Sony SAVA-27 User manual

SAVA-27
US Model
Canadian Model
AEP Model
UK Model
E Model
Australian Model
Chinese Model
SERVICE MANUAL
HOME THEATER ACTIVE SPEAKER SYSTEM
MICROFILM
SPECIFICATIONS
— Continued on next page —
(Rear) (R-ch) (L-ch)

— 2 —
TABLE OF CONTENTS
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK !OR DOTTED LINEWITH
MARK !ON THE SCHEMATIC DIAGRAMS AND INTHE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE !SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE
REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY
DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
TEST MODE ·································································· 3
1. GENERAL ······································································ 4
2. DISASSEMBLY
2-1. Removal Amplifier Block ·················································· 5
3. DIAGRAMS
3-1. Circuit Boards Location ····················································· 6
3-2. Schematic Diagram —Main Section — ····························· 7
3-3. Printed Wiring Board —Main Section — ························ 11
3-4. Schematic Diagram —Display Section — ······················· 14
3-5. Printed Wiring Board —Display Section — ···················· 17
3-6. IC Pin Function ································································ 20
3-7. IC Block Diagrams ··························································· 21
4. EXPLODED VIEWS
4-1. System (L) Assy ······························································· 23
4-2. System (R) Assy ······························································· 24
4-3. Amplifier Section ····························································· 25
4-4. Rear Speaker Section························································ 26
5. ELECTRICAL PARTS LIST ··································· 27
After correcting the original service problem, perform the
following safety checks before releasing the set to the customer:
Checkthe antennaterminals, metaltrim, “metallized”knobs, screws,
and all other exposed metal parts forAC leakage. Check leakage as
described below.
LEAKAGE
The AC leakage from any exposed metal part to earth ground
and from all exposed metal parts to any exposed metal part having
a return to chassis, must not exceed 0.5 mA (500 microampers).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a
VOM or battery-operatedAC voltmeter. The “limit” indication
is 0.75 V, so analog meters must have an accurate low-voltage
scale. The Simpson 250 and Sanwa SH-63Trd are examples of
a passive VOM that is suitable. Nearly all battery operated
digital multimeters that have a 2V AC range are suitable. (See
Fig. A)
SAFETY CHECK-OUT
To Exposed Metal
Parts on Set
0.15
µ F 1.5k Ω
AC
voltmeter
(0.75V)
Earth Ground
Fig.A. Using an AC voltmeter to check AC leakage.

SAVA-27
SECTION 1
GENERAL SECTION 2 DISASSEMBLY SECTION 3 DIAGRAMS
3-1. CIRCUIT BOARDS LOCATION
– 3 – – 4 – – 5 –
1
2
3
44
5
1LEFT CHANNEL SPEAKER/CENTER CHANNEL WOOFER
2CENTER CHANNEL TWEETERS
3RIGHT CHANNEL SPEAKER/CENTER CHANNEL WOOFER
4SUPER WOOFER
5REAR SPEAKER
6
7!§
!¢
!£
!¶
!∞
8
9
!º
!•
!ª @º @¡
@™@£@¢@∞
!¡
!™
6THEATER
7PRO LOGIC
8STADIUM
9GAME
!º INPUT1
!¡ INPUT2
!™ MUTING
!£ MASTER VOL
!¢ SUPER WOOFER MODE (1, 2, OFF)
!∞SUR OFF
!§ HALL
!¶ POWER
!• POWER
!ª STANDBY indicator
@º ON/READY indicator
@¡ VOLUME
@™ S.WOOFER
@£ Remote Sensorg
@¢ SURROUND
@∞INPUT
2-1. REMOVAL AMPLIFIER BLOCK
1 Grill frame assembly
2 Ornament frame
3 Three tapping screws
(4 × 20)
4 Front frame assembly
5 Four tapping screws
(4 × 20)
7 Display panel assembly
!§ One connector
PS Board
!∞ Back panel
8 5th tapping screws (4 × 16)
9 8th tapping screws
(4 × 16)
!º Three tapping screws (4 × 16)
!¡ 6P connector
!™ 5th screws
(BVTP 3 × 8)
!£ Four screws
(BVTP 3 × 8)
!¢ Two screws
(BVTP 3 × 8)
!¶ Amplifier
SDN651
6 Flat type wire
(27core)
– 6 –
This section is extracted
from instruction manual.
INPUT board
MAIN board
POWER board
POW-SW board
POW-SR board
POW-CN board
POW-L board
POW-R board
DOLBY board
PS board
T1 board
T2 board
KEY board
DISPLAY board
TEST MODE
MODE ALL FLUORESCENT INDICATOR TUBES
LIGHT
When the AC plug is inserted to the power outlet with pressing the
MASTER VOL + button, the all fluorescent indicator tubes light.
KEY CHECK, LED LIGHTING MODE
1. Pull out theAC plug from the power outlet and turn the power
OFF.
2. Connect the lead wire to TP3 on the KEY board.
3. Insert the AC plug to the power outlet and set to STANDBY
mode.
4. Let the lead wire connected in step 1 contact to the ground.
5. All fluorescent indicator tubes light, and enter the key check
mode.
6. Pressing any buttons, the number of button will be displayed
on the fluorescent indicator tube.
7. After all buttons are pressed, it will be in the STANDBY mode.
Note:
1. The LED (D505)lights while pressing each button.
The LED lights in red when ever number of buttons are pressed,
and it lights in green when odd number of buttons are pressed.
2. The LED lights even when the pressed button is pressed again.
• Parts Location
[KEY BOARD] — Conductor side —
CN552
IC503
S506 R557
TP3
Button
POWER
MASTER VOL–
MASTER VOL +
INPUT
SURROUND
CTR MODE
S.WOOFER
ButtonNumber
2
3
4
5
6
7
8
LEDColor
Red
Green
Red
Green
Red
Green
Red

