Sony VAIO PCG-V505DC2 Series User manual

Confidential
SERVICE MANUAL
PCG-V505DC2/V505DC2K/V505DC2P
Notebook Computer
9-876-357-01
Ver. 1-2003J
Revision History
For American Area
US Model
Canadian Model
Lineup: PCG-V505DC2*
PCG-V505DC2K*
PCG-V505DC2P*
*: CTO model
•Design and specifications are subject to
change without notice.
S400

– 2 – PCG-V505DC2/V505DC2K/V505DC2P (AM)
Confidential
Service and Inspection Precautions
1. Obey precautionary markings and instructions
Labels and stamps on the cabinet, chassis, and components identify areas
requiring special precautions. Be sure to observe these precautions, as
well as all precautions listed in the operating manual and other associated
documents.
2. Use designated parts only
The set’s components possess important safety characteristics, such as
noncombustibility and the ability to tolerate large voltages. Be sure that
replacement parts possess the same safety characteristics as the originals.
Also remember that the 0mark, which appears in circuit diagrams and
parts lists, denotes components that have particularly important safety
functions; be extra sure to use only the designated components.
3. Always follow the original design when
mounting parts and routing wires
The original layout includes various safety features, such as inclusion of
insulating materials (tubes and tape) and the mounting of parts above the
printer board. In addition, internal wiring has been routed and clamped so
as to keep it away from hot or high-voltage parts. When mounting parts or
routing wires, therefore, be sure to duplicate the original layout.
4. Inspect after completing service
After servicing, inspect to make sure that all screws, components, and wiring
have been returned to their original condition. Also check the area around
the repair location to ensure that repair work has caused no damage, and
confirm safety.
5. When replacing chip components...
Never reuse components. Also remember that the negative side of tantalum
capacitors is easily damaged by heat.
6. When handling flexible print boards...
•The temperature of the soldering-iron tip should be about 270°C.
•Do not apply the tip more than three times to the same pattern.
•Handle patterns with care; never apply force.
Caution: Remember that hard disk drives are easily damaged by
vibration. Always handle with care.
Caution Markings for Lithium/Ion Battery -The following or similar
texts shall be provided on battery pack of equipment or in both the
operating and the service instructions.
CAUTION: Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type recommended by
the manufacturer. Discard used batteries according to the
manufacturer’s instructions.
CAUTION: The battery pack used in this device may present a fire
or chemical burn hazard if mistreated. Do not disassemble, heat
above 100°C (212°F) or incinerate.
Dispose of used battery promptly.
Keep away from children.
CAUTION: Changing the back up battery.
•Overcharging, short circuiting, reverse charging, multilation
or incineration of the cells must bi avoided to prevent one or
more of the following occurrences; release of toxic materials,
release of hydrogen and/or oxygen gas, rise in surface
temperature.
•If a cell has leaked or vented, it should be replaced
immediately while avoiding to touch it without any protection.
Information in this document is subject to change without notice.
Sony, VAIO and CLIE are trademarks or registered trademarks of
Sony. Microsoft, Windows, Windows Media, Outlook, Bookshelf
and other Microsoft products are trademarks or registered trademarks
of Microsoft Corporation in the United States and other countries.
The word Bluetooth and the Bluetooth logo are trademarks of
Bluetooth SIG, Inc.AMD, theAMD logo, otherAMD product names
and combinations thereof are trademarks of Advanced Micro
Devices, Inc. Intel Inside logo, Pentium and Celeron are trademarks
or registered trademarks of Intel Corporation.Transmeta, the
Transmeta logo, Crusoe Processor, the Crusoe logo and
combinations thereof are trademarks of Transmeta Corporation in
the USA and other countries. Graffiti, HotSync, PalmModem, and
Palm OS are resistered trademarks, and the Hotsync logo and Palm
are trademarks of Palm, Inc. or its subsidiaries. (M) and Motrola
are trademarks of Motrora, Inc. Other Motrola products and services
with (R) mark like Dragomball are the trademarks of Motrola, Inc.
All other names of systems, products and services in this manual
are trademarks or registered trademarks of their respective owners.
In this manual, the (TM) or (R) mark are not specified.

