squarebear Big AL User manual

Big AL
STEP STOOL | Assembly Instructions
Thank you for purchasing the Big AL Step Stool!
Please take a few minutes to read the instruction sheets carefully. This
will help you to assemble and use the step stool properly.
! WARNING: ADULT ASSEMBLY AND SUPERVISION REQUIRED.
Prior to assembly, please read the Important Safety Information section
on the last page.
PATENT-PENDING

WOODEN PARTS
HARDWARE
A
F
E
D
B
C
12 12 HEX KEY
ASSEMBLY TIPS
1. WHEN INSTALLING SCREWS WITH HEX KEY, DO NOT
OVER-TIGHTEN. TURN THE SCREW UNTIL JUST SNUG, OTHERWISE
RISK DAMAGING THE PART.
2. IF SCREW RESISTS TIGHTENING, DO NOT FORCE. RATHER, TRY
LOOSENING THE SCREW AND THEN BEGIN TIGHTENING AGAIN.
REPEAT UNTIL THE SCREW EASILY THREADS INTO THE INSERT.

ASSEMBLY STEPS
A
B
STEP 1
INSERT TAB OF
PART B INTO THE
SLOT OF PART A
AS SHOWN.
STEP 2
WITH PART E IN POSITION,
INSERT A LARGE WASHER
INTO POCKET ON PART A
AS SHOWN.
STEP 3
INSERT A SCREW INTO THE
WASHER AS SHOWN. TIGHTEN
WITH THE HEX KEY.

ASSEMBLY STEPS (CONTINUED)
D
STEP 4
JOIN PART C TO THE
SUB-ASSEMBLY
AS SHOWN.
USING HEX KEY,
FASTEN TOGETHER
WITH 2 WASHERS
AND 2 SCREWS.
STEP 6
JOIN PART C TO THE
SUB-ASSEMBLY AS SHOWN.
USING HEX KEY, FASTEN
TOGETHER WITH
2 WASHERS AND 2 SCREWS.
STEP 7
REPEAT STEP 6 TO ATTACH REMAINING PART E TO THE OPPOSITE SIDE.
STEP 5
JOIN PART D TO THE
SUB-ASSEMBLY AS
SHOWN.
USING HEX KEY, FASTEN
TOGETHER WITH A
WASHER AND SCREW.
C
E

ASSEMBLY STEPS (CONTINUED)
F
STEP 8
JOIN PART F TO THE
SUB-ASSEMBLY AS SHOWN.
USING HEX KEY, FASTEN
TOGETHER WITH 3 WASHERS
AND 3 SCREWS.
TIP: A PILLOW POSITIONED AS SHOWN
CAN HELP KEEP PART F IN PLACE MAKING
ASSEMBLY STEP MUCH EASIER.
PILLOW

IMPORTANT SAFETY INFORMATION
WARNING: CHOKING HAZARD DUE TO SMALL PARTS
(ADULT ASSEMBLY REQUIRED)
• THIS PRODUCT IS NOT SUITABLE FOR CHILDREN UNDER 2 YEARS OF AGE.
• UNPACK, ASSEMBLY AND SET UP THE BIG AL STEP STOOL CAREFULLY.
• NEVER LEAVE UNASSEMBLED PARTS/SCREWS/WASHERS/HEX KEY UNATTENDED
DUE TO POTENTIAL HAZARDS.
• THIS PRODUCT IS DESIGNED FOR CHILDREN 2 TO 8 YEARS OLD AND INTENDED
TO BE USED AS A STEP STOOL.
• NEVER USE THE BIG AL STEP STOOL UNLESS IT IS PROPERLY ASSEMBLED.
• IT IS IMPORTANT TO FREQUENTLY INSPECT THE LIL’ AL STEP STOOL AND
RE-TIGHTEN ANY LOOSE SCREWS.
MATERIALS IN THIS PRODUCT WERE TESTED FOR LEAD AT A CPSC
APPROVED LABORATORY. TEST RESULTS COMPLY WITH CPSC
PRODUCT SAFETY REGULATIONS: 16 C.F.R. 1303 requirements for lead
and CPSIA Section 101 requirements for lead.
CLEANING AND CARE
•THE BIG AL STEP STOOL IS INTENDED TO BE USED IN INDOORS ONLY.
•USE A DAMP CLOTH OR SPONGE TO SURFACE CLEAN.
•DO NOT SUBMERGE THE BIG AL STEP STOOL IN WATER.
RETAIN PACKAGING AND THESE INSTRUCTIONS FOR FUTURE REFERENCE.
©SQUARE BEAR KIDS, LLC.
621 23RD AVENUE
TWO HARBORS, MN 55616
www.squarebearkids.com
Small Parts
Choking Hazard
Not recommend for
children under 3 years.