SAVA-27
– 20 – – 21 –
3-6. IC PIN FUNCTION
• IC501 SYSTEM CONTROL (UPD78043FGF-012-3B9)
Pin No.
1 to 7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53 to 70
71
72 to 77
78 to 80
I/O
O
—
O
O
O
O
O
O
I
O
I
—
—
—
O
O
O
O
O
I
I
I
—
I
I
—
—
I
O
O
O
O
—
I
I
—
—
I
—
—
—
—
O
O
O
—
O
—
O
O
Description
FL gride signal output
Power supply (+4.7V)
Power relay output
Dolby IC enable output
Dolby IC data output
Dolby IC clock output
Front speaker mute output
Center speaker mute output
HCD connector input
Super woofer mute output
Reset signal input
Connected to ground
Connected to ground
Ground
Volume IC enable output
Volume IC data output 2
Volume IC clock output 2
Volume IC data output 1
Volume IC clock output 1
Line input level
AD input for key
AD input for key
Power supply (+4.7V)
Analog reference voltage input
STOP input
Not used
Ground
X'tal (5MHz)
X'tal (5MHz)
Rear speaker mute
Connected to ground
Super woofer boost
Power supply (+4.7V)
Extermal center speaker switch input
TV SIRCS enable switch input
Connected to ground
Connected to ground
SIRCS input
Connected to ground
Connected to ground
Connected to ground
Connected to ground
LED output
LED output
LED output
Power supply (+4.7V)
FL segment signal output
Power supply (–25V) for FL segment signal output
FL gride signal output
FL gride signal output
Pin Name
7G to 1G
VDD
POWER RY
PLO/DELAY-CE
PLO/DELAY-DATA
PLO/DELAY-CLK
FRONT MUT
CENTER MUT
HCD IN
S/W MUT
RESET
—
—
AVSS
VOL CE
VOL DI1
VOL CL1
VOL DI2
VOL CL2
AUTO SW
KEY 1
KEY 0
AVDD
AVREF
STOP
XT2
Vss
X1
X2
REAR MUT
REAR POWER
S/W BOOST
—
CENTER EXT-SW
TV/SW
—
—
INT SIRCS
—
—
—
IC
STANDBY LED
READY LED
OPRATE LED
VDD
S24 to S7
VLOAD
S6 to S1
10G to 8G
• Abbreviation
FL : Fluorescent indicator tube
3-7. IC BLOCK DIAGRAMS
1
2
3
4
5
6
7
8
9
15
10
11
12
–+
13
14
16
21
18
19
25
17
24
22
23
20
34
32
33
29
30
35
28
31
27
26
36
40
39
38
37
41
42
NOISE
FILTER NOISE
CH
BALANCE
CONTROL
VR
CONTROL
LPF
V REF
VR
VR
NOISE
GENERATOR
VCAVCA
VCAVCA
VCAVCA
VCAVCA
LPF
LPF
RECT RECT RECT RECT
P. S.P. S.
CMODE
MUTE
DIVIDER OSC
CONTROL
CTRIM
LOG
DIFF LOG DIFF
DUAL T
CONTROL
L-IN
R-IN
VSS
CLK
DATA
VCC
L-OUT
R-OUT
S-OUT
C-OUT
ENABLE
OSC1
CMODE-CAP.
C-TRIM DC CUT
R-BPF1
R-BPF2
R-BPF3
DC CUT
DC CUT
L-R RECT
L+R RECT
VCS-TH
VCS-1
VCS-2
BPF1
BPF2
VREF
S-CH DC OUT
C-CH DC OUT
L-CH DC OUT
R-CH DC OUT
VREF
L-BPF1
L-BPF2
L-BPF3
DC CUT
DC CUT
R RECT
L RECT
VLR-TH
VLR-1
VLR-2
IC301 LA2786
IC701 µPC1237HA
1 2 3 4 5 6 7 8
OVER LOAD DET
F/F
OFFSET DET
LATCH/
AUTORESET
V
CC ON
MUTE
AC OFF
DET
V
CC
15 6
+
–
+
20 19 18 17 16 15 14 13
21
22
2324
2 3 4789 10 12
11
+
DEC
IN-FILTER
(40kHz)
VDD
ADM-CONT SRAM
ADM
OUT-FILTER
(7k/5k)
B-NR
DC-OUT
VOL/MUTE
S-TRIM
INV-PHASE
R+DELAY
L+DELAY
A
B
A
B
A
B
A
B
A
B
A
B
A
B
L–R
L+R
(–6dB)
A
B
A.GND L-OUT
R-OUT
VREF S-OUT
DELAY-OUT
S-IN
R-IN
L-IN
VCC
NR-DET
ENABLE
DATA
CLK
D.GND
DC-CUT VDD OSC OSC
NR-IREF
DC-CUT
+
–
+
–
+
–
+
–+
–
+
–
+
–
+
–
+
–
+
–
+
–
+
–+
–
+
–
+
–
+
–
DECODER LATCH SHIFT
REGISTER CONTROL
–
+
+
–
12 3 45 6 7 8 9 10
20
19
18
17
16
15
14
13
12
11
21
22
2324252627282930313233
34
35
36
37
38
39
40
41
42
43
44
LSELO
L4
L3
L2
L1
VDD
R1
R2
R3
R4
RSELO
RVRIN
RCOM
RT1 RT2 RT3
RTOUT
RSIN
RS1 RS2 RS3
RSOUT
RFIN
RFOUT
RROUT
VSS
CL
DI
CE
VREF
LROUT
LFOUT
LFIN
LSOUT
LS3 LS2 LS1 LSIN LTOUT LT3 LT2 LT1 LCOM LVRIN
IC351 LV1016
IC201 LC75373ED
– 22 –

SECTION 4
EXPLODEDVIEWS
Note:
• -XX,-Xmeanstandardizedparts,sotheymay
havesomediff erencesfromtheor iginalone .
• Itemsmarked“*”arenotstocked since they
areseldomrequiredforroutineservice.Some
delayshouldbeanticipatedwhenorderingthese
items.
• Themechanicalpartswithnoreferencenumber
intheexplodedviewsarenotsupplied.
• Hardware(#mark)list and accessories and
packingmaterialsare given inthelastof this
partslist.
• Abbereviation
G :German SP :Singapore
AUS :Australian CH :Chinese
MY :Malaysian
The components identified by mark !or
dotted line with mark !are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
!sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
— 23 —
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
4-1. SYSTEM (L)ASSY
1 4-991-883-01 FRAME, ORNAMENT
2 X-4948-622-1 FRAME (L) ASSY, GRILLE
3 4-951-733-01 CATCHER
4 1-505-681-11 SPEAKER (5cm)
5 X-4948-623-1 PANEL ASSY, FRONT
6 1-505-680-11 SPEAKER (10cm)
7 X-4948-550-1 PANEL ASSY, DISPLAY
8 4-991-271-01 BUTTON (A)
9 4-991-275-01 WINDOW (IR)
10 4-991-284-01 REFLECTOR
11 4-991-276-01 HOLDER, FL TUBE
*12 A-4403-111-A DISPLAY BOARD, COMPLETE
13 4-991-272-01 BUTTON (B)
*14 1-666-222-11 KEY BOARD
*15 A-4384-736-A CABINET (L) ASSY, SPEAKER (EXCEPT G)
*15 A-4384-738-A CABINET (L) ASSY, SPEAKER (G)
16 4-991-889-01 COVER (W)
17 1-505-679-11 SPEAKER (13cm)
18 4-923-040-11 SCREW (4X16), TAPPING
*19 4-976-741-01 COVER, BUTTON
*20 4-991-890-01 PANEL (L), BACK (US)
*20 4-991-890-11 PANEL (L), BACK (Canadian)
*20 4-991-890-21 PANEL (L), BACK (AEP, UK, G, MY, SP)
*20 4-991-890-31 PANEL (L), BACK (AUS)
*20 4-991-890-41 PANEL (L), BACK (CH)
21 4-914-430-11 SCREW (4X20), TAPPING
FL501 1-517-673-11 INDICATOR TUBE, FLUORESCENT
a
b
a
b
FL501
#2
#2
#1
#3 #
3
#5
#5
#5
11
6
12
21
21
8
15
43
5
3
2
1
97
10
14
21
21
13
21
18
18
20
19
18
16
17
21
AMPLIFIER ASSY

— 24 —
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
4-2. SYSTEM (R)ASSY
51 4-991-883-01 FRAME, ORNAMENT
52 X-4948-752-1 FRAME (R) ASSY, GRILLE
53 4-951-733-01 CATCHER
54 1-505-681-11 SPEAKER (5cm)
55 1-505-680-11 SPEAKER (10cm)
56 X-4948-709-1 PANEL (R) ASSY
*57 A-4384-737-A CABINET (R) ASSY, SPEAKER (EXCEPT G)
*57 A-4384-739-A CABINET (R) ASSY, SPEAKER (EXCEPT G)
58 4-923-040-11 SCREW (4X16), TAPPING
*59 4-991-891-01 PANEL (R), BACK
60 4-991-889-01 COVER (W)
61 1-505-679-11 SPEAKER (13cm)
62 4-914-430-11 SCREW (4X20), TAPPING
63 X-4948-623-1 PANEL ASSY, FRONT
55
57 58
59
60
62
62
63
62
62
62
54 53
53
56
53
52
51
#1
#5 #5
#
5