– 3 – PCG-V505DC2/V505DC2K/V505DC2P (AM)
Confidential
TABLE OF CONTENTS
Section Title Page
CHAPTER 1. BLOCK DIAGRAM ............................... 1-1
(to 1-2)
CHAPTER 2. FRAME HARNESS DIAGRAM ........ 2-1
(to 2-2)
CHAPTER 3. EXPLODED VIEWS AND
PARTS LIST
3-1. Main Section .................................................................... 3-2
3-2. LCD Section .................................................................... 3-6
3-3. Accessories ...................................................................... 3-8
(to 3-8)
CHAPTER 4. OTHERS
4-1. Replacing the CPU .......................................................... 4-1
4-2. CTO Information ............................................................. 4-3
(to 4-4)
History of the changes is shown as the “Revision
History” at the end of this data.

PCG-V505DC2/V505DC2K/V505DC2P (AM)
Confidential
1-1 1-2
CHAPTER 1.
BLOCK DIAGRAM
(END)
Microphone
DVI
PCCard
(type?x 1) i.LINK
RJ-45
RJ-11
ICH
ICH3-m
CPU
P4m
Graphics
ATI M6
Audio
CODEC
MDC
HDD Opt.
Drive
SO-DIMM SO-DIMM
LCD
12 XGA
MS
ATF0
LM86
Thermal
Sensor
LM26
Thermal
Sensor
LM26
ATF1
LM75
EEPROM
(MAC address)
EEPROM
(password)
Battery
PSB
(400MHz)
HUB Link
(66MHz)
DDR
(266MHz)
AGP x 4
(264MHz)
VIF-24
IFX-247
CNX-201 CNX-206
PCI
(33MHz)
Headphone
Internal KeyBoard
TouchPad
LVDS
LPC
(33MHz)
VGA
VGA
MCH
Brookdale
Clock
Gen.
DCJack
(16V)
MBX-93
EEPROM
(GUID)
AC Link
IDE
(Ultra ATA100)
Ether
Kinnereth
RJ-45
DCJack

(16V)
USB-
Parallel
USB
(left)
USB
(right)
Memory
Stick
(SUMIRE2)
CNX-197
FWH
KBC
Debug
CNX-192
i.LINK
&
PC Card
W-LAN
(typeIIIsocket)
USB2.0
hub
DC/DC
USB
USB
Paralle

l

USB
port1
port0
port4
port3
port2
(typeIIIsocket)
TMDS
USB
HC

PCG-V505DC2/V505DC2K/V505DC2P (AM)
Confidential
2-1 2-2
(END)
CHAPTER 2.
FRAME HARNESS DIAGRAM
M
1A
LCD
HARNESS
Y
MBX-93 BOARD
SIDE A
CPU
12
SPEAKER
R ch
12
29 30
LCD
CN721
21
CN3901
INVERTER UNIT
VIF-24 BOARD
SIDE A
CN5000
CN2600 120
2
1
20
19
CN3450 2
1
20
19
CN3401
PWS-24 BOARD
SIDE A
12
49 50
CN1202
CNX-198
BOARD
(COMBO DRIVE)
21
30 29 MODEM
CARD
1
10
CN2860
10 1
SWX-134
BOARD
SIDE A
112
112 CN5800
CN5801
CN5802
1
10
CN5300
110
SWX-130
BOARD
SIDE B
FLEXIBLE FLAT CABLE (LEX43)
LEX-43 BOARD
SIDE B
RIGHT BUTTON
S5802 CENTER BUTTON S5508 LEFT BUTTON
S5801
TOUCH PAD
1
12 CN2830
FFC (TP)
12
49 50
CN1201
HDD ASSY
FLEXIBLE PRINT PWB (HDD)
114
14
1
CN2660
CN5101
FPC (I.LINK&USB)
CN1401
12
79 80
PC CARD
CONNECTOR
PC CARD
1
211 12
CNX-197
BOARD
SIDE A
HEADPHONE
MIC IN
CN5120
i.LINK
CN5130
USB
CN5201
MONITOR
12
39 40
CN5200
CN5100
1
2
11
12
CN5251
CNX-192 BOARD
SIDE A
NICKEL
HYDROGEN
BATTERY
12
CN3902
21 CN101
DC FAN
(WITH HEATSINK)
12
910
CN2900
18
CN4051
LITHIUM ION
BATTERY PACK
Side L
10 9
21
CN2680
CN4602
110
IFX-247
BOARD
SIDE A
1
10
CN4601 MEMORY
STICK
MODULAR
JACK
NETWORK
DOCKING STATION
PCGA-PRV1
2
CN5001
1
100
99
Side R
CN2800
124
KEY BOARD
110
1
2
SPEAKER
L ch
LEX-44 BOARD
SIDE B
DC IN
CN5401
CN5400
FFC (LEX44)
FFC (CNX197)
CN2650
12
39 40
WIRELESS
LAN CARD
FFC (SWX130)
FFC (SWX129)
CN2001
FFC (IFX247)
HARNESS (RJ11)
CN2850
200181
120
200181
HARNESS (WITH DC JACK 2P)
RJ-45 HARNESS
CN5700
From board to connector (direct connection)
Harness (with connectors on both ends)
Harness (soldering on either end)

