Bee-Ball ZY022 User manual

Bee Ball Y022 Backboard
Instruction Manual
Z
Z

Tools Required
Benötigtes Material / Accessoires / Herramientas
Strumenti da lavoro / Benodigdheden
Parts Included
Unterteile / Liste des pièces / Lista de partes
Elenco degli elementi / Onderdelen
Two pairs of
hands
Spanner and Socket Set
1
Part 1
Backboard
Part 3
Hoop/Ring Part 4 Net
Identifying
Bolts
Bolt & Washer
A (x4)
M8 x 65mm
Bolt, Nut &
Washer B (x2)
M8 x 40mm
Wall Achor
Bolt, Nut &
Washer C (x4)
M8 x 70mm
Bolt, Spring,
Nut & Washer
D (x2)
M8 x 110mm
Part 2
Board Brackets
(x2)

2
Before Installation
Check all parts are present!
Our factory takes every eort to make sure everything is packed in its proper place. But just in case a small part has gone
astray please make sure you check every piece is present before you begin installing - right down to the nuts and bolts.
Assemble with Care
Installation should be completed by two adults. Please make sure you follow all the instructions carefully. If you have any
questions during installation please do not hesitate to contact us on [phone] or email
[email protected]o.uk and we will be happy to advise.
Please make sure you read all the safety warnings and advice in this instruction manual. Take extra care and attention over
the wall xing instructions once you have completed the assembly as this will make your equipment is rmly attached.
Make sure you position the backboard somewhere with plenty of space to play.
Using the Basketball Equipment
Improper installation or use of the basketball backboard and ex ring may cause damage to the system or result in serious
injury to the user. We would advise that children are supervised at all times when using this product.
Please adhere to the warnings below to ensure proper use of this equipment and ultimately to ensure full enjoyment!
Attaching the Basketball Net
When attaching the net to your basketball hoop, make sure you have
the net the correct way up. The wider loops/wider part of the net
should be at the top. Slide the loops of the net over the metal loops on
the inside of the basketball hoop - from the inside towards the
outside (see diagram 1). You can also see here a net that has been
assembled correctly and one that has been assembled upside down!
diagram 1
Incorrect
Correct

3
Assembling Your Backboard & Ring
Attach ring (part 3) to the back-
board (part 1) using two Bolts, Nuts
and Washers B (M8 x 40mm) and
two Bolts, Springs & Nuts D (M8 x
110mm). The spring bolts (D) go in
the two holes closest to the ring,
and the plain bolts go in the bottom
holes. The bolts go through the ring
then through the backboard and are
xed in place using the nuts.
1
2
Attach the two Board Bracktes (parts 2) to the Backboard (part 1) using four Bolts, Nuts and Washers A (M8 x
65mm).
Attach Backboard Brackets
You will need:
1 x Backboard (part 1) 4 x Bolts, Nuts & Washers A (M8 x 65mm)
2 x Board Brackets (parts 2)
Attach Ring to Backboard
You will need:
Pre assembled parts from step 1 (backboard with brackets)
2 x Bolts, Springs, Nuts & Washers D (M8 x 110mm)
2 x Bolts, Nuts & Washers B (M8 x 40mm)
Hoop/Ring (part 3)
They should sit in this order once assembled:
Bolt > Washer > Bracket > Backboard > Washer > Nut
They should sit in this order once assembled:
Bolt > Washer > Ring > Backboard > Washer > Nut

4
3
4
Mark the Position of the Backboard
You will need:
Pre assembled Backboard (parts 1 + 2)
Pencil
Decide where you would like your backboard to be xed and using the backboard frame as a template mark
where you will drill the holes in the wall.
Fix Backboard to Wall
You will need:
Pre assembled Backboard (parts 1 + 2)
4 x Bolts, Nut & Washers C (M8 x 70mm)
Fix the backboard brackets to the wall using four wall anchor Bolts, Nuts and Washers C (M8 x 80mm). Using an
equal diameter drill bit to the wall anchor bolts, drill the holes in your wall and insert the bolts with the nuts facing
out. Remove the nuts and place the backboard onto the bolts. Put the nuts back onto the bolts and tighten them.
The anchor bolts will expand as you tighten the nuts, securing the backboard in place (diagram 1).
They should sit in this order once xed:
Bolt > Bracket > Washer > Nut
2Attach Ring to Backboard