— 25 —
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
4-3. AMPLIFIER SECTION
4A:INPUTBOARD
*101 A-4403-112-A POWER BOARD, COMPLETE
*102 A-4403-110-A DOLBY BOARD, COMPLETE
*103 4-975-298-01 BUTTON (PUSH)
*104 A-4403-106-A PS MOUNTED BOARD, COMPLETE
105 1-773-274-11 WIRE (FLAT TYPE) (27 CORE)
*106 A-4403-105-A MAIN BOARD, COMPLETE (US, Canadian)
*106 A-4403-113-A MAIN BOARD, COMPLETE
(AEP, UK, AUS, CH, G, MY, SP)
*107 1-666-219-11 T1 BOARD
*108 1-666-220-11 T2 BOARD
*109 3-703-244-00 BUSHING (2104), CORD
!110 1-575-042-21 CORD, POWER (US,Canadian)
!110 1-575-651-21 CORD, POWER (AEP, G, MY, SP)
!110 1-696-845-11 CORD, POWER (AUS)
!110 1-751-529-11 CORD, POWER (UK)
!110 1-782-510-11 CORD, POWER (CH)
!T901 1-431-428-11 TRANSFORMER, POWER (US, Canadian)
!T901 1-431-433-11 TRANSFORMER, POWER
(AEP, UK, AUS, CH, G, MY, SP)
The components identified by
mark !or dotted line with mark
!are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque !sont critiques
pour la sécurité.
Ne les remplacer que par une
pièceportantlenumérospécifié.
a
a
b
b
CH MODEL
102
103
104
105
106
107 110
110
110
110
not supplied
not supplied
not supplied
not supplied
not supplied
(Included
in
4 A)
not supplied
not supplied
#3
#3
#3
#3
#3
#3
#3 #3
#3
4 A
#3
#3 #3
#3
#3
#3
#3
#3
#3
#4 #4
108
101
109
T901
AEP, G, SP, M
Y
MODEL
US, Canadian
MODEL
UK MODEL
AUS MODEL
110
L-ch

— 26 —
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
4-4. REAR SPEAKER SECTION
151 X-4948-740-1 PANEL ASSY, FRONT
152 1-505-682-11 SPEAKER (8cm) *153 X-4947-156-1 CABINET ASSY, SPEAKER 154 4-929-125-01 SCREW (M4X16), TAPPING
154
154
153
152
151
#1
not supplied

Note: • Duetostandardization,replacements in the
par ts list ma y be different from the par ts
specifiedinthe diagramsorthe components
usedontheset.
• -XX,-Xmeanstandardizedparts,sotheymay
havesomediff erencefromtheor iginalone .
• Itemsmarked“*”arenotstocked since they
areseldomrequiredforroutineservice.Some
delayshouldbeanticipatedwhenorderingthese
items.
• CAPACITORS:
uF: µF
• RESIST ORS
Allresistors areinohms.
METAL:metal-filmresistor
METALOXIDE:MetalOxide-filmresistor
F:nonflammable
• COILS
uH: µH
• SEMICONDUCT ORS
Ineachcase,u: µ,forexample:
uA...: µA..., uPA... , µPA...,
uPB..., µPB...,uPC..., µPC...,
uPD..., µPD...
• Abbereviation
G :German SP :Singapore
AUS :Australian CH :Chinese
MY :Malaysian
When indicating parts by reference number,
please include the board naame.
The components identified by mark !or
dotted line with mark !are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
!sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 27 —
SECTION 5
ELECTRICAL PARTS LIST DISPLAY
*A-4403-111-A DISPLAY BOARD, COMPLETE
***********************
*4-991-276-01 HOLDER, FL TUBE
< CAPACITOR >
C501 1-124-261-00 ELECT 10uF 20% 50V
C502 1-124-261-00 ELECT 10uF 20% 50V
C503 1-164-159-21 CERAMIC 0.1uF 50V
C504 1-164-159-21 CERAMIC 0.1uF 50V
C505 1-164-159-21 CERAMIC 0.1uF 50V
C506 1-126-154-11 ELECT 47uF 20% 6.3V
C507 1-104-905-11 CAPACITOR 0.22F 5.5V
C508 1-164-159-21 CERAMIC 0.1uF 50V
C509 1-124-465-00 ELECT 0.47uF 20% 50V
C510 1-164-159-21 CERAMIC 0.1uF 50V
C512 1-164-159-21 CERAMIC 0.1uF 50V
C513 1-126-154-11 ELECT 47uF 20% 6.3V
< CONNECTOR >
*CN152 1-568-869-11 SOCKET, CONNECTOR 27P
*CN501 1-564-710-11 PIN, CONNECTOR (SMALL TYPE) 8P
< DIODE >
D501 8-719-987-63 DIODE 1N4148M
D502 8-719-987-63 DIODE 1N4148M
D503 8-719-987-63 DIODE 1N4148M
D506 8-719-987-63 DIODE 1N4148M
D507 8-719-987-63 DIODE 1N4148M
< FILTER >
FL501 1-517-673-11 INDICATOR TUBE, FLUORESCENT
< IC >
IC501 8-759-463-21 IC uPD78043FGF-021-3B9
IC502 8-759-165-81 IC PST600D-T
< COIL >
L501 1-410-521-11 INDUCTOR 100uH
< TRANSISTOR >
Q501 8-729-119-79 TRANSISTOR 2SC2785-FEK
Q503 8-729-900-63 TRANSISTOR DTA124ES
Q504 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q505 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q506 8-729-900-63 TRANSISTOR DTA124ES
Q507 8-729-900-36 TRANSISTOR DTC124ES
< RESISTOR >
R501 1-249-417-11 CARBON 1K 5% 1/4W F
R502 1-247-807-31 CARBON 100 5% 1/4W
R503 1-247-807-31 CARBON 100 5% 1/4W
R504 1-247-807-31 CARBON 100 5% 1/4W
R505 1-249-417-11 CARBON 1K 5% 1/4W F
R506 1-249-417-11 CARBON 1K 5% 1/4W F
R507 1-249-417-11 CARBON 1K 5% 1/4W F
R508 1-247-807-31 CARBON 100 5% 1/4W
R509 1-247-807-31 CARBON 100 5% 1/4W
R510 1-249-417-11 CARBON 1K 5% 1/4W F
R511 1-249-417-11 CARBON 1K 5% 1/4W F
R512 1-247-807-31 CARBON 100 5% 1/4W
R513 1-247-807-31 CARBON 100 5% 1/4W
R514 1-249-417-11 CARBON 1K 5% 1/4W F
R515 1-249-417-11 CARBON 1K 5% 1/4W F
R516 1-249-417-11 CARBON 1K 5% 1/4W F
R518 1-249-417-11 CARBON 1K 5% 1/4W F
R519 1-249-417-11 CARBON 1K 5% 1/4W F
R520 1-249-429-11 CARBON 10K 5% 1/4W
R521 1-249-429-11 CARBON 10K 5% 1/4W
R522 1-247-843-11 CARBON 3.3K 5% 1/4W
R526 1-247-843-11 CARBON 3.3K 5% 1/4W
R534 1-247-815-91 CARBON 220 5% 1/4W
R535 1-249-407-11 CARBON 150 5% 1/4W F
R536 1-247-815-91 CARBON 220 5% 1/4W
R537 1-249-437-11 CARBON 47K 5% 1/4W
R538 1-249-437-11 CARBON 47K 5% 1/4W
R539 1-249-437-11 CARBON 47K 5% 1/4W
R540 1-249-437-11 CARBON 47K 5% 1/4W
R541 1-249-437-11 CARBON 47K 5% 1/4W
R542 1-249-437-11 CARBON 47K 5% 1/4W
R543 1-249-437-11 CARBON 47K 5% 1/4W
R544 1-249-437-11 CARBON 47K 5% 1/4W
R545 1-249-437-11 CARBON 47K 5% 1/4W
R546 1-249-437-11 CARBON 47K 5% 1/4W
R547 1-249-437-11 CARBON 47K 5% 1/4W
R548 1-249-437-11 CARBON 47K 5% 1/4W
R549 1-249-437-11 CARBON 47K 5% 1/4W
R550 1-249-437-11 CARBON 47K 5% 1/4W
R551 1-249-437-11 CARBON 47K 5% 1/4W
R552 1-249-437-11 CARBON 47K 5% 1/4W
R553 1-249-437-11 CARBON 47K 5% 1/4W
R554 1-249-437-11 CARBON 47K 5% 1/4W
R555 1-249-417-11 CARBON 1K 5% 1/4W F
R556 1-249-429-11 CARBON 10K 5% 1/4W