3-1 PCG-V505DC2/V505DC2K/V505DC2P (AM)
Confidential
CHAPTER 3.
EXPLODED VIEWS AND PARTS LIST
NOTE:
•Itemsmarked“*”arenot stocked since theyare seldom
required for routine service. Some delay should be
anticipated when ordering these items.
•The mechanical parts with no reference number in the
exploded views are not supplied.
•When twoor morepartsareshown,usethepartdescribed
first as the main part.
•Thepartsmarked“ $”arethe HighValue Modules(HVM).
•The parts marked “ # ”are the parts on which
barcode label is attached.
For the barcode label, refer to CHAPTER 4.
•The parts marked “ & ”are the “Customer Replacable
Parts (CRP)”that can be replaced by Field Customer
Support.
Especiallythe parts withthe<&> mark requirethe special
attention to use them.Here fore, check first whether the
desiredpart is oneofthe targetted parts of the Customer
Replaceable Parts(CRP), or the non-targetted parts by
referring to the exploded view.
The components identified by mark 0or
dotted line with mark 0are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
0sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.

PCG-V505DC2/V505DC2K/V505DC2P (AM)
Confidential
3-2 3-3
3-1. Main Section
*When change the CPU (ref. 48), refer to “Replacing the CPU”
in CHAPTER 4.
Ref.No. Part No. DescriptionRef.No. Part No. Description
1A-8068-225-A $ COMPLETE PWB SWX-130 (BA2) (S)
21-824-996-71 CABLE, FLEXIBLE FLAT (TP)
31-824-996-52 CABLE, FLEXIBLE FLAT (SWX130)
4X-4626-275-1 HOLDER (TP) (C) ASSY
*5 4-670-552-02 PLATE (TP)
61-796-623-14 TOUCH PAD
71-824-996-22 CABLE, FLEXIBLE FLAT (LEX43)
8A-8068-223-A $ COMPLETE PWB LEX-43 (BA2) (S)
91-962-179-12 HARNESS (WITH DC JACK 2P)
*10 4-670-547-01 BRACKET (KENSINGTON)
11 1-824-996-32 CABLE, FLEXIBLE FLAT (LEX44)
12 A-8068-224-A $ COMPLETE PWB LEX-44 (BA2) (S)
13 1-477-748-11 LOUD SPEAKER (2.0CM, WITH BOX)
14 X-4625-593-7 PALMREST (F1) ASSY
15 A-8068-219-A $ COMPLETE PWB IFX-247 (BA2) (S)
16 1-824-996-11 CABLE, FLEXIBLE FLAT (IFX247)
17 1-477-752-22 KEY BOARD UNIT (US)
*18 4-670-521-02 BRACKET (BOTTOM L)
*19 4-670-517-03 BRACKET (PC CARD)
20 1-817-276-14 CONNECTOR, PC CARD
21 1-824-996-61 CABLE, FLEXIBLE FLAT (CNX197)
22 1-687-953-11 FPC (I.LINK & USB)
23 A-8068-221-A $ COMPLETE PWB CNX-197 (BA2) (S)
24 1-694-760-21 JACK, SMALL TYPE (HEADPHONE)
25 1-694-760-41 JACK, SMALL TYPE (MICROPHONE)
26 1-794-548-21 CONNECTOR, USB (A)
27 4-678-049-02 ESCUTCHEON (SIDE L) (UL)
28 X-4625-584-4 DOOR (VGA) ASSY
29 X-4625-583-4 HOUSING (BOTTOM) (F1) ASSY
30 1-824-996-41 CABLE, FLEXIBLE FLAT (SWX129)
31 A-8068-218-A $ COMPLETE PWB SWX-134 (BA2) (S)
32 X-4626-274-1 (W-LAN)...ESCUTCHEON (F) (W-LAN)
(UL) ASSY
32 X-4626-273-1 (No W-LAN)...ESCUTCHEON (F)
(W-LESS) (UL) ASSY
*33 4-670-511-01 BRACKET (HDD) (R)
34 A-8116-402-A $# ASSY HDD 60GB (I, 40) (S)
34 A-8116-404-A $# ASSY HDD 40GB (I, 40) (S)
*35 4-670-510-01 BRACKET (HDD) (F)
36 1-687-015-11 PWB, FLEXIBLE PRINT (HDD)
37 4-671-027-01 SHEET (HDD) (B), INSULATING
38 4-670-526-04 COVER (BOTTOM)
39 4-635-946-41 & FOOT
40 4-670-523-02 DOOR DOCK
41 4-673-102-01 & FOOT (R)
42 4-670-519-03 ESCUTCHEON (SIDE R)
43 X-4625-585-3 DOOR (RJ) ASSY
44 1-962-036-11 HARNESS (RJ11)
45 1-962-095-11 HARNESS,RJ-45
*46 4-670-522-01 PLATE (OP) (T)
47 A-8068-220-A $ COMPLETE PWB CNX-192 (BA2) (S)
48 6-704-652-01 (C_2.0G)...
