Zanussi ZCV55001WA User manual

EN
ZCV55001WA
ZCV55001XA
User Manual
Cooker

Contents
Safety information 2
Safety instructions 4
Product description 6
Before first use 7
Hob - Daily use 7
Hob - Hints and tips 8
Hob - Care and cleaning 8
Oven - Daily use 9
Oven - Using the accessories 10
Oven - Hints and tips 10
Pizza Setting 15
Oven - Care and cleaning 15
Troubleshooting 17
Installation 18
Energy efficiency 20
Guarantee 21
Subject to change without notice.
Safety information
Before the installation and use of the appliance, carefully read the
supplied instructions. The manufacturer is not responsible for any
injuries or damages that are the result of incorrect installation or
usage. Always keep the instructions in a safe and accessible
location for future reference.
Children and vulnerable people safety
WARNING!
Risk of suffocation, injury or permanent disability.
•This appliance can be used by children aged from 8 years and
above and persons with reduced physical, sensory or mental
capabilities or lack of experience and knowledge if they have
been given supervision or instruction concerning the use of the
appliance in a safe way and understand the hazards involved.
•Do not let children play with the appliance.
•Keep all packaging away from children and dispose of it
appropriately.
•Keep children and pets away from the appliance when it
operates or when it cools down. Accessible parts are hot.
•Children shall not carry out cleaning and user maintenance of
the appliance without supervision.
General Safety
•Only a qualified person must install this appliance and replace
the cable.
2 www.zanussi.com

•This appliance must be connected to the mains with a H05VV-
F type cable to withstand the temperature of the rear panel.
•This appliance is intended for use up to an altitude of 2000 m
above sea level.
•This appliance is not intended to be used on a ships, boats or
vessels.
•Do not install the appliance behind a decorative door in order
to avoid overheating.
•Do not install the appliance on a platform.
•Do not operate the appliance by means of an external timer or
separate remote-control system.
•WARNING: Unattended cooking on a hob with fat or oil can be
dangerous and may result in fire.
•NEVER try to extinguish a fire with water, but switch off the
appliance and then cover flame e.g. with a lid or a fire blanket.
•CAUTION: The cooking process has to be supervised. A short
term cooking process has to be supervised continuously.
•WARNING: Danger of fire: Do not store items on the cooking
surfaces.
•Do not use a steam cleaner to clean the appliance.
•Do not use harsh abrasive cleaners or sharp metal scrapers to
clean the glass door or the glass of hinged lids of the hob since
they can scratch the surface, which may result in shattering of
the glass.
•Metallic objects such as knives, forks, spoons and lids should
not be placed on the hob surface since they can get hot.
•If the glass ceramic surface / glass surface is cracked, switch
off the appliance to avoid the possibility of electric shock.
•WARNING: The appliance and its accessible parts become hot
during use. Care should be taken to avoid touching heating
elements. Children less than 8 years of age shall be kept away
unless continuously supervised.
•Always use oven gloves to remove or put in accessories or
ovenware.
•Before maintenance cut the power supply.
•Ensure that the appliance is switched off before replacing the
lamp to avoid the possibility of electric shock.
www.zanussi.com 3

