Swing-N-Slide Timber-Bilt PB 8129 User manual

ASSEMBLY INSTRUCTIONS
Swing•N•Slide • 1212 Barberry Drive • Janesville, Wisconsin 53545
Visit our web site at: www.swing-n-slide.com or call us at 1-800-888-1232
© Swing-N-Slide 2014 Printed in USA
PB 8129
LA 7282
!WARNING:
Assembly by an adult.
!ADVERTENCIA:
El ensamblaje lo
debe hacer un adulto.
!AVERTISSEMENT:
L’assemblage doit être
exécuté par un adulte.
IMPORTANT!!
PLEASE READ BEFORE BEGINNING ASSEMBLY!!
Please make sure all lumber, hardware and accessory parts are accounted for. If you are
missing anything, please DO NOT RETURN to the store where purchased. Please call our
Customer Service Department at the number below.
No. of children: Up to xx
Est. building Time: x-xx hrs.
Two Adults
SLIDE SOLD
SEPARATELY
(NE 4675)

2
Installation Safety –Have You:
Consulted the assembly instructions supplied with your particular model?
Noted this accessory is to be used only on Swing•N•Slide approved designs? (Do not alter its design or add/remove components, this accessory is intended
for wooden playsets only, do not install on metal frame playsets).
Made sure all hardware is tightened securely? (Supplied bolt covers must also be fastened securely.)
Using a hacksaw, cut off all protruding threaded ends of bolts and other fasteners and remove any sharp edges with
a metal file as needed, and coated fastener ends with lead free paint?
Placed the equipment on level ground, not less than six feet (1.8 meters) from any structure or obstruction such as a fence, garage, house, overhanging
branches, laundry lines, or electrical wires?
Made sure home playground equipment is not installed over concrete, asphalt, packed earth or any other hard surface? (A fall onto a hard surface can re-
sult in serious injury to the equipment user.)
Verified that suspended climbing ropes, chain,or cable are securely anchored at both ends and cannot be looped back unpon itself?
Consulted in assembly instructions of your particular model for minimum use zones?
Used a water sealant on your play set to protect the wood and prevent cracking and warping? (Apply water sealant directly afterassembly is complete. If
you live in a coastal area, it is advisable to apply a clear coat finish to all metal parts to discourage rust).
Followed all anchoring and shock absorbing surfacing requirements on the back of this sheet as they apply?
Made sure not to allow children to use equipment until it is properly installed?
Made sure to adjust all swings so there is a minimum 8'' clearance between the swing and the ground surface?
If project requires more than one day to complete, made certain to anchor the tower as soon as it is constructed?
Do not leave the tower unanchored overnight.
Operating Safety –Have You:
Determined that on-site adult supervision is provided for children of all ages?
Warned children the following before allowing them to use the equipment?
Not to walk close to, in front of, behind or between moving items.
Not to twist swing or any other accessory chains or ropes or loop them over the top support bar since this will reduce the strength of chain or rope.
Not to stand on swing seats.
Not to swing empty seats or other accessories.
Not to slide down swing chains.
Be sure to sit in the center of the swing seat and other accessories with full weight on the seat.
Not to attach items to the playground equipment that are not specifically designed for use with the equipment such as but not limited to, jump
ropes, clotheslines, pet leashes,cables and chain. They may cause a strangulation hazard.
Not to climb or walk on the top of swing beams, railings or roof.
Not to use equipment in a manner other than intended.
Not to get off equipment while it is in motion.
Not to climb on the equipment when it is wet.
Be sure to go down slides feet first.
Determined that only one child per planned occupant seat should be allowed on this set at one time.
Determined children must be dressed appropriately for play. Avoid hooded jackets, bicycle or other sports helmets, clothing with draw strings and loose
fitting clothes which could become entangled or snagged on equipment.
Determined that suspended climbing ropes, chain, or cable are securely anchored at both ends and cannot be looped back upon itself.
Made certain the slide is placed so that it is not in direct sunlight.
Safety Maintenance –Follow these preventive maintenance instructions at the intervals required:
Use of weed trimmers too close to board surfaces will cause damage to the wood and compromise protection against rot and insectinfestation.
To prevent the deterioration of materials, remove plastic swing seats and other plastic accessories when outdoors temp dips down to or below 32° F and
take indoors. Reinstall these plastic elements at the beginning of each play season.
At the beginning of each play season check metal parts for rust. If found, sand and repaint using a non lead-based paint meeting the
requirements of 16 CFR 1303 or SOR/2005-109.
At the beginning of each play season and once a month during each play season, check all moving parts for wear, rust or other
deterioration. Replace as needed. If any of these conditions exist, call 1-800-888-1232 to order replacement accessories.
At the beginning of each play season and once a month during each play season lubricate metallic moving parts.
At the beginning of each play season and twice a month during each play season, check all protective coverings on bolts, pipes,edges, and corners.
Replace if they are loose, cracked, or missing.
At the beginning of each play season and twice a month during each play season, rake and check depth of loose fill protective
surfacing material to prevent compaction and maintain appropriate depth. Replace as necessary.
At the beginning of each play season and twice a month during each play season tighten all hardware.
At the beginning of each play season and twice a month during each play season, check all wood members for deterioration and
splinters. Sand down splinters and replace deteriorating wood members.
Disposal Instructions
When the equipment is taken out of service, it must be disassembled and disposed of in such a way that no unreasonable hazards will exist at the time the set is dis-
carded.
Important! Additional Safety Instructions for all Swing-N-Slide Playground Equipment.
Save this instruction sheet in the event the manufacturer needs to be contacted.
Observing the following statements and warnings reduces the likelihood of serious or fatal injury
Safety Checklist for Swing-N-Slide Play Sets and Accessories

