Backyard GBC1870W-C User manual

.
Natural gas conversion kit (model no.
VFK1702W-C) available at Walmart or
www.Walmart.ca
OWNER’S MANUAL
Table of Contents
Important Safeguard s.................... Page 2
Limited Warranty ........................... 5
Expanded View & Hardware ................. 6 &7
Assembly Instructions........................ 8
Installing LP Gas Tank....................... 15
Installing Natural Gas Line ....................15
Operating Instructions....................... 16
Cleaning and Care ......................... 19
Troubleshooting ........................... 21
The use and installation must conform with local
codes or, in the absence of local codes, with either the
National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural
Gas and Propane Installation Code, CSA B149.1, or
Propane Storage and Handling Code, B149.2, or the
Standard for Recreational Vehicles, ANSI A 119.2/NFPA
1192, and CSA Z240 RV Series, Recreational Vehicle
Code, as applicable.
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT
SAFETY INFORMATION. PLEASE READ AND KEEP FOR
FUTURE REFERENCE.
If you are assembling this unit for someone else, give
this manual to him or her to read and save for future
reference.
Outdoor LP Gas Barbecue Grill
.
Manufactured in China for: RevoAce Inc. Limited
Hong Kong, China
1.800.694.0013 • [email protected]
8:00 am to 5:00 pm central time, Monday to Friday.
.
WARNING
FOR YOUR SAFETY:
1. Do NOT store or use gasoline or
other flammable liquids or vapors in
the vicinity of this or any other
appliance.
2. An LP cylinder not connected for
use shall not be stored in the vicinity
of this or any other appliance.
DANGER
Never operate this appliance
unattended.
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only! (outside any enclosure)
DANGER
If you smell gas -
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from
the appliance, immediately call your
gas supplier or your fire department.
Failure to follow these instructions
could result in fire or explosion
which could cause property damage,
personal injury or death.
GBC1870W-C-OM-EF-F101
Model No. GBC1870W-C

2
FOR YOUR SAFETY
WWARNINGS:
1. Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.
2. Read the installation, operation, and maintenance instructions thoroughly before installing or servicing this
equipment.
3. Failure to follow these instructions could result in fire or explosion, which could cause property damage,
personal injury, or death.
4. This instruction manual contains Important information necessary for the proper assembly and safe use of
the appliance.
5. Read and follow all warnings and instructions before assembling and using the appliance.
6. Follow all warnings and instructions when using the appliance.
7. Keep this manual for future reference.
IMPORTANT SAFEGUARDS
WDANGER: Failure to follow the dangers, warnings and cautions in this manual may result in serious
bodily injury or death, or in a fire or an explosion causing damage to property.
WWARNINGS:
WThis grill is for outdoor use only, and should not be
used in a building, garage or any other enclosed
area.
WDo NOT operate, light or use this appliance within
ten feet (3.05 m) of walls, structures or buildings.
WFor residential use only. This grill is NOT for
commercial use.
WThis grill is not intended for and should never be
used as a heater. TOXIC fumes can accumulate and
cause asphyxiation.
WThis grill is safety certified for use in the United
States and/or Canada only. Do NOT modify for use
in any other location. Modification will result in a
safety hazard and will void your warranty.
WThis grill, from the factory, is for use with liquid
propane (LP) gas only. The conversion to or
attempted use of natural gas in this LP gas grill is
dangerous, may cause bodily harm and will void
your warranty.
WThis grill, from the factory, is for use with LP gas.
The natural gas conversion kit model number
VFK1702W-C may be used to convert your grill to
natural gas. The use of any other conversion kit is
dangerous, may cause bodily harm and will void
your warranty.
WLP gas characteristics:
a. LP gas is flammable and hazardous if
handled improperly. Become aware of the
characteristics before using any LP gas
product.
b. LP gas is explosive under pressure, heavier
than air, and settles/pools in low areas.
c. LP gas in its natural state has no odor. For your
safety, an odorant is added that smells like
rotten cabbage.
d. Contact with LP gas can cause freeze burns to
skin.
WNatural gas (NG) characteristics:
a. NG is flammable and hazardous if
handled improperly. Become aware of the
characteristics before using any NG product.
b. NG is explosive under pressure, heavier than air,
and settles/pools in low areas.
c. NG in its natural state has no odor. For your
safety, an odorant is added that smells like
rotten cabbage.
d. Contact with NG can cause freeze burns to skin.
WApartment dwellers: Check with management to
learn the requirements and fire codes for using a
LP gas grill in your apartment complex. If allowed,
use outside on the ground floor with a ten foot
(3.05 m) clearance from any structure. Do NOT use
on or under balconies.
WLP gas cylinder needed to operate. Only cylinders
marked “propane” may be used.
WThe LP gas cylinder must be constructed and
marked in accordance with the Specifications
for LP-gas Cylinders of the U.S. Department of
Transportation (D.O.T.) or the National Standard of
Canada, CAN/CSA-B339, Cylinders, Spheres and
Tubes for the Transportation of Dangerous Goods;
and Commission.
WLP gas cylinder must be arranged for vapor
withdrawal.

