Spear & Jackson SPM41 User manual

QUICKSTART
GUIDE
Important - Please read these instructions fully before operating or maintaining your petrol mower
PETROL SELF PROPELLED LAWNMOWER
41CM
SPM41
Email: [e-mail]
Website: www.spearandjackson-power.com
AFTERSALES SERVICE
01904 727505
MON-FRI 9am-5pm SAT/SUN 11am-4pm
www.spearandjackson-power.com
1 2 3
5
7
6
4
8 9
1. Main mower deck (with upper handle attached)
2. Lower handle
3. Grass collection bag 1pc
4. Handle fixing bolts 4pcs
5. Handle tensioning knob with nut m8 2pcs
6. Cable clip 1pc
7. Rope guide 1pc
8. Wrench 1pc
9. Spanner & philips screwdriver 1pc
BOX CONTENT CHECK

Engine stop
Engine start
Always read the instruction manual thoroughly before starting the lawnmower.
Never allow the starter cord to snap back.
Check the oil level before every use. Always use high quality detergent oil classified
SAE30 oil (or equivalent eg 5W 30, often termed as 4 Stroke lawn mower oil).
Unpack the lawn mower ensuring all parts are present
(see parts list overleaf) before discarding the packaging.
Align the lower handle
with the holes in the
deck. Fix the lower
handle using the 4 handle
fixing bolts onto the deck
firmly with supplied
wrench
Locate the rope guide
over the right hand
bolt so the 90° bend
sits on top of the
handle bar and secure
using the plastic knob.
Lift the flap and
hook the grass bag
over the plastic
hooks on the rear
of the mower.
In cold weather it may be necessary to repeat the cold engine starting
process.
The engine does not
come with oil. Add
0.5 litres of oil.
CHECK THE OIL LEVEL
BEFORE EVERY USE.
Adjust the cutting
height via the lever
located by the rear
right hand wheel.
Slowly pull out starter
cord & hook it through
the eye of rope guide.
You should ALWAYS
start your mower
from this position.
Locate upper handle
bar on lower with the
bolts. Secure the left
bolt using plastic
tightening knob
ensuring cables are
not twisted.
Using the cable
clamp provided,
secure the cables to
the handle without
trapping them.
If you have any difficulties please contact the
helpline on 01904 727505
email [email protected]
or visit www.spearandjackson-power.com
1
2
Add Full
3
6 8
2 4
To stop the mower release the stop/start bar.
When starting a cold
engine, press down the
primer fully 3~5 times.
When starting a warm
engine, the primer
does not need to be
used.
Hold the stop/start bar
firmly to the handle to
disengage the motor
brake and automatic
cut out.
To start the engine slowly
pull the start cord out
until resistance is felt
(approx 10-15cm) then
start the engine with a
sharp vigorous pull.
9
10
11
Do not start the engine before putting 500ml of SAE 30 oil into the engine.
Failure to do so will result in irreparable damage to the engine and
invalidate your warranty.
Fill the petrol tank with 0.8l of normal 95 Octane petrol (standard unleaded) using a funnel and
measuring jug.
1
Pull up the propulsion lever
to engage the self propelled
function.
12
1
5 7
PRIMER BULB
3~5 TIMES
STOP/START-LEVER
CLOSED PULL STARTING -KNOB PROPULSION-LEVER CLOSED
ASSEMBLY
PREPARING TO MOW
MOWING THE LAWN
IMPORTANT INFORMATION!