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 28 —
DISPLAY DOLBY KEY
R560 1-249-413-11 CARBON 470 5% 1/4W F
R561 1-249-413-11 CARBON 470 5% 1/4W F
R562 1-249-437-11 CARBON 47K 5% 1/4W
R563 1-249-437-11 CARBON 47K 5% 1/4W
R564 1-247-807-31 CARBON 100 5% 1/4W
R565 1-247-807-31 CARBON 100 5% 1/4W
R566 1-249-425-11 CARBON 4.7K 5% 1/4W F
R570 1-247-895-91 CARBON 470K 5% 1/4W
R571 1-247-895-91 CARBON 470K 5% 1/4W
R572 1-249-419-11 CARBON 1.5K 5% 1/4W F
R573 1-249-419-11 CARBON 1.5K 5% 1/4W F
R574 1-249-437-11 CARBON 47K 5% 1/4W
R575 1-249-437-11 CARBON 47K 5% 1/4W
< VIBRATOR >
X501 1-579-233-11 VIBRATOR, CERAMIC 5MHz
************************************************************
*A-4403-110-A DOLBY BOARD, COMPLETE
*********************
< CAPACITOR >
C301 1-136-157-00 FILM 0.022uF 5% 50V
C302 1-136-161-00 FILM 0.047uF 5% 50V
C303 1-126-934-11 ELECT 220uF 20% 16V
C304 1-126-964-11 ELECT 10uF 20% 50V
C305 1-126-964-11 ELECT 10uF 20% 50V
C306 1-126-964-11 ELECT 10uF 20% 50V
C307 1-126-964-11 ELECT 10uF 20% 50V
C308 1-126-934-11 ELECT 220uF 20% 16V
C309 1-126-960-11 ELECT 1uF 20% 50V
C310 1-126-960-11 ELECT 1uF 20% 50V
C311 1-136-165-00 FILM 0.1uF 5% 50V
C312 1-136-165-00 FILM 0.1uF 5% 50V
C313 1-126-959-11 ELECT 0.47uF 20% 50V
C314 1-126-963-11 ELECT 4.7uF 20% 50V
C315 1-126-959-11 ELECT 0.47uF 20% 50V
C316 1-126-963-11 ELECT 4.7uF 20% 50V
C317 1-136-167-00 FILM 0.15uF 5% 50V
C318 1-126-962-11 ELECT 3.3uF 20% 50V
C319 1-136-167-00 FILM 0.15uF 5% 50V
C320 1-136-167-00 FILM 0.15uF 5% 50V
C321 1-126-962-11 ELECT 3.3uF 20% 50V
C322 1-136-167-00 FILM 0.15uF 5% 50V
C323 1-126-963-11 ELECT 4.7uF 20% 50V
C324 1-126-959-11 ELECT 0.47uF 20% 50V
C325 1-126-963-11 ELECT 4.7uF 20% 50V
C326 1-126-959-11 ELECT 0.47uF 20% 50V
C327 1-136-165-00 FILM 0.1uF 5% 50V
C328 1-136-165-00 FILM 0.1uF 5% 50V
C329 1-104-664-11 ELECT 47uF 20% 25V
C330 1-126-959-11 ELECT 0.47uF 20% 50V
C331 1-126-960-11 ELECT 1uF 20% 50V
C333 1-126-934-11 ELECT 220uF 20% 16V
C334 1-162-292-31 CERAMIC 680PF 10% 50V
C351 1-126-961-11 ELECT 2.2uF 20% 50V
C352 1-126-934-11 ELECT 220uF 20% 16V
C354 1-136-165-00 FILM 0.1uF 5% 50V
C355 1-136-171-00 FILM 0.33uF 5% 50V
C356 1-126-934-11 ELECT 220uF 20% 16V
C357 1-126-960-11 ELECT 1uF 20% 50V
C358 1-126-960-11 ELECT 1uF 20% 50V
C359 1-126-960-11 ELECT 1uF 20% 50V
C360 1-136-173-00 FILM 0.47uF 5% 50V
C361 1-136-164-00 FILM 0.082uF 5% 50V
C362 1-137-367-11 FILM 0.0033uF 5% 50V
C363 1-136-164-00 FILM 0.082uF 5% 50V
C364 1-126-934-11 ELECT 220uF 20% 16V
C365 1-162-294-31 CERAMIC 0.001uF 10% 50V
C366 1-164-159-21 CERAMIC 0.1uF 50V
< CONNECTOR >
CN251 1-770-731-11 CONNECTOR, BOARD TO BOARD 12P
< IC >
IC301 8-759-442-96 IC LA2786
IC351 8-759-442-97 IC LV1016
IC503 8-759-339-53 IC GP1U28XB (REMOTE SENSOR)
< COIL >
L301 1-408-117-00 INDUCTOR 10uH
L351 1-408-117-00 INDUCTOR 10uH
< RESISTOR >
R354 1-249-436-11 CARBON 39K 5% 1/4W
R355 1-249-431-11 CARBON 15K 5% 1/4W
R356 1-249-439-11 CARBON 68K 5% 1/4W
R357 1-247-903-00 CARBON 1M 5% 1/4W
R358 1-247-807-31 CARBON 100 5% 1/4W
< VIBRATOR >
X351 1-579-125-11 VIBRATOR, CERAMIC 8MHz
************************************************************
*1-666-222-11 KEY BOARD
*********
< CAPACITOR >
C511 1-162-306-11 CERAMIC 0.01uF 20% 16V
< DIODE >
D504 8-719-313-43 DIODE SEL6210S-TH10 (STANDBY)
D505 8-719-045-89 DIODE SML16760CN (ON/READY)
< RESISTOR >
R523 1-249-415-11 CARBON 680 5% 1/4W F
R524 1-249-417-11 CARBON 1K 5% 1/4W F
R525 1-249-419-11 CARBON 1.5K 5% 1/4W F
R527 1-249-415-11 CARBON 680 5% 1/4W F
R528 1-249-417-11 CARBON 1K 5% 1/4W F
R529 1-249-419-11 CARBON 1.5K 5% 1/4W F
R557 1-249-429-11 CARBON 10K 5% 1/4W
R567 1-249-417-11 CARBON 1K 5% 1/4W F
< SWITCH >
S501 1-762-196-21 SWITCH, TACT (INPUT)
S502 1-762-196-21 SWITCH, TACT (S.WOOFER)
S503 1-762-196-21 SWITCH, TACT (SURROUND)
S504 1-762-196-21 SWITCH, TACT (CTR MODE)
S505 1-762-196-21 SWITCH, TACT (MASTER VOL (+))
S506 1-762-196-21 SWITCH, TACT (MASTER VOL (–))
S507 1-762-196-21 SWITCH, TACT (POWER)
************************************************************