3
IMPORTANT SAFEGUARDS
WThe LP gas cylinder must have a listed overfilling prevention device (OPD).
WOnly use LP gas cylinders equipped with a cylinder connection device compatible with the connection for
outdoor cooking appliances.
WThe LP gas cylinder must have a cylinder collar to protect the cylinder valve.
WNever use a LP gas cylinder with a damaged body, valve, collar or footing.
WDented or rusted LP gas cylinders may be hazardous and should be checked by your LP gas supplier prior to
use.
WThe LP gas cylinder should not be dropped or handled roughly.
WLP gas cylinders must be stored outdoors out of the reach of children and must not be stored in a building,
garage or any other enclosed area. Your cylinder must never be stored where temperatures can reach over
125°F.
WDo NOT insert any tool or foreign object into the valve outlet or safety relief valve. You may damage the valve
and cause a leak. Leaking propane may result in an explosion, fire, severe personal injury or death.
WDo NOT block holes in sides or back of grill.
WNever keep an LP gas cylinder in a hot car or trunk. Heat will cause the gas pressure to increase, which may
open the relief valve and allow gas to escape.
WPlace dust cap on cylinder valve outlet whenever the cylinder is not in use. Only install the type of dust cap
on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in
leakage of propane.
WIf grill is not in use, the gas must be turned off at the supply cylinder and disconnected.
WDo NOT store a spare LP gas cylinder under or near this appliance.
WNever fill the cylinder beyond 80 percent full.
WA fire causing serious injury or damage to property may occur if the above is not followed exactly.
WNever attempt to attach this grill to the self-contained LP gas system of a camper trailer, motor home or
house.
WNever use charcoal, lighter fluid, lava rocks, gasoline, kerosene or alcohol with this product.
WYour grill has been checked at all factory connections for leaks. Recheck all connections as described in the
“Operating Instructions” section, as shipping can loosen connections.
WCheck for leaks even if your unit was assembled for you by someone else.
WDo NOT operate if a gas leak is present. Gas leaks may cause a fire or explosion.
WYou must follow all instructions in “Checking for Leaks” section before operating. To prevent fire or explosion
hazard when testing for a leak:
a. Always perform a leak test before lighting the grill and each time the cylinder is connected for use.
b. No smoking. Do NOT use or permit sources of ignition in the area while conducting a leak test.
c. Conduct the leak test outdoors in a well-ventilated area.
d. Do NOT use matches, lighters, or a flame to check for leaks.
e. The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly
assemble or safely operate the appliance.
f. Strong odors, colds, sinus congestion, etc. may prevent the detection of propane. Use caution and
common sense when testing for leaks.
g. Do NOT use grill until any and all leaks are corrected.
LP: If you are unable to stop a leak, disconnect the LP gas supply. Call a gas appliance serviceman or
your local LP gas supplier.
NG: If you are unable to stop a leak, turn off the main valve on the NG supply line. Call a gas appliance
serviceman or your local NG supplier.