3
This product is intended for single family home/residential use only and not intended for use in any public setting.
Placement in any public setting constitutes a misuse of this product.
IMPORTANT!
ADDITIONAL REQUIRED SAFETY INSTALLATION INSTRUCTIONS
According to ASTM requirements, all kits must be anchored to the ground and, if the unit has a climbing rope, the rope end must be anchored to the ground. If soil conditions permit
stakes to be pulled out easily, cementing into ground is necessary.
• To anchor the unit to the ground, Follow the instructions included in this plan for applying Anchor-It devices to your unit, or use 2" x 4" x 18" (45mm x 95mm x 457mm) pressure-
treated stakes. Pound stakes into ground at least 12" (305mm) at all inside corners of the posts (including A-frame legs and climbing unit posts). Attach with four (4) 2-1/2’’
galvanized screws per stake into each tower and/or A-frame upright. NOTE: Leave the soil around anchors as intact as possible. Do not excavate more soil than is necessary to place
anchors.
• If the unit has a climbing rope, securely anchor the rope at both ends.
• Once the unit is completely assembled and before children are allowed to play on it, proper shock-absorbing surfacing material must be installed. This may be accomplished by
using loose-fill materials at a sufficient depth. The Consumer Product Safety Commission “Handbook for Public Playground Safety” lists the following materials and required depths
that are sufficient for home/residential application. Supplemental information may be found in ASTM F1292. For fall height protection up to 9 ft. (2.742m) [recommended for
Swing•N•Slide kits]:
LOOSE FILL MATERIALREQUIRED (UNCOMPRESSED) DEPTH1in. (mm)
Wood Mulch 9" (229mm)
Double Shredded Bark Mulch 9" (229mm)
Uniform Wood Chips 12" (305mm)
These depths were derived from the CPSC Handbook. Swing•N•Slide has not done independent tests to determine these required depths.
When properly installed, shock absorbing material will completely cover the horizontal baseboards on climbing units. This protective surfacing must extend a minimum of 6 ft.
(1.828m) in all directions from the perimeter of the equipment or from the outermost edges of any component. For example, a slide extending beyond the platform must have protec-
tive surfacing at least 6 ft. (1.828mm) out from both sides as well as the end. For swings, the protective surface must extend at least 14 ft. (6m)out from boththe back and front of
the swing when the swing is in its rest position.
Swing-N-Slide® MANUFACTURERS LIMITED WARRANTY
Swing-N-Slide® takes great pride in the quality and durability of our products. Our Manufacturer’s Limited Warranty provides confidence and demonstrates our commitment to
providing quality residential playground products.
MANUFACTURER’S LIFETIME LIMITED WARRANTY
Swing-N-Slide® warrants its thermoformed slides and climbing mountains to be free from defects in workmanship and materials, under normal use and conditions, for the
lifetime of the product.
MANUFACTURER’S 5 YEAR LIMITED WARRANTY
Swing-N-Slide® warrants its Custom Ready-to-Build Play Set kits and accessories to be free from defects in workmanship and materials, under normal use and conditions,
for a period of 5 years.
MANUFACTURER’S 5 YEAR LIMITED WARRANTY
Swing-N-Slide® warrants its No-Cut and Wood Complete Ready-to-Assemble Play Set kits against wood rot and termite damage, and to be free from defects in workman-
ship and materials, under normal use and conditions, for a period of 5 years for structural wood components.
Cosmetic defects that do not affect the structural integrity of the product, or natural defects of wood such as warping, splitting, checking, twisting, shrinkage, swelling or any
other physical properties of wood that do not present a safety hazard, are not covered by this warranty.
MANUFACTURER’S ONE YEAR WARRANTY
Swing-N-Slide® warrants its canopy roofs and/or tarps, playhouses and Timber GLOVE lumber wrap to be free from defects in workmanship and materials, under normal
use and conditions, for a period of one year.
Swing-N-Slide® will repair, or at its discretion, replace any part within the stated warranty period which is defective in workmanship or materials. This decision is subject
to verification of the defect upon delivery of the defective part to Swing-N-Slide® at 1212 Barberry Drive, Janesville, Wisconsin, 53545. Any part(s) returned to Swing-N-
Slide® must have prior approved Return Authorization Number and proof of purchase, including the date of purchase. This warranty is valid only if the product is used for the
purpose for which it was designed and installed at a residential, single family dwelling. This warranty is void if the product is put to commercial or institutional use. This
warranty does not cover (a) products which have been damaged by acts of Nature, negligence, misuse, or accident, or which have been modified or repaired by
unauthorized persons; (b) the cost of labor; or the cost of shipping the product, any part, or any replacement product or part.
Swing-N-Slide® DISCLAIMS ALL OTHER REPRESENTATIONS AND WARRANTIES OF ANY KIND, EXPRESS, IMPLIED, STATUTORY OR OTHERWISE, INCLUDING THE
IMPLIED WARRANTIES OF MERCHANTIBILITY AND FITNESS FOR A PARTICULAR PURPOSE. Swing-N-Slide® WILL NOT BE LIABLE FOR ANY INCIDENTAL OR
CONSEQUENTIAL DAMAGES. This warranty is non-transferable and does not extend to the owners of the product subsequent to the original purchaser. Some states do not
allow limitations on implied warranties or exclusion of incidental or consequential damages, so these restrictions may not be applicable to you. This warranty gives you
specific legal rights. You may also have other rights, which vary from state to state.
This warranty also does not apply to:
• Structures not erected, maintained or inspected in conformance with Swing-N-Slide® installation plans
• Structures that have had parts added or substituted not in conformance with Swing-N-Slide® installation plans
•Parts that have been modified, altered or misused
•Parts that have not been used as designed or intended
•Damage due to acts of Nature, vandalism, abnormal use or abuse as determined by Swing-N-Slide®
For further information on playground safety, the Consumer Product Safety Commission (CPSC)
publishes the Outdoor Home Playground Safety Handbook which can be downloaded for free from
www.cpsc.gov. An additional resource is the American Society of Testing and Materials (ASTM)
Standard Consumer Safety Performance Specification for Home Playground Equipment (ASTM F1148)
which can be purchased and downloaded from www.astm.org.

4
96 Max Fall Height
12 - 6
8
24 - 6
20
10 6
DIMENSIONS
MINIMUM USE ZONE FOR PLAY EQUIPMENT SHALL EXTEND NO LESS THAN 72” FROM ALL SIDES
OF THE PLAY STRUCTURE.
SWING USE ZONE EXTENDS NO LESS THAN 168”.
SWINGS MUST HAVE A MINIMUM CLEARANCE OF 8” ABOVE THE PROTECTIVE SURFACING.

5
TOOLS REQUIRED
DRILL 1/2” SOCKET &
WRENCH
HAMMER ADJUSTABLE
WRENCH
TAPE MEASURE
PHILLIPS BIT CARPENTER
SQUARE
SAFETY GLASSES 1/8” DRILL BITSCREWDRIVER
INCLUDED HARDWARE
1-1/4” Lag Screw (x44)
2-1/2” Deck Screw (x330)
2” Lag Screw (x42)
#8 x 1/2” Pan Screw (x2)
5/16” x 1-1/2” Lag Screw (x4)
5/16” Washer (x7)
T-30 Bit (x1)
T-20 Bit (x1)
5/16” Loc Nut (x3)
#12 x 3/4” Pan Screw (x22)
30mm Deck Screw (x82)
3/4” Flat Head Screw (x40)
1-1/2” Deck Screw (x116)
#14 x 1” Truss Screw (x3)

6
INCLUDED HARDWARE
INCLUDED COMPONENTS
1/4”-20 x 1-1/4” Hex Head Bolt (x8)
4x4 Wrap Loc (x10) 4x4 Shelf Loc (x2) 2x4 Shelf Loc (x8)
3/8’’ DRILL BIT
Weld-Nut (x8)
8mm Loc Washer (x8)
8mm Washer (x8)
3/16” Tarp
Washer (x22)