5
Diagram 1
Fix Backboard to Wall
4

6
Warning!
For family domestic use only. Not suitable for children under 3 years / 36 months because of small parts which could be a
choking hazard. To be used under the supervision of an adult.
Install the product in a way to avoid risk of entrapment - with sucient gap between the product and other surfaces.
Warnung! Nur für den häuslichen Gebrauch. Für Kinder unter 3 Jahren / 36 Monaten der Deckel ist nicht geeignet , wegen verschluckbare Kleinteile.
Durch verschluckbare Kleinteile besteht Erstickungsgefahr. Nur unter der direkten Aufsicht eines. Erwachsenen benutzen. Bei der Montage des
Produktes in ein Spielgerät oder eine andere Konstruktion muss sichergestellt werden, dass keine Fangstellen für Gliedmasse oder Kleidungstelle
enstehen.
Attention! Exclusivement à usage familial. Ne convient pas aux enfants de moins de 3 ans / 36 mois, présence de petits éléments susceptibles d’être
ingérés ou inhalés - risque d’étouffement.. À utiliser sous la surveillance rapprochée d’un adulte. Au cas où l’on incorpore le produit dans un jeu ou
une construction quelconque, il faudra le faire de façon à éliminer tout risque de coinçage.
¡Advertencia! Exclusivamente para uso doméstico. No conveniente para menores de 3 años / 36 meses - partes pequeñas con riesgo de ingestión
o inhalación - riesgo de atragantamiento.. Se utilizará exclusivamente bajo la vigilancia directa de una persona adulta. La instalación de este
producto en un juego infantil o otra construcción debe estar hecho asi que peligro para quedarse atascado quede excluido.
Attenzione! Solo per uso domestico. Non adatto ai bambini di età inferiore a 3 anni / 36 mesi - presenza di piccoli elementi suscettibili di ingestione
o inalazione - pericolo di soocamento.. Utilizzare sotto la sorveglianza diretta di un adulto. Eettuare il montaggio in modo che si eviti il rischio di
intrappolamento.
Waarschuwing! Alleen voor privé gebruik. Niet geschikt voor kinderen jonger dan 3 jaar / 36 maanden wegens kleine elementen met het
risico op inslikken of inademen - verstikkingsgevaar. Alleen voor privé gebruiken onder toezicht van een volwassene. Het
inbouwen van dit product in een speeltoestel of andere constructie dient zodanig te gebeuren dat voor
beknelling uitgesloten is.
Warning!
Failure to comply with these warnings can lead to injury and/or damage of the basketball equipment.
• If using a ladder during assembly, use extreme caution.
• Do not allow children to hang from the hoop or any part of the system including the backboard, rim, support braces
or net.
• Do not perform‘dunk’moves on this basketball backboard as it is not designed for this purpose. During play ensure
face does not come close to the backboard, rim or net as this could result in injury.
• Make sure you check the backboard frequently to ensure it is properly attached to the wall (see the Inspection and
Maintenance section below).
• Check the system before use to make sure all xtures and ttings are tight (see Inspection and Maintenance below).
• During play, do not wear jewellery (e.g. rings, watches, necklaces) objects may become entangled in the net.
• Adverse weather conditions, exposure to extremes of weather, corrosive materials such as salt, herbicides or pesticides
or misuse of the backboard could cause corrosion and result in the system failing.
• This equipment is intended for home recreational use only and NOT excessive competitive play.
Inspection & Maintenance
We recommend the following inspection and maintenance.
Looking After Your Basketball Backboard and Flex Ring
Your basketball backboard and ex ring - just like any other outdoor play equipment - are designed to be used outside but
without proper care and maintenance will not last as long as you might want.
Weekly to monthly / routine visual inspection
Check all nuts and bolts - if any are loose, tighten them where necessary.
1 -2 times per year / annual inspection
Check for rust and corrosion of nuts and bolts and replace with galvanised steel replacements where necessary.

Please retain for future reference
The Bee-Ball brand is owned by: Garden Games Limited
Holly House • Pine Woods Road • Longworth
Oxfordshire • OX13 5HG • England
Bee-Ball®
is exclusive to
Big Game Hunters:
[phone]
[e-mail]
biggamehunters.co.uk
@thePlayExperts
The logo to look out for...
Garden Games Ltd. spreads much wider than the Bee Ball basketball brand. There are many more products
we have created - look out for our Garden Games logo or ower emblem to be sure you have an ocial
Garden Games Limited product. The brand is not just a logo, it is the whole family of ideas,
service and quality that are behind every product.
We are not a huge corporate and do not claim to be -
we are proud of who we are and what we create
so look out for our brand knowing that each product carrying our logo
has a special standard we aim to maintain for years and years to come...
Part of the Big Game Hunters group
Not just Basketball...
You may or may not be aware that Bee-Ball is exclusive to the retailer Big Game Hunters
who not only have a huge range of high quality basketball equipment but are also owners
of the UK’s leading sports ball retailer.
Big Game Hunters’ Sports Ball Shop sells a wide range of balls and sports training
equipment including basketballs. To browse their range go to sportsballshop.co.uk.
Alongside a wide range of basketball and sports equipment Big Game Hunters also
manufacture and sell a wide range of other outdoor toys, games and play equipment.
Having been in the game since the year 1998 as a retailer we have a lot of experience and
expertise in this area.
Some of our other ranges include... Giant Games
Climbing Frames
information on these and other products can be found at:
www.biggamehunters.co.uk
Big Game Hunters is the retail division of Garden Games Ltd.
Wooden Playhouses
Skyhigh Trampolines