Atlas Metal WCPT-3 User manual

Subsidiary of Mercury Aircraft, Inc.
1135 N.W. 159th DR., MIAMI, FL 33169
PHONE [phone], FAX [phone], E-mail: [e-mail]
PARTS LIST REFRIGERATED PASS THROUGH DISPLAY CASE
WCPT SERIES
WCPT-4
SHOWN
7
11
2
10
8
9
1
5
4
3
6
ITEM
NUMBER PART NUMBER DESCRIPTION
27-15 Door Set #3
1 27-20 Door Set #4
2 7002-0+Model # Vinyl Bead Gasket
3 6151-5 Pilaster
4 6151-2 Thumbscrew
5 6151-1 Snap-In Shelf Supports
6 81-7990 Plexiglass Light Cover (White)
27-17 Wire Shelf #3
7 27-16 Wire Shelf #4
8 1003-0 Power Cord
9 1069-1 Compressor Switch
10 2060-1 Condensing Water Evaporator
11 1800-4212 1/2 H.P. Compressor
12 2013-0 Fan Motor (Not Shown)
13 S81441-0 Fan Guard (Not Shown)
14 2014-5 Fan Blade (Not Shown)
15 600010 Expansion Valve
ITEM
NUMBER PART NUMBER DESCRIPTION
Evaporator Coil #3 (Not Shown)
16 2119-0 Evaporator Coil #4 (Not Shown)
17 113-10 Thermometer (Not Shown)
18 7019-2 Bulb Holder (Not Shown)
19 27-125 Light Switch (Not Shown)
20 1034-1 Ballast (Not Shown)
21 60-6056 Door Lock (Optional)
27-108 Mirror Door #3 (Optional)22
23 27-107 Mirror Door #4 (Optional)
27-123 Door Spring #3 (Not Shown)
24 27-122 Door Spring #4 (Not Shown)
27-124 Door Seal (Not Shown)
25 22-2040 Low Pressure Control (Not Shown)
26 22-2036 Bracket (Not Shown)
27 2024 Drier (Not Shown)
680-63 Door Roller
1149 Fan Motor Wire Harness

REFRIGERATED PASS THROUGH DISPLAY CASE
WCPT SERIES
--------------------------------------------------------------------------------------------------------------------------------------------------------------------
--------------------------------------------------------------------------------------------------------------------------------------------------------------------
INSTALLATION
Provide the correct counter cut-out opening (see chart below) and drop unit in. The vinyl gasket assures complete
seating. A non-toxic silicone sealer may be used between the gasket and counter top (not required).
MODEL CUT-OUT
REQUIRED
WCPT-3 22 1/4" X 41 3/4"
WCPT-4 22 1/4" X 55 1/2"
The unit should be level for draining purposes. When installing unit in counter, it is recommended that the operator
side of the counter be completely open for air circulation. When this is not possible, such as in an island counter, it
is recommended that two grill openings are provided approximately 18” x 18” of free air for intake and exhaust at
the opposite ends of counter. Also the counter must have an opening of approximately 24” x 14” to access the
compressor for maintenance. Then the refrigeration components can be reached by removing six (6) screws from
control and rear panels.
The unit is supplied with a power cord and NEMA plug. Refer to data plate on compressor housing for the
amperage and voltage information. Use a licensed electrician when installing power source.
For cleaning and maintenance of inside top evaporator coil a qualified refrigeration technician is recommended.
--------------------------------------------------------------------------------------------------------------------------------------------------------------------
--------------------------------------------------------------------------------------------------------------------------------------------------------------------
OPERATION
The unit is ready to be operated as soon as it is plugged in and switched on. The unit has been pre-tested for proper
operation from 35 to 40 degrees.
-------------------------------------------------------------------------------------------------------------------------------------------
---------------------------------------------------------------------------------------------------------------------------------------
MAINTENANCE
NEVER CLEAN THE UNIT WITH A CHLORIDE BASED PRODUCT. CHLORIDES OR IMPROPER
CLEANING COULD SCAR, MARK AND/OR CORRODE METAL. DO NOT USE STEEL WOOL OR
ABRASIVE PRODUCTS. TO CLEAN USE SOAPY WARM WATER, RINSE THOROUGHLY TO REMOVE
ALL RESIDUES. CLEAN CONDENSER COIL REGULARLY.
FAILURE TO MEET THESE CONDITIONS WILL VOID WARRANTY.

UNIT TYPE BTU / HR EVAPORATOR UNIT TYPE BTU / HR EVAPORATOR
TEMP. ( º F ) TEMP. ( º F )
1 WCM-1 600 6 33 WF-2 600 6
2 WCM-2 600 6 34 WF-3 1000 6
3 WCM-3 600 6 35 WF-4 1300 6
4 WCM-4 1000 6 36 WF-5 1300 6
5 WCM-5 1300 6 37 WF-6 2200 6
6 WCM-6 1300 6 38 RM-1 600 -4
7 WCMD-1 600 6 39 RM-2 920 -2
8 WCMD-2 600 6 40 RM-3 920 -2
9 WCMD-3 600 6 41 RM-4 1390 -2
10 WCMD-4 1000 6 42 RM-5 2430 -2
11 WCMD-5 1300 6 43 RM-6 2430 -2
12 WCMD-6 1300 6 44 RML-2 920 -2
13 WCMDC-1 600 6 45 RML-3 920 -2
14 WCMDC-2 600 6 46 RML-4 1390 -2
15 WCMDC-3 600 6 47 RB-4 3000 6
16 WCMDC-4 1000 6 48 RB-5 3000 6
17 WCMDC-5 1300 6 49 SU-4 4000 6
18 WCMDC-6 1300 6 50 SU-5 4000 6
19 WCML-2 600 6 51 SU-6 4000 6
20 WCML-3 600 6 52 WCMBT-3 1000 6
21 WCML-4 1000 6 53 WCMBT-4 1300 6
22 WCMDL-2 600 6 54 WCMBT-5 1300 6
23 WCMDL-3 600 6 55 WCMBT-6 1300 6
24 WCMDL-4 1000 6 56 WCMHP-2 600 6
25 WCMDCL-2 600 6 57 WCMHP-3 600 6
26 WCMDCL-3 600 6 58 WCMHP-4 1000 6
27 WCMDCL-4 1000 6 59 WCMHP-5 1300 6
28 WDFL 600 -12 60 WCMHP-6 1300 6
29 WDF-2 1000 -12 61 RMHP-2 920 -2
30 WDF-3 1000 -12 62 RMHP-3 920 -2
31 WCPT-3 6000 26 63 RMHP-4 1390 -2
32 WCPT-4 6000 26 64 RMHP-5 2430 -2
65 RMHP-6 2430 -2
REFRIGERATION PRODUCTS BTU-HR EVAP TEMP.xls
TABLE # 1