7
INCLUDED COMPONENTS
Anchor It Strap (x4) Anchor It (x4)
Play Handle (x2) ID Tag (x1)
Tarp, Large (x1)
Plan (x1)
Window (x4)
Climbing Rock (x4)
23-1/4’’ Rungs (x3)
Tarp, Small (x1)
Staple (x6) Bolt Caps (x3)
Net Climber (x1)
Step Bracket (R) (x1) Step Bracket (L) (x1)

8
BOARD LIST
(2) 4’’ x 4’’ x 120’’
(6) 4’’ x 4’’ x 96’’ LUMBER PURCHASED SEPARATELY
(5) [PF 4944] 2’’ x 4’’ x 47-1/2’’
(2) [PF 4943] 2’’ x 4’’ x 27’’
(1) [PF 4942] 2’’ x 4’’ x 17-1/2’’
(2) [PF 4941] 2’’ x 4’’ x 11’’
(4) [PF 4933] 5/4’’ x 4’’ x 47-1/2’’
(4) [PF 4931] 5/4’’ x 4’’ x 40-1/2’’
(4) [PF 4930] 5/4’’ x 4’’ x 40-1/4’’
(4) [PF 4903] 5/4’’ x 4’’ x 10-1/2’’
(2) [PF 4929] 1’’ x 4’’ x 47-1/2’’
(2) [PF 4932] 1’’ x 4’’ x 42-7/8’’
(2) [PF 4928] 1’’ x 4’’ x 45-3/4’’
(2) [PF 4926] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4927] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4925] 1’’ x 4’’ x 25-1/4’’
(4) [PF 4913] 5/8’’ x 4’’ x 47-1/2’’
(1) [PF 4912] 5/8’’ x 4’’ x 43-1/4’’
(2) [PF 4911] 5/8’’ x 4’’ x 42’’
(2) [PF 4908] 5/8’’ x 4’’ x 27’’
(4) [PF 4907] 5/8’’ x 4’’ x 12-7/8’’
(2) [PF 4906] 5/8’’ x 4’’ x 12-3/8’’
(2) [PF 4905] 5/8’’ x 4’’ x 10-1/2’’
(2) [PF 4910] 5/8’’ x 4’’ x 4-1/4’’
(1) [PF 4936] 5/4’’ x 6’’ x 47’’
(7) [PF 4937] 5/4’’ x 6’’ x 47-1/2’’
(1) [PF 4923] 5/8’’ x 6’’ x 47-1/2’’
(1) [PF 4924] 5/8’’ x 6’’ x 47-1/2’’
(2) [PF 4921] 5/8’’ x 6’’ x 42’’
(8) [PF 4920] 5/8’’ x 6’’ x 40-1/2’’
(5) [PF 4919] 5/8’’ x 6’’ x 36’’
(2) [PF 4918] 5/8’’ x 6’’ x 30’’
(2) [PF 4917] 5/8’’ x 6’’ x 27’’
(8) [PF 4916] 5/8’’ x 6’’ x 20’’
(1) [PF 4915] 5/8’’ x 6’’ x 17-7/8’’
(1) [PF 4909] 5/8’’ x 6’’ x 17-7/8’’
(8) [PF 4914] 5/8’’ x 6’’ x 12-7/8’’
(2) [PF 4904] 5/8’’ x 3’’ x 14-3/4’’
(6) [PF 4940] 1-1/2’’ x 1-5/8’’ x 35-1/2’’
(3) [PF 4939] 1-1/2’’ x 1-5/8’’ x 30’’
(1) [PF 4946] 1-1/2’’ x 1-5/8’’ x 27’’
(2) [PF 4938] 1-1/2’’ x 1-5/8’’ x 10-1/4’’
(1) [PF 4338] 2’’ x 2’’ x 17’’ SLIDE STAKE
(1) [PF 4922] 5/4’’ x 6’’ x 47’’
(3) [PF 4935] 5/4’’ x 6’’ x 44’’
(2) 4’’ x 4’’ x 120’’
(6) 4’’ x 4’’ x 96’’ LUMBER PURCHASED SEPARATELY
(5) [PF 4944] 2’’ x 4’’ x 47-1/2’’
(2) [PF 4943] 2’’ x 4’’ x 27’’
(1) [PF 4942] 2’’ x 4’’ x 17-1/2’’
(2) [PF 4941] 2’’ x 4’’ x 11’’
(4) [PF 4933] 5/4’’ x 4’’ x 47-1/2’’
(4) [PF 4931] 5/4’’ x 4’’ x 40-1/2’’
(4) [PF 4930] 5/4’’ x 4’’ x 40-1/4’’
(4) [PF 4903] 5/4’’ x 4’’ x 10-1/2’’
(2) [PF 4929] 1’’ x 4’’ x 47-1/2’’
(2) [PF 4932] 1’’ x 4’’ x 42-7/8’’
(2) [PF 4928] 1’’ x 4’’ x 45-3/4’’
(2) [PF 4926] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4927] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4925] 1’’ x 4’’ x 25-1/4’’
(4) [PF 4913] 5/8’’ x 4’’ x 47-1/2’’
(1) [PF 4912] 5/8’’ x 4’’ x 43-1/4’’
(2) [PF 4911] 5/8’’ x 4’’ x 42’’
(2) [PF 4908] 5/8’’ x 4’’ x 27’’
(4) [PF 4907] 5/8’’ x 4’’ x 12-7/8’’
(2) [PF 4906] 5/8’’ x 4’’ x 12-3/8’’
(2) [PF 4905] 5/8’’ x 4’’ x 10-1/2’’
(2) [PF 4910] 5/8’’ x 4’’ x 4-1/4’’
(1) [PF 4936] 5/4’’ x 6’’ x 47’’
(7) [PF 4937] 5/4’’ x 6’’ x 47-1/2’’
(1) [PF 4923] 5/8’’ x 6’’ x 47-1/2’’
(1) [PF 4924] 5/8’’ x 6’’ x 47-1/2’’
(2) [PF 4921] 5/8’’ x 6’’ x 42’’
(8) [PF 4920] 5/8’’ x 6’’ x 40-1/2’’
(5) [PF 4919] 5/8’’ x 6’’ x 36’’
(2) [PF 4918] 5/8’’ x 6’’ x 30’’
(2) [PF 4917] 5/8’’ x 6’’ x 27’’
(8) [PF 4916] 5/8’’ x 6’’ x 20’’
(1) [PF 4915] 5/8’’ x 6’’ x 17-7/8’’
(1) [PF 4909] 5/8’’ x 6’’ x 17-7/8’’
(8) [PF 4914] 5/8’’ x 6’’ x 12-7/8’’
(2) [PF 4904] 5/8’’ x 3’’ x 14-3/4’’
(6) [PF 4940] 1-1/2’’ x 1-5/8’’ x 35-1/2’’
(3) [PF 4939] 1-1/2’’ x 1-5/8’’ x 30’’
(1) [PF 4946] 1-1/2’’ x 1-5/8’’ x 27’’
(2) [PF 4938] 1-1/2’’ x 1-5/8’’ x 10-1/4’’
(1) [PF 4338] 2’’ x 2’’ x 17’’ SLIDE STAKE
(1) [PF 4922] 5/4’’ x 6’’ x 47’’
(3) [PF 4935] 5/4’’ x 6’’ x 44’’
(2) 4’’ x 4’’ x 120’’
(6) 4’’ x 4’’ x 96’’ LUMBER PURCHASED SEPARATELY
(5) [PF 4944] 2’’ x 4’’ x 47-1/2’’
(2) [PF 4943] 2’’ x 4’’ x 27’’
(1) [PF 4942] 2’’ x 4’’ x 17-1/2’’
(2) [PF 4941] 2’’ x 4’’ x 11’’
(4) [PF 4933] 5/4’’ x 4’’ x 47-1/2’’
(4) [PF 4931] 5/4’’ x 4’’ x 40-1/2’’
(4) [PF 4930] 5/4’’ x 4’’ x 40-1/4’’
(4) [PF 4903] 5/4’’ x 4’’ x 10-1/2’’
(2) [PF 4929] 1’’ x 4’’ x 47-1/2’’
(2) [PF 4932] 1’’ x 4’’ x 42-7/8’’
(2) [PF 4928] 1’’ x 4’’ x 45-3/4’’
(2) [PF 4926] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4927] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4925] 1’’ x 4’’ x 25-1/4’’
(4) [PF 4913] 5/8’’ x 4’’ x 47-1/2’’
