Chandler Limited TG2-500 User manual

For more information, visit www.chandlerlimited.com. © 2015 Chandler Limited, Inc. All Rights Reserved. TG2-500_UM_72815
Abbey Road Studios, EMI, REDD and their associated logos are trademarks of EMI (IP) Limited.
Chandler Limited®
TG2-500 Pre Amp
User Manual
OFFICIAL
EQUIPMENT
564
3
2
1
0
7
8
9
10
PHASE
48v
IMPEDANCE
300
1200
MIC
LINE
0
-10 +10
+25
+30
+35
+40
+45
+20 +50
2-500
COARSE GAIN
OUTPUT
FINE GAIN
®

2
For more information, visit www.chandlerlimited.com. © 2015 Chandler Limited, Inc. All Rights Reserved. TG2-500_UM_72815
Abbey Road Studios, EMI, REDD and their associated logos are trademarks of EMI (IP) Limited.
Chandler Limited®
TG2-500 Pre Amp
User Manual
Thank you for purchasing the Chandler Limited
TG2-500 Pre Amp, you now own a piece of EMI /
Abbey Road Studios ofcial equipment.
The Chandler Limited TG2-500 Pre Amp is a rec-
reation of the rare EMI TG12428 pre amp used in
EMI/Abbey Road Studios recording and master-
ing consoles from the late 60s and early 70s.
The TG2-500 Pre Amp features the same discrete,
transformer-balanced ampliers as Chandler Lim-
ited’s TG series rack-mount counterparts.
The TG-500 Pre Amp uses a 100% discrete tran-
sistor circuit and custom wound transformers.
Your Chandler Limited TG2-500 Pre Amp has been
carefully crafted and built by hand at Chandler
Limited in Shell Rock IA, U.S.A, using through-
hole components for the ultimate analog experi-
ence.
At Chandler Limited we are proud of our American
made products and we hope you like them!
Please feel free to call our shop anytime for help
or questions.
Phone: [phone]
HISTORY
The EMI / Abbey Road Studios TG12428 amplier
was rst conceived in the late 1960s as the work-
horse amplier for EMI’s next generation record-
ing and mastering consoles, the transistor based
TG series.
TG desks were developed to handle Abbey Road
Studios’ growing session requirements, and de-
sire for more stability over their vacuum tube-
based predecessors, EMI’s REDD class of con-
soles.
EMI and Abbey Road Studios ofcially launched
the TG series of consoles with the TG MK I in
1968.
TG consoles would reliably serve Abbey Road
Studios from 1968 to 1983. During its reign, TG
desks would see many revisions, ending with
the nal recording console produced by EMI, the
iconic wrap-around TG MK IV.
The TG series of consoles and their discrete solid-
state ampliers left their pleasing and now leg-
endary sonic imprint on many records, including
the Beatles’ nal album ‘Abbey Road’, and Pink
Floyd’s ‘Dark side of the Moon’.
OFFICIAL
EQUIPMENT

3
For more information, visit www.chandlerlimited.com. © 2015 Chandler Limited, Inc. All Rights Reserved. TG2-500_UM_72815
Abbey Road Studios, EMI, REDD and their associated logos are trademarks of EMI (IP) Limited.
COARSE GAIN
‘COARSE GAIN’ is a stepped input control, switchable in 5db incre-
ments, with a range of +20db to +50db gain. Use this control to set
your initial input gain level.
FINE GAIN
‘FINE GAIN’ is a variable control, adding an additional +/-10db
available input gain, for a total of +60db maximum gain in combi-
nation with ‘COARSE GAIN’. When gain staging, set this control to
middle (0), and set the ‘COARSE
GAIN’ rst. Use the ‘Fine Gain’
to variably ne-tune the input
gain +/-10db.
TIP: Interactively using the ‘FINE GAIN’ with the ‘COARSE
GAIN’ is great way to dial-in pre-amp coloration.
Historical Note: The stepped ‘COARSE GAIN’ combined
with a separate variable ‘FINE GAIN’ control was how gain
staging was achieved on original TG consoles.
MIC/LINE
Use this switch to set the pre-amp for use with mi-
crophones or line level signals. When using microphones, set this switch to ‘MIC’. Set
the switch to ‘LINE’ when supplying signals from your recording device, converters or
DAW into the pre-amplier.
TIP: Sending line level source material into the pre-amplier is great way to further
process your material, adding the rich harmonic texture available from this historic
circuit. Use a pair of TG2-500’s on your mix bus!
IMPEDANCE
The ‘IMPEDNACE’ switch has two settings: 300 or 1200 OHMS. This switch allows
for better matching of microphones to the pre-amp. When pairing a microphone with
any pre-amp, it’s considered proper practice to try and match the impedance of the
microphone and pre-amp, typically this results in greater output from the mic.
TIP: While technically proper to match a microphone’s output impedance to an input’s
impedance (i.e. less ohms into more ohms,) sometimes rules are meant to be broken.
You may nd that inserting a source with higher impedance into a lower ohms setting
will yield surprising results.
564
3
2
1
0
7
8
9
10
PHASE
48v
IMPEDANCE
300
1200
MIC
LINE
0
-10 +10
+25
+30
+35
+40
+45
+20 +50
2-500
COARSE GAIN
OUTPUT
FINE GAIN
®
5
64
3
2
1
0
7
8
9
10
PHASE
48v
IMPEDANCE
300
1200
MIC
LINE
0
-10 +10
+25
+30
+35
+40
+45
+20 +50
2-500
OUTPUT
FINE GAIN
®
564
3
2
1
0
7
8
9
10
PHASE
48v
IMPEDANCE
300
1200
MIC
LINE
0
-10 +10
+25
+30
+35
+40
+45
+20 +50
2-500
OUTPUT
FINE GAIN
®
564
3
2
1
0
7
8
9
10
PHASE
48v
IMPEDANCE
300
1200
MIC
LINE
0
-10 +10
+25
+30
+35
+40
+45
+20 +50
2-500
COARSE GAIN
OUTPUT
FINE GAIN
®