•If the mains power supply cable is damaged, it must be
replaced by the manufacturer, its Authorised Service Centre or
similarly qualified persons to avoid an electrical hazard.
•The means for disconnection must be incorporated in the fixed
wiring in accordance with the wiring rules.
•WARNING: Use only hob guards designed by the
manufacturer of the cooking appliance or indicated by the
manufacturer of the appliance in the instructions for use as
suitable or hob guards incorporated in the appliance. The use
of inappropriate guards can cause accidents.
Safety instructions
Installation
WARNING!
Only a qualified person must install
this appliance.
• Remove all the packaging.
• Do not install or use a damaged appliance.
• Follow the installation instruction supplied
with the appliance.
• Always take care when moving the appliance
as it is heavy. Always use safety gloves and
enclosed footwear.
• Do not pull the appliance by the handle.
• The kitchen cabinet and the recess must
have suitable dimensions.
• Keep the minimum distance from the other
appliances and units.
• Make sure that the appliance is installed
below and adjacent safe structures.
• Parts of the appliance carry current. Close
the appliance with furniture to prevent
touching the dangerous parts.
• The sides of the appliance must stay
adjacent to appliances or to units with the
same height.
• Do not install the appliance adjacent to a
door or under a window. This prevents hot
cookware to fall from the appliance when the
door or the window is opened.
• Make sure to install a stabilizing means in
order to prevent tipping of the appliance.
Refer to Installation chapter.
Electrical Connection
WARNING!
Risk of fire and electrical shock.
• All electrical connections should be made by
a qualified electrician.
• The appliance must be earthed.
• Make sure that the parameters on the rating
plate are compatible with the electrical
ratings of the mains power supply.
• Always use a correctly installed shockproof
socket.
• Do not use multi-plug adapters and
extension cables.
• Do not let mains cables touch or come near
the appliance door, especially when the door
is hot.
• The shock protection of live and insulated
parts must be fastened in such a way that it
cannot be removed without tools.
• Connect the mains plug to the mains socket
only at the end of the installation. Make sure
that there is access to the mains plug after
the installation.
• If the mains socket is loose, do not connect
the mains plug.
• Do not pull the mains cable to disconnect
the appliance. Always pull the mains plug.
• Use only correct isolation devices: line
protecting cut-outs, fuses (screw type fuses
removed from the holder), earth leakage trips
and contactors.
• The electrical installation must have an
isolation device which lets you disconnect
the appliance from the mains at all poles.
The isolation device must have a contact
opening width of minimum 3 mm.
4 www.zanussi.com

• Fully close the appliance door, before you
connect the mains plug to the mains socket.
Use
WARNING!
Risk of injury and burns.
Risk of electrical shock.
• This appliance is for household use only.
• Do not change the specification of this
appliance.
• Make sure that the ventilation openings are
not blocked.
• Do not let the appliance stay unattended
during operation.
• Deactivate the appliance after each use.
• Be careful when you open the appliance
door while the appliance is in operation. Hot
air can release.
• Do not operate the appliance with wet hands
or when it has contact with water.
• Do not use the appliance as a work surface
or as a storage surface.
WARNING!
Risk of fire and explosion
• Fats and oil when heated can release
flammable vapours. Keep flames or heated
objects away from fats and oils when you
cook with them.
• The vapours that very hot oil releases can
cause spontaneous combustion.
• Used oil, that can contain food remnants,
can cause fire at a lower temperature than
oil used for the first time.
• Do not put flammable products or items that
are wet with flammable products in, near or
on the appliance.
• Do not let sparks or open flames to come in
contact with the appliance when you open
the door.
• Open the appliance door carefully. The use
of ingredients with alcohol can cause a
mixture of alcohol and air.
WARNING!
Risk of damage to the appliance.
• To prevent damage or discoloration to the
enamel:
– do not put ovenware or other objects in
the appliance directly on the bottom.
– do not put water directly into the hot
appliance.
– do not keep moist dishes and food in the
appliance after you finish the cooking.
– be careful when you remove or install
the accessories.
• Discoloration of the enamel or stainless steel
has no effect on the performance of the
appliance.
• Use a deep pan for moist cakes. Fruit juices
cause stains that can be permanent.
• Do not keep hot cookware on the control
panel.
• Do not let cookware boil dry.
• Be careful not to let objects or cookware fall
on the appliance. The surface can be
damaged.
• Do not activate the cooking zones with
empty cookware or without cookware.
• Do not put aluminium foil on the appliance or
directly on the bottom of the appliance.
• Cookware made of cast iron, aluminium or
with a damaged bottom can cause
scratches. Always lift these objects up when
you have to move them on the cooking
surface.
• This appliance is for cooking purposes only.
It must not be used for other purposes, for
example room heating.
Care and Cleaning
WARNING!
Risk of injury, fire, or damage to the
appliance.
• Before maintenance, deactivate the
appliance.
Disconnect the mains plug from the mains
socket.
• Make sure the appliance is cold. There is the
risk that the glass panels can break.
• Replace immediately the door glass panels
when they are damaged. Contact the
Authorised Service Centre.
• Fat and food remaining in the appliance can
cause fire.
• Clean regularly the appliance to prevent the
deterioration of the surface material.
• Clean the appliance with a moist soft cloth.
Only use neutral detergents. Do not use any
abrasive products, abrasive cleaning pads,
solvents or metal objects.
• If you use an oven spray, obey the safety
instructions on the packaging.
• Do not clean the catalytic enamel (if
applicable) with any kind of detergent.
www.zanussi.com 5

