Turboair TGM-14RV User manual

GLASS DOOR
MERCHANDISER
INSTRUCTION MANUAL
Model No.: TGM-14RV
TGM-14CRV
Castors are applied to TGM-14CRV model.
How to install the castor and castor brake : Refer to page 3.
Before operating this unit, please read these instructions completely.
SHELF
BOTTOM
GRILL DOOR
ASSEMBLY
HINGE*UNDER
CONDENSER
FAN
CONDENSER
ADJUSTABLE
FOOT
ADVERTISING
PANEL
FLUORESCENT
LAMP
EXIT HOLE OF
COLD AIR
EVAPORATOR FAN
EVAPORATOR
INDUCTION
HOLE OF
COLD AIR
DRAIN PAN
COMPRESSOR
FLUORESCENT
LAMP (25W)
HINGE*TOP
HANDLE
FEATURE CHART
FRONT SIDE

2
HOW TO INSTALL
■ In good ventilation.
• Place the refrigerator in a
well ventilated area for
better cooling.
• Temperature of room
should be less than 90°F
degrees.
■ Install the refrigerator
indoors only.
• The refrigerator should not
get wet.
■ Install the refrigerator on
the places with 41~95°F.
• Do not set temperature
control too cold. Food may
freeze and soda containers
may burst.
■ Place the refrigerator on
hard and level floor.
• Unlevel floor may cause the
refrigerator to make noise.
■ Avoid places that are
exposed to smoke.
• Discoloring can occur to the
refrigerator.
■ Set the front of the
refrigerator a little bit
higher than back-side by
using adjustable feet to
drain the water away with
easily.
■ Put away heat source from
the refrigerator.
• High ambient temperature
will make cooling efficiency
lower.
■ Place the refrigerator in an
area with low moisture.
• Splashing water or a high
moisture area may cause
short circuit and make
rusting easier.
■ Ajust the temperature in
the refrigerator.
• Temperature control is
located on top right side.
1
2
3
45
6
OFF
TEMP
CONTROLLER
Set the front
side higher than
back side.
Install
at the degree
of 41~95°F

3
1) Screw the castor (in rear side) and the castor brakes (in front side) by using castor wrench.
2) Use the castor shims to level the cabinet, if necessary, by inserting them to stems of the castors.
INSTALLATION OF CASTOR AND CASTOR BRAKE
ROTATION
CASTOR (WITH BRAKE)(2EA)
CASTOR SHIM(4EA)
CASTOR(2EA)
Model : TGM-14CRV

4
■ Cleaning the interior and exterior
• Wash with warm soapy water and rinse with
wet cloth.
• Wipe with dry cloth.
• Clean gasket frequently.
• Wash shelves with water.
• If unit has dew drops on exterior, wipe away
with dry cloth. This tends to happen in the
rainy season.
■ Compressor
• A dirty condenser will not let unit cool
efficiently. Clean the condenser every three
months by using a brush or vacuum cleaner.
• Especially, be sure to clean the condensor
before reoperating, after a long period of non-
operation.
■ Condenser filter
• Take out the filter and clean it with brush or
water 1~2 times a month.
■ Check points after cleaning
• Check again the refrigerator for safety.
• Do not plug the power cord with wet hands.
• Check for noise or unit not getting cold.
■ Caution
• Unplug the power cord before cleaning.
• Clean the refrigerator periodically.
• Do not use the abrasive cleaners, solvents or
polishing agents on plastic parts. These
cleansers may cause cracking or discoloring.
■ Drainage
• Take out the bottom grill to empty the tray.
• Clean it at least once in 2days.
(in rainy season, it needs everyday.)
CLEANING

5
■ Ventilation
- Place the unit in a well ventilated area.
- Keep the cabinet 4” from rear wall.
■ Start-up
- Plug the power cord into the wall outlet.
- The outlet should be only for the refrigerator.
- The temperature controller should be on
normal position.
- If disconnected, shut down, wait 5 minutes
before re-starting it.
■ Warning
- Warranty will be voided if the following is
found.
• Low voltage to unit. Should be 115V/60Hz.
• Power cord should not be more than 7 feet
long from plug in connection to compressor.
• Multiple units plugged into same circuit.
• On extension cord.
■ Temperature control
- To keep the temperature down : Turn the dial
by CLOCK-WISE.
- To keep the temperaure up : Turn the dial by
COUNTER-CLOCK-WISE.
CAUTION
■ Before you operate the unit.
Please unscrew the Bottom grill and take out the pad in the Drain pan.
BOTTOM GRILL
DRAIN PAN
PAD