x 18 ( AMF )
~
NOS.
QUANT
DESIGNATION
PRICE
~
NOS . QUANT I
DESIG NA TION
DIN 3 16-4D M8x15
Screw for mountin g screen
.1 5 19
141x234
I gn ition cab le for cyl.
No . 2
DIN433-St 8 ,4
Plain washer
.05
20
DIN84- 5S M6x12
4
Screw f or moun ti ng fly wheel magneto
82x127
Screen for cooling air intake
9. 30
21
DIN137 A6
4
Lockwasher
4
549x397
Air sh roud
110.00
22
787x 1 60
Marked bushing f or ignition c abl e No. 1
810x2 78
Cov er for a ir shrou d
1. 80
23
141x235
Ig nition cab le for cyl.
No. 1
DIN137 A6
Lockwasher
.05
24
9Z8 1x1 34
Fly wheel magne to assembly
DIN 933 -5D M6x 12
Sc rew for mounting and air shroud
.15
25
547x6
Fan
26
DI N835 - 5D M8x15
4
Stud for fixing ai r shroud
287x32
Breaker c over
2.30
27
209x82
Nut for mounting fly wheel
954x86
Stu d for fixin g air shroud
. 60
28
141x237
Wire for stop button
10 DIN137 A8
Lockwasher
.05
29 141x238
Wire for s top button
11
DIN934- 5S M8
Nut for fixing air shroud
. 08
30
9367x24
Stop button
12 583x24 1
Fly wheel
52.00
31
DIN933-5S M3x8
Screw for stop button
13
DIN7976 Bz 4. 8x 19
Sc rew for moun ti ng fan
.15
32
929x179
Support clip for insulating sheath
14
DIN64 -5S M5x15
Screw for fixing armature plate
• 15 33
204211 005
I gnition Coil
15
DIN137 AS
Lockwasher
.05
34
237 330 037
Condensor
16 DIN433 St 5, 3xlO
Pla in washer
.05
35
217013 006
Contact Set
17
787xl61
Marked bushing for ignit ion cable No.
. 25
18
143x1 60
Insulating sheath
1. 00
-16 -

c
CRANKSHAFT
2
14
CRANKSHAFT
PARTS LIST
ITEM NOS.
4
10
II
12
13
14
15
16
17
18
19
20
9020x29
9020x29 - R I
9020x29 -R 2
9020 x2 9- R3
9020x29 - R4
DIN73123 - B2 0
240xl25
240x 125 - RI
240x12 5-R Z
240x1Z5-R3
240x125-R4
DIN73121-K
D20x14x60
DI N93 1- 5D M8x40
DINI 37 A8
334x92
9002x l 0
9493x80
3Zlx39
1212 -202 - 109
9341 xl 44
DIN6885 St
A5x5x30
9090x72
934 1 x66
321x143
1 652xl80
DINI37 A8
DIN931 - 5D M8x20
7 32x80
ENGINE
TYPE 2054 - SRB
x 18 (AMF)
QUANTITIES
DESIGNATION
4
Piston assembl
- do - 0 ,2 5 mm 6- standard
-d o- 0.50 mm O· S.
- do - 0 .7 5 mm . S.
- do - I 00 O. S.
• rnm O. S.
Retaining ring for piston pin
Piston rin
_ do - O. 25 ~ - mS~ndard
-do - 0 , 50 mm O· S.
-d o- 0, 75 mm O· S.
- do - 1, 00 mm O : ~ :
Piston pin
Screw f or r
ope starte r she ave
Lockwasher
Rope starter sheave
Starting rope assembly
Oil sea l f
fly whee lOerndcrankShaft, T
.0. and
~hru s t washer for In .
Y whee.l end am bearing.
Cam f or break er contacts
Main hearin
g. fly wheel end
Key for mountin g cam and fly wheel
Crankshaf
t assembly
. . end
Main bearing T 0
Th r ust wash
T. O. end er for main bea .
Ting
pate, T. O. end
Main bearin g 1
Lockwasher
Screw for main b
Piston . ea ri ng plate
ptn bushing
1 7-
8
l,

GENERATOR AND VOLTAGE REGULATOR
r
I
I
I
I
4
".. -
:~
\ \ 14
13
crt
16 15
8
7
5
~J
8
9
12
GENERATOR AND VOLTAGE REGULATOR PARTS LIST
ENGINE TYPE 2054 - SRB x 18 (AMF)
ITEM NOS.
QUANTITIES DESIGNATION
9281x1l3 Starter generator assembly
DlN9 34 -5S M8 Nut for adjusting strap
DlNI37 A8
Lockwasher
DlNI25 8,4 Plain washer for adjusting strap
1552x603
Strap (or s tart e r gene rator belt
adjustment
DlN933 - 5D M8x25 Screw for mounting adjusting strap
DlN934 -5S MIO
Nut for fixing starter gene ratar
DlNI 37 AIO Lockwasher
112x9 3
Stud for mounting starter gene rator
10 221x149 Driven pulley on sta rt e r generator
II 332x52 Belt for starter gene rator
12 9448x34 Current vo ltage regulator assembly
13 889x215
Spacer for mounting s tart er genera -
tor
14 1552x604 Support bracket for starter genera-
tor
15
813x49
Rubber hood for cable terminal
16 B13x63
Rubber hood for cable terminal
-1 8-
)