Internal light
• The type of light bulb or halogen lamp used
for this appliance is only for household
appliances. Do not use it for house lighting.
WARNING!
Risk of electrical shock.
• Before replacing the lamp, disconnect the
appliance from the power supply.
• Only use lamps with the same specifications.
Disposal
WARNING!
Risk of injury or suffocation.
• Disconnect the appliance from the mains
supply.
• Cut off the mains electrical cable close to
the appliance and dispose of it.
• Remove the door catch to prevent children
or pets from becoming trapped in the
appliance.
Service
• To repair the appliance contact an
Authorised Service Centre.
• Use original spare parts only.
Product description
General overview
6
7
8
1 3 4 5
2
9
1
2
3
4
1Knobs for the hob
2Temperature indicator / symbol
3Knob for the temperature
4Knob for the oven functions
5Hob lamp / symbol / indicator
6Heating element
7Lamp
8Fan
9Shelf positions
6 www.zanussi.com

Cooking surface layout
180 mm
180 mm
140 mm
140 mm
6 5
1 2 3
4
1Cooking zone 1200 W
2Steam outlet - number and position depend
on the model
3Cooking zone 1700 W
4Cooking zone 1200 W
5Residual heat indicator
6Cooking zone 1700 W
Accessories
•Wire shelf
For cookware, cake tins, roasts.
•Baking tray
For cakes and biscuits.
•Aluminium baking tray
For cakes and biscuits.
•Storage compartment
The storage compartment is below the oven
cavity. To use the compartment, lift the lower
front door then pull it down.
WARNING!
The storage compartment can
become hot when the appliance
operates.
Before first use
WARNING!
Refer to Safety chapters.
Initial Cleaning
Remove all accessories from the appliance.
Refer to "Care and cleaning"
chapter.
Clean the appliance and the accessories before
first use.
Put the accessories back to their initial position.
Preheating
Preheat the empty appliance to burn off the
remaining grease.
1. Set the function and the maximum
temperature.
2. Let the appliance operate for 1 hour.
3. Set the function and set the maximum
temperature. The maximum temperature for
this function is 210 °C.
4. Let the appliance operate for 15 minutes.
Accessories can become hotter than usual. The
appliance can emit an odour and smoke. This is
normal. Make sure that the airflow in the room is
sufficient.
Hob - Daily use
WARNING!
Refer to Safety chapters.
www.zanussi.com 7

Heat setting
Symbols Function
Off position
1 - 6 Heat settings
Use the residual heat to decrease
energy consumption. Deactivate the
cooking zone approximately 5 - 10
minutes before the cooking process
is completed.
Turn the knob to a necessary heat setting.
The hob control indicator comes on.
To complete the cooking process, turn the knob
to the off position.
If all cooking zones are deactivated, the hob
control indicator goes out.
Residual heat indicator
WARNING!
There is a risk of burns from residual
heat.
The indicator comes on when a cooking zone is
hot.
Hob - Hints and tips
WARNING!
Refer to Safety chapters.
Cookware
The bottom of the cookware must be
as thick and flat as possible.
Cookware made of enamelled steel
and with aluminium or copper
bottoms can cause the colour
change on the glass-ceramic
surface.
Examples of cooking applications
Heat
set-
ting:
Application:
1 Keeping warm
Heat
set-
ting:
Application:
2 Gentle simmering
3 Simmering
4 Frying / browning
5 Bringing to the boil
6 Bringing to the boil / quick frying /
deep-frying
Hob - Care and cleaning
WARNING!
Refer to Safety chapters.
General information
• Clean the hob after each use.
• Always use cookware with clean bottom.
• Scratches or dark stains on the surface have
no effect on how the hob operates.
• Use a special cleaner applicable for the
surface of the hob.
• Use a special scraper for the glass.
Cleaning the hob
•Remove immediately: melted plastic,
plastic foil, sugar and food with sugar. If not,
the dirt can cause damage to the hob. Take
care to avoid burns. Put the special scraper
on the glass surface at an acute angle and
move the blade on the surface.
•Remove when the hob is sufficiently
cool: limescale rings, water rings, fat stains,
shiny metallic discoloration. Clean the hob
with a moist cloth and non-abrasive
8 www.zanussi.com

