SLEIPNER MOTOR AS Side-Power SH Series User manual

Made in Norway
©Sleipner Motor AS 2020
SLEIPNER MOTOR AS
P.O. Box 519
N-1612 Fredrikstad
Norway
www.side-power.com
Document id:
Revision:
Date:
6572
2
SH SERIES
OPERATIONAL
HYDRAULIC USER MANUAL
To download your language go to www.side-power.com
Keep this
manual onboard !
2020

26572 22020
-
SH user manual
DECLARATION OF CONFORMITY
Sleipner Motor AS
P.O. Box 519, Arne Svendsensgt. 6-8
N-1612 Fredrikstad, Norway
Declare that this product with accompanying standard control systems complies with
the essential health and safety requirements according to:
DIRECTIVE 2013/53/EU
DIRECTIVE 2014/30/EU
DIRECTIVE 2014/35/EU
MC_0020
Important User Considerations and Precautions................. 3
User Manual
Thruster Operation .................................................................... 4
Control Panel............................................................................. 5
Maintenance........................................................................ 6 - 7
Troubleshooting......................................................................... 8
Checklist.................................................................................... 8
Spare Parts................................................................................ 9
Contents
EN
MC_0048
Important Thruster User Considerations and Precautions
EN
IMPORTANT
Failure to follow the Considerations and precautions can cause serious injury / damage and will render all warranty given by Sleipner
Motor AS VOID.
Never use thrusters when close to objects/ persons or pets in the water. The thruster will draw objects into the tunnel and
the rotating propellers. This will cause serious injuries and damage the thruster.
• Always turn the control device/panel off when the thruster is not in use or when leaving the boat.
• When leaving the boat always turn off the main power switch for the thruster.
• Never use thrusters out of water.
• If the thruster stops giving thrust while running, there is possibly a problem in the drive system. You must immediately stop running the thruster and
turn it off . Running the thruster for more than a few seconds without resistance from the propeller can cause serious damage to the thruster.
• If the performance of the thruster is reduced check the hydraulic system or check the tunnel for marine growth.
• If two panels are operated with confl icting directions at the same time the thruster will not run. If both are operated in the same direction, the thruster
will run in this direction.
• If you notice any faults with the thruster switch it off to avoid further damage.
• It is the owner/ captain/ other responsible parties full responsibility to assess the risk of any unexpected incidents on the vessel. If the thruster stops
giving thrust for some reason while manoeuvring you must have considered a plan on how to avoid damage to persons or other objects.
• The primary purpose of the thruster is to manoeuvre/ dock the vessel. Expect reduced performance at higher speeds.
Products
SH1000/513-BA45 - SH1000 Tunnel thruster, Ø513mm
SH100/185T-U06 - SH100 Tunnel thruster, U06
SH100/185T-U10 - SH100 Tunnel thruster, U10
SH160/215T-U14 - SH160 Tunnel thruster, U14
SH160/215T-U06 - SH160 Tunnel thruster, U06
SH240/250TC-U08 - SH240 Tunnel thruster, U08
SH240/250TC-U10 - SH240 Tunnel thruster, U10
SH240/250TC-U19 - SH240 Tunnel thruster, U19
SH320/300TC-U16 - SH320 Tunnel thruster, U16
SH320/300TC-U19 - SH320 Tunnel thruster, U19 [Archived]
SH320/300TC-U08 - SH320 Tunnel thruster, U8
SH320/300TC-U23 - SH320 Tunnel thruster, U23
SH320/300TC-U14 - SH320 Tunnel thruster, U14
SH320/300TC-U11 - SH320 Tunnel thruster, U11
SH320/300TC-BA19 - SH320 Tunnel thruster, BA19
SH320/300TC-BA16 - SH320 Tunnel thruster, BA16
SH420/386TC-U37 - SH420 Tunnel thruster, U37
SH420/386TC-BA40 - SH420 Tunnel thruster, BA40
SH420/386TC-BA32 - SH420 Tunnel thruster, BA32
SH420/386TC-U33 - SH420 Tunnel thruster, U33
SH420/386TC-U26 - SH420 Tunnel thruster, U26
SH420/386TC-BA40-S - SH420 Tunnel thruster, BA40
SH420/386TC-U29 - SH420 Tunnel thruster, U29
SH550/BA40-S - Hydraulikk thruster, >550kg
SH550/386TC-P52 - SH550 Tunnel thruster, P52
SH550/386TC-BA60 - SH550 Tunnel thruster, BA60
SH550/386TC-BA32 - SH550 Tunnel thruster, BA32
SH550/386TC-BA40 - SH550 Tunnel thruster, BA40
SH550/386TC-U50 - *Hydraulikk thruster >550-U50
SH550/386TC-U33 - SH550 Tunnel thruster, U33
SH550/386TC-U37 - SH550 Tunnel thruster, U37
SH550/386TC-BA40-S - SH550 Tunnel thruster, BA40
SH550/386TC-BA75 - SH550 Tunnel thruster, BA75
SH550/386TC-G45 - SH550 Tunnel thruster, G45
SH700/412-BA60 - SH700 Tunnel thruster, BA60
SH700/412-BA75 - SH700 Tunnel thruster, BA75
SH700/412-BA45 - SH700 Tunnel thruster, BA45
SH700/412-BA56 - SH700 Tunnel thruster, BA56 [Archived]
SH1000/513-BA110 - * BRUK SH1000/513-BA110D13
SH1000/513-G80 - SH1000 Tunnel thruster, G80
SH1000/513-BA125 - SH1000 Tunnel thruster, BA125
SH1000/513-G75 - SH1000 Tunnel thruster, G75
SH1000/513-BA80 - SH1000 Tunnel thruster, BA80
SH1000/513-G70 - SH1000 Tunnel thruster, G70
SH1000/513-BA60 - SH1000 Tunnel thruster, BA60
SH1000/513-BA110D13 - SH1000 Tunnel thruster, BA110
SH1400/610-BA160 - SH1400 Tunnel thruster, BA160
SH1400/610-BA125 - SH1400 Tunnel thruster, BA125
SH1400/610-BA80 - SH1400 Tunnel thruster, BA80
SH1400/610-BA180 - SH1400 Tunnel thruster, BA180
SH1400/610-BA110 - SH1400 Tunnel thruster, BA110
SH1400/610-BA150 - SH1400 Tunnel thruster, BA150 [Archived]
SH1400/610-BA080 - SH1400 Tunnel thruster, BA80
SH100/185T-U11 - SH100 Tunnel thruster, U11
SH160/215T-U08 - SH160 Tunnel thruster, U08 [Archived]
SH1000/513-BA75 - SH1000 Tunnel thruster, BA75
SH160/215T-U11 - SH160 Tunnel thruster, U11 [Archived]
SH320/300TC-U10 - SH320 Tunnel thruster, U10
SH550/386TC-BA56 - SH550 Tunnel thruster, BA56
SH1000/513-BA90 - SH1000 Tunnel thruster, BA90
SH100/185T-U08 - SH100 Tunnel thruster, U08 [Archived]
SH160/215T-U10 - SH160 Tunnel thruster, U10
SH240/250TC-U14 - SH240 Tunnel thruster, U14
SH240/250TC-U16 - SH240 Tunnel thruster, U16
SH240/250TC-U11 - SH240 Tunnel thruster, U11
SH550/386TC-BA45 - SH550 Tunnel thruster, BA45