4
IMPORTANT SAFEGUARDS
WNG: The appliance and its individual shutoff valve must be disconnected from the gas supply piping system
during any pressure testing of that system at pressure in excess of ½ psig (3.5 kpa).
WNG: The appliance must be isolated from the gas supply piping system by closing its individual manual
shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less
than ½ psig (3.5 kpa).
WThis grill is designed to operate at an inlet pressure of: LP gas: 11 inches water column; NG: 7 inches water
column.
WDo NOT store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance.
WDo NOT use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline
and other flammable vapors and liquids.
WMinimum clearance from sides and back of unit to combustible construction is 36 inches (91.4 cm). Do NOT
use this appliance under any type of overhang or roof.
WIt is essential to keep the grill’s valve compartment, burners and circulating air passages clean.
WInspect grill before each use.
WDo NOT alter grill in any manner. Any alteration will void your warranty.
WDo NOT use the grill unless it is COMPLETELY assembled and all parts are securely fastened and tightened.
WDo NOT build this model of grill in any built-in or slide-in construction. Ignoring this warning could cause a
fire or an explosion that can damage property and cause serious bodily injury or death.
WThis grill should be thoroughly cleaned and inspected on a regular basis.
WClean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts or
leaks, the hose must be replaced prior to operation.
WUse only the regulator and hose assembly provided. Use only the replacement regulator and hose assembly
specified by RevoAce Inc. Limited.
WUse only RevoAce Inc. Limited factory-authorized parts. The use of any part that is not factory-authorized can
be dangerous and will void your warranty.
WDo NOT operate this appliance without reading “Operating Instructions” in this manual.
WDo NOT touch metal parts of grill until they have completely cooled (about 45 min.) to avoid burns, unless you
are wearing protective gear (pot holders, gloves, BBQ mittens, etc.).
WDo NOT install or use in or on boats or recreational vehicles.
WWhen cooking, fire extinguishing materials should be readily accessible. In the event of an oil/grease fire, do
NOT attempt to extinguish with water. Use type BC dry chemical fire extinguisher or smother with dirt, sand
or baking soda.
WDo NOT use grill in high winds.
WNever lean over the grill when lighting.
WDo NOT leave a lit grill unattended. Keep children and pets away from grill at all times.
WDo NOT leave grill unattended while preheating or burning off food residue on high. If grill has not been
cleaned, a grease fire can occur that may damage the product.
WDo NOT place empty cooking vessels on the appliance while in operation.
WUse caution when placing anything on the grill while the appliance is in operation.
WDo NOT attempt to move grill when in use. Allow the grill to cool before moving or storing.
WLP gas cylinder must be properly disconnected and removed prior to moving this grill.
WStorage of grill indoors is permissible only if the cylinder is disconnected, removed from the grill and properly
stored outdoors.
WAlways open grill lid carefully and slowly as heat and steam trapped within grill can cause severe burns.
WDo NOT attempt to disconnect the gas regulator from the cylinder or any gas fitting while the grill is in use.

5
Limited Warranty
RevoAce Inc. Limited (“RA”) warrants to the original retail purchaser of this product, and to no other person, that if
this product is assembled, maintained, and operated in accordance with the printed instructions accompanying it,
then for a period of one (1) year for all remaining parts from the date of purchase, all parts in such product shall be
free from defects in material and workmanship. RA may require reasonable proof of your date of purchase. Therefore,
you should retain your sales slip or invoice. This Limited Warranty shall be limited to the repair or replacement of
parts, which prove defective under normal use and service and which RA shall determine in its reasonable discretion
upon examination to be defective. Before returning any parts, you should contact RA’s Customer Care Department
using the contact information listed below. If RA conforms, after examination, a defect covered by this Limited
Warranty in any returned part, and if RA approves the claim, RA will replace such defective part without charge. If
you return defective parts, transportation charges must be prepaid by you. RA will return replacement parts to the
original retail purchaser, freight or postage prepaid. This Limited Warranty does not cover any failures or operating
difficulties due to accident, abuse, misuse, alteration, misapplication, improper installation or improper maintenance
or service by you or any third party, or failure to perform normal and routine maintenance on the product as set out in
this owner’s manual. In addition, the Limited Warranty does not cover damage to the finish, such as scratches, dents,
discoloration, rust or other weather damage, after purchase.
This Limited Warranty is in lieu of all other express warranties. RA disclaims all warranties for products that are
purchased from sellers other than authorized retailers or distributors, including the warranty of merchantability or the
warranty of fitness for a particular purpose. RA ALSO DISCLAIMS ANY AND ALL IMPLIED WARRANTIES, INCLUDING
WITHOUT LIMITATION THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE.
RA SHALL HAVE NO LIABILITY TO PURCHASER OR ANY THIRD PARTY FOR ANY SPECIAL, INDIRECT, PUNITIVE,
INCIDENTAL, OR CONSEQUENTIAL DAMAGES. RA further disclaims any implied or express warranty of, and assumes
no responsibility for, defects in workmanship caused by third parties. This Limited Warranty gives the purchaser
specific legal rights; a purchaser may have other rights depending upon where he or she lives. Some jurisdictions
do not allow the exclusion or limitation of special, incidental or consequential damages, or limitations on how long a
warranty lasts, so the above exclusion and limitations may not apply to everyone. RA does not authorize any person or
company to assume for it any other obligation or liability in connection with the sale, installation, use, removal, return,
or replacement of its equipment, and no such representations are binding on RA.
Manufactured in China for: RevoAce Inc. Limited
Hong Kong, China
1.800.694.0013 • [email protected]
8:00 am to 5:00 pm central time, Monday to Friday.
IMPORTANT SAFEGUARDS
WAlways place your grill on a hard, non-combustible, level surface. An asphalt or blacktop surface may not be
acceptable for this purpose.
WMove gas hoses as far away as possible from hot surfaces and dripping hot grease.
WKeep all electrical cords away from a hot grill.
WAfter a period of storage and/or nonuse, check for leaks, burner obstructions and inspect for any abrasion,
wear or cuts to the hose.
WFailure to open lid while igniting the grill’s burners, or not waiting 5 minutes to allow the gas to clear if the
grill does not light, may result in an explosive flame-up.
WNever operate grill without its heat plates installed.
WAlways use a meat thermometer to ensure food is cooked to a safe temperature.
WUse protective gloves when assembling this product.
WDo NOT force parts together as this can result in personal injury or damage to the product.
WNever cover entire cooking area with aluminum foil.
WDeath, serious injury or damage to property may occur if the above is not followed exactly.