detergent. After cleaning, wipe the hob dry
with a soft cloth. •Remove shiny metallic discoloration: use a solution of water with vinegar and
clean the glass surface with a moist cloth.
Oven - Daily use
WARNING!
Refer to Safety chapters.
Activating and deactivating the
appliance
It depends on the model if your
appliance has lamps, knob
symbols or indicators:
• The lamp turns on when the
appliance operates.
• The symbol shows whether the
knob controls one of the cooking
zones, the oven functions or the
temperature.
• The indicator turns on when the
oven heats up.
1. Turn the knob for the oven functions to
select an oven function.
2. Turn the knob for the temperature to select
a temperature.
3. To deactivate the appliance, turn the knobs
for the oven functions and temperature to
the off position.
Safety thermostat
Incorrect operation of the appliance or defective
components can cause dangerous overheating.
To prevent this, the oven has a safety
thermostat which interrupts the power supply.
The oven activates again automatically when the
temperature drops.
Oven functions
Sym-
bol Oven function Application
Off position The appliance is off.
Conventional Cooking To bake and roast food on one shelf position.
Grilling To grill flat food and to toast bread.
The maximum temperature for this function is 210 °C.
Bottom Heat To bake cakes with crispy bottom and to preserve food.
Fan Cooking To roast or roast and bake food with the same cooking tem-
perature on more than one shelf position, without flavour
transference.
Defrost This function can be used for defrosting frozen foods, such as
vegetables and fruits. The defrosting time depends on the
amount and size of the frozen food.
To use this function, the knob for the temperature must be in
the off position.
www.zanussi.com 9

Sym-
bol Oven function Application
Light Cooking To bake in tins and dry on one shelf position at a low temper-
ature.
Defrost This function can be used for defrosting frozen foods, such as
vegetables and fruits. The defrosting time depends on the
amount and size of the frozen food.
To use this function, the knob for the temperature must be in
the off position.
Oven - Using the accessories
WARNING!
Refer to Safety chapters.
Inserting the accessories
Wire shelf:
The wire shelf has a special shape in
the rear which help with the heat
circulation.
Put the shelf on the correct shelf position. Make
sure it does not touch the back wall of the oven.
Tray:
Do not push the baking tray all the
way to the back wall of the cavity.
This prevents the heat from
circulating around the tray. The food
may be burnt, especially in the rear
part of the tray.
Put the tray or deep pan on the shelf position.
Make sure it does not touch the back wall of the
oven.
Oven - Hints and tips
WARNING!
Refer to Safety chapters.
The temperature and baking times in
the tables are guidelines only. They
depend on the recipes and the
quality and quantity of the
ingredients used.
General information
• The appliance has four shelf positions.
Count the shelf positions from the bottom of
the appliance floor.
• The appliance has a special system which
circulates the air and constantly recycles the
steam. With this system you can cook in a
steamy environment and keep the food soft
inside and crusty outside. It decreases the
cooking time and energy consumption to a
minimum.
• Moisture can condense in the appliance or
on the door glass panels. This is normal.
Always stand back from the appliance when
you open the appliance door while cooking.
To decrease the condensation, operate the
appliance for 10 minutes before cooking.
10 www.zanussi.com