IC RH80532NC041256SL6VJ
48 6-704-614-01 (P4M_2.2G)...
IC RH80532GC049512SL6VB
48 6-704-615-01 (P4M_2.4G)...
IC RH80532GC056512SL6VC
*49 4-670-532-02 BRACKET (CPU)
*50 4-670-563-01 BRACKET (VGA)
51 1-756-038-21 BATTERY, NICKEL HYDROGEN
52 4-670-168-01 STAND OFF M2X6
53 4-655-326-01 OFF, STAND
*54 X-4625-591-2 BRACKET (MBX) ASSY
55 A-8068-226-A $# COMPLETE PWB VIF-24 (BA2) (S)
56 1-761-606-14 CARD, MODEM
57 4-671-515-01 FILM (MODEM)
58 A-8068-217-A $ COMPLETE PWB PWS-24 (BA2) (S)
59 A-8068-227-A $# COMPLETE PWB MBX-93 (S)
Ref.No. Part No. Description
60 4-670-524-01 BRACKET WIRE
61 1-763-974-14 FAN, D.C
62 4-668-785-01 THERMAL SHEET CPU
63 4-670-509-02 HEAT SINK UNIT
64 1-761-784-31 CARD, WIRELESS LAN
65 4-671-501-01 SHEET (PWS24), INSULATING
*66 4-670-534-02 BRACKET MBX FR
67 4-670-525-01 COVER (BATTERY LOCK)
68 4-671-188-01 SHEET (MBX), INSULATING
69 4-671-028-01 SHEET (HDD) (T), INSULATING
70 6-600-158-01 (256MB)...IC HYS64D32020GDL-7-B
70 A-8067-880-A (512MB)...COMPLETE PWB MM-10
71 4-671-184-01 SHEET (FAN), INSULATING
72 4-651-989-51 SPACER (MBX)
73 4-671-460-02 TAPE, ETHER CABLE
74 4-671-462-01 TAPE, ETHER CABLE 2 (9X34)
*75 4-670-503-02 BRACKET (OP) (F)
*76 4-670-504-02 BRACKET (OP) (R)
77 4-671-026-01 SHEET (OP), INSULATING
78 1-796-626-12 $# COMBO DRIVE (UJDA745, 9.5MM)
78 1-796-822-11 $# COMBO DRIVE (UJDA755, 9.5MM)
79 A-8068-222-A $ COMPLETE PWB CNX-198 (BA2) (S)
80 X-4625-590-2 BEZEL (OP) (M) ASSY
81 4-670-528-01 SHEET (MCH), THERMAL
82 4-670-796-02 STOPPER HINGE
83 4-670-529-01 SHEET (GFX), THERMAL
84 4-671-336-03 & COVER SEAL 6X4
85 4-671-463-02 TAPE, FPC CABLE (60X10)
86 4-671-506-01 GASKET (FAN)
87 4-662-881-02 CUSHION, KEY BOARD
88 4-670-846-01 CUSHION (PALM)
89 4-671-180-01 COVER (LENS KB)
*90 4-670-533-03 HEAT SINK (POWER)
91 4-672-928-01 CUSHION (LIGHT SHIELDING)
92 4-670-554-02 (No W-LAN)...COVER, LENS
92 4-670-554-12 (W-LAN)...COVER, LENS
93 1-400-255-11 FERRITE CORE
94 4-672-754-01 COVER CABLE (10X10)
95 4-673-025-01 COVER FERRITE CORE
96 4-673-009-02 SHADE CLOTH (A)
97 4-673-026-01 FILM (FAN)
98 1-793-365-21 CONNECTOR, USB (A)
99 4-673-302-01 ADHESIVE TAPE (RJ)
100 4-672-759-01 HOOK (COVER BOTTOM)
101 4-673-292-01 COPPER TAPE FAN
102 4-679-137-01 (V505DC2P)...ID LABEL (U-CTO)
102 4-679-137-11 (V505DC2)...ID LABEL (U-CTO)
102 4-679-137-21 (V505DC2K)...ID LABEL (U-CTO)
103 4-673-761-01 TAPE 7X18
105 4-673-762-01 CUSHION T4.5
106 4-673-758-01 SPACER T2 (DIM)
114 4-675-709-01 PLATE KB
115 4-678-050-01 COVER (L)
116 4-678-051-01 COVER (R)
117 4-678-052-02 COVER (C)
118 4-678-053-02 CUSHION (DC)
119 4-678-054-01 SHEET (VENT)
120 4-679-387-01 TAPE (5X35)
121 4-679-438-01 SHEET (M)
B1 4-672-834-21 SCREW, +B EG GRIP (M2X3.5)
B2 4-672-834-01 SCREW, +B EG GRIP (M2X2.5)
B3 4-672-834-31 <&> SCREW, +B EG GRIP (M2X5.0)
B4 4-672-840-01 SCREW, M2 TAPPING, FLAT HEAD
(M2X5.0)
B5 4-672-834-11 SCREW, +B EG GRIP (M2X3.0)
B6 4-672-836-01 SCREW, M2 SPECIAL HEAD, EG GRIP
(M2X3)
B7 4-635-966-01 SCREW (HEX)
B8 4-672-834-41 <&> SCREW, +B EG GRIP (M2X13)
B9 4-672-839-01 HEAD, M3 FLAT (M3X4)
B11 4-671-538-01 SCREW (M2X2), SPECIAL HEAD
B12 4-671-539-01 & M2 +P EG GRIP (M2X4)
B13 4-672-835-01 SCREW, M2.6 +B EG GRIP (M2.6X5)
B14 4-672-836-11 SCREW, M2 SPECIAL HEAD, EG GRIP
(M2X4)
B16 4-672-834-51 SCREW, +B EG GRIP (M2X4)