3
6572 22020
-
SH user manual
DECLARATION OF CONFORMITY
Sleipner Motor AS
P.O. Box 519, Arne Svendsensgt. 6-8
N-1612 Fredrikstad, Norway
Declare that this product with accompanying standard control systems complies with
the essential health and safety requirements according to:
DIRECTIVE 2013/53/EU
DIRECTIVE 2014/30/EU
DIRECTIVE 2014/35/EU
MC_0020
MC_0048
Important Thruster User Considerations and Precautions
EN
IMPORTANT
Failure to follow the Considerations and precautions can cause serious injury / damage and will render all warranty given by Sleipner
Motor AS VOID.
Never use thrusters when close to objects/ persons or pets in the water. The thruster will draw objects into the tunnel and
the rotating propellers. This will cause serious injuries and damage the thruster.
• Always turn the control device/panel off when the thruster is not in use or when leaving the boat.
• When leaving the boat always turn off the main power switch for the thruster.
• Never use thrusters out of water.
• If the thruster stops giving thrust while running, there is possibly a problem in the drive system. You must immediately stop running the thruster and
turn it off . Running the thruster for more than a few seconds without resistance from the propeller can cause serious damage to the thruster.
• If the performance of the thruster is reduced check the hydraulic system or check the tunnel for marine growth.
• If two panels are operated with confl icting directions at the same time the thruster will not run. If both are operated in the same direction, the thruster
will run in this direction.
• If you notice any faults with the thruster switch it off to avoid further damage.
• It is the owner/ captain/ other responsible parties full responsibility to assess the risk of any unexpected incidents on the vessel. If the thruster stops
giving thrust for some reason while manoeuvring you must have considered a plan on how to avoid damage to persons or other objects.
• The primary purpose of the thruster is to manoeuvre/ dock the vessel. Expect reduced performance at higher speeds.