• Clean the moisture after each use of the
appliance.
• Do not put the objects directly on the
appliance floor and do not put aluminium foil
on the components when you cook. This can
change the baking results and cause
damage to the enamel.
Baking
• Your oven may bake or roast differently to
the appliance you had before. Adapt your
usual settings such as temperature, cooking
time and shelf position to the values in the
tables.
• Use the lower temperature the first time.
• If you cannot find the settings for a special
recipe, look for the similar one.
• You can extend baking times by 10 – 15
minutes if you bake cakes on more than one
shelf position.
• Cakes and pastries at different heights do
not always brown equally at first. If this
occurs, do not change the temperature
setting. The differences equalize during the
baking procedure.
• Trays in the oven can twist during baking.
When the trays become cold again, the
distortions disappear.
Baking cakes
• Do not open the oven door before 3/4 of the
set cooking time is up.
• If you use two baking trays at the same time,
keep one empty level between them.
Cooking meat and fish
• Use a deep pan for very fatty food to prevent
the oven from stains that can be permanent.
• Leave the meat for approximately 15 minutes
before carving so that the juice does not
seep out.
• To prevent too much smoke in the oven
during roasting, add some water into the
deep pan. To prevent the smoke
condensation, add water each time after it
dries up.
Cooking times
Cooking times depend on the type of food, its
consistency, and volume.
Initially, monitor the performance when you
cook. Find the best settings (heat setting,
cooking time, etc.) for your cookware, recipes
and quantities when you use this appliance.
Conventional cooking
Food Quantity
(g) Tempera- ture (°C) Time (min) Shelf posi-
tion
Accessories
Pastry stripes 250 150 25 - 30 3 baking tray
Flat cake 1) 1000 160 - 170 30 - 35 2 baking tray
Yeast cake with
apples 2000 170 - 190 40 - 50 3 baking tray
Apple pie 2) 1200 + 1200 180 - 200 50 - 60 1 2 round aluminized
trays (diameter: 20
cm)
Small cakes 1) 500 160 - 170 25 - 30 2 baking tray
Fatless sponge
cake 1)
350 160 - 170 25 - 30 1 1 round aluminized
tray (diameter: 26
cm)
Drip pan cake 1500 160 - 170 45 - 55 3) 2 baking tray
www.zanussi.com 11

Food Quantity
(g) Tempera- ture (°C) Time (min) Shelf posi-
tion
Accessories
Chicken, whole 1350 200 - 220 60 - 70 2 wire shelf
1 baking tray
Chicken, half 1300 190 - 210 35 + 30 3 wire shelf
1 baking tray
Pork roast cutlet 600 190 - 210 30 - 35 3 Wire shelf
1 baking tray
Flan bread 4) 800 230 - 250 10 - 15 2 baking tray
Stuffed yeast cake
5)
1200 170 - 180 25 - 35 2 baking tray
Pizza 1000 200 - 220 25 - 35 2 baking tray
Cheese cake 2600 170 - 190 60 - 70 2 baking tray
Swiss apple flan 5) 1900 200 - 220 30 - 40 1 baking tray
Christmas cake 5) 2400 170 - 180 55 - 65 6) 2 baking tray
Quiche Lorraine 5) 1000 220 - 230 40 - 50 1 1 round tray (diam-
eter: 26 cm)
Peasant bread 7) 750 + 750 180 - 200 60 - 70 1 2 aluminized trays
(length: 20 cm)
Romanian sponge
cake 1)
600 + 600 160 - 170 40 - 50 2 2 aluminized trays
(length: 25 cm) on
the same shelf posi-
tion
Romanian sponge
cake - traditional 600 + 600 160 - 170 30 - 40 2 2 aluminized trays (length: 25 cm) on
the same shelf posi-
tion
Yeast buns 5) 800 200 - 210 10 - 15 2 baking tray
Swiss roll 1) 500 150 - 170 15 - 20 1 baking tray
Meringue 400 100 - 120 40 - 50 2 baking tray
Crumble cake 5) 1500 180 - 190 25 - 35 3 baking tray
Sponge cake 1) 600 160 - 170 25 - 35 3 baking tray
12 www.zanussi.com

Food Quantity
(g) Tempera- ture (°C) Time (min) Shelf posi-
tion
Accessories
Buttered cake 1) 600 180 - 200 20 - 25 2 baking tray
1) Preheat the oven for 10 minutes.
2) Preheat the oven for 15 minutes.
3) After you switch off the appliance, leave the cake in the oven for 7 minutes.
4) Preheat the oven for 20 minutes.
5) Preheat the oven for 10 - 15 minutes.
6) After you switch off the appliance, leave the cake in the oven for 10 minutes.
7) Set the temperature for 250 °C and preheat the oven for 18 minutes.
Fan cooking
Food Quantity
(g) Tempera- ture (°C) Time (min) Shelf position Accessories
Pastry stripes 1) 250 145 25 3 baking tray
Pastry stripes 1) 250 + 250 145 25 1 + 3 baking tray
Flat cake 1) 1000 150 30 2 baking tray
Flat cake 1) 1000 + 1000 155 40 1 + 3 baking tray
Yeast cake with
apples 2000 170 - 180 40 - 50 3 baking tray
Apple pie 1200 + 1200 175 55 2 2 round alumi-
nized trays (di-
ameter: 20 cm)
on the same
shelf position
Small cakes 1) 500 155 30 2 baking tray
Small cakes 1) 500 + 500 155 40 1 + 3 baking tray
Fatless sponge
cake 1)
350 160 30 1 1 round alumi-
nized tray (diam-
eter: 26 cm)
Drip pan cake 1200 150 - 160 30 - 35 2) 2 baking tray
Chicken, whole 1400 180 55 2 wire shelf
1 baking tray
Pork roast 800 170 - 180 45 - 50 2 wire shelf
1 baking tray
www.zanussi.com 13