PCG-V505DC2/V505DC2K/V505DC2P (AM)
Confidential
3-4 3-5
14
92 89
102
13
53
72
72
99
54
81 70
53
49
95
B1
65
52
B1
B3
B1
B1
B1
B1
B3
B1
B1
B1
B4
B3
B3
B2
B14
B14
B3
B4
B2
B4
B1
B1
B6
B6
B7
B8
B1
55
73
74
68
61
47
50
71
83
83
59
98
45
B1
B1
56
57
44
74
1
2
2
0
5
9
6
wh
7
1
A
D
A
58
90
53
94
66
48
62
63
97
51
106
11
12
13
9
10
7
8
3
wg
4
qg
qj
qk
wa
wd
wf
qk
qh
qj
4
B
M
O
B
R
R
15 16
88
88
91
103
103
103
103
12
3
4
5
6
40
W-LAN model
W-LAN model
29 41
39
67 46
B5
B13
B3 B13
B1
B1
B1
B1
B1
B3
86
82
82
93
85
30 31
32
28
27
21
22
23
24 25 26
D
E
C
5
qd
qf
qh
ql
qg
qa
w;
qs
qa
qs
8
6
8
0
C
I
IP
E
20
F
F
18
19
9
G
J
K
L
H
60
43
64
87
M
N
87 87
87
87 101
J
O
K
L
N
B3
B16
B16
B3 B3
B3
B3
B3
B5
B5
B11
B11
78
76
80
75
P
qd
qf
B9
B9
33
34
35
37
36
38 100
69
96
P
17
Q
Q
P
ql
wa
wd
7
ws
ws
w;
105
87
wh
79
77
W-LAN model
Memory x 2 model
70
114
B8 39
B12
84
B8
B3
42
3
wg
G
H
117
115
116
120
119
118
121
*When change the CPU (ref. 48), refer to “Replacing the CPU”
in CHAPTER 4.

