WESTERSTRAND LED190 BASIC User manual

WESTERSTRAND SPORTSYSTEM
Dokument:
4253en08.docx
örfattare:
C
BASIC 190/250
Datum:
2019
-
11
-
19
Page:
1
av
18
Operation Instructions
WESTERSTRAND URFABRIK AB
Box 133 Tel. [phone] Internet: http://www.westerstrand.se
545 23 TÖREBODA ax. 0506 48051 E-Mail: [email protected]
Important Safeguards ........................................................................................................................................ 2
System Overview .............................................................................................................................................. 3
Sports ........................................................................................................................................................... 4
Remote Control............................................................................................................................................. 4
Scoreboard Layouts ..........................................................................................................................................
Module 1 ......................................................................................................................................................
Module 2 ...................................................................................................................................................... 7
Module 7 ...................................................................................................................................................... 7
Installation ........................................................................................................................................................ 8
Assembly of Scoreboards .............................................................................................................................. 8
Mounting of Shot Clock LED-stripes ............................................................................................................ 9
Connections ................................................................................................................................................ 10
Time and ID Settings .................................................................................................................................. 13
Startup and Configuration ............................................................................................................................... 16
Technical Specifications ................................................................................................................................. 17
Troubleshooting .............................................................................................................................................. 18
Cable Layings ................................................................................................................................................. 18
Operation Instructions
LED190/ 50 BASIC

WESTERSTRAND SPORTSYSTEM
Dokument:
4253en08.docx
örfattare:
C
BASIC 190/250
Datum:
2019
-
11
-
19
Page:
2
av
18
Operation Instructions
WESTERSTRAND URFABRIK AB
Box 133 Tel. [phone] Internet: http://www.westerstrand.se
545 23 TÖREBODA ax. 0506 48051 E-Mail: [email protected]
Important Safeguards
Read all these instructions and save them for later use
 Do not place this product on an unstable cart, stand or table. The product may fall, causing
serious damage to the product and/or person.
 Slots and openings in the cabinet and the back are provided for ventilation to ensure reliable
operation of the product and to protect it from overheating, these openings must not be
blocked or covered. This product should never be placed near or over a heat source. This
product should not be placed in a built-in installation unless proper ventilation is provided.
 Never push objects of any kind into this product through cabinet slots as they may touch
dangerous voltage points or short out parts that could result in a risk of fire or electric shock.
 f installation is required, it must only be done by appropriately skilled personnel. For
permanently installed equipment, a certified electrician must perform the installation.
 Except as explained elsewhere in the operating manual, do not attempt to service this product
yourself. Removing covers may expose you to dangerous voltage points or other risks. Refer
all servicing in those compartments to a service technician.
 Product that intents to be connected to mains as a permanent installation shall be connected
by a readily accessible safety switch.
 f the product is equipped with a plug (grounding type) this shall be connected to an outlet that
is intended for the product. The plug must be easy to disconnect without moving or dismantle
the product.

WESTERSTRAND SPORTSYSTEM
Dokument:
4253en08.docx
örfattare:
C
BASIC 190/250
Datum:
2019
-
11
-
19
Page:
3
av
18
Operation Instructions
WESTERSTRAND URFABRIK AB
Box 133 Tel. [phone] Internet: http://www.westerstrand.se
545 23 TÖREBODA ax. 0506 48051 E-Mail: [email protected]
System Overview
The BASIC system consists of a number of different modules that can be can be set up in different
combinations. The scoreboards are meant for indoor use. The most common add on modules are the penalty
module (Module 2), the foul module (Module 7) and the shot clocks (Module 4).
Module 7 Module 2 Module 2 Module 7
Home Home Module 1 Guest Guest
Module 4 Remote Control
 Module 1 and the remote control are the base of the system. The remote control is delivered with
preprogrammed rules for each sport. The scoreboard usually has an internal piezo siren but can also be
delivered with an external siren (Option). The system can be hardwired or controlled via radio.
 Module 2 is used to show penalties in sports like handball and ice hockey. Some versions can also be used to
show set results in sports like volleyball.
 Module 7 shows player number and foul dots for each player. There is also a version that shows player
results.
 Module 4, the shot clock, can be ordered with or without match clock. Shot clocks with match clock (FIBA
version) can also be connected to a LED-stripe. The shot clock is controlled by a handle that is connected
to the remote control.