Food Quantity
(g) Tempera- ture (°C) Time (min) Shelf position Accessories
Stuffed yeast cake 1200 150 - 160 20 - 30 2 baking tray
Pizza 1000 + 1000 200 - 210 30 - 40 1 + 3 baking tray
Pizza 1000 190 - 200 25 - 35 2 baking tray
Cheese cake 2600 160 - 170 40 - 50 1 baking tray
Swiss apple flan 3) 1900 180 - 200 30 - 40 2 baking tray
Christmas cake 1) 2400 150 - 160 35 - 40 2) 2 baking tray
Quiche Lorraine 3) 1000 190 - 210 30 - 40 1 1 round tray (di-
ameter: 26 cm)
Peasant bread 4) 750 + 750 160 - 170 40 - 50 1 baking tray
Romanian sponge
cake 3)
600 + 600 155 - 165 40 - 50 2 2 aluminized
trays (length: 25
cm) on the
same shelf posi-
tion
Romanian sponge
cake - traditional 600 + 600 150 - 160 30 - 40 2 2 aluminized trays (length: 25
cm) on the
same shelf posi-
tion
Yeast buns 1) 800 190 15 3 baking tray
Yeast buns 5) 800 + 800 190 15 1 + 3 baking tray
Swiss roll 1) 500 150 - 160 15 - 20 3 baking tray
Meringue 400 110 - 120 30 - 40 2 baking tray
Meringue 400 + 400 110 - 120 45 - 55 1 + 3 baking tray
Crumble cake 1500 160 - 170 25 - 35 3 baking tray
Sponge cake 1) 600 150 - 160 25 - 35 2 baking tray
Buttered cake 1) 600 + 600 160 - 170 25 - 35 1 + 3 baking tray
1) Preheat the oven for 10 minutes.
2) After you switch off the appliance, leave the cake in the oven for 7 minutes.
3) Preheat the oven for 10 - 15 minutes.
4) Set the temperature for 250 °C and preheat the oven for 10 - 20 minutes.
5) Preheat the oven for 15 minutes.
14 www.zanussi.com

Light cooking
Food Quantity
(g) Tempera- ture (°C) Time (min) Shelf position Accessories
Pastry stripes 1) 250 150 - 160 20 - 25 2 baking tray
Flat cake 1) 500 160 - 170 35 - 40 2 baking tray
Pizza 1) 1000 200 - 210 30 - 40 2 baking tray
Swiss roll 1) 500 160 - 170 20 - 30 2 baking tray
Meringue 2) 400 110 - 120 50 - 60 2 baking tray
Sponge cake 1) 600 160 - 170 25 - 30 2 baking tray
Buttered cake 1) 600 160 - 170 25 - 30 2 baking tray
Chicken, whole 1200 220 - 230 45 - 55 2 wire shelf
1 baking tray
1) Set the temperature for 250 °C and preheat the oven for 20 minutes.
2) Set the temperature for 250 °C and preheat the oven for 10 minutes.
Pizza Setting
When you cook Pizza, for best
results turn the control knobs for
oven functions and oven
temperature to the Pizza position.
Oven - Care and cleaning
WARNING!
Refer to Safety chapters.
Notes on cleaning
• Clean the front of the appliance with a soft
cloth with warm water and a cleaning agent.
• To clean metal surfaces, use a dedicated
cleaning agent.
• Clean the appliance interior after each use.
Fat accumulation or other food remains may
result in a fire.
• Clean stubborn dirt with a special oven
cleaner.
• Clean all accessories after each use and let
them dry. Use a soft cloth with warm water
and a cleaning agent.
• If you have nonstick accessories, do not
clean them using aggressive agents, sharp-
edged objects or a dishwasher. It can cause
damage to the nonstick coating.
Stainless steel or aluminium appliances
Clean the oven door with a damp
cloth or sponge only. Dry it with a
soft cloth.
Do not use steel wool, acids or
abrasive materials as they can
damage the oven surface. Clean the
oven control panel with the same
precautions.
www.zanussi.com 15