(1) [PF 4912] 5/8’’ x 4’’ x 43-1/4’’
(2) [PF 4911] 5/8’’ x 4’’ x 42’’
(2) [PF 4908] 5/8’’ x 4’’ x 27’’
(4) [PF 4907] 5/8’’ x 4’’ x 12-7/8’’
(2) [PF 4906] 5/8’’ x 4’’ x 12-3/8’’
(2) [PF 4905] 5/8’’ x 4’’ x 10-1/2’’
(2) [PF 4910] 5/8’’ x 4’’ x 4-1/4’’
(1) [PF 4936] 5/4’’ x 6’’ x 47’’
(7) [PF 4937] 5/4’’ x 6’’ x 47-1/2’’
(1) [PF 4923] 5/8’’ x 6’’ x 47-1/2’’
(1) [PF 4924] 5/8’’ x 6’’ x 47-1/2’’
(2) [PF 4921] 5/8’’ x 6’’ x 42’’
(8) [PF 4920] 5/8’’ x 6’’ x 40-1/2’’
(5) [PF 4919] 5/8’’ x 6’’ x 36’’
(2) [PF 4918] 5/8’’ x 6’’ x 30’’
(2) [PF 4917] 5/8’’ x 6’’ x 27’’
(8) [PF 4916] 5/8’’ x 6’’ x 20’’
(1) [PF 4915] 5/8’’ x 6’’ x 17-7/8’’
(1) [PF 4909] 5/8’’ x 6’’ x 17-7/8’’
(8) [PF 4914] 5/8’’ x 6’’ x 12-7/8’’
(2) [PF 4904] 5/8’’ x 3’’ x 14-3/4’’
(6) [PF 4940] 1-1/2’’ x 1-5/8’’ x 35-1/2’’
(3) [PF 4939] 1-1/2’’ x 1-5/8’’ x 30’’
(1) [PF 4946] 1-1/2’’ x 1-5/8’’ x 27’’
(2) [PF 4938] 1-1/2’’ x 1-5/8’’ x 10-1/4’’
(1) [PF 4338] 2’’ x 2’’ x 17’’ SLIDE STAKE
(1) [PF 4922] 5/4’’ x 6’’ x 47’’
(3) [PF 4935] 5/4’’ x 6’’ x 44’’
(2) 4’’ x 4’’ x 120’’
(6) 4’’ x 4’’ x 96’’ LUMBER PURCHASED SEPARATELY
(5) [PF 4944] 2’’ x 4’’ x 47-1/2’’
(2) [PF 4943] 2’’ x 4’’ x 27’’
(1) [PF 4942] 2’’ x 4’’ x 17-1/2’’
(2) [PF 4941] 2’’ x 4’’ x 11’’
(4) [PF 4933] 5/4’’ x 4’’ x 47-1/2’’
(4) [PF 4931] 5/4’’ x 4’’ x 40-1/2’’
(4) [PF 4930] 5/4’’ x 4’’ x 40-1/4’’
(4) [PF 4903] 5/4’’ x 4’’ x 10-1/2’’
(2) [PF 4929] 1’’ x 4’’ x 47-1/2’’
(2) [PF 4932] 1’’ x 4’’ x 42-7/8’’
(2) [PF 4928] 1’’ x 4’’ x 45-3/4’’
(2) [PF 4926] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4927] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4925] 1’’ x 4’’ x 25-1/4’’
(4) [PF 4913] 5/8’’ x 4’’ x 47-1/2’’
(1) [PF 4912] 5/8’’ x 4’’ x 43-1/4’’
(2) [PF 4911] 5/8’’ x 4’’ x 42’’
(2) [PF 4908] 5/8’’ x 4’’ x 27’’
(4) [PF 4907] 5/8’’ x 4’’ x 12-7/8’’
(2) [PF 4906] 5/8’’ x 4’’ x 12-3/8’’
(2) [PF 4905] 5/8’’ x 4’’ x 10-1/2’’
(2) [PF 4910] 5/8’’ x 4’’ x 4-1/4’’
(1) [PF 4936] 5/4’’ x 6’’ x 47’’
(7) [PF 4937] 5/4’’ x 6’’ x 47-1/2’’
(1) [PF 4923] 5/8’’ x 6’’ x 47-1/2’’
(1) [PF 4924] 5/8’’ x 6’’ x 47-1/2’’
(2) [PF 4921] 5/8’’ x 6’’ x 42’’
(8) [PF 4920] 5/8’’ x 6’’ x 40-1/2’’
(5) [PF 4919] 5/8’’ x 6’’ x 36’’
(2) [PF 4918] 5/8’’ x 6’’ x 30’’
(2) [PF 4917] 5/8’’ x 6’’ x 27’’
(8) [PF 4916] 5/8’’ x 6’’ x 20’’
(1) [PF 4915] 5/8’’ x 6’’ x 17-7/8’’
(1) [PF 4909] 5/8’’ x 6’’ x 17-7/8’’
(8) [PF 4914] 5/8’’ x 6’’ x 12-7/8’’
(2) [PF 4904] 5/8’’ x 3’’ x 14-3/4’’
(6) [PF 4940] 1-1/2’’ x 1-5/8’’ x 35-1/2’’
(3) [PF 4939] 1-1/2’’ x 1-5/8’’ x 30’’
(1) [PF 4946] 1-1/2’’ x 1-5/8’’ x 27’’
(2) [PF 4938] 1-1/2’’ x 1-5/8’’ x 10-1/4’’
(1) [PF 4338] 2’’ x 2’’ x 17’’ SLIDE STAKE
(1) [PF 4922] 5/4’’ x 6’’ x 47’’
(3) [PF 4935] 5/4’’ x 6’’ x 44’’
(2) 4’’ x 4’’ x 120’’
(6) 4’’ x 4’’ x 96’’ LUMBER PURCHASED SEPARATELY
(5) [PF 4944] 2’’ x 4’’ x 47-1/2’’
(2) [PF 4943] 2’’ x 4’’ x 27’’
(1) [PF 4942] 2’’ x 4’’ x 17-1/2’’
(2) [PF 4941] 2’’ x 4’’ x 11’’
(4) [PF 4933] 5/4’’ x 4’’ x 47-1/2’’
(4) [PF 4931] 5/4’’ x 4’’ x 40-1/2’’
(4) [PF 4930] 5/4’’ x 4’’ x 40-1/4’’
(4) [PF 4903] 5/4’’ x 4’’ x 10-1/2’’
(2) [PF 4929] 1’’ x 4’’ x 47-1/2’’
(2) [PF 4932] 1’’ x 4’’ x 42-7/8’’
(2) [PF 4928] 1’’ x 4’’ x 45-3/4’’
(2) [PF 4926] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4927] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4925] 1’’ x 4’’ x 25-1/4’’
(4) [PF 4913] 5/8’’ x 4’’ x 47-1/2’’
(1) [PF 4912] 5/8’’ x 4’’ x 43-1/4’’
(2) [PF 4911] 5/8’’ x 4’’ x 42’’
(2) [PF 4908] 5/8’’ x 4’’ x 27’’
(4) [PF 4907] 5/8’’ x 4’’ x 12-7/8’’
(2) [PF 4906] 5/8’’ x 4’’ x 12-3/8’’
(2) [PF 4905] 5/8’’ x 4’’ x 10-1/2’’
(2) [PF 4910] 5/8’’ x 4’’ x 4-1/4’’
(1) [PF 4936] 5/4’’ x 6’’ x 47’’
(7) [PF 4937] 5/4’’ x 6’’ x 47-1/2’’
(1) [PF 4923] 5/8’’ x 6’’ x 47-1/2’’
(1) [PF 4924] 5/8’’ x 6’’ x 47-1/2’’
(2) [PF 4921] 5/8’’ x 6’’ x 42’’
(8) [PF 4920] 5/8’’ x 6’’ x 40-1/2’’
(5) [PF 4919] 5/8’’ x 6’’ x 36’’
(2) [PF 4918] 5/8’’ x 6’’ x 30’’
(2) [PF 4917] 5/8’’ x 6’’ x 27’’
(8) [PF 4916] 5/8’’ x 6’’ x 20’’
(1) [PF 4915] 5/8’’ x 6’’ x 17-7/8’’
(1) [PF 4909] 5/8’’ x 6’’ x 17-7/8’’
(8) [PF 4914] 5/8’’ x 6’’ x 12-7/8’’
(2) [PF 4904] 5/8’’ x 3’’ x 14-3/4’’
(6) [PF 4940] 1-1/2’’ x 1-5/8’’ x 35-1/2’’
(3) [PF 4939] 1-1/2’’ x 1-5/8’’ x 30’’
(1) [PF 4946] 1-1/2’’ x 1-5/8’’ x 27’’
(2) [PF 4938] 1-1/2’’ x 1-5/8’’ x 10-1/4’’