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 29 —
MAIN INPUT
*A-4403-105-A MAIN BOARD, COMPLETE (US, Canadian)
*********************
*A-4403-113-A MAIN BOARD, COMPLETE (EXCEPT US,
********************* Canadian)
INPUT BOARD
***********
< CAPACITOR >
C101 1-162-286-21 CERAMIC 220PF 10% 50V
C102 1-162-286-21 CERAMIC 220PF 10% 50V
C109 1-126-960-11 ELECT 1uF 20% 50V
C110 1-126-960-11 ELECT 1uF 20% 50V
C161 1-162-286-21 CERAMIC 220PF 10% 50V
C162 1-162-286-21 CERAMIC 220PF 10% 50V
C166 1-126-964-11 ELECT 10uF 20% 50V
C167 1-126-964-11 ELECT 10uF 20% 50V
C168 1-126-964-11 ELECT 10uF 20% 50V
C201 1-126-960-11 ELECT 1uF 20% 50V
C203 1-126-960-11 ELECT 1uF 20% 50V
C204 1-126-933-11 ELECT 100uF 20% 16V
C205 1-126-960-11 ELECT 1uF 20% 50V
C207 1-126-960-11 ELECT 1uF 20% 50V
C208 1-126-964-11 ELECT 10uF 20% 50V
C211 1-126-960-11 ELECT 1uF 20% 50V
C212 1-126-960-11 ELECT 1uF 20% 50V
C213 1-136-168-00 FILM 0.18uF 5% 50V
C214 1-136-168-00 FILM 0.18uF 5% 50V
C215 1-126-960-11 ELECT 1uF 20% 50V
C216 1-126-964-11 ELECT 10uF 20% 50V
C219 1-126-960-11 ELECT 1uF 20% 50V
C220 1-136-165-00 FILM 0.1uF 5% 50V
C221 1-126-960-11 ELECT 1uF 20% 50V
C222 1-126-960-11 ELECT 1uF 20% 50V
C223 1-136-168-00 FILM 0.18uF 5% 50V
C225 1-126-960-11 ELECT 1uF 20% 50V
C226 1-128-551-11 ELECT 22uF 20% 25V
C240 1-126-960-11 ELECT 1uF 20% 50V
C251 1-126-933-11 ELECT 100uF 20% 16V
C252 1-126-964-11 ELECT 10uF 20% 50V
C253 1-137-367-11 FILM 0.0033uF 5% 50V
C254 1-136-157-00 FILM 0.022uF 5% 50V
C256 1-126-960-11 ELECT 1uF 20% 50V
C257 1-126-960-11 ELECT 1uF 20% 50V
C258 1-126-964-11 ELECT 10uF 20% 50V
C259 1-137-367-11 FILM 0.0033uF 5% 50V
C260 1-136-157-00 FILM 0.022uF 5% 50V
C262 1-126-960-11 ELECT 1uF 20% 50V
C263 1-126-960-11 ELECT 1uF 20% 50V
C265 1-126-960-11 ELECT 1uF 20% 50V
C266 1-128-551-11 ELECT 22uF 20% 25V
C267 1-126-960-11 ELECT 1uF 20% 50V
C281 1-126-960-11 ELECT 1uF 20% 50V
C282 1-136-159-00 FILM 0.033uF 5% 50V
C283 1-136-159-00 FILM 0.033uF 5% 50V
C284 1-137-437-11 FILM 0.0056uF 5% 50V
C285 1-137-437-11 FILM 0.0056uF 5% 50V
C286 1-136-159-00 FILM 0.033uF 5% 50V
C287 1-136-159-00 FILM 0.033uF 5% 50V
C288 1-136-159-00 FILM 0.033uF 5% 50V
C289 1-136-159-00 FILM 0.033uF 5% 50V
C290 1-126-960-11 ELECT 1uF 20% 50V
C291 1-126-960-11 ELECT 1uF 20% 50V
C293 1-126-960-11 ELECT 1uF 20% 50V
C294 1-126-960-11 ELECT 1uF 20% 50V
C296 1-126-960-11 ELECT 1uF 20% 50V
C297 1-162-294-31 CERAMIC 0.001uF 10% 50V
C403 1-136-169-00 FILM 0.22uF 5% 50V
C404 1-136-169-00 FILM 0.22uF 5% 50V
C405 1-136-169-00 FILM 0.22uF 5% 50V
C406 1-136-169-00 FILM 0.22uF 5% 50V
C407 1-126-960-11 ELECT 1uF 20% 50V
C421 1-126-960-11 ELECT 1uF 20% 50V
C422 1-126-961-11 ELECT 2.2uF 20% 50V
C431 1-126-960-11 ELECT 1uF 20% 50V
C432 1-126-961-11 ELECT 2.2uF 20% 50V
C441 1-126-960-11 ELECT 1uF 20% 50V
C442 1-126-961-11 ELECT 2.2uF 20% 50V
C451 1-126-960-11 ELECT 1uF 20% 50V
C452 1-126-961-11 ELECT 2.2uF 20% 50V
C453 1-126-960-11 ELECT 1uF 20% 50V
C460 1-126-961-11 ELECT 2.2uF 20% 50V
C461 1-126-960-11 ELECT 1uF 20% 50V
C462 1-162-282-31 CERAMIC 100PF 10% 50V
C463 1-162-282-31 CERAMIC 100PF 10% 50V
C801 1-104-664-11 ELECT 47uF 20% 25V
C803 1-126-959-11 ELECT 0.47uF 20% 50V
C908 1-104-664-11 ELECT 47uF 20% 25V
C921 1-126-947-11 ELECT 47uF 20% 35V
C922 1-126-941-11 ELECT 470uF 20% 25V
C923 1-104-664-11 ELECT 47uF 20% 25V
C930 1-127-539-11 ELECT(SOLID) 1uF 20% 25V
< CONNECTOR >
*CN101 1-568-842-11 SOCKET, CONNECTOR 27P
CN104 1-778-241-11 CONNECTOR, BOARD TO BOARD 5P
*CN105 1-770-727-11 CONNECTOR, BOARD TO BOARD 8P
*CN201 1-770-747-11 CONNECTOR, BOARD TO BOARD 12P
CN801 1-564-980-11 PIN, CONNECTOR 4P (CONTROL S (HCD IN))
< DIODE >
D101 8-719-987-63 DIODE 1N4148M
D102 8-719-987-63 DIODE 1N4148M
D401 8-719-987-63 DIODE 1N4148M
D402 8-719-987-63 DIODE 1N4148M
D403 8-719-987-63 DIODE 1N4148M
D801 8-719-987-63 DIODE 1N4148M
D802 8-719-987-63 DIODE 1N4148M
D804 8-719-933-54 DIODE HZS9A2L
D805 8-719-987-63 DIODE 1N4148M
D806 8-719-987-63 DIODE 1N4148M
D807 8-719-987-63 DIODE 1N4148M
D808 8-719-987-63 DIODE 1N4148M
< IC >
IC103 8-759-634-51 IC M5218AP
IC201 8-759-443-67 IC LC75373ED
IC251 8-759-443-67 IC LC75373ED
IC401 8-759-634-51 IC M5218AP
IC402 8-759-634-51 IC M5218AP
IC403 8-759-634-51 IC M5218AP
IC901 8-759-701-59 IC NJM78M09FA
IC903 8-759-605-01 IC M5F78M18L

