Turboair JUR-36 User manual

Turbo Air Speed up the Pace of Innovation
Refrigerator
Freezer
Installation and Operation Manual
CAUTION!
PLEASE KEEP POWER
SWITCH ON BEFORE
OPERATING THIS EQUIPMENT
Please read this manual completely before attempting to install or operate this equipment!
SOLID DUAL TEMPERATURE
JRF-19 JRF-45
SALAD TABLE (WITHOUT HOOD)
JBT-36 JBT-48
JBT-60 JBT-72
UNDERCOUNTER
REFRIGERATOR / FREEZER
JUR-36 JUF-36
JUR-48 JUF-48
JUR-60 JUF-60
JUR-72
www.turboairinc.com

2
CONTENTS
AFTER SLAE SERVICE
CHECK THE FOLLOWS BEFORE REQUESTING SERVICE
1. THE INTRODUCTION 2
2. PART NAME AND FUNCTION
UP-RIGHT
SALAD/UNDERCOUNTER
3-4
5-7
8-11
12
13
13
14
3. CAUTION
4. INSTALLATION AND OPERATION
INSTALLATION NOTE
CLEANING
BEFORE REQUESTING SERVICE
PRECAUTIONS
PAGE
THE GUIDE OF AFTER SALE SERVICE
1. UNDER WARRANTY : The unit is not covered by this warranty...
- Condenser is dirty - The product isn’t set correctly
- Incorrect Operation - Unauthorized service
2. OUT OF WARRANTY : We will repair the unit with pay by your needs.
Please consult with the after sale service for details.
• The unit has the data label, the serial number is in the left side of unit.
• Purchasing date
• Trouble (Detail)
• Your address, name, phone
• Your free time
15-16
5. WARRANTY

3
PART NAME AND FUNCTION

4
DISPLAY PANEL OF DUAL TEMP

5
PART NAME AND FUNCTION

6
DISPLAY PANEL OF REFRIGERATOR

7
DISPLAY PANEL OF FREEZER

8
CAUTION

9
CAUTION

10
CAUTION

11
CAUTION

12
INSTALLATION AND OPERATION

13
INSTALLATION AND OPERATION

14
INSTALLATION AND OPERATION

15
MANUFACTURING COMPANY
Turbo air warrants to the original purchaser of every new-Turbo air refrigerated unit, the cabinet and all parts thereof, to be
free from defects in material or workmanship, under normal use and service, for a period of one (1) year from the date of
original installation or 15 months after shipment date from Turbo air , whichever occurs first.
Any parts covered by this warranty that are examined and determined by Turbo air to have been defective within one (1)
year of original installation or fifteen (15) months after shipment date from manufacturer, whichever occurs first, shall be
repaired or replaced as stated below. Turbo air shall be deemed to have fully complied with its obligation under the
foregoing warranties by electing either one of the following procedures, at the sole discretion of Turbo air.
1. Furnishing a replacement part, freight collect, in even exchange for the returned part, freight collect.
2. Receiving the defective part, freight collect; repairing it; and returning it, freight collect.
In addition to the (1) one year warranty stated above, Turbo air warrants its hermetically and semi-hermetically sealed
compressor to be free from defects in both material and workmanship under normal use and service for a period of four (4)
additional years from the date of original installation but not to exceed five (5) years and three (3) months after shipment
from manufacturer.
Compressors determined by Turbo air have been defective within this extended time period will, at Turbo airʼs option, be
either repaired or replaced with a compressor or compressor parts of similar design and capacity.
The four (4) year extended compressor warranty applies only to hermetically and semi-hermetically sealed parts of the
compressor and does not apply to any other parts or components, including, but not limited to, cabinet, paint finish,
temperature control, refrigerant, metering device, driers, motor starting equipment, fan assembly any other electrical
component, etc.
The four year compressor warranty detailed above will be voided if the following procedure is not carefully adhered to:
1. This system contains R134A (R404A) refrigerant and polyol ester lubricant. The Poyol ester lubricant has rapid moisture
absorbing qualities. If long exposure to the ambient conditions occur, the lubricant must be removed and replaced with
new. Listed below are the approved lubricants for the Tecumseh compressors.
1. ICI-Emkarate RL 184
2. Emery-2927-A
3. Mobile Artic 22A
Failure to comply with recommended lubricant specification will void the compressor warranty.
2. Dryer replacement is very important and must be changed when a system is opened for servicing. Dryer must be used
with XH-9 desiccant.
3. Micron level vacuums must be achieved to insure low moisture levels in the system. 500 microns or lower must be
obtained.
TURBO AIR MANUFACTURING COMPANY CARSON, CA 90746, Plant Incheon R.O.K
(Name of Company purchasing cooler)
(Type of Business) (City and State of Purchaser)
(Model No. of Cooler) (Cabinet Serial Number) (Compressor Serial Number)
This is to inform TURBO AIR MANUFACTURING COMMPANY that I,
(Signature of individual who owns a Business)
have had the above TURBO AIR COOLER installed in my place of business
(Installation date)
The above warranties are in effect from this installation date, or 90 days after shipment from TURBO AIR, whichever comes first.
MANUFACTURING COMPANY
WARRANTY
REGISTRATION
CARD
MANUFACTURING COMPANY
MAIL CARD
IMMEDIATELY
This card must be
mailed immediately
after installation
date for warranty to
be in effect.
ONE YEAR WARRANTY
ADDITIONAL FOUR YEAR COMPRESSOR WARRANTY
134A (404A) COMPRESSOR WARRANTY

