Andrew James Domestic Vacuum Sealer User manual

1
Please read the manual fully before using the appliance and keep the
manual safe for future reference.
Domesc Vacuum Sealer

2
Contents page
Important safeguards Page 3
Illustraon of funcons Page 5
Illustraon of operaon Page 6
Operang instrucons Page 7
Vacuum bag guidelines Page 8
Troubleshoong Page 10
Cleaning & maintenance Page 11
Disposal of the appliance Page 11
UK and EU Guarantee Page 12
Electrical informaon Page 12
Bags & rolls Page 14
Contact details Page 14

3
When using any electrical appliance, basic safety precauons should always be
followed, including:
 This appliance can be used by children aged from 8 years and above and
persons with reduced physical, sensory or mental capabilies or lack of
experience and knowledge if they have been given supervision or
instrucon concerning use of the appliance in a safe way and understand
the hazards involved. Children shall not play with the appliance. Cleaning
and user maintenance shall not be made by children unless they are older
than 8 and supervised. Keep the appliance and its cord out of reach of
children less than 8 years old.
 Always ensure the voltage on the rang label corresponds to the voltage in
your home.
 Check the power cord and plug regularly for any damage. If the cord or the
plug is damaged, it must be replaced by a qualied electrician or a service
repair centre. If in doubt please contact our customer service team.
 The appliance is intended for domesc use only. Industrial or commercial
use will void the warranty. The supplier cannot be held responsible for
injury or damage if the appliance has been used for anything other than its
intended use.
 Incorrect operaon and use can damage the appliance and cause injury to
the user.
 Do not use the appliance if it has been dropped or damaged in anyway. If
the unit has been damaged take the unit for examinaon and or repair by
and authorised service agent.
 Do not immerse or expose the motor assembly, plug or the power cord in
water or any other liquid for any reason.
 If the supply cord is damaged, it must be replaced by the manufacturer or
by someone who is suitably qualied to avoid a potenal hazard.
 Do not let the cord hang over the edge of a table or counter. Ensure that
the cord is not in a posion where it can be pulled or tripped over
accidentally.
 Do not allow the cord to touch hot surfaces and do not place the cord near
hot gas or electric burners or in a heated oven.
 Use of an extension cord with this appliance is not recommended.
However if it is necessary to use an extension cord, ensure that the
extension cord is equal to or greater than the power consumpon of the
appliance to avoid overheang of the appliance and extension cord. Do
not use any other appliance on the extension cord. Do not place the
Important safeguards

4
extension cord in a posion where it can be pulled on by children or animals
or be tripped over.
 Always operate the appliance on a smooth, even and stable surface. Do not
place the unit on a hot surface.
 Always remove the plug of the appliance safely. Do not pull on the
appliances cord to remove the appliance plug from the electrical socket.
 Never handle or operate the appliance with wet hands.

5
Illustraon of funcons
Funcons and features
Vacuum/Seal: This draws air out of the bag, and automacally switches to seal
the bag aer the vacuum is completed.
Seal only: Used to seal the bag without vacuum so that the vacuum can be
formed.
Cancel: Switches o the appliance and has a sealing acon whenever the
operator wants to stop the operaon.
Cover lock: Unlock or lock the cover. On the le side and right side of the cover.
Indicator lamp: To indicate the status of vacuum or seal process.
Sealing strip: Contains a heang wire covered with Teon, which allows the bag
to seal but not sck to the strip.
Sealing gasket: Presses the bag onto the sealing strip.
Vacuum surface: Draws air out of bag and catches any liquid that overows.
Airproof loop of sponge: Airproof the vacuum area.
1. 2.
34. 5.
1. Seal only
2. Indicator lamp (for seal)
3. Cancel
4. Indicator lamp
(for vacuum)
5. Vacuum/seal

6
Illustraon of operaon
1. Push the opening of the bag to the
boom of the air portal.
2. Press to Lock.
3. Press for release.
Fig 2.
Fig 1.
Fig 3.