(1) [PF 4338] 2’’ x 2’’ x 17’’ SLIDE STAKE
(1) [PF 4922] 5/4’’ x 6’’ x 47’’
(3) [PF 4935] 5/4’’ x 6’’ x 44’’
(2) 4’’ x 4’’ x 120’’
(6) 4’’ x 4’’ x 96’’ LUMBER PURCHASED SEPARATELY
(5) [PF 4944] 2’’ x 4’’ x 47-1/2’’
(2) [PF 4943] 2’’ x 4’’ x 27’’
(1) [PF 4942] 2’’ x 4’’ x 17-1/2’’
(2) [PF 4941] 2’’ x 4’’ x 11’’
(4) [PF 4933] 5/4’’ x 4’’ x 47-1/2’’
(4) [PF 4931] 5/4’’ x 4’’ x 40-1/2’’
(4) [PF 4930] 5/4’’ x 4’’ x 40-1/4’’
(4) [PF 4903] 5/4’’ x 4’’ x 10-1/2’’
(2) [PF 4929] 1’’ x 4’’ x 47-1/2’’
(2) [PF 4932] 1’’ x 4’’ x 42-7/8’’
(2) [PF 4928] 1’’ x 4’’ x 45-3/4’’
(2) [PF 4926] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4927] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4925] 1’’ x 4’’ x 25-1/4’’
(4) [PF 4913] 5/8’’ x 4’’ x 47-1/2’’
(1) [PF 4912] 5/8’’ x 4’’ x 43-1/4’’
(2) [PF 4911] 5/8’’ x 4’’ x 42’’
(2) [PF 4908] 5/8’’ x 4’’ x 27’’
(4) [PF 4907] 5/8’’ x 4’’ x 12-7/8’’
(2) [PF 4906] 5/8’’ x 4’’ x 12-3/8’’
(2) [PF 4905] 5/8’’ x 4’’ x 10-1/2’’
(2) [PF 4910] 5/8’’ x 4’’ x 4-1/4’’
(1) [PF 4936] 5/4’’ x 6’’ x 47’’
(7) [PF 4937] 5/4’’ x 6’’ x 47-1/2’’
(1) [PF 4923] 5/8’’ x 6’’ x 47-1/2’’
(1) [PF 4924] 5/8’’ x 6’’ x 47-1/2’’
(2) [PF 4921] 5/8’’ x 6’’ x 42’’
(8) [PF 4920] 5/8’’ x 6’’ x 40-1/2’’
(5) [PF 4919] 5/8’’ x 6’’ x 36’’
(2) [PF 4918] 5/8’’ x 6’’ x 30’’
(2) [PF 4917] 5/8’’ x 6’’ x 27’’
(8) [PF 4916] 5/8’’ x 6’’ x 20’’
(1) [PF 4915] 5/8’’ x 6’’ x 17-7/8’’
(1) [PF 4909] 5/8’’ x 6’’ x 17-7/8’’
(8) [PF 4914] 5/8’’ x 6’’ x 12-7/8’’
(2) [PF 4904] 5/8’’ x 3’’ x 14-3/4’’
(6) [PF 4940] 1-1/2’’ x 1-5/8’’ x 35-1/2’’
(3) [PF 4939] 1-1/2’’ x 1-5/8’’ x 30’’
(1) [PF 4946] 1-1/2’’ x 1-5/8’’ x 27’’
(2) [PF 4938] 1-1/2’’ x 1-5/8’’ x 10-1/4’’
(1) [PF 4338] 2’’ x 2’’ x 17’’ SLIDE STAKE
(1) [PF 4922] 5/4’’ x 6’’ x 47’’
(3) [PF 4935] 5/4’’ x 6’’ x 44’’
(2) 4’’ x 4’’ x 120’’
(6) 4’’ x 4’’ x 96’’ LUMBER PURCHASED SEPARATELY
(5) [PF 4944] 2’’ x 4’’ x 47-1/2’’
(2) [PF 4943] 2’’ x 4’’ x 27’’
(1) [PF 4942] 2’’ x 4’’ x 17-1/2’’
(2) [PF 4941] 2’’ x 4’’ x 11’’
(4) [PF 4933] 5/4’’ x 4’’ x 47-1/2’’
(4) [PF 4931] 5/4’’ x 4’’ x 40-1/2’’
(4) [PF 4930] 5/4’’ x 4’’ x 40-1/4’’
(4) [PF 4903] 5/4’’ x 4’’ x 10-1/2’’
(2) [PF 4929] 1’’ x 4’’ x 47-1/2’’
(2) [PF 4932] 1’’ x 4’’ x 42-7/8’’
(2) [PF 4928] 1’’ x 4’’ x 45-3/4’’
(2) [PF 4926] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4927] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4925] 1’’ x 4’’ x 25-1/4’’
(4) [PF 4913] 5/8’’ x 4’’ x 47-1/2’’
(1) [PF 4912] 5/8’’ x 4’’ x 43-1/4’’
(2) [PF 4911] 5/8’’ x 4’’ x 42’’
(2) [PF 4908] 5/8’’ x 4’’ x 27’’
(4) [PF 4907] 5/8’’ x 4’’ x 12-7/8’’
(2) [PF 4906] 5/8’’ x 4’’ x 12-3/8’’
(2) [PF 4905] 5/8’’ x 4’’ x 10-1/2’’
(2) [PF 4910] 5/8’’ x 4’’ x 4-1/4’’
(1) [PF 4936] 5/4’’ x 6’’ x 47’’
(7) [PF 4937] 5/4’’ x 6’’ x 47-1/2’’
(1) [PF 4923] 5/8’’ x 6’’ x 47-1/2’’
(1) [PF 4924] 5/8’’ x 6’’ x 47-1/2’’
(2) [PF 4921] 5/8’’ x 6’’ x 42’’
(8) [PF 4920] 5/8’’ x 6’’ x 40-1/2’’
(5) [PF 4919] 5/8’’ x 6’’ x 36’’
(2) [PF 4918] 5/8’’ x 6’’ x 30’’
(2) [PF 4917] 5/8’’ x 6’’ x 27’’
(8) [PF 4916] 5/8’’ x 6’’ x 20’’
(1) [PF 4915] 5/8’’ x 6’’ x 17-7/8’’
(1) [PF 4909] 5/8’’ x 6’’ x 17-7/8’’
(8) [PF 4914] 5/8’’ x 6’’ x 12-7/8’’
(2) [PF 4904] 5/8’’ x 3’’ x 14-3/4’’
(6) [PF 4940] 1-1/2’’ x 1-5/8’’ x 35-1/2’’
(3) [PF 4939] 1-1/2’’ x 1-5/8’’ x 30’’
(1) [PF 4946] 1-1/2’’ x 1-5/8’’ x 27’’
(2) [PF 4938] 1-1/2’’ x 1-5/8’’ x 10-1/4’’
(1) [PF 4338] 2’’ x 2’’ x 17’’ SLIDE STAKE
(1) [PF 4922] 5/4’’ x 6’’ x 47’’
(3) [PF 4935] 5/4’’ x 6’’ x 44’’
(2) 4’’ x 4’’ x 120’’
(6) 4’’ x 4’’ x 96’’ LUMBER PURCHASED SEPARATELY
(5) [PF 4944] 2’’ x 4’’ x 47-1/2’’
(2) [PF 4943] 2’’ x 4’’ x 27’’
(1) [PF 4942] 2’’ x 4’’ x 17-1/2’’
(2) [PF 4941] 2’’ x 4’’ x 11’’
(4) [PF 4933] 5/4’’ x 4’’ x 47-1/2’’
(4) [PF 4931] 5/4’’ x 4’’ x 40-1/2’’
(4) [PF 4930] 5/4’’ x 4’’ x 40-1/4’’
(4) [PF 4903] 5/4’’ x 4’’ x 10-1/2’’
(2) [PF 4929] 1’’ x 4’’ x 47-1/2’’
(2) [PF 4932] 1’’ x 4’’ x 42-7/8’’
(2) [PF 4928] 1’’ x 4’’ x 45-3/4’’
(2) [PF 4926] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4927] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4925] 1’’ x 4’’ x 25-1/4’’
(4) [PF 4913] 5/8’’ x 4’’ x 47-1/2’’
(1) [PF 4912] 5/8’’ x 4’’ x 43-1/4’’
(2) [PF 4911] 5/8’’ x 4’’ x 42’’
(2) [PF 4908] 5/8’’ x 4’’ x 27’’
(4) [PF 4907] 5/8’’ x 4’’ x 12-7/8’’
(2) [PF 4906] 5/8’’ x 4’’ x 12-3/8’’
