Sun Water Systems Health AIR 500 Series User manual

HealthAIR PURIFIER
TM
Owners Manual
For 500 Series EMF Air Cleaners
Advanced Air Purification Systems
HealthAIR PURIFIER
TM
Sun Water Systems, Inc.
6310 Midway Rd
Haltom City, Texas 76117
877- FDA-PURE
Symptom
• Is the unit plugged into a “working”
120 Volt, AC, earth grounded outlet?
• Is the unit’s top cover in place, and
snapped shut?
• Is the Main Filter locked in place,
with the Main Filter locking handles
facing toward the center of the unit?
Unit will not turn ON
Check/ Remedy
Unit will still not turn ON • Call HealthAirTM Customer Service.
Unit is ON, but no speed change • Call HealthAirTM Customer Service.
Unit runs, but power light is OFF • Call HealthAirTM Customer Service.
Main Filter light is out • Replace Main Filter.
• Main Filter has reached its
contaminant holding capacity.
Bio Monitor light is out • Call HealthAirTM Customer Service.
Trouble Shooting Guide:

Where to Place the Air Purifier:
The 500 Series EMF Air Cleaner is designed as a portable floor model. Place the air
purifier anywhere in the room; being careful not to block air from “entering” the
intake grill, or “exiting” the top grill cover. Do not place the air purifier where drapes
or other objects block airflow. For best performance, it is recommended to place the
air purifier at least two (2) feet from walls and other obstructions.
Air Cleaner Operation:
After removing the protective plastic from the unit – plug the unit into a standard 120
volt earth grounded AC circuit and turn the On/Off button on the control panel. The
control panel lights should be illuminated as follows:
On/Off - green light is ON
Main Filter - green light is ON
Bio Monitor - green light is ON
The HealthAirTM indicator light system is an all “green” system.
When the unit is operating properly, both indicator lights will be “green”.
Main Filter Light:
When the Main Filter is operating at full efficiency, the green light is always ON.
When the light goes OFF, this is your indication to “replace” the Main Filter. The
average life expectancy of the Main Filter is 12 to 16 months. See Main Filter
replacement instructions.
Bio Monitor Light:
Green light ON indicates that airborne microorganisms are continuously being
destroyed in the EMF Filtration System. If the light goes OFF, microorganism destruction
has been interrupted. Immediately turn off the unit and unplug it from the outlet. Call
HealthAirTM customer service at 877-FDA-PURE for servicing instructions.
Cleaning the Unit:
Before cleaning the unit, shut the air purifier OFF and unplug it from the outlet. Clean
exterior surfaces only with a soft cloth dampened with water. Do not use abrasive
cleansers. Do not spray the unit with any liquid cleaner. Wipe the intake grill weekly
with a clean, dry non-static cloth.
Filter Replacement:
Post Filter – At least every 3 months, replace the post filter. This insures continued
control of household odors.
Ordering Replacement Filters:
Enclosed is a convenient form for ordering the replacement filters directly from
HealthAirTM Simply fill out the order form and fax, mail or call in your order. For any
questions, please call our Customer Service Department at 877-FDA-PURE
Post Filter Installation Instructions:
1. Turn the air purifier off and
unplug from power outlet.
2. To access post filter, release
latch, open and raise lid.
(Fig. A) Separate lid from
the air purifier. Turn over to
reveal inside of lid.
3. Remove the post filter by
pulling it from the inside
rim of the lid and discard.
(Fig. B)
4. Carefully place new post
filter in the lid. Press filter
under the five tabs in the rim
of the lid to secure in place.
5. Replace the lid by matching
the front tab to the catch below
the control panel buttons, and
press down gently until rear
latch engages. Plug air purifier
into power outlet and turn on.
EMF Main Filter Installation Instructions:
When the green Main Filter indicator light goes OFF, it
is time to replace the EMF Main Filter. The average life
expectancy of the EMF Main Filter is 12 to months.
1. Turn the air purifier off and
unplug from power outlet.
2. To access post filter, release
latch, open and raise lid.
(Fig. A) Separate lid from
the air purifier and set aside.
3. To release EMF Main Filter,
move both gray handles toward
front of air purifier. (Fig. B)
4To remove EMF Main Filter, lift filter
from the internal chamber. (Fig. C)
Before installing the new EMF Main
Filter, make sure the filter
seal “O” ring is seated properly in the
“O” ring channel.
5. To load EMF Main Filter, align hole in filter
tab with brass pin. Press filter down. To lock filter in
place, move both gray handles in toward the center
of the filter as shown. (Fig. D)
6 Replace lid and latch. Plug air purifier into power
outlet and turn on. Note: The proper filter must be
used and loaded correctly or air purifier will not turn
on. For additional instructions call Customer Service
at: 877-FDA-PURE
AB

HealthAirTM patented
EMF Filtration System
The new standard in clean air
Important Safety Precautions (continued)
9. The air purifier is designed for indoors, do not use this air purifier
outdoors.
10. Do not operate this unit with a damaged cord or plug, or after the
unit malfunctions or has been damaged in any manner. Call HealthAirTM
Service at 877-FDA-PURE for servicing instructions.
11. This unit is designed for residential use only. Do not use in
industrial or severe commercial applications.
12. A short power supply cord is provided to reduce the risk resulting from
becoming entangled in or tripping
WARNING: To prevent fire or shock hazard, do not expose this unit to rain or moisture.
The HealthAirTM EMF Air Cleaner is designed for “plug and play” operation and
comes complete, ready for use. Simply follow the instructions for set up contained in
this owner’s manual.
To receive maximum benefit from the HealthAirTM EMF Air Cleaner, we recommend
replacing the EMF main filter every 12, and the charcoal post filter every 3 months.
Order online at aquasana.com or call 877-FDA-PURE.
Important Safety Precautions
Please read all instructions before operating your air purifier. Basic precautions
should always be observed when using electric appliances to reduce the risk of
fire, shock and injury.
Observe the following general precautions to insure effective, safe
and trouble-free operation of your HealthAirTM EMF Air Cleaner.
Warning: This air purifier must be plugged into a 120 Volt, AC earth grounded
outlet. Do not use this air purifier with a wall outlet adapter. Do not operate this
air purifier with an extension cord.
1. Plug the unit DIRECTLY into an earth grounded standard 120 volt, AC
electrical outlet. Insert the plug into the outlet fully. The plug is a polarized line plug
(one blade is wider than the other) and can only be inserted one way as a safety
feature.
2. Place the unit on a flat and level surface to allow continuous airflow to
the bottom intake and out the top outlet grill.
3. Always unplug the air purifier before moving it, opening the top lid,
changing the post filter, main filter or before cleaning.(Clean only with a dry,
non-static cloth.)
4. Do not place any foreign objects inside the unit because electric shock
and injury could result.
5. Do not use the unit if any part is missing or damaged in any way.
6. Do not run power cord under carpeting or near heaters, registers,
radiators, stoves or fireplaces. To avoid a tripping hazard, keep the power
cord away from traffic areas.
7. Never operate the air purifier in areas where combustible gases o r
vapors are present or any other flammable materials.
8. Never immerse the unit in water or other liquids, spray the air purifier
with liquids or clean the air purifier under running water.