7
Operang instrucons
Making a bag
1. Plug the unit into the power source.
2. Unroll the bag and put one end of the bag on top of the black rubber strip,
then close the cover (Fig 1).
3. Press the cover down on both sides by the line area using two hands, unl
two click sounds can be heard (Fig 2).
4. Press the “Seal Only” buon and the red LED will illuminate.
5. When the LED light disappears, the bag is sealed. Note, it will not make a
noise while sealing,
6. Pull out the bag roll and cut to your desired length. The bag is now ready.
Preserve food with vacuum:
1. Put the food that you want to preserve inside the bag.
2. Clean and straighten the open end of the bag, ensure there are no wrinkles
or ripples on the panels of the open ends.
3. Make sure that both panels of the bag are located within the rippled area
(vacuum plate) below the round post (vacuum pump hole), to prevent
leaking.
4. Close the cover and then press heavily on both sides of the cover in the lined
areas unl two click sounds can be heard.
5. Press the “vacuum/seal” buon, then the bag will be automacally
vacuumed and sealed.
6. Press the two side lock buons and the process is completed.
Hints for best vacuuming performance:
1. Do not put too much food inside the bag, leave enough empty space so the
operang process is not hindered.
2. Do not wet the open end of the bag. Wet bags may be dicult to melt and
seal ghtly.
3. Clean and straighten the open end of the bag before sealing the bags. Make
sure there are no wrinkles or creased lines on the open panels, as foreign
objects or creased bags may be dicult to ghtly seal.
4. Do not leave too much air inside the bag. Press the bag down to allow extra
air to escape from the bag before vacuuming it. Too much air inside the bag
increases the vacuum pump loading and may cause the motor to have
insucient power to draw away all the air inside the bag.
5. Do not vacuum seal objects with sharp points like sh bones and hard shells,

8
as sharp points may penetrate and tear the bag.
6. For the best sealing eect, it is best to let the appliance cool down for 1
minute before using it again.
7. Wipe o any excess liquid or food residue le on the Interface aer each bag
package.
8. If the vacuum has not been created, the vacuum system will shut
automacally aer 30 seconds. If this occurs please check if the bag has a
leak, or the bag was not placed properly on the appliance.
Open a sealed bag
 Cut the bag straight across with scissors, just inside of the seal.
Resealing
 You can reseal many foods in their original packaging (i.e. crisp packets)
follow steps of “Preserve food with Vacuum”.
 Note: The vacuum preservaon system can’t be directly used for the
vacuum sealing of the canisters or jars.
Vacuum bag guidelines
Vacuum sealing for the refrigerator
For the busy family, on-the-go meals can be prepared ahead and vacuum-sealed in
individual servings, ready to heat at any me.
Preparing food for the freezer
1. In properly stored condions, the vacuum sealer helps you to maintain the
foods freshness. Try to start with the freshest food possible.
2. Freeze foods which need to hold their shape or are fragile in nature, then
vacuum seal in a vacuum bag and return to freezer.
3. To vacuum seal liquid-based foods, such as soups, casseroles or stews, rst
freeze them in a baking pan or tempered dish. Next, vacuum seal, label and
stack in your freezer as soon as they are frozen solid.
4. Blanch the vegetables by cooking them briey in boiling water or
microwaving them. Then allow them to cool down, and vacuum seal in
convenient porons.
5. To vacuum seal the foods that are not frozen, allow two extra inches of bag
length to allow for expansion while freezing. Place the meat or sh on a

9
paper towel, and vacuum seal with the paper towel in the bag. This will help
to absorb moisture from the foods.
6. Before storing the foods such as torllas, crepes or hamburger paes, use
wax or parchment paper between them to stack the pieces. This makes it
convenient to remove some of the food, reseal the rest and immediately
place them in the freezer.

10
Nothing happens when
pressing the vacuum sealer
 Make sure the power cord is correctly plugged
into the electrical outlet and in the “on”
posion. Test electrical outlet by plugging in
another appliance, if it is not working, please
check the circuit breakers or fuses in your
home.
 Check power cord and plug, make sure they are
not damaged in any way. If damaged, do not
use the vacuum sealer.
Air is not removed from
the bag completely
 To seal properly, the open end of the bag
should be resng enrely inside the vacuum
channel area.
 Check the sealing strip and gasket beneath the
lid for debris and posion. Wipe clean and
smooth them back into place.
 The bag may have a hole. To test, seal the bag
with some air in it, submerge in water, and
apply pressure. If bubbles are present it is an
indicator that there is a leak and a new bag
should be used.
 Check if the lid is completely latched into place.
Vacuum sealer bag loses
vacuum aer being sealed.
 Wrinkles, crumbs, grease or liquids may cause
leaks along the seal. Reopen the bag, wipe the
top inside of the bag and smooth it out along
the sealing strip before resealing.
 Check if there is moisture or juices from the
food present within the bag, you may need to
cut open the bag and reseal it, or use an
enrely new bag. Foods with excess liquids
should be frozen before vacuum sealing.
 Items with sharp edges, may have punctured
the bag, and released the vacuum. Cushion
sharp edges in the contents of the bag with
paper towels.
Troubleshoong