PCG-V505DC2/V505DC2K/V505DC2P (AM)
Confidential
3-6 3-7
3-2. LCD Section – Made byTO –
Ref.No. Part No. Description
201 4-670-474-01 & CUSHION (L)
202 4-670-476-01 & CUSHION (CENTER)
203 X-4625-579-4 HOUSING (BEZEL) ASSY
204 4-670-473-01 & CUSHION (U)
205 4-670-475-01 & CUSHION (LATCH)
*206 4-670-481-02 BRACKET (LCD L)
207 A-8118-175-A $# LCD UNIT (12.1 TFT XGA) (S)
*208 4-670-482-02 BRACKET (LCD R)
209 1-961-998-13 HARNESS, LCD ( * 2)
210 1-476-735-11 INVERTER UNIT ( * 2)
211 4-670-477-02 COVER (L), HINGE
212 4-670-483-01 TILT UNIT (L)
213 4-670-479-01 CAP (L), HINGE
214 4-670-484-02 TILT UNIT (R)
215 4-670-478-02 COVER (R), HINGE
216 4-670-480-03 CAP (R), HINGE
217 X-4625-580-3 LATCH ASSY
218 1-754-272-12 ANTENNA, FILM (FOR LEFT)
219 1-754-272-22 ANTENNA, FILM (FOR RIGHT)
220 A-8117-843-A HOUSING (DISPLAY) ASSY (BADGE)
(S)
221 4-673-031-01 COPPER TAPE (LCD)
222 4-670-485-01 CUSHION (ANT)
223 4-673-032-01 CUSHION (GAP)
225 4-673-088-01 TAPE, HARNESS (INV)
226 FILAMENT TAPE (W12X50) ( * 1)
227 FILAMENT TAPE (W12X30) ( * 1)
228 FILAMENT TAPE (W12X40) ( * 1)
230 4-662-881-02 CUSHION, KEY BOARD
B2 4-672-834-01 SCREW, +B EG GRIP (M2X2.5)
B14 4-672-836-11 SCREW, M2 SPECIAL HEAD, EG GRIP
(M2X4)
B15 4-671-538-11 <&> SCREW (M2X4), SPECIAL HEAD
*1 Use the FILAMENT TAPE.
*2 When you exchange Ref. 209 or Ref. 210, please exchange
both together.
204
B15
203
206
207
208
209 (*2)
221
210 (*2)
211
212 213
217
222
218
219
220
226 (*1)
226 (*1)
227 (*1)
228 (*1)
214
215
216
223
224
B2
B2
B
B
A
A
B15
B14
2
1
1
2
B15
B14
B15
B14
B15B14
225
W-LAN model
W-LAN model
3
4
3
4
230
201
202
B15
205

3-8 PCG-V505DC2/V505DC2K/V505DC2P (AM)
Confidential
(END)
3-3. Accessories
802
AC Adaptor
803
Battery Pack
801
Power Cord
The components identified by mark 0or
dotted line with mark 0are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
0sont critiques pour la sécurité. Ne les
remplacer que par une pièce portant le
numéro spécifié.
Ref.No. Part No. Description
ACCESSORIES
***********
0801 1-757-562-21 & CORD, POWER
0802 1-477-749-51 $ ADAPTOR, AC
803 A-8114-137-A $ BP2V (U) ASSY (S)
803 A-8114-139-A $ BP4V (U) ASSY (S)
4-679-216-01 & QUICK (START)
4-679-219-01 & SPECIFICATION SHEET

PCG-V505DC2/V505DC2K/V505DC2P (AM)
Confidential
4-1. Replacing the CPU
Note: We have two kinds of CPU for this set, and either of them is used.
Two kinds of CPU have differences in the lock position and the unlock position.
1. Socket configuration 1 2. Socket configuration 2
4-1 4-2
1. How to remove the CPU
2. How to install the CPU
(FOX)
lock position
unlock position
unlock position
lock position
1Rotate the lock with a flat-blade screwdriver toward 
 the unlock position shown in the figure.
2Remove up the CPU.
2
CPU
1Position the mark on the CPU to the mark on the CPU 
 socket and put in all pins to the holes on the CPU socket.
2Pressing two corners marked with in the figure, 
 rotate the lock with a flat-blade screwdriver toward 
 the lock position.
(FOX)
mark
mark
Note:Lock the CPU properly, or operation
 becomes unstable.
CPU socket
CPU socket
1
CPU
2
2
CHAPTER 4.
OTHERS
(MOLEX)
1
2
2
CPU
(MOLEX)
1
CPU
1. How to remove the CPU
lock position
unlock position
unlock position
lock position
1Rotate the lock with a flat-blade screwdriver toward 
 the unlock position shown in the figure.
2Remove up the CPU.
mark
CPU socket
CPU socket
2. How to install the CPU
1Position the mark on the CPU to the mark on the CPU 
 socket and put in all pins to the holes on the CPU socket.
2Pressing two corners marked with in the figure, 
 rotate the lock with a flat-blade screwdriver toward 
 the lock position.
mark
Note:Lock the CPU properly, or operation
 becomes unstable.

