SportsPlay 902-875 User manual

902-875 ROCK CLIMBING TUNNEL
INSTALLATION INSTRUCTIONS
WWW.SPORTSPLAYINC.COM
1
W E I G H T
A G ES
SI Z E
USE Z O N E
280
68 3/4x95 1/2x30
80 3/4x107 1/2
I D
PA R T #
D ESC R IP T I O N
Q T Y
1
913-391
Side Panel for Rock Wall
2
2
913-392
Top Panel for Rock Wall
1
3
913-393
Rock Wall Leg
3
4
Set of 10
Climbing Rock Set 1-10
2
5
316-601
3/8 Washer
50
6
316-501
5/16 Washer
22
7
116-538
5/16x1 ¾Buttonhead Bolt
22
8
216-512
5/16x1 Buttonhead Nut
42
9
116-529
5/16x3/4 Buttonhead Bolt
20
10
1/4x1 Buttonhead Bolt
20
11
¼Tee Nut
20
12
126-703
3/8x1 Buttonhead Bolt
8
13
236-601
3/8 T-Nut
8
14
913-394
Middle Support Bracket
4

902-875 ROCK CLIMBING TUNNEL
INSTALLATION INSTRUCTIONS
WWW.SPORTSPLAYINC.COM
2
I M P O R T A N T
PLEASE READ THESE INSTRUCTIONS BEFORE BEGINNING
ASSEMBLY. It contains important replacement parts information. It is
important to use and maintain all public playground equipment
properly. Playground equipment which is improperly maintained, can
cause serious injury. Periodical inspections, maintenance, repair and/or
replacemnt of damaged parts is necessary for safe operation of
equipment. Appropriate publications, available at no charge, from the
&RQVXPHU3URGXFW6DIHW\&RPPLVLRQLQFOXGH³$+DQGERRNIRU
3XEOLF3OD\JURXQG6DIHW\´<RXFDQUHFHLYH\RXUIUHHFRS\E\FDOOLQJ
1-301-504-0708.
A D U L T SU P E R V ISI O N IS R E Q U IR E D A T A L L T I M ES!
G E N E R A L M A I N T E N A N C E I NST R U C T I O NS:
Check MONTHLY for loose bolts, damaged or broken parts. Tighten
and/or replace immediately. Replace any parts the show a reduction of
25% from original size.
SHOULD A COMPONENT BECOME DAMAGED YOU MUST
CLOSE THE UNIT TO PLAY UNTIL THE REPAIRS ARE MADE!
In order to prevent injury to personnel and damage to components a
minimum or two people are required to lift all panels.
To prevent damage to compenents during install all components
should be placed on a protective surface (cardboard, plastic sheet or
tarp) and not placed directly on the ground while they are being sorted.
E A C H R O C K IS I NS T A L L E D I N A C E R T A I N L O C A T I O N O N
T H E PA N E L .V I E W T H E R O C K L A Y O U T P A G E A T T H E
E N D O F T H E SE INST RU C T I O NS F O R PR O PE R
P L A C E M E N T .
Each hardware box has 2 sets of rocks, one set of rocks is required for
each side.
T H IS U NI T ,6'(6,*1(')25´2)/226(),//
SU R F A C I N G .

902-875 ROCK CLIMBING TUNNEL
INSTALLATION INSTRUCTIONS
WWW.SPORTSPLAYINC.COM
3
SP E C I F I C ASSE M B L Y INST R U C T I O NS
1. %HJLQE\GLJJLQJKROHV´LQGLDPHWHUDQG´ deep based
off of the dimensions on the side view footing page at the back
of these instructions.
2. ,QVWDOOWKHOHJVLQWKHKROHVE\ILOOLQJWKHKROHVZLWK´RI
concrete.
3. Attach the side panels to the legs with one sloped end of the
panel pointing to the left on one side of the structure and he
other sloped end pointing to the right on the other side of the
structure by using the 5/16x1 3/4 Buttonhead bolt and 5/16
washer on the front side of the panel and by using the 3/8
washer and 5/16x1 Buttonhead nut on the back side of the
panel. (view detail drawing on the first page)
4. Attach the top panel as shown using the 5/16x1 ¾Buttonhead
bolts and 5/16 washers on the top side of the panel and 5/16x1
Buttonhead nut and 3/8 washer on the bottom side of the panel.
5. Attach the rocks to the panels using the 5/16x3/4 Buttonhead
bolt in the large hole on the front of the rock and the 1/4x1
Buttonhead bolt in the small hole on the front of the rock and
the 5/16x1 Buttonhead nut with the 3/8 washer in the large hole
on the back side of the panel and the ¼tee nut in the small hole
on the back side of the panel. ROCKS MUST BE PLACED
ON PANELS IN CERTAIN ORDER. Refer to the following
rock layout page to determine which rocks should go were.
6. Install middle support bracket along edge of top plastic piece.
Place directly between support legs on the under side of plastic,
mark and drill holes, then attach bracket using (2) 3/8´x 1´
bolts with 3/8´washers on top side and (2) 3/8´t-nuts on
bottoms side.

902-875 ROCK CLIMBING TUNNEL
INSTALLATION INSTRUCTIONS
WWW.SPORTSPLAYINC.COM
4

902-875 ROCK CLIMBING TUNNEL
INSTALLATION INSTRUCTIONS
WWW.SPORTSPLAYINC.COM
5

902-875 ROCK CLIMBING TUNNEL
INSTALLATION INSTRUCTIONS
WWW.SPORTSPLAYINC.COM
6
Top View
Footing
Layout