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 30 —
MAIN INPUT
The components identified by
mark !or dotted line with mark
!are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque !sont critiques
pour la sécurité.
Ne les remplacer que par une
pièceportantlenumérospécifié.
< JACK >
J101 1-766-851-11 JACK, PIN 4P (1 (L IN,L OUT,R IN,R OUT))
J102 1-766-851-11 JACK, PIN 4P (2 (L IN,L OUT,R IN,R OUT))
J103 1-774-136-11 CONNECTOR, ROUND TYPE 6P
(WIRELESS REAR SPEAKER (TRANSMITTER))
J801 1-566-819-41 JACK 1P (CONTROL S (TV IN) (US,Canadian)
< TRANSISTOR >
Q401 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q421 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q422 8-729-900-63 TRANSISTOR DTA124ES
Q431 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q441 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q442 8-729-900-63 TRANSISTOR DTA124ES
Q451 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q452 8-729-900-63 TRANSISTOR DTA124ES
Q461 8-729-141-30 TRANSISTOR 2SC3623A-LK
Q462 8-729-900-63 TRANSISTOR DTA124ES
Q803 8-729-111-29 TRANSISTOR 2SD1616A-K
Q804 8-729-116-57 TRANSISTOR 2SB1068-K
< RESISTOR >
R101 1-249-417-11 CARBON 1K 5% 1/4W F
R102 1-249-417-11 CARBON 1K 5% 1/4W F
R103 1-249-437-11 CARBON 47K 5% 1/4W
R104 1-249-437-11 CARBON 47K 5% 1/4W
R117 1-249-415-11 CARBON 680 5% 1/4W F
R118 1-249-441-11 CARBON 100K 5% 1/4W
R119 1-249-415-11 CARBON 680 5% 1/4W F
R120 1-249-441-11 CARBON 100K 5% 1/4W
R121 1-249-441-11 CARBON 100K 5% 1/4W
R122 1-249-417-11 CARBON 1K 5% 1/4W F
R123 1-249-441-11 CARBON 100K 5% 1/4W
R124 1-249-417-11 CARBON 1K 5% 1/4W F
R125 1-249-441-11 CARBON 100K 5% 1/4W
R126 1-247-815-91 CARBON 220 5% 1/4W
R127 1-247-815-91 CARBON 220 5% 1/4W
R151 1-249-417-11 CARBON 1K 5% 1/4W F
R152 1-249-417-11 CARBON 1K 5% 1/4W F
R153 1-249-437-11 CARBON 47K 5% 1/4W
R154 1-249-437-11 CARBON 47K 5% 1/4W
R201 1-247-843-11 CARBON 3.3K 5% 1/4W
R202 1-249-430-11 CARBON 12K 5% 1/4W
R203 1-249-430-11 CARBON 12K 5% 1/4W
R205 1-249-425-11 CARBON 4.7K 5% 1/4W F
R231 1-249-439-11 CARBON 68K 5% 1/4W
R232 1-249-441-11 CARBON 100K 5% 1/4W
R233 1-249-441-11 CARBON 100K 5% 1/4W
R281 1-249-435-11 CARBON 33K 5% 1/4W
R282 1-249-439-11 CARBON 68K 5% 1/4W
R283 1-249-429-11 CARBON 10K 5% 1/4W
R284 1-247-852-11 CARBON 7.5K 5% 1/4W
R285 1-249-436-11 CARBON 39K 5% 1/4W
R286 1-247-876-11 CARBON 75K 5% 1/4W
R287 1-249-439-11 CARBON 68K 5% 1/4W
R288 1-249-435-11 CARBON 33K 5% 1/4W
R289 1-249-417-11 CARBON 1K 5% 1/4W F
R290 1-249-417-11 CARBON 1K 5% 1/4W F
R291 1-247-863-91 CARBON 22K 5% 1/4W
R292 1-247-863-91 CARBON 22K 5% 1/4W
R293 1-247-889-00 CARBON 270K 5% 1/4W
R294 1-247-889-00 CARBON 270K 5% 1/4W
R295 1-247-889-00 CARBON 270K 5% 1/4W
!R297 1-249-474-11 CARBON 1 5% 1/2W F
R403 1-249-417-11 CARBON 1K 5% 1/4W F
R404 1-249-418-11 CARBON 1.2K 5% 1/4W F
R405 1-249-418-11 CARBON 1.2K 5% 1/4W F
R406 1-249-417-11 CARBON 1K 5% 1/4W F
R407 1-249-441-11 CARBON 100K 5% 1/4W
R408 1-249-401-11 CARBON 47 5% 1/4W F
R409 1-249-429-11 CARBON 10K 5% 1/4W
R410 1-249-431-11 CARBON 15K 5% 1/4W
R411 1-249-435-11 CARBON 33K 5% 1/4W
R412 1-249-421-11 CARBON 2.2K 5% 1/4W F
R413 1-247-876-11 CARBON 75K 5% 1/4W
R414 1-249-429-11 CARBON 10K 5% 1/4W
R415 1-249-429-11 CARBON 10K 5% 1/4W
R421 1-249-441-11 CARBON 100K 5% 1/4W
R422 1-249-417-11 CARBON 1K 5% 1/4W F
R423 1-249-429-11 CARBON 10K 5% 1/4W
R424 1-247-863-91 CARBON 22K 5% 1/4W
R425 1-249-437-11 CARBON 47K 5% 1/4W
R431 1-249-441-11 CARBON 100K 5% 1/4W
R432 1-249-417-11 CARBON 1K 5% 1/4W F
R433 1-249-429-11 CARBON 10K 5% 1/4W
R441 1-249-441-11 CARBON 100K 5% 1/4W
R442 1-249-417-11 CARBON 1K 5% 1/4W F
R443 1-249-429-11 CARBON 10K 5% 1/4W
R444 1-247-863-91 CARBON 22K 5% 1/4W
R445 1-249-437-11 CARBON 47K 5% 1/4W
R451 1-249-441-11 CARBON 100K 5% 1/4W
R452 1-249-417-11 CARBON 1K 5% 1/4W F
R453 1-249-429-11 CARBON 10K 5% 1/4W
R454 1-247-863-91 CARBON 22K 5% 1/4W
R455 1-249-437-11 CARBON 47K 5% 1/4W
R461 1-249-441-11 CARBON 100K 5% 1/4W
R462 1-249-417-11 CARBON 1K 5% 1/4W F
R463 1-249-429-11 CARBON 10K 5% 1/4W
R464 1-247-863-91 CARBON 22K 5% 1/4W
R465 1-249-437-11 CARBON 47K 5% 1/4W
R801 1-249-429-11 CARBON 10K 5% 1/4W
R803 1-249-393-11 CARBON 10 5% 1/4W F
R809 1-247-807-31 CARBON 100 5% 1/4W
R810 1-249-393-11 CARBON 10 5% 1/4W F
R811 1-249-437-11 CARBON 47K 5% 1/4W
R812 1-249-437-11 CARBON 47K 5% 1/4W
R813 1-249-441-11 CARBON 100K 5% 1/4W
R814 1-249-425-11 CARBON 4.7K 5% 1/4W F
R815 1-249-429-11 CARBON 10K 5% 1/4W
R816 1-249-417-11 CARBON 1K 5% 1/4W F
< SWITCH >
S801 1-571-588-11 SWITCH, SLIDE (VOLUME SYNCHRO(ON,OFF))
*************************************************************

