Winnebago 179404 Quick start guide


Dangerofelectricalshock,burnsordeath.Alwaysremoveallpowersourcesbeforeaempnganyrepair,service
ordiagnoscwork.Powercanbepresentfromshorepower,generator,inverterorbaery.Allpowersourcesmust
bedisabledandsecuredbeforeperforminganyservice.

Ifyoulacktheskills,toolsorequipmenttoperformdiagnoscorrepairworkleavesuchworktoanauthorized
WinnebagoIndustriesdealerorotherqualifiedshop.
Copyright©2012WinnebagoIndustries,Inc.

GENERATOR WITHOUT
ZONE
TWO-PLACE (X.XX)
B
5
1
ANGLE
WHOLE DIM (X)
3
8
4
DSNR
REV
3
2
P.E.
ONE-PLACE (X.X)
D
REV
D
ALL DIMENSIONS ARE
IN MILLIMETERS
DATE
TITLE:
CHKR
7
MATERIAL:
B
M.E.
7 4
COPYRIGHT 2011
WINNEBAGO
INDUSTRIES, INC.
DO NOT SCALE DRAWING
A
PART NO
THIRD ANGLE
DWG
NO
DATE
2
C
FIRST USED
PROJECTION
DFTR
DFTR-ORIG
REFER TO ES0018 FOR FASTENER
TIGHTENING GUIDELINES
A
5
R
8
6
REVISION RECORD
REF:
C
REV
1
UNSPECIFIED TOLERANCES ARE:
ORIG. DATE
6
OF
SHEET
1 5
CODES/STANDARDS USA
1A3
265
GEN-4.0KW-ONAN-GAS-MICROLITE
2.
RELEASE
FOR ELECTRICAL
TORQUE
SPECIFICATIONS
SEE DWG NO.
128783-01-000
265
ALL WIRES TO BE SECURED WITH CLAMP 10495-01-000
OR CLIP 80734-01-000 EVERY 600MM. USE SCREW
G67-10-12B UNLESS OTHERWISE SPECIFIED.
179404
CODES/STANDARDS-CSA/CMVSS
NOTES:
X-X
FOR
ELECTRICAL
CALLOUTS
SEE DWG NO.
121339-01-000
A
40N
1B1
WIRING INSTL-BODY 12V
12 231J/JP
1.
5
1B1
USE ONE OF THE SPEAKERS PROVIDED IN THE KIT.
SEND THE SCREWS IN THE KIT TO THE SURPLUS STORE.
SEND THE KIT WIRE ASM-PIGTAIL TO WIRE PREP TO
BE INCORPORATED INTO A WIRE ASM.
1
3
1.5
0.50
ROUTE TANK SENSOR WIRES SO THEY DO NOT PASSOVER
SENSORS. USE WIRE TIE MOUNT 155366-01-000 AND
WIRE TIE 8343-01-000 AS NEEDED. TANK SURFACE MUST
BE CLEANED USING ISOPROPYL ALCOHOL AND PRIME WITH
PRIMER 94.
179404
23T
DRAINAGE SYSTEM-HEATED
4 SEE DRAINAGE SYSTEM INSTL FOR ADDITIONAL INFORMATION.
3 ROUTE WIRE ALONG DRAINAGE PIPE & CONNECT TO
PIPE WITH TIE-WIRE 8343-04-000.