6
Expanded View
1
3
9
5
10
8
2
7
6
22
4
12
27
28
17
20
14
21
22
24 29
18
19
26
25
33
34
32 30
31
36
37
38
41
11
16
15
13
14
15
23
27
32
28 35
39
40

7
1Warming Rack G1255-010
2Cooking Grid (3) G1870-020
3Temperature Gauge B0104-C01
4Temperature Gauge Seat G1870-060
5Lid Handle G1748-040
6Lid Handle Seat (2) G1748-030
7Lid* G1870-070
8Heat Plate-A (4) B0212-A03
9Grill Body Assembly* G1870-100
10 Infrared Sear Burner* G1870-120
11 Main Burner (4)* G1870-110
12 Light Assembly* G1870-180
13 Grill Light Button* G1870-190
14 Control Knob Bezel (5)* G1650-200
15 Control Knob (6) G1870-210
16 Infrared Control Knob Bezel*
G1650-410
17 Regulator/Hose Assembly* G1870-220
18 Side Burner G1461-140
19 Side Burner Grid B0222-C01
20 Right Side Shelf G1870-230
21 Left Side Shelf G1870-150
22 Grease Tray G1143-240
23 Grease Cup B0219-H01
24
Left Cart Frame
G1870-270
25
Rear Cart Frame
G1870-290
26
Right Cart Frame
G1870-230
27 LP Gas Tank Blocking Wire (2) G1870-280
28 Magnet (4)* B0303-C01
29 Upper Front Frame Support G1870-260
30 LP Gas Tank Retainer Wire G1870-330
31 Bottom Shelf G1870-340
32 Door Handle (2) G1870-310
33 Left Door G1870-320
34 Lower Front Frame Support G1870-350
35 Lighting Rod* B0122-B01
36 Right Door G1870-400
37 Locking Caster (2) B0302-A01
38 Caster (2) B0302-B01
39 Heat Plate-B G1870-170
40 Bottle Opener* G1650-090
41 Battery Box G1870-170
* Pre-assembled
Hardware
Tools Required for Assembly (Included)
Parts List
#2 Phillips Head Screwdriver 1 pc M10-M6 Wrench 1 pc
AScrew M4x10 Nickel Plated Phillips Truss Head 4 pcs
BScrew M6x15 Nickel Plated Phillips Truss Head 22 pcs
CScrew M6x25 Nickel Plated Phillips Truss Head 2 pcs
DScrew M4x12 Nickel Plated Phillips Hex Head 12 pcs
EBolt M6x16 Nickel Plated Hex Head 8 pcs
FWing Nut M6 Nickel Plated 4 pcs
GWasher ø6.2 Nickel Plated 24 pcs
HLock
Washer ø6.5 Nickel Plated 20 pcs
ICotter Pin ø1.4 Nickel Plated 2 pcs
JAA
Batteries 4 pcs

8 Assembly Instructions
12
Please have your owner’s manual and model number available
for reference.
For Easiest Assembly:
1. Select an area where you will assemble this product. To
protect components, choose a smooth surface that’s free
of cracks or openings.
2. Spread out all parts.
3. Tighten all hardware connections by hand first. Then,
before completing each step, go back and fully tighten
all hardware. Be careful not to overtighten. That could
damage surfaces or strip threads.
4. For best results, complete each step in the order
presented.
To complete assembly you will need:
• One bag of charcoal (not included)
Typical assembly is approximately one hour.
DO NOT RETURN TO PLACE OF PURCHASE.
Attach Casters
4
Attach Left & Right Cart Frame
3
Attach Lower Front Frame Support
Note: Locking casters go in the back.
G
B
HB
Bx 6
Gx 6
Hx 6
Bx 2