WESTERSTRAND SPORTSYSTEM
Dokument:
4253en08.docx
örfattare:
C
BASIC 190/250
Datum:
2019
-
11
-
19
Page:
4
av
18
Operation Instructions
WESTERSTRAND URFABRIK AB
Box 133 Tel. [phone] Internet: http://www.westerstrand.se
545 23 TÖREBODA ax. 0506 48051 E-Mail: [email protected]
Sports
The remote control can be programmed with several sports, listed below. The sports are described in separate
manuals.
 Handball
 Basketball
 Basketball with player score
 Volleyball
 Futsal
 Tennis
 Table tennis
 Badminton
 Floorball
 Indoor Football
 Ice hockey
 Korfball
 Mini-Football
Remote Control
The remote control can be hardwired or control the scoreboard via radio.
The radio remote has an internal rechargeable lithium ion battery which can be charged with the included
battery eliminator. When the battery is being charged, a red LED is lit next to the power connector. When the
battery is fully charged, the LED turns green.
Never try to replace the battery on your own. The battery must always be replaced by a service technician and
only with a battery of the same type.
Note! Installing the wrong type of battery can result in a damaged product and/or fire.
When the battery is discharged below a certain level, the remote will automatically be turned off. To restart the
remote, the charger must be connected.
After the remote is turned off by the software due to low battery charge, it might be possible to restart it without
connecting the charger. In this case, it will be turned off again in a few minutes. If this is done several times, the
battery might be discharged to a level where the remote will not start at all, until the battery has been recharged
to a certain level. This can take up to 30 minutes. During this time, both LED:s might be on for some time.
What happens when the remote is turned off?
The remote control is continuously saving all information in an internal memory. When it is turned off or
unplugged, the data is saved and can be restored when the remote is restarted. If a match was running when the
remote was turned off, the question “Restore Data?” will be shown at startup. Press [Yes] to restore the match or
[No] to go to the start menu.

WESTERSTRAND SPORTSYSTEM
Dokument:
4253en08.docx
örfattare:
C
BASIC 190/250
Datum:
2019
-
11
-
19
Page:
5
av
18
Operation Instructions
WESTERSTRAND URFABRIK AB
Box 133 Tel. [phone] Internet: http://www.westerstrand.se
545 23 TÖREBODA ax. 0506 48051 E-Mail: [email protected]
Scoreboard Layouts
Different sports are shown in different ways on the scoreboards. This is described in the pictures below.
Module 1
BASKETBALL FUTSAL
HANDBALL / FLOORBALL TENNIS
VOLLEYBALL BADMINTON / TABLE TENNIS
Score
Team
foul
Time
-
out
Match time
Match indicator
Start/stop
Period
Ball
Possession
Score
Team
foul
Time
-
out
Match time
Match indicator
Start/stop
Period
Score
Time
-
out
Match time
Period
Match indicator
Start/stop
Penalty
time
Current set
Serve
Player changes /
Time
-
out
Set
Time
-
out
Score
Score
Set
Current set
Serve
Serve
Score
Current set
Game
Set

WESTERSTRAND SPORTSYSTEM
Dokument:
4253en08.docx
örfattare:
C
BASIC 190/250
Datum:
2019
-
11
-
19
Page:
6
av
18
Operation Instructions
WESTERSTRAND URFABRIK AB
Box 133 Tel. [phone] Internet: http://www.westerstrand.se
545 23 TÖREBODA ax. 0506 48051 E-Mail: [email protected]
Score
Time-out
Match time
Period
Match indicator
Start/stop
Penalty
time
10-min
penalty
Player number
1/100 sec
Time keeping
Clock started
/stopped
Weight Player
number
1/10 kg
Attempt Match time
Clock started
/stopped
Score
Time-out
Period
Match time
Match indicator
Start/stop
Penalty
time
Score
Match indicator
Start/stop
Match time
Period
Score
Warning
Rond
Match indicator
Start/stop
Match time