46572 22020
-
SH user manual
Thruster Operation
EN
Take time to practice operation in open water to become familiar with the thruster and to avoid damages to your boat or people.
How to use the Thruster
1. Ensure hydraulic power is supplied for the thruster. (NB: Hydraulic power is supplied when the engine is running).
2. Turn on the control panel by pushing both “ON” buttons on the Side-Power panel simultaneously.
* Turn off the control panel by pushing the “OFF” button
Joystick Control
To Turn the bow in the desired direction move the joystick in the direction you wish the bow to move.
Button Control
To Turn the bow in the desired direction push the red button for port movement or the green button for starboard.
* For other controls like foot switches or toggle-switches please refer to that products user manual for detailed operational use.
How to use a combined bow and stern thruster
The combination of a bow and stern thruster off ers total manoeuvrability to the boat and the ability to move the bow and the stern separately from each
other. This enables you to move the boat sideways in both directions and turn the boat around its axis 360º staying stationary.
NB: At speed the side thruster will have little or no eff ect to steer the vessel.
MC_0361
!Please refer to the graphic for special considerations relating to your model !
8950 8960 8940 8909c 8955 8965
RCT-20 RCT-21 RCT-23
ON/ OFF CONTROL PANEL
REMOTE CONTROL

5
6572 22020
-
SH user manual
MG_0047
Activating the bow thruster
Turn ON thruster Turn OFF thruster
*Control panel example *Control panel example
*Control panel example
*Control panel example*Control panel example
Activating the stern thruster
Activating both bow and
stern thruster to rotate the
boat on axis
Activating both bow and
stern thruster to push the
boat sideways
Control Panel

66572 22020
-
SH user manual
MG_0148
KEY:
1. Hydraulic Motor
2. Mounting Plate
3. Motor bracket
4. Flexible coupling
5. Gear Leg
6. Propeller
7. Anode
8. Drive pin
9. Washer
10. Lock Nut
11. Fastening Screw for anode
12. Oil drain screw
13. Shaft Key
14. Anode pins
15. Locking Washer
SH
* 100
* 160
* 240
SH
* 320
SH
* 420
* 550
SH
* 700
* 1000
* 1400
11
13
11
11
10
10
10
9
9
9
8
8
7
7
7
7
7
7
6
6
6
6
6
6
5
5
5
5
5
5
4
4
4
3
3
3
2
2
2
1
1
1
11
14 12
12
13
10
15
7
7
6
6
5
5
4
3
2
1
MC_0362
Maintenance
EN
As a part of the seasonal service of your Thruster before every season, always check that:
In Water/ Out of the Water
• The area around the thruster inside the boat is clean and dry. Ensure there are no signs of water or oil leaks.
• All electrical connections are clean and fastened fi rmly.
• Ensure that your batteries are in good condition.
Out of Water
• Check the propeller(s) or tunnel for any damage for example impact damage.
• The propeller(s) is fastened securely to the gear leg.
• Check all components of thruster are fastened securely.
• Clean the tunnel and gear leg from marine growth.
• Paint the propeller and gear leg with anti-fouling before every season to keep it clean from sea growth. (NB: Never paint the anode, rubber seals
or propeller shaft. Ensure paint does not enter the space between the propeller and the gear leg.)
• Change the anode before every season, or when half the anode has eroded. Always use a sealant or thread glue on the securing screw to ensure
that it does not fall off .
• Ensure propellers are attached correctly. (NB: Counter rotating models use a left hand/ right hand propeller.)
• If an external oil tank is installed with your model, ensure the oil level remains the same.
!Please refer to the graphic for special considerations relating to your model !