23R
DRAINAGE SYSTEM/HEAT-PREP
5
TO FURNACE
40N
4 PIN HSG
TO WATER HEATER
WIRE ASM-JUMPER
142263-01-000
COAX-INPUT (RED)
DETAIL
AA
LO1-3
2
SPEAKER
110465-01-000
SCREW
G11-08-08U (4)
WIRE ASM-LEFT
179409-01-000
MONITOR PANEL
134940-06-CHT
134940-07-CHT
SCREW
G11-08-08U (4)
WIRE ASM-TANK,
AUX HOLDING
151316-03-000
3 PIN HSGS
TO RANGE VENT
1A3
SWITCH
DETAIL
CJ
WIRE ASM-WATER TANK
151317-01-000
WIRE ASM-OVHD
165079-01-000
WIRE ASM-HEATER-TANK
134551-09-000
LO2-3
LO1-3
2
2 PIN HSG
TO WATER PUMP
15,9,6 PIN HSGS
CONNECTS TO WIRE ASM-CHASSIS
COAX RED,GRN
ADAPTOR
82134-01-000 (2)
THERMOSTAT
135618-03-CHT
SWITCHES-SLIDEOUT
DETAIL
CB
WIRE ASM-TANK,
MAIN HOLDING
151317-03-000
15,6 PIN HSGS
TO WIRE ASM-ROOF
COAX
(RED,GRN)
ADAPTORS
82134-01-000 (2)
SWITCH
DETAIL
CE
TO SIDE MARKER
LAMP MM,MS
WIRE ASM-HEATER RELAY
153891-01-000
RELAY
63912-02-000
SCREW
G11-08-12B
53Z
WTR HTR-6GAL/110/LP/MTR/AUTO
53Z
23T
23T
23R
23R
3 4 OR
OR
CONNECTS TO
WIRE ASM-
SIDEWALL
6
SLIDEOUT WIRING IS PART OF WIRE ASM-CHASSIS. 6
23R 23T OR
SWITCH
DETAIL
CH
7
7
NOT USED WITH
53Z
PANEL-SERVICE
132862-04-CHT
SCREW
G11-08-12U (4)
PLATE-WALL
149557-07-CHT
SCREW
G39-08-08U (2)
DETAIL
AA
GREAT ALASKAN RENTAL PACKAGE
644
CONNECT BOTH
RED WIRES TO
YELLOW & BLACK
WIRE TO WHITE
ON CO DETECTOR
1
BATH WALL
DRILL 19MM
HOLE IN WALL
FOR WIRE ROUTING
DETAIL
AB
2
CONNECT TO
WIRE ASM-
COACH IN
BATH OVHD
CABINET
644
175
330
DETECTOR-CO
146126-03-CHT
SCREW
G12-08-170 (2)
CONNECTOR
58028-01-000
DETAIL
AB
WIRE ASM-EXTENSION
149130-01-012
644
644
64R
8
EXTERIOR WASH STATION
64R
64R
SWITCH-WATER PUMP
108357-15-000
ACTUATOR-SWITCH
108356-04-CHT
INSTALL SWITCH ON WIRE ASM. ROUTE AND SECURE
PUMP SWITCH BACK ALONG FRAME RAIL, THRU
UPPER FLOOR ASM AT WIRE ASM-CHASSIS AND
WIRE ASM-LEFT CONNECTION POINT. WITHOUT
SWITCH-WATER PUMP
DETAIL
CK
8
SLIDEOUT LOCK RELAY
063912-02-000
INPUT
1/17/2012

2
D
C
1
FIRST USED
8 3
B
28 1
DO NOT SCALE DRAWING
4
4
DWG
NO
3
TITLE:
C
6
B
7 5
PART NO
2
D
REV
5
AA
6
7
SHEET
SEE INTERIOR INSTL-FRONT FOR ADDITIONAL INFORMATION.
1MK
WIRING INSTL-BODY 12V
5
USE ONE OF THE SPEAKERS PROVIDED IN THE KIT.
SEND THE SCREWS IN THE KIT TO THE SURPLUS STORE.
SEND THE KIT WIRE ASM-PIGTAIL TO WIRE PREP
TO BE INCORPORATED INTO A WIRE ASM.
2.
3
SEE WIRING INSTL-TV/DVD FOR ADDITIONAL INFORMATION.
4
TV-19"DC,STEREO SYS,VDEO SEL
1L9
CODES/STANDARDS USA
1E2
1B1
ENTRANCE STEP-ELEC.
1.
179404
1B1
CODES/STANDARDS-CSA/CMVSS
6
265
12 231J/JP
X-X
FOR
ELECTRICAL
CALLOUTS
SEE DWG NO.
121339-01-000
FOR ELECTRICAL
TORQUE
SPECIFICATIONS
SEE DWG NO.
128783-01-000
NOTES:
ALL WIRES TO BE SECURED WITH CLAMP 10495-01-000
OR CLIP 80734-01-000 EVERY 600MM. USE SCREW
G67-10-12B UNLESS OTHERWISE SPECIFIED.
SEE WIRING INSTL-TV/DVD,FRONT FOR ADDITIONAL INFORMATION.