WESTERSTRAND SPORTSYSTEM
Dokument:
4253en08.docx
örfattare:
C
BASIC 190/250
Datum:
2019
-
11
-
19
Page:
7
av
18
Operation Instructions
WESTERSTRAND URFABRIK AB
Box 133 Tel. [phone] Internet: http://www.westerstrand.se
545 23 TÖREBODA ax. 0506 48051 E-Mail: [email protected]
Module
Module 2 exists in two versions, one for multisport and one for ice hockey. The multisport version can display
both penalties and results from previous sets. The ice hockey version only has three digits for showing time and
can only show penalties.
Module 7
Variant 1 Variant 2
Variant 1: Individual foul with variable player numbers
Variant 2: Individual foul with variable player numbers and score per player.
Penalty
times
Player
numbers
Previous set
results
Penalties Set results
Set
number
Foul dots
Player numbers
Player
score
Player numbers
Foul dots

WESTERSTRAND SPORTSYSTEM
Dokument:
4253en08.docx
örfattare:
C
BASIC 190/250
Datum:
2019
-
11
-
19
Page:
8
av
18
Operation Instructions
WESTERSTRAND URFABRIK AB
Box 133 Tel. [phone] Internet: http://www.westerstrand.se
545 23 TÖREBODA ax. 0506 48051 E-Mail: [email protected]
Installation
Assembly of Scoreboards
IMPORTANT! The front glass must NOT be removed when the scoreboard is mounted.
On radio controlled system, attach the included antennas both on top of the scoreboard and on the
remote control unit.
For scoreboards in 110-housing intended for mounting outdoor or in ice rinks: Install the scoreboard
according to drawing 081716-00.
For scoreboards meant for indoor wall mounting, see the picture below for mounting options.
Holders are included in the delivery.

WESTERSTRAND SPORTSYSTEM
Dokument:
4253en08.docx
örfattare:
C
BASIC 190/250
Datum:
2019
-
11
-
19
Page:
9
av
18
Operation Instructions
WESTERSTRAND URFABRIK AB
Box 133 Tel. [phone] Internet: http://www.westerstrand.se
545 23 TÖREBODA ax. 0506 48051 E-Mail: [email protected]
Mounting of Shot Clock LED-stripes
The LED-stripes for the FIBA shot clocks are delivered as strips of 30cm and are placed and connected to fit the
backboard. They are attached to the backboard by included double sided tape. The strips are connected to each
other with attached connectors, see the picture below. The LED-stripe that has both red and yellow LED:s is
placed on the top of the backboard and is connected with two connectors. The stripe with only red LED:s is
placed around the rest of the backboard and is only connected with one connector.
See chapter “Connections” for instructions on how to connect the LED-stripe to the shot clock.

WESTERSTRAND SPORTSYSTEM
Dokument:
4253en08.docx
örfattare:
C
BASIC 190/250
Datum:
2019
-
11
-
19
Page:
10
av
18
Operation Instructions
WESTERSTRAND URFABRIK AB
Box 133 Tel. [phone] Internet: http://www.westerstrand.se
545 23 TÖREBODA ax. 0506 48051 E-Mail: [email protected]
Connections
Document 4287 shows cable specifications and layouts for the most common sport systems.
Note: For service purpose, all connected cables should have a spare length of at least 40cm.
The power is connected to the supply cord on the scoreboard. All other connections are made on the circuit
board according to the picture below. The connections are usually located in the bottom left of the scoreboard.
External Horn
The scoreboard is normally delivered with a built in piezo siren. When an external siren is used, connect the
12V signal to one of the “External horn” outputs in the picture. Connect + to + and – to –. Connect the power
supply cord to 230VAC.
Add-On Modules
Add-on modules, such as penalty and foul modules, are connected to the main scoreboard using the “Extra
modules” connectors. Any of the connectors can be used. If more than two extra modules are used, they can be
connected to the closest module with an unused connector.
DCF, WL-receiver and Time code (TC)
DCF and WL-receiver: Attach the DCF-antenna according to the figure above. – to –, + to + and DCF to DCF.
See section “Time and ID Settings” for DIP and jumper settings.
TC: Connect +IMP to +IMP and –IMP to –IMP. See the next page for DIP and jumper settings.
Note that DCF has a limited range and will not work in all regions.