(2) [PF 4905] 5/8’’ x 4’’ x 10-1/2’’
(2) [PF 4910] 5/8’’ x 4’’ x 4-1/4’’
(1) [PF 4936] 5/4’’ x 6’’ x 47’’
(7) [PF 4937] 5/4’’ x 6’’ x 47-1/2’’
(1) [PF 4923] 5/8’’ x 6’’ x 47-1/2’’
(1) [PF 4924] 5/8’’ x 6’’ x 47-1/2’’
(2) [PF 4921] 5/8’’ x 6’’ x 42’’
(8) [PF 4920] 5/8’’ x 6’’ x 40-1/2’’
(5) [PF 4919] 5/8’’ x 6’’ x 36’’
(2) [PF 4918] 5/8’’ x 6’’ x 30’’
(2) [PF 4917] 5/8’’ x 6’’ x 27’’
(8) [PF 4916] 5/8’’ x 6’’ x 20’’
(1) [PF 4915] 5/8’’ x 6’’ x 17-7/8’’
(1) [PF 4909] 5/8’’ x 6’’ x 17-7/8’’
(8) [PF 4914] 5/8’’ x 6’’ x 12-7/8’’
(2) [PF 4904] 5/8’’ x 3’’ x 14-3/4’’
(6) [PF 4940] 1-1/2’’ x 1-5/8’’ x 35-1/2’’
(3) [PF 4939] 1-1/2’’ x 1-5/8’’ x 30’’
(1) [PF 4946] 1-1/2’’ x 1-5/8’’ x 27’’
(2) [PF 4938] 1-1/2’’ x 1-5/8’’ x 10-1/4’’
(1) [PF 4338] 2’’ x 2’’ x 17’’ SLIDE STAKE
(1) [PF 4922] 5/4’’ x 6’’ x 47’’
(3) [PF 4935] 5/4’’ x 6’’ x 44’’
(2) 4’’ x 4’’ x 120’’
(6) 4’’ x 4’’ x 96’’ LUMBER PURCHASED SEPARATELY
(5) [PF 4944] 2’’ x 4’’ x 47-1/2’’
(2) [PF 4943] 2’’ x 4’’ x 27’’
(1) [PF 4942] 2’’ x 4’’ x 17-1/2’’
(2) [PF 4941] 2’’ x 4’’ x 11’’
(4) [PF 4933] 5/4’’ x 4’’ x 47-1/2’’
(4) [PF 4931] 5/4’’ x 4’’ x 40-1/2’’
(4) [PF 4930] 5/4’’ x 4’’ x 40-1/4’’
(4) [PF 4903] 5/4’’ x 4’’ x 10-1/2’’
(2) [PF 4929] 1’’ x 4’’ x 47-1/2’’
(2) [PF 4932] 1’’ x 4’’ x 42-7/8’’
(2) [PF 4928] 1’’ x 4’’ x 45-3/4’’
(2) [PF 4926] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4927] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4925] 1’’ x 4’’ x 25-1/4’’
(4) [PF 4913] 5/8’’ x 4’’ x 47-1/2’’
(1) [PF 4912] 5/8’’ x 4’’ x 43-1/4’’
(2) [PF 4911] 5/8’’ x 4’’ x 42’’
(2) [PF 4908] 5/8’’ x 4’’ x 27’’
(4) [PF 4907] 5/8’’ x 4’’ x 12-7/8’’
(2) [PF 4906] 5/8’’ x 4’’ x 12-3/8’’
(2) [PF 4905] 5/8’’ x 4’’ x 10-1/2’’
(2) [PF 4910] 5/8’’ x 4’’ x 4-1/4’’
(1) [PF 4936] 5/4’’ x 6’’ x 47’’
(7) [PF 4937] 5/4’’ x 6’’ x 47-1/2’’
(1) [PF 4923] 5/8’’ x 6’’ x 47-1/2’’
(1) [PF 4924] 5/8’’ x 6’’ x 47-1/2’’
(2) [PF 4921] 5/8’’ x 6’’ x 42’’
(8) [PF 4920] 5/8’’ x 6’’ x 40-1/2’’
(5) [PF 4919] 5/8’’ x 6’’ x 36’’
(2) [PF 4918] 5/8’’ x 6’’ x 30’’
(2) [PF 4917] 5/8’’ x 6’’ x 27’’
(8) [PF 4916] 5/8’’ x 6’’ x 20’’
(1) [PF 4915] 5/8’’ x 6’’ x 17-7/8’’
(1) [PF 4909] 5/8’’ x 6’’ x 17-7/8’’
(8) [PF 4914] 5/8’’ x 6’’ x 12-7/8’’
(2) [PF 4904] 5/8’’ x 3’’ x 14-3/4’’
(6) [PF 4940] 1-1/2’’ x 1-5/8’’ x 35-1/2’’
(3) [PF 4939] 1-1/2’’ x 1-5/8’’ x 30’’
(1) [PF 4946] 1-1/2’’ x 1-5/8’’ x 27’’
(2) [PF 4938] 1-1/2’’ x 1-5/8’’ x 10-1/4’’
(1) [PF 4338] 2’’ x 2’’ x 17’’ SLIDE STAKE
(1) [PF 4922] 5/4’’ x 6’’ x 47’’
(3) [PF 4935] 5/4’’ x 6’’ x 44’’
(2) 4’’ x 4’’ x 120’’
(6) 4’’ x 4’’ x 96’’ LUMBER PURCHASED SEPARATELY
(5) [PF 4944] 2’’ x 4’’ x 47-1/2’’
(2) [PF 4943] 2’’ x 4’’ x 27’’
(1) [PF 4942] 2’’ x 4’’ x 17-1/2’’
(2) [PF 4941] 2’’ x 4’’ x 11’’
(4) [PF 4933] 5/4’’ x 4’’ x 47-1/2’’
(4) [PF 4931] 5/4’’ x 4’’ x 40-1/2’’
(4) [PF 4930] 5/4’’ x 4’’ x 40-1/4’’
(4) [PF 4903] 5/4’’ x 4’’ x 10-1/2’’
(2) [PF 4929] 1’’ x 4’’ x 47-1/2’’
(2) [PF 4932] 1’’ x 4’’ x 42-7/8’’
(2) [PF 4928] 1’’ x 4’’ x 45-3/4’’
(2) [PF 4926] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4927] 1’’ x 4’’ x 31-1/2’’
(2) [PF 4925] 1’’ x 4’’ x 25-1/4’’
(4) [PF 4913] 5/8’’ x 4’’ x 47-1/2’’
(1) [PF 4912] 5/8’’ x 4’’ x 43-1/4’’
(2) [PF 4911] 5/8’’ x 4’’ x 42’’
(2) [PF 4908] 5/8’’ x 4’’ x 27’’
(4) [PF 4907] 5/8’’ x 4’’ x 12-7/8’’
(2) [PF 4906] 5/8’’ x 4’’ x 12-3/8’’
(2) [PF 4905] 5/8’’ x 4’’ x 10-1/2’’
(2) [PF 4910] 5/8’’ x 4’’ x 4-1/4’’
(1) [PF 4936] 5/4’’ x 6’’ x 47’’
(7) [PF 4937] 5/4’’ x 6’’ x 47-1/2’’
(1) [PF 4923] 5/8’’ x 6’’ x 47-1/2’’
(1) [PF 4924] 5/8’’ x 6’’ x 47-1/2’’
(2) [PF 4921] 5/8’’ x 6’’ x 42’’
(8) [PF 4920] 5/8’’ x 6’’ x 40-1/2’’
(5) [PF 4919] 5/8’’ x 6’’ x 36’’
(2) [PF 4918] 5/8’’ x 6’’ x 30’’
(2) [PF 4917] 5/8’’ x 6’’ x 27’’
(8) [PF 4916] 5/8’’ x 6’’ x 20’’
(1) [PF 4915] 5/8’’ x 6’’ x 17-7/8’’
(1) [PF 4909] 5/8’’ x 6’’ x 17-7/8’’
(8) [PF 4914] 5/8’’ x 6’’ x 12-7/8’’
(2) [PF 4904] 5/8’’ x 3’’ x 14-3/4’’
(6) [PF 4940] 1-1/2’’ x 1-5/8’’ x 35-1/2’’
(3) [PF 4939] 1-1/2’’ x 1-5/8’’ x 30’’
(1) [PF 4946] 1-1/2’’ x 1-5/8’’ x 27’’
(2) [PF 4938] 1-1/2’’ x 1-5/8’’ x 10-1/4’’
(1) [PF 4338] 2’’ x 2’’ x 17’’ SLIDE STAKE
(1) [PF 4922] 5/4’’ x 6’’ x 47’’
(3) [PF 4935] 5/4’’ x 6’’ x 44’’
LUMBER PURCHASED SEPARATELY
IF NO SLIDE IS PURCHASED
(To Close Off Slide Opening)
(1) 1’’ x 4’’ x 8’
(1) 5/4’’ x 6’’ x 10’