11
Cleaning and maintenance
 Always unplug the unit before cleaning the appliance.
 Do not immerse it in water or any other liquid.
 Do not use abrasive cleaners to clean the unit, as they will scratch the
surface.
 Wipe the outside of the unit with a damp cloth or sponge and mild
detergent.
 To clean the inside of the unit, wipe away any food or liquid with a paper
towel
 Dry thoroughly before using it again.
Preserving the bags
 Wash the bags in warm water with a mild detergent, then rinse the bags
well and allow them to dry thoroughly before re-using them.
 Bags can be washed on the top rack in your dishwasher by turning the bags
inside out. Stand the bag up so the water can ow from inside of the bag.
Dry thoroughly before re-using.
Note: Bags used to store raw meats, sh or greasy foods can’t be re-used.
Storing your vacuum sealer:
Keep the unit in a at and safe place, out of the reach of children.
Disposal of the appliance
Please note that this Andrew James product is mark with this Symbol: This
means that this product must not be disposed of together with ordinary
household waste, as electrical and electronic waste must be disposed of
separately.
In accordance with the WEEE direcve, every member state must ensure correct
collecon, recovery, handling and recycling of electrical and electronic waste.
Private households in the E.U. can take used equipment to special recycling
staons free of charge. In certain member states used apparatus can be returned
to the dealer where they were bought on the condion you buy new products.
Contact your retailer, distributor or the municipal authories for further
informaon on what you should do with electrical and electronic waste.

12
UK and EU Guarantee
Your new Andrew James product comes with a 24 month guarantee and a 2 year
xed warranty, eecve from receipt conrmaon. Your receipt or order number is
required as proof of purchase date so it is imperave that you keep it safe. This
guarantee only applies if the item has been used solely for the use intended, and all
instrucons have been followed accordingly. Please note this product is only for
domesc use only and is not for commercial use.
Abuse of your product will invalidate the guarantee. Returned goods can only be
accepted if repackaged properly within the original colour product box, and
presented with the original receipt of sale/order number. This does not aect your
statutory rights.
Returned products must be cleaned and returned to us in as close to delivery
condion as possible.
If your product develops a problem within the rst 12 months of the xed
warranty, we will pay all shipping costs to have it returned to us. Aer 12 months
the customer will be liable for the cost of returning the product to us. We will then
pay to have the repaired/replaced item shipped back to the customer.
If you wish to return your item for a full refund, you have the right to do so within
the rst 7 days. For our returns policy please go to
www.andrewjamesworldwide.com
Customers are responsible for any taxes applied to our products when they are
shipped outside of the EU.
All of our prices are inclusive of VAT.
Once a product has been returned to us, we will aim to repair or replace it within
30 days of receipt.
The guarantee does not cover any defect arising from improper use, damage, build-
up of lime scale or repair aempts made by third-pares. Also, the guarantee does
not cover normal wear and tear of individual parts.

13
Electrical Plug Informaon
Please note:
It is extremely important that the wires or cores in the ex are connected to the
correct terminals in the plug. If the colour of the mains lead of the appliance does
not correspond with the coloured markings idenfying the terminals in your plug
proceed as follows:
 The Live (Brown) wire
connects to the right-
most live (L) terminal
nearest to the fuse.
 The Neutral (Blue) wire
connects to the le-
most neutral (N)
terminal.
 The Earth (Green and
Yellow) wire connects
to the central, top most
earthed (E) terminal.
Warning:
If the appliance is double insulated indicated by the double insulated symbol:
it should not have an earth wire or earth connecon.
Plug
The plug must be protected by the correct AMP fuse; this will be indicated on the
case of the plug. Only BSI or ASTA approved fuses should be used. When changing
the fuse always replace it with a fuse that is of the same idencal rang as the
original. If you are unsure about which plug or fuse to use, always refer to a
qualied electrician.

14
Please note aer replacing the fuse, ensure that the cover is correctly ed back
onto the plug. Never aempt to run the appliance if the plug does not have a cover.
If a moulded plug is ed and has to be removed take great care in disposing of the
plug and severed cable, it must be destroyed to prevent it from engaging into a
socket. If the supply cord is damaged it must be replaced by a service agent or a
similarly qualied person in order to avoid a hazard.
All of our electrical appliances conform to pre-exisng EC Direcves 2006/95/EC
(Low Voltage Direcve) and 2004/108/EC (EMC Direcves).
For further informaon please visit hp://www.esc.org.uk/industry/product-
safety/product-tesng-screening/kitchen-appliances/

15
Bags and Rolls
Your machine includes 10 bags 22cm X 30cm + 5 bags of 28cm X 40cm For
replacement bags and rolls please call us on 0844 335 8464 or purchase direct from
our website www.andrewjamesworldwide.com
Contact details
Andrew James UK LTD
Unit 1
P C Henderson Premises
Bowburn North Industrial Estate
Bowburn
Co Durham
DH6 5NG
Customer Service / Technical Support- Telephone [phone]
Customer Service/ Technical Support Email:
[e-mail]
Website: www.andrewjamesworldwide.com
Copyright Andrew James