9
Attach Rear Cart Frame
5
Attach Upper Front Frame Support
6
8
Attach LP Gas Tank Retainer Wire
7
Attach LP Gas Tank Blocking Wire
I
H
BB
G
H
Bx 4
Gx 4
Hx 4 Bx 4
Gx 4
Hx 4
Ix 2
G

10
10
Attach Door Handle
9
12
11
Attach Doors
Attach Temperature Gauge Attach Grill Body Assembly
GF
Gx 4
Fx 4
B
G
Dx 12
D
H
Bx 4
Gx 4
Hx 4

11
B
EE
Attach Left Side Shelf
13 14
Attach Right Side Shelf
Secure Right Side Shelf
1615
Secure Left Side Shelf
EE
B
Note: Leave 5 mm of bolt threads exposed.
Ex 2 Ex 2
E
Note: Leave 5 mm of bolt threads exposed.
E
B
Bx 1 Ex 2 Ex 2
Bx 1
1
3
2
E
B
E

12
Insert Side Burner, Side Burner Grid and Igniter Wire
1817
Attach Side Burner Valve and Control Knob Bezel
Attach Control Knobs
19
Attach Lid Handle
20
A
G
1
2
3
Ax 2
A
H
C
Ax 2
Cx 2
Gx 2 Hx 2

13
Insert Cooking Grid and Heat Plate
2221
Insert Grease tray and Grease cup
Insert Warming Rack
23
Insert AA Batteries
24
Jx 4

14
25
Insert and Connect Battery Box
Natural gas conversion kit (model no.
VFK1702W-C) available at Walmart or
www.Walmart.ca

15 Installing LP Gas Tank
To operate, you will need one precision-filled standard grill LP gas tank with external valve threads.
20 lb
9 Kg
17.9 in. / 45.5 cm
12.2 in. / 31 cm
Securing LP Gas Tank
Secure tank by sliding the tank retainer wire over shoulder of LP gas
tank.
Inserting LP Gas Tank
Place precision-filled LP gas tank upright into the notches in the right
cart frame so the tank valve is facing the gas line connection.
Connecting LP Gas Tank
1. Before connecting, be sure
there is no debris caught in
the head of the LP gas tank,
head of the regulator valve or
in the head of the burner or
burner ports.
2. Connect regulator/hose
assembly to tank by turning
knob clockwise until it stops.
Disconnecting LP Gas
Tank
1. Before disconnecting, make
sure the LP gas tank valve is
“CLOSED.”
2. Disconnect regulator/
hose assembly from LP
gas tank by turning knob
counterclockwise until it is
loose.
WCAUTION: LP gas tank must be properly
disconnected and removed prior to moving this
grill.
3. Place the protective cap cover on the LP tank and store the tank
outdoors in a well ventilated area out of direct sunlight.
.
W: LP gas tank must be properly disconnected and
removed prior to moving this grill.
Caution
Getting More Propane
Need a tank of gas? One option is to try propane exchange. It’s
easy, fast, safe, and available at tens of thousands of conveniently
located retail outlets nationwide, which are typically open nights
and weekends. You can purchase a fresh, precision-filled tank or
exchange your empty for a fresh, precision-filled tank. Another option
is to have your tank refilled at a refill station. Be sure to check the
hours of operation for the refill station.
Installing Natural Gas Line
Installation should be done by a qualified service person.
WCAUTION: If young children are in the area, a locking valve should be
considered.
Connecting Natural Gas Line
1. Before connecting, be sure there is no debris caught in the head of the natural gas line, head of the
grill natural gas line or in the head of the burner or burner ports.
2. Connect grill natural gas line to natural main gas line.
Disconnecting Natural Gas Line
1. Before disconnecting, make sure the natural gas main line valve is “OFF.”
2. Disconnect grill natural gas line from natural gas main line.
X
X