7
6572 22020
-
SH user manual
MG_0148
KEY:
1. Hydraulic Motor
2. Mounting Plate
3. Motor bracket
4. Flexible coupling
5. Gear Leg
6. Propeller
7. Anode
8. Drive pin
9. Washer
10. Lock Nut
11. Fastening Screw for anode
12. Oil drain screw
13. Shaft Key
14. Anode pins
15. Locking Washer
SH
* 100
* 160
* 240
SH
* 320
SH
* 420
* 550
SH
* 700
* 1000
* 1400
11
13
11
11
10
10
10
9
9
9
8
8
7
7
7
7
7
7
6
6
6
6
6
6
5
5
5
5
5
5
4
4
4
3
3
3
2
2
2
1
1
1
11
14 12
12
13
10
15
7
7
6
6
5
5
4
3
2
1

MC_0360
Basic Troubleshooting
EN
Before seeking assistance from the website help desk from your Side-Power dealer/ distributor, please perform these tests.
(NB: If you are unable to understand what to check, you must consult a Side Power distributor.)
CHECK SOLUTION
The motor runs, but there is no thrust
Check propellers are fi tted, fastened correctly and not
damaged on the prop shaft. Re-fasten or replace if necessary
On counter rotating models ensure LH and RH propellers
are installed correctly Install correctly
Check the fl exible coupling between the motor and drive
shaft is fi tted correctly and not damaged. Replace if necessary
Check the gears are not damaged. Replace if necessary
The thrusters performance is reduced
Check the propeller, gear house and tunnel are free from
growth/ barnacles or debris and damage.
If there is growth in the tunnel, this will disturb/ block the water fl ow and signifi cantly
reduce performance
Check oil pressure and levels. Fill if necessary
86572 22020
-
SH user manual

MC_0161
Seasonal Checklist
EN
CHECK TO PERFORM DATE
The thruster components are fastened securely. The area around the thruster is clean and dry. If there are signs of water or oil leaks Paint the propeller and gear leg with anti-fouling. Batteries are in good condition. All electrical connections are clean and fastened fi rmly. Change the anode. Check oil in the oil reservoir.
9
6572 22020
-
SH user manual

10 6572 22020
-
SH user manual
1. The equipment manufactured by Sleipner Motor AS (The “Warrantor”) is warranted to be free from defects in workmanship and materials under normal
use and service.
2. This Warranty is in eff ect for of two years (Leisure Use) or one year (Commercial use) from the date of purchase by the user. Proof of purchase must be
included, to establish that it is inside the warranty period.
3. This Warranty is transferable and covers the product for the specifi ed time period.
4. In case any part of the equipment proves to be defective, other than those parts excluded in paragraph 5 below, the owner should do the following:
(a) Prepare a detailed written statement of the nature and circumstances of the defect, to the best of the Owner’s knowledge, including the date of
purchase, the place of purchase, the name and address of the installer, and the Purchaser’s name, address and telephone number;
(b) The Owner should return the defective part or unit along with the statement referenced in the preceding paragraph to the warrantor,
Sleipner Motor AS or an authorized Service Centre, postage/shipping prepaid and at the expense of the Purchaser;
(c) If upon the Warrantor’s or Authorized Service Centre’s examination, the defect is determined to result from defective material or workmanship, the
equipment will be repaired or replaced at the Warrantor’s option without charge, and returned to the Purchaser at the Warrantor’s expense;
(d) no refund of the purchase price will be granted to the Purchaser, unless the Warrantor is unable to remedy the defect after having a reasonable
number of opportunities to do so. Prior to refund of the purchase price, Purchaser must submit a statement in writing from a professional boating
equipment supplier that the installation instructions of the Installation and Operation Manual have been complied with and that the defect remains;
(e) warranty service shall be performed only by the Warrantor, or an authorized Service Centre, and any attempt to remedy the defect by anyone else
shall render this warranty void.
5. There shall be no warranty for defects or damages caused by faulty installation or hook-up, abuse or misuse of the equipment including exposure to
excessive heat, salt or fresh water spray, or water immersion except for equipment specifi cally designed as waterproof.
6. No other express warranty is hereby given and there are no warranties which extend beyond those described in section 4 above. This Warranty is
expressly in lieu of any other expressed or implied warranties, including any implied warranty of merchantability, fi tness for the ordinary purposes for
which such goods are used, or fi tness for a particular purpose, and any other obligations on the part of the Warrantor or its employees and
representatives.
7. There shall be no responsibility or liability whatsoever on the part of the Warrantor or its employees and representatives for injury to any person or
persons, or damage to property, loss of income or profi t, or any other consequential or resulting damage or cost which may be claimed to have been
incurred through the use or sale of the equipment, including any possible failure or malfunction of the equipment, or part thereof.
8. The Warrantor assumes no liability for incidental or consequential damages of any kind including damages arising from collision with other vessels
or objects.
9. This warranty gives you specifi c legal rights, and you may also have other rights which vary from country to country.
For the most up to date documentation, we advise you to
visit our website www.side-power.com for the spare parts
list.
For additional supporting documentation, we advise you
to visit our website www.side-power.com for the spare
parts list.
Spare Parts
Product Templates and Additional Resources
Warranty statement
EN
EN
EN
MC_0024
MC_0024
MC_0024