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 31 —
POWER PSPOW-SWPOW-SRPOW-CN POW-L POW-R
*A-4403-112-A POWER BOARD, COMPLETE
***********************
POW-CN BOARD
**************
POW-L BOARD
************
POW-R BOARD
************
POW-SR BOARD
**************
POW-SW BOARD
**************
< CAPACITOR >
C601 1-162-294-31 CERAMIC 0.001uF 10% 50V
C602 1-162-282-31 CERAMIC 100PF 10% 50V
C603 1-104-664-11 ELECT 47uF 20% 25V
C604 1-162-191-31 CERAMIC 2.2PF 10% 50V
C605 1-162-294-31 CERAMIC 0.001uF 10% 50V
C606 1-162-282-31 CERAMIC 100PF 10% 50V
C607 1-104-664-11 ELECT 47uF 20% 25V
C608 1-162-191-31 CERAMIC 2.2PF 10% 50V
C609 1-162-294-31 CERAMIC 0.001uF 10% 50V
C610 1-162-282-31 CERAMIC 100PF 10% 50V
C611 1-104-664-11 ELECT 47uF 20% 25V
C612 1-162-191-31 CERAMIC 2.2PF 10% 50V
C613 1-162-294-31 CERAMIC 0.001uF 10% 50V
C614 1-162-282-31 CERAMIC 100PF 10% 50V
C615 1-104-664-11 ELECT 47uF 20% 25V
C616 1-162-191-31 CERAMIC 2.2PF 10% 50V
C617 1-162-294-31 CERAMIC 0.001uF 10% 50V
C618 1-162-282-31 CERAMIC 100PF 10% 50V
C619 1-104-664-11 ELECT 47uF 20% 25V
C620 1-162-191-31 CERAMIC 2.2PF 10% 50V
C621 1-117-910-91 ELECT 10uF 20% 50V
C622 1-117-910-91 ELECT 10uF 20% 50V
C623 1-117-910-91 ELECT 10uF 20% 50V
C624 1-117-910-91 ELECT 10uF 20% 50V
C625 1-136-157-00 FILM 0.022uF 5% 50V
C626 1-136-157-00 FILM 0.022uF 5% 50V
C627 1-136-157-00 FILM 0.022uF 5% 50V
C628 1-136-157-00 FILM 0.022uF 5% 50V
C629 1-136-157-00 FILM 0.022uF 5% 50V
C631 1-126-960-11 ELECT 1uF 20% 50V
C632 1-126-960-11 ELECT 1uF 20% 50V
C633 1-126-960-11 ELECT 1uF 20% 50V
C634 1-126-960-11 ELECT 1uF 20% 50V
C635 1-126-960-11 ELECT 1uF 20% 50V
< CONNECTOR >
*CN153 1-564-522-11 PLUG, CONNECTOR 7P
*CN601 1-564-214-11 PIN, CONNECTOR (B3PS-VH) 3P
CN605 1-564-524-11 PLUG, CONNECTOR 9P
< DIODE >
D701 8-719-987-63 DIODE 1N4148M
< IC >
IC601 8-759-502-31 IC SI-18751
IC602 8-759-502-31 IC SI-18751
IC603 8-759-502-31 IC SI-18751
IC604 8-759-502-31 IC SI-18751
IC605 8-759-502-31 IC SI-18751
< RESISTOR >
R601 1-249-431-11 CARBON 15K 5% 1/4W
R602 1-249-414-11 CARBON 560 5% 1/4W F
R603 1-249-431-11 CARBON 15K 5% 1/4W
R604 1-249-431-11 CARBON 15K 5% 1/4W
R605 1-249-414-11 CARBON 560 5% 1/4W F
R606 1-249-431-11 CARBON 15K 5% 1/4W
R607 1-249-431-11 CARBON 15K 5% 1/4W
R608 1-247-815-91 CARBON 220 5% 1/4W
R609 1-249-431-11 CARBON 15K 5% 1/4W
R610 1-249-431-11 CARBON 15K 5% 1/4W
R611 1-249-407-11 CARBON 150 5% 1/4W F
R612 1-249-431-11 CARBON 15K 5% 1/4W
R613 1-249-431-11 CARBON 15K 5% 1/4W
R614 1-249-406-11 CARBON 120 5% 1/4W F
R615 1-249-431-11 CARBON 15K 5% 1/4W
R616 1-249-385-11 CARBON 2.2 5% 1/6W F
R617 1-249-385-11 CARBON 2.2 5% 1/6W F
R618 1-249-385-11 CARBON 2.2 5% 1/6W F
R619 1-249-385-11 CARBON 2.2 5% 1/6W F
R620 1-249-385-11 CARBON 2.2 5% 1/6W F
R701 1-249-441-11 CARBON 100K 5% 1/4W
R702 1-249-441-11 CARBON 100K 5% 1/4W
R703 1-249-441-11 CARBON 100K 5% 1/4W
R704 1-249-441-11 CARBON 100K 5% 1/4W
R705 1-249-441-11 CARBON 100K 5% 1/4W
R712 1-249-411-11 CARBON 330 5% 1/4W
R713 1-249-411-11 CARBON 330 5% 1/4W
R714 1-249-411-11 CARBON 330 5% 1/4W
< RELAY >
RY701 1-755-142-11 RELAY
RY702 1-755-142-11 RELAY
RY703 1-755-142-11 RELAY
************************************************************
*A-4403-106-A PS BOARD, COMPLETE
*******************
7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
< CAPACITOR >
C703 1-126-933-11 ELECT 100uF 20% 16V
C704 1-126-963-11 ELECT 4.7uF 20% 50V
C705 1-104-664-11 ELECT 47uF 20% 25V
C901 1-136-165-00 FILM 0.1uF 5% 50V
C902 1-136-165-00 FILM 0.1uF 5% 50V
C903 1-117-691-11 ELECT 8200uF 20% 50V
C904 1-117-691-11 ELECT 8200uF 20% 50V
C905 1-136-165-00 FILM 0.1uF 5% 50V
C907 1-126-944-11 ELECT 3300uF 20% 25V
C909 1-126-964-11 ELECT 10uF 20% 50V
C910 1-126-925-11 ELECT 470uF 20% 10V
C911 1-126-951-11 ELECT 470uF 20% 35V
C912 1-126-967-11 ELECT 47uF 20% 50V
C913 1-126-964-11 ELECT 10uF 20% 50V
C914 1-126-967-11 ELECT 47uF 20% 50V
C920 1-126-968-11 ELECT 100uF 20% 50V
C924 1-126-964-11 ELECT 10uF 20% 50V
C925 1-104-664-11 ELECT 47uF 20% 25V