Removing and installing the oven glass
panels
You can remove the internal glass panels to
clean it. The number of glass panels is different
for different models.
WARNING!
Keep the oven door slightly open
during the cleaning process. When
you open it fully it may accidentally
close causing potential damage.
WARNING!
Do not use the appliance without the
glass panels.
1. Open the door until it is at an angle of
approximately 30°. The door stands alone
when slightly open.
30°
2. Hold the door trim (B) at the top edge of
the door on both sides and push inwards to
release the clip seal.
2
B
1
3. Pull the door trim to the front to remove it.
WARNING!
When you take out the glass
panels the oven door tries to
close.
4. Hold the top edge of the door glass panels
and pull them up one by one.
5. Clean the glass panel with water and soap.
Dry the glass panel carefully.
When the cleaning is complete, install the glass
panels and the oven door. Do the above steps
in the opposite sequence. Install the smaller
panel first, then the larger.
CAUTION!
The screen with a printing on the
inner glass panel must face the inner
side of the door.
CAUTION!
Make sure that after installation the
surface of the frame of the glass
panel on the screen with a printing is
not rough when you touch it.
CAUTION!
Make sure that you install the
internal glass panel in the
appropriate seats.
Replacing the lamp
Put a cloth on the bottom of the interior of the
appliance. It prevents damage to the lamp glass
cover and the cavity.
WARNING!
Danger of electrocution! Disconnect
the fuse before you replace the
lamp.
The lamp and the lamp glass cover
can be hot.
1. Deactivate the appliance.
2. Remove the fuses from the fuse box or
deactivate the circuit breaker.
The back lamp
1. Turn the lamp glass cover counterclockwise
to remove it.
2. Clean the glass cover.
3. Replace the lamp with a halogen, 230 V, 40
W, 300 °C heat resistant lamp.
4. Install the glass cover.
16 www.zanussi.com

Troubleshooting
WARNING!
Refer to Safety chapters.
What to do if...
Problem Possible cause Remedy
You cannot activate the appli-
ance. The appliance is not connected to an electrical supply or it is
connected incorrectly.
Check if the appliance is correct-
ly connected to the electrical
supply.
You cannot activate or operate
the hob.
The oven does not heat up.
The fuse is blown. Make sure that the fuse is the
cause of the malfunction. If the
fuse is blown again and again,
contact a qualified electrician.
The oven / hob display shows an
error code that is not in this ta-
ble.
There is an electrical fault. Deactivate the appliance with the
house fuse or the safety switch in
the fuse box and activate it again.
If the display shows the error
code again, contact the Custom-
er Care Department.
You cannot activate or operate
the hob. The fuse is blown. Activate the hob again and set the heat setting in less than 10
seconds.
Residual heat indicator does not
come on. The zone is not hot because it operated only for a short time. If the zone operated sufficiently long to be hot, speak to an Au-
thorised Service Centre.
The lamp does not operate. The lamp is defective. Replace the lamp.
Steam and condensation settle
on the food and in the cavity of
the oven.
You left the dish in the oven for
too long. Do not leave the dishes in the oven for longer than 15 - 20 mi-
nutes after the cooking process
ends.
The oven does not heat up. The necessary settings are not
set. Make sure that the settings are correct.
It takes too long to cook the
dishes or they cook too quickly. The temperature is too low or too high. Adjust the temperature if neces- sary. Follow the advice in the
user manual.
Service data
If you cannot find a solution to the problem
yourself, contact your dealer or an Authorised
Service Centre.
The necessary data for the service centre is on
the rating plate. The rating plate is on the front
frame of the appliance cavity. Do not remove
the rating plate from the appliance cavity.
www.zanussi.com 17