9
USE THE CORRECT FASTENER
Use the guides below to help select the correct length, quantity & location of
screws for the board installation.
Avoid splitting your lumber by offsetting your screws at least 3/4” from edge.
All hardware should be driven until ush with the surface or no deeper than 1/16”.
1x4 to 2x4 & 3x3
(3) 2-1/2” screws
per attachment point
1x4 to 1x4
(2) 30mm screws
per attachment point
English(*) Metric(Cm) English(*) Metric(Cm)
1x42.5x10.25/8x3-3/8 1.59x8.57
1x52.5x12.75/8x4-1/2 1.59x11.43
5/4x43.2x10.21x3-1/2 2.5x8.89
5/4x63.2x15.31x5-1/2 2.5x14
2x25x5 1-1/2x1-1/23.8x3.8
2x35x7.6 1-1/2x2-1/23.8x6.4
2x45x101-1/2x3-1/2 3.8x9
2x65x15.31-1/2x5-1/2 3.8x14
3x37.6x7.6
4x410x10 3-1/2x3-1/29x9
(*) Estimated Sizing Due to Cutting Process
NOMINAL MATERIAL SIZE
LISTED SIZE
TRUE SIZE
7.6x7.6
3x3

10
BRACKET INSTALLATION
4’’ x 4’’ Shelf-Loc bracket
12 3
CORRECT INCORRECT
2’’ x 4’’ Shelf-Loc bracket
12 3
CORRECT INCORRECT
Bracket mounting
1. Always use lag screws
2. Brackets interlock with each other. NEVER position them in a non-interlocking position.
3. Place lag screws in brackets only where instructed.
Do NOT ll in every hole as this will lead to a hardware shortage.
NOTCH