7
ENTERTAINMENT CENTER-CABOVER
265
179404
TV(REAR)19" DC LCD STEREO 1MQ
SWITCH
DETAIL
CC
TO WIRE ASM-ROOF
WALLPLATE-TV
76319-09-000
SPEAKER-SUBWOOFER
124884-01-000
GRILLE-SPEAKER
151844-01-CHT
SCREW
76790-01-000 (4)
CONNECTS TO
WIRE ASM-CHASSIS
LO1-3
WALLPLATE-TV
176294-01-CHT
SCREW
G12-06-08U (2)
LPGD
3
LCR-1
ET,EU
TO REFRIGERATOR
PREP PLATE-COAX
149557-05-CHT
SCREW
G67-10-08U (2)
SWITCH-TV
DETAIL
CM
SWITCHES
DETAIL
CD
WIRE ASM-RIGHT
179408-01-000
1MK
SPEAKER
110465-01-000
SCREW
049465-03-000 (4)
LOAD CENTER/ATS ASM
DETAIL
CA
FROM WIRE ASM-ROOF
8 7
8
TO SIDE MARKER
LAMP MM,MS
WIRE ASM-SLIDEOUT
180597-01-000
NOT USED WITH
1L9
8
LO1-3
2
9
SWITCH-TV
LIGHT WARDROBE
87694-01-000
SCREWS
G11-10-12U (2)
CONNECTOR
58028-01-000 (2)
10C
6 PIN HOUSING
CONNECTS TO
WIRE ASM-CHASSIS
DETAIL
CF
TV-19" STEREO
FLAT PANEL-LCD
TO BE USED FOR BOTTOM BUNK TV.
TO BE USED FOR TOP BUNK TV.
NOT USED WITH
1MQ
9
10
DVD PLAYERS(2)W/LCD MONITORS
10C
OUTLET-COAX/12V EXTERIOR
168516-01-CHT
SCREW
G11-08-16T
DETAIL
BA
TV-7" FLIPDOWN
164136-01-000 (2)
SCREW
G11-08-16T (4)
G39-08-40T (4)
DETAIL
EA
CABLE-RCA 12"
136860-01-000
DETAIL
EA
SWITCH
DETAIL
CG
WALLPLATE,TV
76319-09-000 (2)
10
4
10C
10C
JF
NF
DETAIL
BA
LAMP-DINETTE
93575-59-CHT
CONNECTOR
58028-01-000 (2)
SCREW
G11-08-16U (2)
INTERIOR UPGRADE PACKAGE
086
6
6
INTERIOR UPGRADE - WITHOUT
08P
MOUNT LIGHTS WITH SWITCH LOCATED TOWARD THE BUNKS FACING DOWN.
5
GREAT ALASKAN RENTAL PACKAGE
644
2-PIN HSG
COAX (UNMARKED)
RCA CABLE
FROM ROOF
644
TV-22" STEREO
FLAT PANEL LED
180602-01-000
SCREW
(SUPPLIED WITH TV) (4)
WASHER
E11-10-00B (4)
WIRE ASM-TV,SIDE
182448-01-000
WIRE ASM-POWERCORD
170909-02-000
CONVOLUTE
41953-06-000 (600MM)
WIRE TIE
8343-01-000 (2)
644
AWNING - PATIO, ELECTRIC
52N
1L9
1MQ
RELAY
63912-02-000
SCREW
G11-08-12B
52N
OR 644
OR 644
644
RADIO-WALL MOUNT
169536-01-CHT
SCREW
76790-03-000 (4)
644
644
1/17/2012

179404
SWITCH-ROCKER
135740-01-CHT (2)
SWITCH-BASE
135741-02-CHT
SWITCH-BEZEL
135742-19-CHT
SCREW
G11-08-08U (4)
PL
PORCH CEILING
FOR ELECTRICAL
TORQUE
SPECIFICATIONS
SEE DWG NO.
128783-01-000
D
C
1
FIRST USED
8 3
B
28 1
DO NOT SCALE DRAWING
4
4
DWG
NO
3
TITLE:
C
6
B
7 5
PART NO
2
D
REV
5
AA
6
7
SHEET
PJ
WIRING INSTL-BODY 12V
3
JC
12 231J/JP
JE
X-X
FOR
ELECTRICAL
CALLOUTS
SEE DWG NO.