We recommend that you write the data here:
Model (MOD.) .........................................
Product number (PNC) .........................................
Serial number (S.N.) .........................................
Installation
WARNING!
Refer to Safety chapters.
Location of the appliance
You can install your freestanding appliance with
cabinets on one or two sides and in the corner.
For minimal distances for fitting check the table.
A
C
B
Minimum distances
Dimension mm
A400
B650
C150
Technical data
Voltage 230 V
Frequency 50 Hz
Appliance class 1
Dimension mm
Height 858
Width 500
Depth 600
Levelling of the appliance
Use small feet on the bottom of appliance to set
the appliance top surface level with other
surfaces.
Anti-tilt protection
Set the correct height and area for the
appliance before you attach the anti-tilt
protection.
CAUTION!
Make sure you install the anti-tilt
protection at the correct height.
Make sure that the surface behind
the appliance is smooth.
You must install the anti-tilt protection. If you do
not install it, the appliance can tilt.
18 www.zanussi.com

Your appliance has the symbol shown on the
picture (if applicable) to remind you about the
installation of the anti-tilt protection.
1. Install the anti-tilt protection 317 - 322 mm
down from the top surface of the appliance
and 80 - 85 mm from the side of the
appliance into the circular hole on a
bracket. Screw it into the solid material or
use applicable reinforcement (wall).
80-85
mm
317-322
mm
2. You can find the hole on the left side at the
back of the appliance. Lift the front of the
appliance and put it in the middle of the
space between the cupboards. If the space
between the bench cupboards is larger
than the width of the appliance, you must
adjust the side measurement to centre the
appliance.
If you changed the dimensions of the
cooker, you must align the non-tip
device correctly.
CAUTION!
If the space between the bench
cupboards is larger than the width of
the appliance, you must adjust the
side measurement to the centre of
the appliance.
Electrical installation
WARNING!
The manufacturer is not responsible
if you do not follow the safety
precautions from Safety chapters.
This appliance is supplied without a main plug
or a main cable.
WARNING!
Before you connect the mains cable
to the terminal, measure the voltage
between phases in the house
network. Then, refer to the
connection label at the back of the
appliance to use the correct
electrical installation. This order of
steps prevents from installation
errors and damage to the electrical
components of the appliance.
Applicable types of cables for different phases:
Phase Min. size cable
1 3x6.0 mm²
3 with neutral 5x1.5 mm²
WARNING!
The power cable must not touch the
part of the appliance shaded in the
illustration.
www.zanussi.com 19

Energy efficiency
Product information for hob according to EU 66/2014
Model identifica-
tion ZCV55001WA ZCV55001XA
Type of hob Hob inside Freestanding Cooker
Number of cook-
ing zones 4
Heating technolo-
gy Radiant Heater
Diameter of circu-
lar cooking zones
(Ø)
Left rear
Right rear
Right front
Left front
14.0 cm
18.0 cm
14.0 cm
18.0 cm
Energy consump-
tion per cooking
zone (EC electric
cooking)
Left rear
Right rear
Right front
Left front
180.3 Wh/kg
179.4 Wh/kg
180.3 Wh/kg
179.4 Wh/kg
Energy consumption of the hob (EC electric hob) 179.9 Wh/kg
EN 60350-2 - Household electric cooking
appliances - Part 2: Hobs - Methods for
measuring performance.
Hob - Energy saving
You can save energy during everyday cooking if
you follow below hints.
• When you heat up water, use only the
amount you need.
• If it is possible, always put the lids on the
cookware.
• Before you activate the cooking zone put the
cookware on it.
• The cookware bottom should have the same
diameter as the cooking zone.
• Put the smaller cookware on the smaller
cooking zones.
• Put the cookware directly in the centre of the
cooking zone.
• Use the residual heat to keep the food warm
or to melt it.
Product Fiche and information for ovens according to EU 65-66/2014
Supplier's name Zanussi
Model identification ZCV55001WA
ZCV55001XA
Energy Efficiency Index 97.4
Energy efficiency class A
Energy consumption with a standard load, conventional mode 0.84 kWh/cycle
Energy consumption with a standard load, fan-forced mode 0.76 kWh/cycle
Number of cavities 1
20 www.zanussi.com