16
Operating Instructions
Checking for Leaks
Burner Connections
1. Make sure the regulator hose and valve connections are securely fastened to the burner and the
tank.
2. Visually check the connection between the burner/venturi tube and orifice.
3. Make sure the burner/venturi tube fits over the orifice.
WWARNING: Failure to inspect this connection or follow these instructions
could cause a fire or an explosion which can cause death, serious bodily
injury or damage to property.
4. Please refer to diagram for proper installation (Figure 1).
5. If the burner/venturi tube does not rest flush to the orifice, as shown, please contact
1.800.694.0013 for assistance.
Tank/Gas Line Connection
1. Make 2-3 oz. of leak detection solution by mixing one part liquid dishwashing soap with three
parts water.
2. Make sure control knobs are in the “ OFF” position (Figure 2).
3. LP: Connect LP gas tank per “Installing LP Gas Tank” section.
NG: Connect NG main line per “Installing Natural Gas Line” section.
4. LP: Turn LP gas tank valve to “OPEN.”
NG: Turn “ON” natural gas main valve.
5. Spoon several drops of solution, or use a squirt bottle, at all “X” locations (Figures 1 and 3).
a. LP: If any bubbles appear, turn LP gas tank valve to “CLOSED,” reconnect and re-test.
NG: If any bubbles appear, turn natural gas main valve “OFF,” reconnect and re-test.
b. LP: If you continue to see bubbles after several attempts, turn LP gas tank valve to “CLOSED”
and disconnect LP gas tank, per “Disconnect LP Gas Tank” section. Contact 1.800.694.0013 for
assistance.
NG: If you continue to see bubbles after several attempts, turn natural gas main valve to “OFF.”
Disconnect natural gas line and contact 1.800.694.0013 for assistance.
c. LP: If no bubbles appear after one minute, turn LP gas tank valve to “CLOSED,” wipe away
solution and proceed.
NG: If no bubbles appear after one minute, turn natural gas main valve to “OFF,” wipe away
solution and proceed.
First Use
1. Make sure all labels, packaging and protective films have been removed from the grill.
2. Remove manufacturing oils before cooking on this grill for the first time by operating the grill for
at least 15 minutes on (HIGH) with the lid closed. This will “heat clean” the internal parts and
dissipate odors. Figure 4
X
XX
XX
Operating Main Burners
Lighting
WCAUTION: Keep outdoor gas cooking appliance area clear and free from
combustible materials, gasoline and other flammable vapors and liquids.
WCAUTION: Do NOT obstruct the flow of combustion and ventilation air.
WCAUTION: Check and clean burner/venturi tubes for insects and insect nests.
A clogged tube can lead to a fire.
WCAUTION: Attempting to light the burner with the lid closed may cause an
explosion.
1. Open lid.
2. Check for obstructions of airflow to the burners. Spiders, insects and webs can clog the burner/venturi tube. A clogged burner tube can
lead to a fire.
3. All control knobs must be in the “ OFF” position (Figure 2).
4. LP: Connect LP gas tank per “Installing LP Gas Tank” section.
NG: Connect NG main line per “Installing Natural Gas Line” section.
Figure 1：Main Burners
Burner/
Venturi Tube
LP Gas Valve
with Orifice
LP Gas
Connection
Figure 2: Side Burner
LP Gas
Connection
Valve Soft Pipe
Connection
LP Gas Valve
with Orifice
Burner/
Venturi Tube
Figure 3

17 Operating Instructions (Continued)
5. LP: Turn LP gas tank valve to “OPEN.”
NG: Turn natural gas main valve to “ON.”
6. Push and turn any control knob to (HIGH). The burner should light. If it does not, repeat up to
three times.
7. If ignition does not occur in 5 seconds, turn burner control knob “ OFF,” wait 5 minutes, and
repeat lighting procedure.
8. If igniter does not light burner, use a lit match secured with the Lighting Rod (included with grill) to
light burners. Access the burners through the cooking grid and heat plates. Position lit match near
side of burner (Figure 5).
Important: Always use the Lighting Rod (included) when lighting burners with a match.
9. After lighting, observe the burner flame. Make sure all burner ports are lit and flame height
matches illustration (Figure 6).
Note: Each burner lights independently - repeat steps 5-9 for the other burners.
Burner
Flame Slight
Yellow
Slight
Blue
Dark
Blue
Figure 6
Figure 5
Lighting Hook
Match
WCAUTION: If burner flame goes out during operation, immediately turn the
control knobs to the “ OFF” position
(a) LP gas tank valve “CLOSED” or
(b) NG main valve “OFF”
and open lid to let the gas clear for 5 minutes before re-lighting.
Turning Off
1. LP: Turn LP gas tank valve to “CLOSED.”
NG: Turn natural gas main valve to “OFF.”
2. Turn all control knobs clockwise to the “ OFF” position.
Note: A “poof” sound is normal as the last of the LP gas is burned.
3. LP: Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
NG: Keep NG main gas line connected.
Controlling Flare-ups
WCAUTION: Putting out grease fires by only closing the lid is not possible.
1. If a grease fire develops, turn control knobs to the “ OFF” position
(a) LP gas tank valve “CLOSED” or
(b) NG main valve “OFF”
Do NOT use water on a grease fire. This can cause the grease to splatter and could result in serious
burns, bodily harm or other damage.
2. Do NOT leave grill unattended while preheating or burning off food residue on (HIGH). If grill has not
been cleaned, a grease fire can occur.
WWARNING: When cooking, fire extinguishing materials should be readily accessible. In the event of an oil/
grease fire, use type BC dry chemical fire extinguisher or smother with dirt, sand or baking soda. Do NOT
attempt to extinguish with water.
Flare-ups are a part of cooking meats on a grill and add to the unique flavor of grilling.
Excessive flare-ups can over-cook your food and be dangerous.
Important: Excessive flare-ups result from the build-up of grease in the bottom of your grill.
If a grease fire occurs, close the lid AND turn the control knob(s) to “ OFF” until the grease burns out. Be careful when opening the lid as
sudden flare-ups may occur.
If excessive flare-ups occur, do NOT pour water onto the flames.
Minimize Flare-ups:
1. Trim excess fat from meats prior to cooking.
2. Cook high fat content meats on (LOW) setting or indirectly.
3. Ensure that your grill is on a hard, level, non-combustible surface and the grease is allowed to drain into grease receptacle.
Operating Side Burner
Note: Side burner can be used while main burners are operating.
Never use side burner as a grill.
WCAUTION: Maximum weight for side burner and side shelf is 33 lbs.
WCAUTION: Using pots larger than 6 quarts in capacity could exceed weight limit of the side burner shelf,
resulting in failure of grill cart components.

