WSSL PPT 30X User manual

STRUCTURES & TENTS
..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf
Locate, mark, and AVOID any overhead or underground electrical, phone, gas,
sprinkler or other lines. Take note and always be aware of any and all hazards.
DO NOT BEGIN ANY ASSEMBLY UNTIL THE HAZARDS HAVE BEEN
MARKED AND CAN BE SAFELY AVOIDED.

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf
PARTS LIST & QUANTITIES
SIDE POLES
AND WALLS ARE
INTERCHANGEABLE
WITH WSSL
PEAK MARQUEE TENT
30’
>
>
20’
>
>
10’
>
>
6’
>
>
20’
>
>
20’
>
>
GUYING WITH
WEBBING AND RATCHETS
FOR MORE ACCURATE
FABRIC PRESTRES
57
7
10
8
4
8
6
DOLLY
CARRY
RACK
MODEL
PEAK POLE TENT
PPT30X
T
E
T
S
E
24’
RATCHET WEBBING (HOOK)
RATCHET WEBBING (LOOP)
1”X42” TRIBAR
ALUM 2.5”X 8’
TOP MID 30’X30’
CENTERPOLE
SIDE POLE
GUYING
STAKES
3 PIECE ASSEMBLY
5 PIECE ASSEMBLY
FLAGPOLE
DOLLY, CENTERPOLE
TOP MID 30’X20’
TOP END 30’X20’
PART PART # WEIGHT lb (kg)
ASSEMBLY # 11733 11732 70801 11734 11735
30X40 30X90 30X100 ADD’L 20’ MID ADD’L 30’ MID
1
2
4
3
5
6
7
8
10
11145
11053 10 (4.6)
5 (2.3)
WEIGHT lb (kg) 981 (445)
22
32 34 4
32 34 4
22
14 24 26 4 6
6
6
11
3311
3311
1-1-
11
22
2
-
-
-
1- -
1
1
-
-
2
1850 (839) 1924 (873) 366 (166) 476 (216)
12065
11736
11737
11738
11102
11170
10782
10884
11103
10 (4.6)
84 (38)
1.3 (0.6)
119 (54)
106 (48)
146 (66)
203 (92)
154 (70)

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf
50'x1/2" Poly Ropes

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf
21’ for 8’ sidepole
23’ for 10’ sidepole

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf
40’
30’
50’ 50’
CAUTION:
Before beginning any installation, locate, identify and AVOID
all hazards and obstructions. DO NOT SETUP IN HAZARDOUS
AREAS. Take general tent measurements to determine that
tent will fit into space.
a.) From corner 1 mark 30’ arc perpendicular to tent side line.
b.) From 40’ point along side line measure 50’ intersecting 30’ arc.
c.) Mark 10’ increments along side and end.
3
4
5
90°

Locate stakeline with the sidepoles
POST
STAKE SIDE LINE
..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf
7’ for 8’ sidepole
9’ for 10’ sidepole
a.) Measure 7’ (for 8’ sidepole) or 9’ (for 10’ sidepole)
outward from side and end lines at each corner and
mark each location with spray paint.
b.) Measure and mark 10’ increments along side and
end lines.

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf

>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
>
..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf
Flagpole

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf
TENT LENGTH
Snap each webbing hook to
corresponding plate.
1 per laceline and side.

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf
VERTICAL VERTICAL
VERTICAL
VERTICAL
SIDEPOLE
NUT CROWN
SIDE PLATE
8” - 10”> >
SIDEPOLE WEBBING
Bases of sidepoles exactly on previously marked positions.
• Starting with the corners, place sidepole base at
previously determined mark.
• Tighten the guy webbing straps keeping the top
of sidepole leaning 8” - 10” inward.
• After all (4) corners are installed using webbing
guys, adjust each to approach vertical.