121339-01-000
WB
(LP LEAK DETECTOR)
DETAIL
CC
5
15
DETAIL
CA
3 7 9
1515
BATT
POS
5
GND
CONV
POS
4
5 15 15
30 30
15
1
BATT
NEG
2
30 AMP
6 8
30 AMP
ET
(REFRIGERATOR)
JD
(LAMPS)
JC
(LAMPS)
JE
(LAMPS)
J
(CHASSIS ASM)
JB
(FURNACE)
JA
(MONITOR PANEL & PUMP)
HR
23T
TURN OFF When Not In Use
JP
SEE OPERATORS MANUAL
HOLDING TANK HEATER
SWITCH-ROCKER
135740-06-CHT
SWITCH-BASE
135741-01-CHT
SWITCH-BEZEL
135742-01-CHT
SCREW
G11-08-08U (2)
LABEL-SWITCH
134563-01-CHT
DETAIL
CJ
JA
179404
CEILING
SWITCH-ROCKER
135740-01-CHT
SWITCH-BASE
135741-01-CHT
SWITCH-BEZEL
135742-07-CHT
SCREW
G11-08-08U (2)
DETAIL
CE
JC
PE
OR
23R
PLATE-KEY, SLIDE ROOM
163987-01-CHT
SCREW
76790-05-000 (4)
LABEL-SLIDROOM CONTROL, MAN
163988-01-CHT
SWITCH-KEY,SPST-ILLINOIS LCK
163097-01-000
(CONNECTS TO CIRCUITS DY & DDJ)
LABEL-WARNING, SLIDEOUT
116549-01-000
LABEL-SLIDEOUT,DRIVER,FRONT
163992-01-CHT
PLATE-SWITCH
144363-09-CHT
SWITCH
108357-06-000
ACTUATOR
108356-02-CHT
NUT
D65-08-00B (2)
LABEL
116220-01-000
JF
(AUDIO/VIDEO)
LABEL-SLIDEOUT
PASSENGER REAR
163992-03-CHT
TV
SWITCH-ROCKER
135740-01-CHT
SWITCH-BASE
135741-01-CHT
SWITCH-BEZEL
135742-45-CHT
SCREW
G11-08-08U (2)
DETAIL
CG
JF
EX
10C
NM
(HEATED TANKS)
OR
15
23T 23R
DETAIL
CB
1D2 09L
52N
1 NOT USED WITH
NOTES:
23R
CABLE ASM-COAX
(GRN)
FROM WIRE ASM-SLIDEOUT
FROM WIRE ASM-SLIDEOUT
CABLE ASM-COAX
(GRN/GRN)
SPLITTER-3WAY
86756-02-000
SCREW
G11-08-12B (2)
FROM WIRE ASM-CHASSIS
CABLE ASM-COAX
(GRN/GRN/GRN)
FROM WIRE ASM-SLIDEOUT
DETAIL
CF
PLATE
98351-22-CHT
SCREW
G11-06-10U (4)
SWITCH-BATTERY
108357-17-000
ACTUATOR
108356-19-CHT
(CIRCUITS KF,LG,
LJ,LJ,KF,KF,LK)
DETAIL
CD
WATER
HTR 110V
SWITCH-ROCKER
135740-06-CHT
SWITCH-BASE
135741-01-CHT
SWITCH-BEZEL
135742-35-CHT
SCREW
G11-08-08U (2)
DETAIL
CH
JA
HHJ JP
CODES/STANDARDS USA
CODES/STANDARDS-CSA/CMVSS
SLIDEOUT ROOM FRONT LEFT
SLIDEOUT ROOM-REAR RIGHTHAND
DVD PLAYERS(2)W/LCD MONITORS
DRAINAGE SYSTEM-HEATED
DRAINAGE SYSTEM/HEAT-PREWIRE
265 1B1
1B1
265
09L
1D2
10C
23T
53Z
CABLE ASM-COAX
(GRN)
52N
AWNING - PATIO, ELECTRIC
DETAIL
CK
SWITCH-PUMP
108357-15-000
ACTUATOR-SWITCH
108356-23-CHT
PLATE
98351-07-CHT
SCREW
G11-06-10U (2)
SWITCH-AWNING
108357-06-000
ACTUATOR-SWITCH
108356-12-CHT
PLATE
98351-07-CHT
SCREW
G11-06-10U (2)
SWWITCH-BLANK
096241-03-000
52N
WTR HTR-6GAL/110/LP/MTR/AUTO
53Z
GREAT ALASKAN RENTAL PACKAGE
644
644
OR
2 INSTALL SWITCH INTO STEP SWITCH LOCATION BUT DO NOT
CONNECT THE AWNING WIRES TO THE SWITCH WITH
OR 644
644
2
TV
SWITCH-ROCKER
135740-01-CHT
SWITCH-BASE
135741-01-CHT
SWITCH-BEZEL
135742-45-CHT
SCREW
G11-08-08U (2)
DETAIL
CM
JF
EX
644
PLATE-SWITCH
144363-09-CHT
SWITCH
108357-06-000
ACTUATOR
108356-02-CHT
NUT
D65-08-00B (2)
LABEL
116220-01-000
1
DRIVER'S
SIDE FRONT
PASSENGER'S
SIDE REAR
NOTICE
Remove room locking bar before
operating slide room or damage may occur.
This switch must be on
and park brake applied
to perate any slide room.