4
For more information, visit www.chandlerlimited.com. © 2015 Chandler Limited, Inc. All Rights Reserved. TG2-500_UM_72815
Abbey Road Studios, EMI, REDD and their associated logos are trademarks of EMI (IP) Limited.
OUTPUT
The ‘OUTPUT’ control acts as a fader would on a mixing con-
sole. Use this to control the overall output level of the pre-am-
plier to your recording device or DAW. When setting input gain
levels, start with the ‘OUTPUT’ control set fully clockwise for
unity level, adjust back as needed so as not to clip your convert-
ers, or DAW.
TIP: If you want to overdrive the pre-amp for wonderful crunchy
tone, set the ‘OUTPUT’ control lower, crank the ‘COARSE GAIN’,
and use the ‘FINE GAIN’ to achieve just the right color.
48V
Some microphones require phantom power. Depress this switch
to enable 48 volt phantom power; use only for microphones that
require it.
WARNING: Only engage or disengage phantom power with the
microphone already connected to the pre-amplier. Disconnect-
ing a microphone while phantom power is on may cause dam-
age to equipment downstream. Never use phantom power with
ribbon microphones.
PHASE
The ‘PHASE’ button, when depressed, reverses phase of the
input signal 180º. This feature may be useful when a microphone
is not ideally placed, a cable is wired incorrectly, or source mate-
rial is out of phase.
564
3
2
1
0
7
8
9
10
PHASE
48v
IMPEDANCE
300
1200
MIC
LINE
0
-10 +10
+25
+30
+35
+40
+45
+20 +50
2-500
COARSE GAIN
OUTPUT
FINE GAIN
®
564
3
2
1
0
7
8
9
10
PHASE
48v
IMPEDANCE
300
1200
MIC
LINE
0
-10 +10
+25
+30
+35
+40
+45
+20 +50
2-500
COARSE GAIN
OUTPUT
FINE GAIN
®

5
For more information, visit www.chandlerlimited.com. © 2015 Chandler Limited, Inc. All Rights Reserved. TG2-500_UM_72815
Abbey Road Studios, EMI, REDD and their associated logos are trademarks of EMI (IP) Limited.
CONNECTIVITY
Connections - All connections on the TG2-500 Pre Amp are transformer balanced, pin 2 hot.
POWER
Current draw - Here are the current draw specications for the TG2-500 Pre Amp when the unit is
loaded 600 ohm and operating at a continuous level of unity gain. Please consult your rack and PSU
specications to make sure you are not overloading your system.
+16 volt power rail = +95ma
-16 volt power rail = -70ma
ENCLOSURE COMPATIBILTY
The TG2-500 Pre Amp has no known issues with any 500-series racks.
POWER SUPPLY RECOMMENDATIONS
We recommend using a rack with an external power supply such as the API 500v rack with external
L200 supply and the BAE 11-slot with external supply.
NOTES on BAE racks
We recommend adding a wire from Earth to power supply common on all BAE racks. In many cases
hum can be avoided and Earth to common is standard procedure on most electronic equipment.

6
For more information, visit www.chandlerlimited.com. © 2015 Chandler Limited, Inc. All Rights Reserved. TG2-500_UM_72815
Abbey Road Studios, EMI, REDD and their associated logos are trademarks of EMI (IP) Limited.
Service
Prior to sending in your gear for repair, please contact our shop at the number listed below. We will
assist you in troubleshooting the problem and, if needed, we will issue you an RMA# to send in the
gear.
Send repairs to:
Chandler Limited, Inc.
Attention: Repairs
222 S. Cherry St.
PO Box 38 (if sending via the postal service)
Shell Rock IA 50670
Phone: [phone]
Email: [email protected]
CE Certication
Chandler Limited declares under its sole responsibility that all products manufactured by them are in
compliance with Electromagnetic Compatibility (EMC) Directive 2014/30/EU; Standards: EN55103-
1:2009+A1:2012; EN55103-2:2009; EN55013:2013 and Low Voltage Directive (LVD) 2014/35/EU;
Standards: EN60065:2002+A1:2006+A11:2008+A2:2010+A12:2011.