c
C
c
2
MANIFOLD AND MUFFLER
12
1
~11
I 13
I
I
I
MANIFOLD AND MUFFLER PARTS LIST
ENGINE TYPE 20S4·SRB x 18 (AMF)
ITEM NOS .
QUANTITIES DESIGNATION
9003x484
Muffle r
DIN933 -SD M8x2S
Screw for muffler strap
929x246
Mu ffl er st r ap
DIN9 34- M8 Laitan
Nut for muffler strap
DIN939-SD M8xl8
4 Stud for exhaus t pipe
9003 x 48S
Pipe nipp le for muffl er mounting
7 S9x l82
Ga ske t for pipe nipple for muffler
73xl42
Ga sket for intake manifold
903x301
Intake manifo ld
10
DIN939-SD M8x2S
4 StUQ for intake manifold
II
DINI3 7 A8
Lockwasher
12
DIN934 -SS M8
Nu t for intak e manifold
13
DIN939- SD M8x 22
Stud fo r intake manifold
14
DINI37 A6
Lockwasher
IS
DIN9 33 -SS M6x l S
Screw for support at carbure t or
- 19-

II.)
0
I
NOTICE: Parts liste d on th is page available from--Tillotson Mfg . Co . --
Part s &: Service Di vision- -761 - 69 Berdan Ave. - - Toledo, Ohio- - or through
any Authorized Tillotson Servic e outlet.
Ref. HR-3A
No. Part No.
Part Name
1 014387 Body
(Service)
2 02531 * Body Channel Welch
Plug (2)
3 013737 * Body Channel Welch
Plug
4 04784 Choke
Friction Ba ll
5 08805 Cho
ke Fric ti on Spring
6 014359 Ch oke Shaft & Lever ·
7 0143
56
Choke Shutter
8 08942 Choke Shutter Screw & Lockwasher (2)
9 010393 Choke Wire Connec tion
10 010392 Choke Hire Connection Ret. Clip
11 058 * Choke IHre Ret. Screw
12 012473 Diaphragm Gasket
13
012475 * Diaphragm
14 014402 Diaphragm
Cover
15 05322 Economiser Check Ball
16 014319 Flange Gasket
17 012930 Fuel Pump Gasket
18 014230 * Fuel Pum p Diaphragm (Pulse)
19 014229 *
Fuel Pump Diaphragm (Valve)
20 013335 Fuel Pump Body
21 010098
Fuel Pump Body Screw &Lockwasher (6)
22 010530 *
Fuel Strainer Screen
23 010529
Fuel Strainer Cover Gasket
24 010527
Fuel Strainer Cover
25 010571 * F
uel Strain er Cover Ret. Screw
1
26 014321 *
Idle Mixture Screw
27 08793 *
Idle Mixture Screw Spring
28 011428
Idle Mixture Screw Washer
29
01,1401
Idle Mixture Screw Packin g
30 014326 *
Idl e Speed Screw
31 0788 *
Idl e Speed Screw Spring
32 010513 *
Inlet Contr ol Lever
33 013406 *
Inlet Control L ever Fulcrum Pin
34 013269 *
Inl et Control Lever Fulcrum Pin Ret. Screw
35 013546 *
Inlet Needle, Seat & Gasket
36 010165
Iniet Seat Gasket
37 013434 *
In le t Tens io n Spring
38 014323 *
High Speed Mixture Screw
39 011103 *
High Speed Mixture Screw Spring
40 03114
High Speed Mixture Screw Washer
41 010511
High Speed Mixture Screw Pack ing
42 014334 * Nozz
le Check Va l ve
4.3 014361 Th
ro ttl e Shaft & Lever
44 09678
Throttle Shaft C lip
45 0992
Throttle Shaft C lip Lockwasher
46 01974
Throttle Shaft Clip Ret. Screw
47 014324 *
Throttle Shaf t Re turn Spring
48 014320
Throttle Shutter
49
08942 *
Throttle Shutter Screw & Lockwasher (2)
50 012305 *
Throttle Wire Ret . Screw
51 GS-199 *
Gasket & Packing Set
52 RK-756 Repai r Parts Kit
(* ) Indicates conten t s of Repair Parts Kit
specif ic atio ns are subject to change without notice.
J..JI
II--!>o
1&
-. ---------.
~ -:31
. ,30
.4P'V /'
2
I
lI,g~
333~:~
( \" ···c·'·. '
... . :. : . ~ ' ·:· ~ · . t-- 1 8
........
~
L .~ \.
I ..I~. ' ·· : 5> . 1--19
II "",~
.... ~ \.
p..J~~}--20
u