18
Figure 8
Figure 9
Operating Instructions (Continued)
WCAUTION: Do NOT lean on the side burner shelf.
WCAUTION: Attempting to light the burner with the lid closed may cause an explosion.
Lighting
1. Open lid.
2. Check for obstructions of airflow to the burners. Spiders, insects and webs can clog the burner/venturi tube. A clogged burner tube can
lead to a fire.
3. Control knob must be in the “ OFF” position
(Figure 3).
4. LP: Connect LP gas tank per “Installing LP Gas Tank” section.
NG: Connect NG main line per “Installing Natural Gas Line” section.
5. LP: Turn LP gas tank valve to “OPEN.”
NG: Turn natural gas main valve to “ON.”
6. Push and turn control knob to (HIGH). The burner should light. If not, repeat up to three times.
7. If ignition does not occur in 5 seconds, turn burner control knob “ OFF,” wait 5 minutes and repeat lighting procedure.
8. If igniter does not light burner, use a lit match secured with the Lighting Rod (included with grill) to light burners. Position the lit match near
side of the burner (Figure 7).
Important: Always use the Lighting Rod (included) when lighting burner with a match.
9. After lighting, observe the burner flame. Make sure all burner ports are lit and flame height matches illustration (Figure 6).
WCAUTION: If burner flame goes out during operation, immediately turn the control knob to the “ OFF”
position
(a) LP gas tank valve “CLOSED” or
(b) NG main valve “OFF”
and open lid to let the gas clear for 5 minutes before re-lighting.
Turning Off
1. LP: Turn LP gas tank valve to “CLOSED.”
NG: Turn natural gas main valve to “OFF.”
2. Turn control knob clockwise to the “ OFF” position.
Note: A “poof” sound is normal as the last of the LP gas is burned.
3. LP: Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
NG: Keep NG main gas line connected.
Figure 7
Lighting
Rod
Match
Operating Grill Lights
Turning On
1. Make sure the grill light button is in the (OFF) position (Figure 8).
2. Connect and secure battery box, per assembly instructions.
3. Push grill light button to (ON) position
(Figure 9).
Turning Off
1. Push grill light button to (OFF) position
(Figure 8).
2. Disconnect battery box cord.
Note: battery cord should always be unplugged when not in use.
Replacing the batteries (See Assembly Step 24)
WWARNING: Do not mix old and new batteries
WWARNING: Do not mix alkaline, standard (carbon-zinc), or rechargeable (ni-
cad, ni-mh, etc.) batteries
1. Remove battery box back cover.
2. Replace AA batteries (4).
3. Replace battery box back cover.