16
WHAT IS NOT COVERED BY THIS WARRANTY
Turbo airʼs obligation under warranty is limited to either repair or replacement of parts, subject to the additional limitations
below. This warranty neither assumes nor authorizes any person to assume obligations other than expressly covered by
this warranty.
1. WARRANTY IS NOT TRANSFERABLE. This warranty is not assignable and applies in favor of the original
purchaser/user to whom delivered. Any such assignment or transfer shall void the warranties herein made and shall void
all warranties, express or implied, including any warranty of merchantability or fitness for a particular purpose.
2. NO CONSEQUENTIAL DAMAGES. Turbo air is not responsible for economic loss: profit loss or special, indirect, or
consequential damages, including without limitation, losses or damages arising from food or product spoilage claims
whether or not on account of refrigeration failure.
3. ALTERATION, NEGLECT, ABUSE, MISUSE, ACCIDENT, DAMAGE DURING TRANSIT OR INSTALLATION, FIRE,
FLOOD, ACTS OF GOD. Trubo air is not responsible for the repair or replacement of any parts that Turbo Air determines
have been subjected after the date of manufacture to alteration, neglect, abuse, misuse, accident, damage during transit
or installation, fire, flood, or an Act of God.
4. NO IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. There are no
other warranties, express, implied or statutory, except the one(1) year warranty and the additional four(4) year
compressor warranty as described above. These warranties are exclusive and in lieu of all other warranties, including
implied warranty and merchantability or fitness for a particular purpose. There are no warranties which extend beyond the
description on the face hereof.
5. TRANSPORTATION COSTS. Turbo Air will accept parts covered under this warranty freight collect, provided that
shipment has received prior approval. Turbo Air is not responsible for any other transporation costs, but will ship freight
collect parts either repaired or replaced under these warranties.
6. WARRANTY CLAIMS. All claims should include: model number of the cooler, the serial number of the cabinet, proof of
purchase, date of installation, and all pertinent information supporting the existence of the alleged defect. Any action or
breach of these warranty provisions must be commenced within one (1) year after that cause of action has accused.
1250 Victoria street
CARSON, CA 90746
TEL: [phone]
FAX: [phone]
Toll Free: 1-800-627-0032
(U.S.A. In Canada)
http://www.turboairinc.com