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf
VERTICAL VERTICAL
VERTICAL
VERTICAL
Corner sidepoles are vertical
Sidepoles are slanted inward 8” - 10”

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf
TENT TOP CENTREPOLE
If using
an appropriate vehicle .
DOLLY
C
O
SLIDE IN
SHORTENED CENTREPOLE
Recommended ways in raising the centrepoles are:
• manually starting with a shortened centrepole
• using a winch, pickup truck, or other appropriate vehicle.
Use whichever is most applicable depending on the
availability of personnel and equipment.
SHORTENING FIRST CENTREPOLE LENGTH
• To erect centrepole, attach a rope to the ring
at the bottom of the dolly.
• Pull on rope and carefully raise centrepole,
watching the flagpole is clear of the fabric
folds.
• With two men raising the top end of the
centre-pole, pull dolly until centrepole base is
right at the corresponding marked location.
• Slowly raise the dolly handle up to lower
centrepole to the ground and remove stake.
• Continue to install the rest of the centre-poles
using the same procedure.
• If shortened first centerpole method is used,
with all centrepoles raised, take down the
shortened centrepole, and adjust to proper
height and reinstall.

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf

..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf
1. Mark location of poles and anchor bars.
2. Layout stake bars and drive in stakes.
3. Lay down drop sheet.
4. Unfold top ends and top mids.
5. Insert flag pole through centre plates.
6. Daisy chain all lacelines.
7. Install flag
8. Attach guy webbing to stake bars.
9. Assemble and attach side poles
10. Attach guy snap to side plates.
11. Erect side poles starting with the four
corners, then lacelines, then the rest
(8” - 10” inward lean).
12. Assemble and install centrepoles.
13. Adjust webbings to straighten side poles.
14. Remove and fold drop sheet.
15. Install any required centrepole and side
pole stakes.
16. Install walls and gutters if required.
17. Make final inspection to ensure everything
is in operational condition.
18. Clean up site.

STRUCTURES & TENTS
..\graphicshome\Peak Pole\Manuals\PT 30x\PT30x Manual 2014A.pdf

STRUCTURES & TENTS
Warner Shelter Systems Limited creates fabric-clad structures to suit virtually every
purpose, from special events, trade shows, catering and outdoor concerts to
warehousing and industrial use. Our award-winning tents are user-friendly, durable
and set-up quickly.
We have earned a reputation for providing a high level of service to customers since
1970. It is a pleasure to serve you. Please contact us for further information.
PEAK POLE TENT
MODULAR CLEARSPAN BUILDING
PEAK MARQUEE TENT
e
e
e
e
e
e
e
er
r
oato
ARABESQUE STAGECOVER DOME STAGECOVER
WSSL GIGA-SPAN TENT -C- CAN WSSL GARAGE TENT-X-SPAN
The Arabesque Theatre with Its high
arched ends allows generous height
over a stage at one end and bleacher
seating at the other. These tents
singularly or joined together, create a
large attractive, clearspan interior.
The WSSL Clearspan
Series structures are
designed, engineered,
and manufactured in
our CWB certified plant.
The open web truss
galvanized steel frames
are assembled to
satisfy the applicable
building code.
The WSSL Tent -C- Can:
For its 40 years anniversary
Warner Shelter Systems
Limited WSSL offers to the
world with a NEW Warner
Innovation.
WSSL Garage come complete
with galvanized steel frame
and fire retardant cover, easy
to relocate structure featuring
clear span truss framing, and
12’ x 12’ sliding door for easy
access.
Sturdy, versatile and portable,
the Tent-X-Span fabric
structures are light weight,
easy to transport, store, and
erect. Box beam aluminum
frame, interchangeable parts,
and easily joins to peak
marquee tents.
TheArabesque Stagecover creates a
striking backdrop for any outdoor
concert with its dramatic curves and
bold stripes. It is renowned for its
superb acoustic projection and excel-
lent sight lines.
With great acoustics and excellent
sight lines, our attractive SC series is
available in four sizes, with the
SC-70A large enough to accommo-
date a full orchestra.
Modular building Often used for large
special events, but are equally
suitable for warehousing, retail and
industrial use and environmental
projects."MODS" are spacious and
strongly built.
Great Solution for large functions of
all types, combining the nostalgic
appeal of old fashioned circus "big
tops" with the advantages of modern
technology. Available in 40', 60', 80',
and 90' widths.
ARABESQUE THEATRE TENT
A favorite for special events, fairs,
trade shows, and food service use.
With its ease of setup and lightweight
frame, the Marquee is user-friendly
as well as attractive.
2014/12/10