PCG-V505DC2/V505DC2K/V505DC2P (AM)
Confidential
4-2. CTO Information
4-3 4-4
(END)
Model name:PCG-V505DC2P (American Area)
Model number:PCG-681L(With W-LAN),682L(No W-LAN)
OS:Windows XP Pro
V
er.1.0
Mobile P4-2.4GHz-M Mobile P4-2.2GHz-M Mobile Celeron 2.0GHz
6-704-615-01 6-704-614-01 6-704-652-01
IC RH80532GC056512SL6VC IC RH80532GC049512SL6VB IC RH80532NC041256SL6VJ
60 GB 40 GB
A-8116-402-A A-8116-404-A
ASSY HDD 60GB (I,40)(S) ASSY HDD 40GB (I,40)(S)
12.1 XGA
A-8118-175-A
LCD UNIT (12.1 TFT XGA) (S)
1024 MB (512MBx2) 512 MB (512MBx1) 512 MB (256MBx2) 256 MB (256MBx1)
A-8067-880-A x2 A-8067-880-A x1 6-600-158-01 x2 6-600-158-01 x1
COMPLETE PWB MM-10 COMPLETE PWB MM-10 IC HYS64D32020GDL-7-B IC HYS64D32020GDL-7-B
9.5mm Combo (×8)
1-796-626-12 / 1-796-822-11
COMBO DRIVE (UJDA745, 9.5MM) / COMBO DRIVE (UJDA755, 9.5MM)
MiniPCI
1-761-784-31 None
CARD, WIRELESS LAN
BP4V BP2V
A-8114-139-A A-8114-137-A
BP4V (U) ASSY (S) BP2V (U) ASSY (S)
Office XP Pro Office XP SBE None
V505DC2P
4-679-137-01
ID LABEL (UCTO)
ESCUCHEON (F) (W-LAN) (UL) ASSY ESCUCHEON (F) (W-LESS) (UL) ASSY
-
L
X-4626-274-1 X-4626-273-1
(W-LAN)...ESUCUTCHEON (F) (W-LAN) (UL) ASSY (No W-LAN)...ESUCUTCHEON (F) (W-LESS) (UL) ASSY
LENS COVER LENS COVER
C
4-670-554-12 4-670-554-02
(W-LAN)...LENS COVER (No W-LAN)...LENS COVER
ESCUCHEON
LENS COVER
Opt.Drive
W-Lan
LABEL ID
Battery
Office
CPU
HDD
LCD
Memory
Model name:PCG-V505DC2 (American Area)
Model number:PCG-681L(With W-LAN),682L(No W-LAN)
OS:Windows XP Home
V
er.1.0
Mobile P4-2.4GHz-M Mobile P4-2.2GHz-M Mobile Celeron 2.0GHz
6-704-615-01 6-704-614-01 6-704-652-01
IC RH80532GC056512SL6VC IC RH80532GC049512SL6VB IC RH80532NC041256SL6VJ
60 GB 40 GB
A-8116-402-A A-8116-404-A
ASSY HDD 60GB (I,40)(S) ASSY HDD 40GB (I,40)(S)
12.1 XGA
A-8118-175-A
LCD UNIT (12.1 TFT XGA) (S)
1024 MB (512MBx2) 512 MB (512MBx1) 512 MB (256MBx2) 256 MB (256MBx1)
A-8067-880-A x2 A-8067-880-A x1 6-600-158-01 x2 6-600-158-01 x1
COMPLETE PWB MM-10 COMPLETE PWB MM-10 IC HYS64D32020GDL-7-B IC HYS64D32020GDL-7-B
9.5mm Combo (×8)
1-796-626-12 / 1-796-822-11
COMBO DRIVE (UJDA745, 9.5MM) / COMBO DRIVE (UJDA755, 9.5MM)
MiniPCI
1-761-784-31 None
CARD, WIRELESS LAN
BP4V BP2V
A-8114-139-A A-8114-137-A
BP4V (U) ASSY (S) BP2V (U) ASSY (S)
Office XP Pro Office XP SBE None
V505DC2
4-679-137-11
ID LABEL (UCTO)
ESCUCHEON (F) (W-LAN) (UL) ASSY ESCUCHEON (F) (W-LESS) (UL) ASSY