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 32 —
PS T1 T2
The components identified by
mark !or dotted line with mark
!are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque !sont critiques
pour la sécurité.
Ne les remplacer que par une
pièceportantlenumérospécifié.
< CONNECTOR >
CN154 1-778-240-11 CONNECTOR, BOARD TO BOARD 5P
*CN155 1-770-723-11 CONNECTOR, BOARD TO BOARD 8P
*CN701 1-564-243-11 PIN, CONNECTOR 6P
< DIODE >
D901 8-719-062-39 DIODE D4SBL20UF1
D902 8-719-200-82 DIODE 11ES2
D903 8-719-200-82 DIODE 11ES2
D904 8-719-200-82 DIODE 11ES2
D905 8-719-200-82 DIODE 11ES2
D907 8-719-200-82 DIODE 11ES2
D908 8-719-200-82 DIODE 11ES2
D909 8-719-002-43 DIODE UZL-27L-TA
D910 8-719-014-66 DIODE UZP-5.6B
D911 8-719-987-63 DIODE 1N4148M
D912 8-719-987-63 DIODE 1N4148M
D913 8-719-200-82 DIODE 11ES2
D914 8-719-933-41 DIODE HZS6C3L
D915 8-719-987-63 DIODE 1N4148M
< IC >
IC701 8-759-111-68 IC uPC1237HA
IC904 8-759-158-62 IC TA78057S
< JACK >
J701 1-537-952-11 TERMINAL BOARD,PUSH(ANTENNA)2P
(EXTERNAL CENTER SPEAKER(+,–))
J702 1-537-925-41 TERMINAL BOARD
(REAR SPEAKER(L+,L–,R+,R–)
< TRANSISTOR >
Q902 8-729-116-57 TRANSISTOR 2SB1068-K
Q903 8-729-119-76 TRANSISTOR 2SA1175-HFE
Q904 8-729-119-76 TRANSISTOR 2SA1175-HFE
< RESISTOR >
R710 1-249-435-11 CARBON 33K 5% 1/4W
R711 1-249-427-11 CARBON 6.8K 5% 1/4W F
R906 1-247-843-11 CARBON 3.3K 5% 1/4W
R907 1-249-437-11 CARBON 47K 5% 1/4W
R908 1-247-807-31 CARBON 100 5% 1/4W
R909 1-247-807-31 CARBON 100 5% 1/4W
R910 1-249-431-11 CARBON 15K 5% 1/4W
!R912 1-215-865-11 METAL 220 5% 1W F
R913 1-249-429-11 CARBON 10K 5% 1/4W
R914 1-249-429-11 CARBON 10K 5% 1/4W
R915 1-247-843-11 CARBON 3.3K 5% 1/4W
R926 1-249-431-11 CARBON 15K 5% 1/4W
< RELAY >
RY901 1-515-840-11 RELAY
< SWITCH >
S701 1-762-405-11 SWITCH, PUSH
(CENTER SPEAKER(INTERNAL,EXTERNAL))
< CORD >
SDN701 1-782-492-11 CORD (WITH CONNECTOR)
************************************************************
*1-666-219-11 T1 BOARD
********
1-533-217-31 HOLDER, FUSE
< CONNECTOR >
CN901 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P
!F901 1-576-108-11 FUSE 4A 125V (US, Canadian)
!F901 1-532-503-51 TIME LAG FUSE T1.6AL
(AEP, UK, AUS, CH, G, MY, SP)
************************************************************
*1-666-220-11 T2 BOARD
********
< CONNECTOR >
CN904 1-564-511-11 PLUG, CONNECTOR 8P
< FUSE >
!F902 1-576-110-11 FUSE 6A 125V (US, Canadian)
!F902 1-532-504-51 FUSE 4A TIME LAG
(AEP, UK, AUS, CH, G, MY, SP)
!F903 1-576-110-11 FUSE 6A 125V (US, Canadian)
!F903 1-532-504-51 FUSE 4A TIME LAG
(AEP, UK, AUS, CH, G, MY, SP)
< RESISTOR >
!R901 1-212-950-00 FUSIBLE 4.7 5% 1/2W F
!R902 1-212-934-00 FUSIBLE 1 5% 1/2W F
************************************************************
MISCELLANEOUS
**************
4 1-505-681-11 SPEAKER (5cm)
6 1-505-680-11 SPEAKER (10cm)
17 1-505-679-11 SPEAKER (13cm)
54 1-505-681-11 SPEAKER (5cm)
55 1-505-680-11 SPEAKER (10cm)
62 1-505-679-11 SPEAKER (13cm)
105 1-773-274-11 WIRE (FLAT TYPE) (27 CORE)
!110 1-782-510-11 CORD, POWER (CH)
!110 1-575-042-21 CORD, POWER (US, Canadian)
!110 1-575-651-21 CORD, POWER (AEP, G, MY, SP)
!110 1-696-845-11 CORD, POWER (AUS)
!110 1-751-529-11 CORD, POWER (UK)
!110 1-782-510-11 CORD, POWER (CH)
152 1-505-682-11 SPEAKER (8cm)
!T901 1-431-428-11 TRANSFORMER, POWER (US, Canadian)
!T901 1-431-433-11 TRANSFORMER, POWER
(AEP, UK, AUS, CH, G, MY, SP)
************************************************************

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
— 33 —
ACCESSORIES & PACKING MATERIALS
*******************************
1-475-042-11 ADAPTOR (21PIN D.SUB) (AEP, UK, G)
1-475-248-11 REMOTE COMMANDER (RM-J27)
1-558-787-81 CORD, CONNECTION (AUDIO 150cm)
1-751-347-11 CORD, CONNECTION (For REAR SPEAKER 10m)
1-775-531-11 CORD, CONNECTION
(For FRONT L-R CONNECTION 3.5m)
3-860-339-11 MANUAL, INSTRUCTION (ENGLISH)
3-860-339-21 MANUAL, INSTRUCTION (FRENCH, SPANISH)
(CND, AEP, SP)
3-860-339-31 MANUAL, INSTRUCTION (PORTUGUESE,
GERMAN, DUTCH, SWEDISH, ITALIAN)(AEP, G)
3-860-339-41 MANUAL, INSTRUCTION (CHINESE)
(CH, MY, SP)
4-981-643-01 COVER, BATTERY (For RM-J27)
4-914-430-11 SCREW (4X20), TAPPING
4-991-888-01 BASE
************************************************************
**************
HARDWARE LIST
**************
#1 7-685-659-79 SCREW +BVTP 4.8
#2 7-685-134-19 SCREW +P 2.6X8
#3 7-685-646-79 SCREW +BVTP 3X8
#4 7-685-881-09 SCREW +BVTT 4X8 (S)
#5 7-621-846-60 SCREW, WOOD 4.1X25

SAVA-27
— 34 —
Sony Corporation
Home A&V Products Company 97G1695-1
Printed in Japan © 1997.7
Published by General Engineering Dept.
(Shibaura)
9-920-927-11