Anvil TSI 7002 User manual

UNPACKING: Unpack the product and check for any damage incurred during
transit. This should be reported to the responsible carrier, railway or postal
authority, and a request for a damage report should be made
THESE INSTRUCTIONS MUST BE FOLLOWED FOR US
TO GUARANTEE OUR FULL SUPPORT OF YOUR CLAIM
FOR PROTECTING AGAINST LOSS FROM CONCEALED
DAMAGE. THE FORM FOR FILING SUCH A CLAIM WILL
BE PROVIDED BY THE CARRIER.

!
GENERAL INSTALLATION AND OPERATION
INSTRUCTIONS:
IT IS ESSENTIAL TO MAKE SURE THAT THE INCOMING
VOLTAGE IS THESAME AS THE RATED VOLTAGE OF THE
OF THE UNIT AS FOUND ON THE SERIAL PLATE. THE
SERIAL PLATE IS LOCATED AT THE REAR OF THE UNIT
ADJACENT TO THE INCOMING CABLE ENTRY.

!
INSTALLATION, OPERATION AND CARE OF :
TSI 7001 / TSI 8002
CONTACT GRILLERS
Page 1
The contact grillers are medium-duty electrical appliances capable of toasting
a variety of bread products and sandwiches. It can also be used to grill steaks
and various other meat products. The temperature is thermostatically controlled
between the range of 120° and 570°F. The thermostat also acts as the “ON”
and “OFF” switch. A signal lamp adjacent to the thermostat indicates when the
heating elements are energized.

Page 6
TSI 7001- CONTACT GRILLER DOUBLE
TSI 7001- CONTACT GRILLER SINGLE

Page 5

Page 2
1. Install the contact griller in the most convenient location for ease of
cleaning, maintenance and general operation. If the unit is to be
positioned in close proximity to a wall, partitions, kitchen furniture,
decorative nishes, etc. it is recommended that they be made of a
non-combustible material. If not, they shall be clad with a suitable non-
combustible heat insulating material, and the closest attention be paid
to re prevention regulations.
2. The appliance is equipped with a signal lamp to indicate when the
heating elements are energized.
3. Buttering both sides of the sandwich will prevent the sandwich from
sticking as well as giving a golden brown nish to the end product.
4. With use, plates of the toaster become “naturally” conditioned to create
a non-stick surface. Use of tinfoil or other coverings will not only
impede the conditioning process, but may also affect performance.
5. When the sandwich press is not in use, turn the temperature control to
the lowest temperature and ensure that the lid is kept open.
SPECIFIC INSTALLATION AND OPERATING INSTRUCTIONS:
TSI 7001 / TSI 8002 – CONTACT GRILLER
1. Before using the ,contact griller turn the control knob to 570°F. Close
the lid and allow the toaster to burn in for +/- 30 minutes. You will notice
smoke appearing due to the internal protective mill-board burning in.
This is normal.
2. After the 30 minute burning in time has elapsed, turn the sandwich
press down to operating temperature of +/- 390°F and grease plates
generously with butter or oil. Never allow excess fat or oil to build up as
this will result in build – up of carbon on the plates. This can be re
moved with a scraper or grill brick
CLEANING:
1. Always ensure that the contact griller is disconnected from the main
power supply before cleaning.
2. The contact griller should not be cleaned with a water jet or immersed
in water. Use only a damp cloth or sponge dipped in soapy water.

Page 3
3. Wipe off the contact griller with a dry cloth and wait at least half an hour
before re – connecting to the mains outlet.
4. A fat tray positioned at the front of the unit catches grease and
should be emptied periodically, depending on the usage of the griller.
SAFETY:
1. The units are designed to operate on alternating current only (A.C.).
DO NOT CONNECT TO DIRECT CURRENT (D.C.).
2. Care should be taken when operating the units as HOT SURFACES
are present which may cause burns.
3. Ensure that the power supply cord does not come into contact with hot
surfaces.
4. If the supply cord is damaged, it must be replaced with a new cord as
sembly available from the suppliers agent or directly from Anvil America
Inc.
MODEL DESCRIPTION VOLTS
V /Hz
POWER
WATTS
PLUG
TYPE
TSI 7001 CONTACT GRILLER
SINGLE
12O/60 1800 NEMA 5-15P
TSI 8002 CONTACT GRILLER
DOUBLE
220/60 3080 NEMA 6-15P
ELECTRICAL CONNECTION INFORMATION

Page 4

4-INS-TSI 7001

INSTRUCTION MANUAL
CONTACT GRILLER ELECTRIC
CONTACT GRILLER SINGLE
TSI 7001
CONTACT GRILLER DOUBLE
TSI 8002