MC_0037
Notes
EN
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
..................................................................................................................................................................................................................................................
11
6572 22020
-
SH user manual
1. The equipment manufactured by Sleipner Motor AS (The “Warrantor”) is warranted to be free from defects in workmanship and materials under normal
use and service.
2. This Warranty is in eff ect for of two years (Leisure Use) or one year (Commercial use) from the date of purchase by the user. Proof of purchase must be
included, to establish that it is inside the warranty period.
3. This Warranty is transferable and covers the product for the specifi ed time period.
4. In case any part of the equipment proves to be defective, other than those parts excluded in paragraph 5 below, the owner should do the following:
(a) Prepare a detailed written statement of the nature and circumstances of the defect, to the best of the Owner’s knowledge, including the date of
purchase, the place of purchase, the name and address of the installer, and the Purchaser’s name, address and telephone number;
(b) The Owner should return the defective part or unit along with the statement referenced in the preceding paragraph to the warrantor,
Sleipner Motor AS or an authorized Service Centre, postage/shipping prepaid and at the expense of the Purchaser;
(c) If upon the Warrantor’s or Authorized Service Centre’s examination, the defect is determined to result from defective material or workmanship, the
equipment will be repaired or replaced at the Warrantor’s option without charge, and returned to the Purchaser at the Warrantor’s expense;
(d) no refund of the purchase price will be granted to the Purchaser, unless the Warrantor is unable to remedy the defect after having a reasonable
number of opportunities to do so. Prior to refund of the purchase price, Purchaser must submit a statement in writing from a professional boating
equipment supplier that the installation instructions of the Installation and Operation Manual have been complied with and that the defect remains;
(e) warranty service shall be performed only by the Warrantor, or an authorized Service Centre, and any attempt to remedy the defect by anyone else
shall render this warranty void.
5. There shall be no warranty for defects or damages caused by faulty installation or hook-up, abuse or misuse of the equipment including exposure to
excessive heat, salt or fresh water spray, or water immersion except for equipment specifi cally designed as waterproof.
6. No other express warranty is hereby given and there are no warranties which extend beyond those described in section 4 above. This Warranty is
expressly in lieu of any other expressed or implied warranties, including any implied warranty of merchantability, fi tness for the ordinary purposes for
which such goods are used, or fi tness for a particular purpose, and any other obligations on the part of the Warrantor or its employees and
representatives.
7. There shall be no responsibility or liability whatsoever on the part of the Warrantor or its employees and representatives for injury to any person or
persons, or damage to property, loss of income or profi t, or any other consequential or resulting damage or cost which may be claimed to have been
incurred through the use or sale of the equipment, including any possible failure or malfunction of the equipment, or part thereof.
8. The Warrantor assumes no liability for incidental or consequential damages of any kind including damages arising from collision with other vessels
or objects.
9. This warranty gives you specifi c legal rights, and you may also have other rights which vary from country to country.
For the most up to date documentation, we advise you to
visit our website www.side-power.com for the spare parts
list.
For additional supporting documentation, we advise you
to visit our website www.side-power.com for the spare
parts list.
Spare Parts
Product Templates and Additional Resources
Warranty statement
EN
EN
EN
MC_0024
MC_0024
MC_0024

MC_0030
Worldwide sales and service
www.side-power.com
SLEIPNER MOTOR ✴AS P.O. Box 519 ✴N-1612 Fredrikstad ✴Norway
The information given in the document was correct at the time it was published. However, Sleipner Motor AS can not accept liability for any inaccuracies or omissions it
may contain. Continuous product improvement may change the product specifi cations without notice. Therefore, Sleipner Motor AS can not accept liability for any possi-
ble differences between product and document.