19
WCAUTION:
1. All cleaning and maintenance should be done when grill is cool and with the fuel supply disconnected.
2. Do NOT clean any grill part in a self-cleaning oven. The extreme heat will damage the finish.
3. Do NOT enlarge valve orifices or burner ports when cleaning the valves or burners.
WCAUTION: Unplug rotisserie motor from the outlet when not in use and before cleaning. Allow to cool before
putting on or taking off parts.
Notices
1. This grill should be thoroughly cleaned and inspected on a regular basis.
2. Abrasive cleaners will damage this product.
3. Never use oven cleaner to clean any part of grill.
Before Each Use:
1. Keep the grill area clean and free from any combustible materials, gasoline, and other flammable vapors and liquids.
2. Do NOT obstruct the flow of the combustion of LP gas and the ventilation of air.
3. Keep the ventilation opening(s) of the LP gas tank area free and clear from debris.
4. Visually check the burner flames to make sure your grill is working properly (Figure 10).
5. See below for proper cleaning instructions.
6. Check for obstructions of airflow to the burners. Spiders, insects and webs can clog the burner/venturi tube. A clogged burner tube can
lead to a fire.
Cleaning Surfaces
1. Wipe surfaces clean with mild dishwashing detergent or baking soda mixed with water.
2. For stubborn surfaces, use a citrus-based degreaser and a nylon scrubbing brush.
3. Rinse clean with water.
4. Allow to air dry.
Cleaning Main Burners
1. LP: Turn LP gas tank valve to “CLOSED.”
NG: Turn natural gas main valve to “OFF.”
2. Turn all control knobs clockwise to the “ OFF” position.
Note: A “poof” sound is normal as the last of the gas is burned.
3. LP: Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
NG: Disconnect main gas line per “Disconnecting Natural Gas Line” section.
4. Remove cooking grids and heat plates.
5. Remove burners by removing the fasteners, which secure the burners to the grill bottom.
6. Lift burners up and away from gas valve orifice.
7. Disconnect wire from spark electrode.
8. Clean venturi of each burner with small bottle brush or compressed air.
9. Remove all food residue and dirt on burner surfaces.
10. Clean any clogged ports with a stiff wire (such as an opened paper clip).
11. Inspect burners for any damage (cracks or holes). If damage is found, replace with new burner(s)
from manufacturer.
12. Reinstall burners, checking to insure that gas valve orifice is correctly positioned inside each
burner venturi. Also, check position of spark electrode.
13. Replace heat plate(s) and cooking grid(s).
14. LP: Connect LP gas tank per “Installing LP Gas Tank” section.
NG: Connect NG main line per “Installing Natural Gas Line” section.
15. Perform leak test per “Checking for Leaks” section.
Cleaning and Care
Figure 10
Burner Flame Conditions
Use this chart to see if your burners
need to be cleaned.
1-2 in. /
25.4 - 50.8 mm
Normal: Soft blue flames with yellow
tips between 1 in. - 2 in. height.
Needs cleaning: Noisy with hard
blue flames.
Has to be replaced: Wavy with
yellow flames.

20
Cleaning and Care (Continued)
Cleaning Side Burner
1. LP: Turn LP gas tank valve to “CLOSED.”
NG: Turn natural gas main valve to “OFF.”
2. Turn all control knobs clockwise to the “ OFF” position.
Note: A “poof” sound is normal as the last of the gas is burned.
3. LP: Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
NG: Disconnect main gas line per “Disconnecting Natural Gas Line” section.
4. Remove side burner grid.
5. Remove burner by removing the screws that secure the burner to the side shelf.
6. Lift burner up and away from gas valve orifice.
7. Clean venturi of burner with small bottle brush or compressed air.
8. Remove all food residue and dirt on burner surface.
9. Clean any clogged ports with a stiff wire (such as an opened paper clip).
10. Inspect burner for any damage (cracks or holes). If damage is found, replace with new burner from manufacturer.
11. Reinstall burner, check to insure that gas valve orifice is correctly positioned inside burner/venturi tube also check position of the spark
electrode.
12. Replace cooking grid(s).
13. LP: Connect LP gas tank per “Installing LP Gas Tank” section.
NG: Connect NG main line per “Installing Natural Gas Line” section.
14. Perform leak test per “Checking for Leaks” section.
Before Storing
1. LP: Turn LP gas tank valve to “CLOSED.”
NG: Turn natural gas main valve to “OFF.”
2. Turn all control knobs clockwise to the “ OFF” position.
Note: A “poof” sound is normal as the last of the gas is burned.
3. LP: Disconnect LP gas tank per “Disconnecting LP Gas Tank” section.
NG: Disconnect main gas line per “Disconnecting Natural Gas Line” section.
4. Clean all surfaces.
5. Lightly coat the burner(s) and cooking grid(s) with cooking oil to prevent excess rusting.
6. If storing the grill indoors, disconnect the LP tank per “Disconnecting LP Gas Tank” section.
7. Place the protective cap cover on the LP tank and store the tank outdoors in a well-ventilated area out of direct sunlight.
8. If storing the grill indoors, cover the grill and store in a cool dry place.
9. If storing the grill outdoors, cover the grill with a grill cover for protection from the weather.