-
L
X-4626-274-1 X-4626-273-1
(W-LAN)...ESUCUTCHEON (F) (W-LAN) (UL) ASSY (No W-LAN)...ESUCUTCHEON (F) (W-LESS) (UL) ASSY
LENS COVER LENS COVER
C
4-670-554-12 4-670-554-02
(W-LAN)...LENS COVER (No W-LAN)...LENS COVER
ESCUCHEON
LENS COVER
CPU
HDD
LABEL ID
Battery
Office
Opt.Drive
W-Lan
LCD
Memory
Model name:PCG-V505DC2K (American Area)
Model number:PCG-681L(With W-LAN),682L(No W-LAN)
OS:Windows 2K
V
er.1.0
Mobile P4-2.4GHz-M Mobile P4-2.2GHz-M Mobile Celeron 2.0GHz
6-704-615-01 6-704-614-01 6-704-652-01
IC RH80532GC056512SL6VC IC RH80532GC049512SL6VB IC RH80532NC041256SL6VJ
60 GB 40 GB
A-8116-402-A A-8116-404-A
ASSY HDD 60GB (I,40)(S) ASSY HDD 40GB (I,40)(S)
12.1 XGA
A-8118-175-A
LCD UNIT (12.1 TFT XGA) (S)
1024 MB (512MBx2) 512 MB (512MBx1) 512 MB (256MBx2) 256 MB (256MBx1)
A-8067-880-A x2 A-8067-880-A x1 6-600-158-01 x2 6-600-158-01 x1
COMPLETE PWB MM-10 COMPLETE PWB MM-10 IC HYS64D32020GDL-7-B IC HYS64D32020GDL-7-B
9.5mm Combo (×8)
1-796-626-12 / 1-796-822-11
COMBO DRIVE (UJDA745, 9.5MM) / COMBO DRIVE (UJDA755, 9.5MM)
MiniPCI
1-761-784-31 None
CARD, WIRELESS LAN
BP4V BP2V
A-8114-139-A A-8114-137-A
BP4V (U) ASSY (S) BP2V (U) ASSY (S)
Office XP Pro Office XP SBE None
V505DC2K
4-679-137-21
ID LABEL (UCTO)
ESCUCHEON (F) (W-LAN) (UL) ASSY ESCUCHEON (F) (W-LESS) (UL) ASSY
-
L
X-4626-274-1 X-4626-273-1
(W-LAN)...ESUCUTCHEON (F) (W-LAN) (UL) ASSY (No W-LAN)...ESUCUTCHEON (F) (W-LESS) (UL) ASSY
LENS COVER LENS COVER
C
4-670-554-12 4-670-554-02
(W-LAN)...LENS COVER (No W-LAN)...LENS COVER
ESCUCHEON
LENS COVER
CPU
HDD
LABEL ID
Battery
Office
Opt.Drive
W-Lan
LCD
Memory

– 20 –
Model Service Manual
Parts No.
PCG-V505AX 9-876-082-XX
PCG-V505AXP
PCG-V505FP 9-876-084-XX
PCG-V505BL
PCG-V505BX 9-876-311-XX
PCG-V505BXP
PCG-V505DC2*
PCG-V505DC2K*9-876-357-XX
PCG-V505DC2P*
*: Additional Model
PCG-V505DC2/V505DC2K/V505DC2P (AM)
List of PCG-V505 Series (As of October, 2003)
Sony Corporation
9-876-357-01
English
2003J0500-1
© 2003 Sony Corporation
Published by Sony EMCS VAIO-GSC [SNT]
*
This manual and the constituent data may not be
replicated, copied nor reprinted in whole or in part
without prior written authorization of Sony Corporation.
本マニュアルの一部，または全部について，無断で
データの複製，複写，転載することを禁じます。

Revision History
Suffix Ver. Date Contents QM No.
<Remarks>
[Confidential]
PCG-V505DC2/V505DC2K/V505DC2P (AM)
-01 Ver. 1 2003.10.10 First Edition