7
For more information, visit www.chandlerlimited.com. © 2015 Chandler Limited, Inc. All Rights Reserved. TG2-500_UM_72815
Abbey Road Studios, EMI, REDD and their associated logos are trademarks of EMI (IP) Limited.
Product Limited Warranty
During the rst year from the date of the original purchase, this product is warranted to be free from
defects in materials and workmanship under normal use, service and maintenance. This warranty ap-
plies to the original purchaser and is subject to the following terms and conditions:
What Is Covered: The product’s components as originally installed by the manufacturer that are de-
fective in materials or workmanship under normal use, service and maintenance.
What Is Not Covered By This Warranty: This warranty does not extend to or cover:
1. Any defect due to the negligence of others; failure to install, operate or maintain the product properly; unreason-
able use; accidents; alteration; use of unauthorized or non-standardized parts; acts of God; theft; vandalism; elec-
trical malfunctions (i.e., resulting from power surges, shorted or overloaded circuits, etc.), use of any power source
other than supplied by manufacturer; repair by anyone other than an authorized Chandler Limited representative;
or damage resulting from improper packing or mishandling by a shipper.
2. Normal wear and tear of parts.
3. Shipping, handling, packaging and delivery costs of the product.
Who Is Covered: The original purchaser.
Repair During The First Year: During the rst year, all defective product components that are cov-
ered by this Limited Warranty will be repaired free of charge including parts and labor. The purchaser
will pay shipping costs AND a $35 handling fee per unit.
What You Must Do for Warranty Service (in the United States): If you live in the United States and
your product was purchased through a U.S. Dealer, please contact your dealer OR call 319-885-4200
or e-mail [email protected].
What You Must Do for Warranty Service (outside of the United States): For warranty service if you live outside
of the United States, please contact the dealer where you purchased the product.
Any products returned to Chandler Limited for repair should include: (1) complete description of the
problem; (2) name, address, phone number, fax number, and/or e-mail address; (3) receipt of original
purchase; (4) power supply and all accessories and cables. The purchaser is responsible for the ship-
ping costs to and from Chandler Limited. Chandler Limited is not responsible for damage resulting
from improper packing and/or mishandling by a shipper.
If sent by UPS or Federal Express, ship to: Chandler Limited, 222 South Cherry Street, Shell Rock IA
50670
If sent by Postal Service, ship to: Chandler Limited, PO Box 38, Shell Rock IA 50670
The foregoing expresses Chandler Limited’s obligations and liabilities with respect to the quality of
the product, its components and accessories. All other warranties, express or implied, including the
warranties of merchantability or tness for a particular purpose are disclaimed. Chandler Limited shall
not be liable for the loss or use of the product, its components and accessories, inconvenience, loss
or any other damages, direct or consequences arising out of the use of, or inability to use the product
or its components or damages resulting from or attributable to defects in the products or its compo-
nents. No one other than Chandler Limited has authority to extend or modify the terms of this limited
warranty in any manner whatsoever.

8
For more information, visit www.chandlerlimited.com. © 2015 Chandler Limited, Inc. All Rights Reserved. TG2-500_UM_72815
Abbey Road Studios, EMI, REDD and their associated logos are trademarks of EMI (IP) Limited.
DISCLAIMER OF WARRANTY
EXCEPT FOR THE FOREGOING WARRANTIES, CHANDLER LIMITED HEREBY DISCLAIMS AND EX-
CLUDES ALL OTHER WARRANTIES, EXPRESS OR IMPLIED, INCLUDING, BUT NOT LIMITED TO
ANY AND/OR ALL IMPLIED WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR
PURPOSE AND/OR ANY WARRANTY WITH REGARD TO ANY CLAIM OF INFRINGEMENT THAT
MAY BE PROVIDED IN SECTION 2-312(3) OF THE UNIFORM COMMERCIAL CODE AND/OR IN ANY
OTHER COMPARABLE STATE STATUTE.
LIMITATION OF LIABILITY
THE LIABILITY OF CHANDLER LIMITED, IF ANY, AND PURCHASER’S SOLE AND EXCLUSIVE REM-
EDY FOR DAMAGES FOR ANY CLAIM OF ANY KIND WHATSOEVER, REGARDLESS OF THE LE-
GAL THEORY AND WHETHER ARISING IN TORT OR CONTRACT, SHALL NOT BE GREATER THAN
THE ACTUAL PURCHASE PRICE OF THE PRODUCT WITH RESPECT TO WHICH SUCH CLAIM IS
MADE. IN NO EVENT SHALL CHANDLER LIMITED BE LIABLE TO PURCHASER FOR ANY SPECIAL,
INDIRECT, INCIDENTAL, OR CONSEQUENTIAL DAMAGES OF ANY KIND INCLUDING, BUT NOT
LIMITED TO, COMPENSATION, REIMBURSEMENT OR DAMAGES ON ACCOUNT OF THE LOSS OF
PRESENT OR PROSPECTIVE PROFITS OR FOR ANY OTHER REASON WHATSOEVER.