Buffalo Tools GEN7500DF User manual

2
4
4
Add
Oil Engine
Start
Recoil
Start
Follow This Step-By-Step
Guide To Using Your Generator
GENERATOR SPECIFICATIONS:
• 120/240 Volt Operation
• 13 HP Engine, 4 Stroke OHV
• Air Cooled
• Displacement (CC): 389cc
• AVR Automatic Voltage Regulation
• Low Oil Shut Off
• Gasoline Fuel Maximum Capacity: 7 Gallon
• Spark Arrestor
• UL Listed Electrical Components
• Engine Shut Off Switch
• Circuit Breaker & Power Outlets
• 1-12V DC Outlet
• 4-120V Outlets
• 1-120/240V Outlet
• 1-120V RV Outlet
• Complies with EPA emissions
• Run time = 9 hours @ 50% load
• Decibel Rating < 80 db
• Mobility Kit: Included
• Warranty: 1 YEAR limited
GEN7500DF
1
2
3
Remove generator from package
Add Oil
Connect Fuel
4Start Generator
7,500 Surge / 6,000 Running Watts
DUAL FUEL GASOLINE OR PROPANE
A BATTERY IS NOT INCLUDED! TO USE
THE ELECTRIC START FEATURE, BUY A
BATTERY WITH THESE SPECIFICATIONS:
Dimensions: 151 mm x 99 mm x 98 mm
(6" L x 3.8" H x 3.8" W)
CCA (Cold Cranking Amps): 130 Min CCA
Comparable brands/models are:
12 Volt 12 Ah Sealed Lead Acid
Model # UB12120
Oil Type: SAE10W-30 Oil (Must add BEFORE first use)
Oil Capacity: 25 fluid oz (1.13 L)
Because this generator includes Low Oil Shut Off, the
generator will not start with low oil)
Choose either LPG or Gasoline fuel. If using
LPG, connect regulator that was included
with the generator first to Propane Fuel Tank
then to Gas Inlet. (Fig A) (O-Ring should be
attached to Gas Inlet.) If using gasoline, add
Unleaded gasoline only octane rating of 87 or
higher. Maximum Capacity: 7 Gallons
www.sportsmanseriesbrand.com/generators
Use the generator OUTDOORS in a WELL VENTILATED AREA.
DO NOT CONNECT electrical devices until AFTER the generator
is started.
If using LPG, turn Fuel Switch ON Propane Tank.
If using Gasoline, turn Fuel Petcock ON. (Figure B)
Adjust the CHOKE to CLOSED position (Figure C)
Start the generator manually with the Recoil (Pull) Start. To use
the Electric Start, a battery must be purchased (sold separately).
Once the engine has started and runs for about a minute, move
the choke lever approximately half way towards the “Open/Run”
position. Wait an additional 30 seconds and then move the choke
lever completely over to the “Open/Run” position.
You can now connect electrical devices.
Choke (Figure C)
Visit our website for Troubleshooting & Frequently Asked Questions
Need Help? Do Not Return This Generator To The Store! Call Us First!
Monday-Friday 8:00-4:30 Central Time
TOLL-FREE NATIONWIDE HELP LINE! 866-460-9436
O
LP Gas Inlet
(Figure A)
Battery Tray
Gas Fuel Petcock
Choke Open Choke Closed
Gasoline Fuel Tank
Fuel O
Fuel On
(Figure B)

Outlets available on this generator, from left to right:
12V DC, 120/240V AC, 120V AC RV, and 4 each 120V AC. GEN7500DF
WARNING
Always follow Warning labels placed on the
generator, and read and follow all Warning
labels included inside the Product Manual.
WARNING: NEVER use a generator inside
a home or a garage, EVEN IF the doors
and windows are open.
ONLY USE OUTSIDE and far way from
windows, doors and vents leading into an
enclosed area.
Using a generator indoors can kill you in
minutes. The generator produces an
exhaust that contains carbon monoxide.
This is a poison you cannot see or smell.
Do not attach a chain or rope to secure the
generator to a post as this can be difficult to
remove in the event of an emergency.
WARNING: According to the State of
California, the exhaust from this generator
contains chemicals known to cause cancer,
birth defects, or other reproductive harm.
Battery Installation
A battery must be installed before the electric start feature can be used.
Disconnect all electrical loads from this generator before installing/changing
the battery.
Mount the battery tray to the generator frame by using the rubber strap to
secure the battery in place.
Take the red (positive) cable from the engine and attach it to the positive
terminal on the battery.
Take the black (negative) cable from the engine and attach it to the negative
terminal on the battery.
IF THERE IS ANY QUESTION ABOUT A
CONDITION BEING SAFE OR UNSAFE,
DO NOT OPERATE THIS PRODUCT!
SEEK THE ADVISE OF A LICENSED
ELECTRICIAN FOR 120V / 240V WIRING
120/240V AC 120V AC RV 4 EACH 120V AC
Engine
Switch
DO NOT CONNECT electrical devices until AFTER the generator is started.
www.sportsmanseriesbrand.com/generators
Visit our website for Troubleshooting & Frequently Asked Questions
Need Help? Do Not Return This Generator To The Store! Call Us First!
Monday-Friday 8:00-4:30 Central Time
TOLL-FREE NATIONWIDE HELP LINE! 866-460-9436
7,500 Surge / 6,000 Running Watts
DUAL FUEL GASOLINE OR PROPANE
12V DC