We recommend running the
engine to insure adequate
battery power.
ON
MASTER SLIDE ROOM
CONTROL SWITCH
OFF
WARNING
116549-01F
CRUSH HAZARD. Keep people and objects clear of the inside
and the outside of the slideout room when operating. Failure
to comply could result in death or serious injury.
!
EXTEND
SLIDEOUT
CONTROL
SWITCH
RETRACT
EXTEND
SLIDEOUT
CONTROL
SWITCH
RETRACT
WATER
PUMP
1/17/2012

4
265
NOT USED WITH
1B1
WIRING INSTL-BODY 12V
X-X
FOR
ELECTRICAL
CALLOUTS
SEE DWG NO.
121339-01-000
FOR ELECTRICAL
TORQUE
SPECIFICATIONS
SEE DWG NO.
128783-01-000
1B1
1L9
2
3
LO2-3
4
D
C
1
FIRST USED
8 3
B
28 1
DO NOT SCALE DRAWING
4
4
DWG
NO
3
TITLE:
C
6
B
7 5
PART NO
2
D
REV
5
AA
6
7
SHEET
NOTES:
SEE ROOF ASM FOR ADDITIONAL INFORMATION.
265
1L9
ENTERTAINMENT CENTER-CABOVER
12 231J/JP
179404
2
CODES/STANDARDS USA
1L9
CODES/STANDARDS-CSA/CMVSS
SPEAKER
160867-01-CHT
SCREW
G1208-12-170 (4)
LOSN3
LO1-3
1.
ANT-3
4
1J8
NOT USED WITH 3
1J8
SEE ANTENNA INSTALLATION MANUAL FOR
CORRECT INSTALLATION PROCEDURE.
4
179404
TV ANTENNA-OMNIDIRECTIONAL 1J8
LOSN3
TV-19"DC,STEREO SYS,VDEO SEL
1MK
1L9
SPEAKER
160867-01-CHT
SCREW
G1208-12-170 (4)
1MK
ANT-5
BRACKET ANTENNA
GROUND
VIEW
DA
NF
FROM WIRE ASM-COACH
5
ANT-R 1MK 644
644
GREAT ALASKAN RENTAL PACKAGE
DETAIL
DA
SPEAKER
160867-01-CHT
SCREW
G1208-12-170 (4)
1L9 1MK
664 644
SPEAKER
160867-01-CHT
SCREW
G1208-12-170 (4)
1L9
5
WRAP BRACKET LEGS AROUND ANTENNA BASE.
1/17/2012

D
C
1
FIRST USED
8 3
B
28 1
DO NOT SCALE DRAWING
4
4
DWG
NO
3
TITLE:
C
6
B
7 5
PART NO
2
D
REV
5
AA
6
7
SHEET
5
12 231J/JP
WIRING INSTL-BODY 12V
179404
NOTES:
ALL WIRES ARE TO SECURED WITH CLAMP10495 OR 10497 OR WIRE
TIE 8343 OR 104046 EVERY 600 MM, USE SCREWS G64-XX-XXX
OR G56-XX-XXX AS APPROPRIATE FOR INSTALLATION.
1.
179404
REMOTE IR RECEIVER SUPPLIED WITH DVD PLAYER,
TO BE MOUNTED IN BOTTOM BUNK.
2.
REMOVE SHIPPING RESTRAINT SCREWS FROM DVD PLAYER. 3.
CODES/STANDARDS USA
CODES/STANDARDS-CSA/CMVSS
DVD PLAYERS(2)W/LCD MONITORS
265 1B1
1B1
265
10C
ND
DETAIL
EA
AV INPUT
CABLE (AV1)
EX
YEL
TV-FLIP DOWN
(TOP BUNK)
(PRIMARY PLAYER)
RED
RED
YEL
AV OUTPUT CABLE
BLK
WIRE ASM-
SLIDEOUT
3-WAY RCA CABLE ROUTED
WITH 12V WIRING. CONNECT AS SHOWN:
YEL TO YEL; WHT TO WHT; AND RED TO RED
EX
TV-FLIP DOWN
(BOTTOM BUNK)
(SECONDARY PLAYER)
WIRE ASM-
SLIDEOUT
AV INPUT
CABLE (AV1)
(NOT USED)
ND
BLK
10C
AV OUTPUT CABLE
(NOT USED)
X-X
FOR
ELECTRICAL
CALLOUTS
SEE DWG NO.
121339-01-000
FOR ELECTRICAL
TORQUE
SPECIFICATIONS
SEE DWG NO.
128783-01-000
1/17/2012