11
STEP 1
1. Attach brackets to posts as shown.
4’’ x 4’’ x 120’’ 4’’ x 4’’ x 120’’
47’’
59’’
(2) 1-1/4” Lag Screws
per bracket
1-1/4” Lag Screw (x8)
FRAME 1

12
STEP 2
1. Assemble Frame 1 as shown. Note the bracket orientation.
2-1/2” Deck Screw (x12)
Check to make sure
structure is square FRAME 1
[PF 4924] 5/8’’ x 6’’ x 47-1/2’’
[PF 4933] 5/4’’ x 4’’ x 47-1/2’’
108’’ 103-1/2’’
4’’ x 4’’ x 120’’
4’’ x 4’’ x 120’’
(3) 2-1/2’’
Screw
Per Joint
FLUSH
47-1/2’’

13
STEP 3
1. Attach support board to Frame 1 as shown.
Check to make sure
structure is square
FRAME 1
(3) 1-1/4” Lag & (2) 2” Lag
per 2x4 Shelf Loc bracket
[PF 4944] 2’’ x 4’’ x 47-1/2’’
FLIP
FRAME
OVER
2” Lag Screw (x4) 1-1/4” Lag Screw (x6)
47-1/2’’
FLUSH

14
STEP 4
4’’ x 4’’ x 96’’ 4’’ x 4’’ x 96’’
59’’
(2) 1-1/4” Lag Screws
per bracket
1-1/4” Lag Screw (x4)
FLUSH
2” Lag Screw (x4)
Gap
(2) 2” Lag Screws
per bracket
1. Attach brackets to posts as shown.
FRAME 2

15
STEP 5
96’’
3-1/8’’
9-3/8’’
9-3/8’’
3-1/8’’
12-1/2’’
21-7/8’’
1. Drill (3) 3/8’’ holes in (1) 4’’ x 4’’ x 96’’ as shown. This will be
used as the tower accessory arm.
CENTER
HOLES
CENTER
HOLES

16
STEP 6
1. Assemble Frame 2 as shown. Note the bracket orientation.
2-1/2” Deck Screw (x12)
Check to make sure
structure is square FRAME 2
[PF 4929] 1’’ x 4’’ x 47-1/2’’
4’’ x 4’’ x 96’’
62-1/2’’
[PF 4913] 5/8’’ x 4’’ x 47-1/2’’
4’’ x 4’’ x 96’’
4’’ x 4’’ x 96’’
(4) 2” Lag per
4x4 Shelf Loc bracket
TIP: Flex bracket(s) to make
installation of 4x4 easier
2” Lag Screw (x8)
NOTE HOLE PLACEMENT
(3) 2-1/2’’
Screw
Per Joint
1’’
47-1/2’’
FLUSH
FLUSH

17
STEP 7
1. Attach support board to Frame 2 as shown.
FRAME 2
(3) 1-1/4” Lag & (2) 2” Lag
per 2x4 Shelf Loc bracket
[PF 4944] 2’’ x 4’’ x 47-1/2’’
FLIP
FRAME
OVER
2” Lag Screw (x4) 1-1/4” Lag Screw (x6)
FLUSH

18
STEP 8
1. Attach support boards to Frame 1 as shown.
2-1/2” Deck Screw (x10)
[PF 4928] 1’’ x 4’’ x 45-3/4’’
[PF 4928] 1’’ x 4’’ x 45-3/4’’
[PF 4913] 5/8’’ x 4’’ x 47-1/2’’
[PF 4913] 5/8’’ x 4’’ x 47-1/2’’
1-3/4’’
1-3/4’’
(3) 2-1/2’’
Screw
(3) 2-1/2’’
Screw
(2) 2-1/2’’
Screw
(2) 2-1/2’’
Screw
FRAME 1
Check to make sure
structure is square
62-1/2’’
FLUSH

19
STEP 9
1. Attach Frame 1 to Frame 2 as shown.
2-1/2” Deck Screw (x12)
(3) 2-1/2’’
Screw
(3) 2-1/2’’
Screw
FRAME 1
FRAME 2
(3) 2-1/2’’
Screw
(3) 2-1/2’’
Screw
47-1/2’’

20
STEP 10
1. Attach boards as shown.
2-1/2” Deck Screw (x8)
(2) 2-1/2’’
Screw
per joint
[PF 4931] 5/4’’ x 4’’ x 40-1/2’’
[PF 4931] 5/4’’ x 4’’ x 40-1/2’’
(2) 2-1/2’’
Screw
per joint