SPARTAN sport 1159 User manual

USER 'S MANUAL FOR :
THE
2
UNIT OUTDOOR PLAY GYM
SPSE
-
1575
-
2
SWING
SWING

01/07
Assembly, Installation, Care, Maintenance and Use Instructions
Manual depicts typical installation –your model may differ from illustrations
Thank you for purchasing our product
IN CASE OF MISSING OR BROKEN PARTS,
PLEASE CONTACT PLACE OF PURCHASE
FOR ASSISTANCE.
Caution:
This unit is designed for a maximum of 2 children between the age of 3 to 10 years old
on the motion rides. Maximum weight for each seat -110lb.
Warning!
Please read this instruction manual before you start with the assembly or use this
swing set. You must follow all safety instructions while using this equipment; be
absolutely sure that the surface on whichthis swing set is set up on, is properly
surfaced with fine sand, and wood chips. Do not use this swing set on hard pack soil,
concrete or any kind of hard surface. Read all cautionary statement before using this
equipment.

ATTENTION AND CAUTION
1. This play GYM must be assembled by an adult and make sure all the nuts and bolts
were screwed tightly.
2. This play GYM can be used indoor or outdoor, but if used indoor please make sure
there is sufficient space for it (3M from each leg).
3. This play GYM can be used on general ground, lawn or concrete floor, our
recommendation is lawn. (Pay attention to the method of fixing it on different surface).
4. This unit must be used under the supervision of adult.
5. Not suitable for children under3 years due to small parts.
SAFETY INSTRUCTIONS
Pleasefollowthese instructions carefullyand keep them forfuture reference.
1) The equipment must be assembled by an adult.
2) Adult supervision is required at all times when using this product.
3) Age recommendation: 3 To 10 years of age.
4) Maximum weight for each seat is 110lb.
5) Recheck screws and nuts if properly tighten.
6) Make sure the bolts are protected by rubber caps.
7) Use the equipment only in an open area, Free from obstructions that could harm a child.
8) Use the equipment on a flat grassy surface. Patios, concrete or other hard surfaces must be
avoided.
9) Children must be shown how to use this product safely. Do not let children climb all over the
equipment or do roll over on the end frame. This practice can cause serious injury.
10) The seat surface of the swing shall not be higher than 600mm from the ground. The swing
is use for sitting only and not for standing.
11) Suspension systems, Anchor points and fixings must be checked regularly for wear and tear
and replaced where necessary.
12) Ropes must be replaced every 12 months if necessary.
13) Paintwork should be checked regularly and if necessary can be touched up using a non-
toxic enamel or “CAR” type paint.
14) It is indispensable that the legs are concreted into the ground. If this is not possible, then the
ground anchor provided must be used instead.
15) Do not leave young children unattended while playing on the equipment.
16) For family domestic use only.

ASSEMBLING THE PLAYASSEMBLY INSTRUCTION FOR THE GYM: 2 UNIT
OUTDOOR PLAYGYM
Model. SPSE-1575-2
PACKAGE CONTENTS / DIAGRAMS FOR PARTS:
1. CARTON PACK ( F Screwsbag)
PART NO
NAME
Q'TY
PART NO
NAME
Q'TY
1
Top Support Bar (A)
1
F2
M6X40 Hex Bolt
4
2
Side Girt (With Safety Cap)
2
U1
M6 Safety Nut
4
3
Leg (Upper)A
2
U2
M8 Safety Nut
4
4
Leg (Upper) B
2
X3
M6 Iron Wascher
4
5
Leg Lower
4
X4
M8 Iron Wascher
4
6
Ground Anchor
4
Z1
Spanner
1
F15
M8x45Hex Bolt
4
Y1
M6 Hex Wrench
1
Y2
M8 Hex Wrench
1

A. InsertLegUpper (3) andLeg Upper (4) intoTop SupportBar ¾, secure withHex Bolt(F15), M8 Wascher
(X4) and M8 Nuts (U2).
B. InsertLeg Lower (5) intoLeg Upper (3) and Leg Upper(4) attach Side Girt(With Safety Cap (5) to Leg Upper
(3) and Leg Upper (4) using Hex Bolt (F2), M8 wascher(X3) and M8 nut (U1).
ASSEMBLE INSTRUCTION OF THE SWING

2. SWING ACCESSORY （A Screws bag)
PART NO
NAME
Q'TY
PART NO
NAME
Q'TY
1
Swing Seat &Rope
1
G4
M8 U-Screw
2
X2
M8 Iron Washer
4
U2
M8 Safety Nut
4
1: Hang two swing set & Rope(1) onto U-screw (G4), then assemble the U-screw onto the top support bar,
fasten them with safetynut (U2) and washer (X4). Adjust the swing rope (1) to ensure the swing’s balance and
the height of the seat should be no more than 400 mm from the ground.

CARE AND MAINTENANCE
This swing set was designedand manufactured with quality materials and
craftsmanship. With proper care and maintenance, it will provide all players with
years of exercise,fun, and enjoyment. Pleasefollowthe guidelinesbelow:
This swing setis designedtowithstand a specificweightand usage.Child over110
pounds (50kgs) should not use the swing set. Players should remove all sharp
objects from their personprior to using the swing set. All sharp or pointed objects
should be kept offthe playground at all times.
Always inspectthe swing setbeforeeachuse forworn, damagedor missingparts.
Pleasebe aware of:
Loosed ormissingbolt
Sagging supporttop bar
Bent or brokenframe parts, suchas the supportleg
Broken, missing,or damagedseats
Damaged,missing,or insecurelyattached rope
Protrusions of any types (especiallysharp types)on the frame or any other
places,
IF YOUFIND ANY OF THEPREVIOUS CONDITIONS,OR ANYTHING ELSE
THAT YOU FEELCOULDCAUSE HARM TOANY USER, THESWING SET
SHOULD BE DISASSEMBLEDORSECUREDFROM USE UNTIL THE
CONDITION(S)HAS BEEN RECTIFIED.