CHAT BOARD Classic User manual

Installation guide 1201 Sizes: 100 x 150 cm
CHAT BOARD A/S
Tempovej 10
DK-2750 Ballerup
Tel. [phone]
Fax [phone]
[email protected]
www.chat-board.dk
Attach the metal hanging rail on the wall positioned 5 mm below the position where you want the top
edge of the glass to be. The rail opening facing upwards and out. Use screws and plugs suitable for the
material of the wall.
Attach the round magnets on the wall as indicated on the drawings above:
For horizontal attachment - two wall magnets with the centre spaced 80 mm away from the sides and
bottom edge of the glass panel.
For vertical attachment - the same as for horizontal attachment but with the third magnet attached in the
middle.Make sure to put a washer between the wall and the magnet for necessary distance needed for
the magnet to adhere on to the steel backing of the board.
Now locate the board centred onto the hanging rail and the job is done as the wall magnets will draw
the board rmly against the wall.
120 x 150 cm
Horizontal installation
Instructions: Vertical installation
ENG
Installation guide
CHAT BOARD®Classic
80 mm
W
A
L
L
1 x Hanging rail
Content:
3 x Round wall magnets
3 x Washers
1 x Black magnet with grip
2 x Chrome magnets
1 x Dry-erase marker
Danish design - made in Denmark
80 mm
80 mm
80 mm
80 mm
80 mm
80 mm
80 mm
100 x 200 cm 120 x 200 cm 122 x 244 cm

Following guidelines should be observed and known to all people handling magnetic materi-
al, especially Rare Earth magnetic materials.
Always keep a safe distance of strong magnetic elds. “Guidelines on limits of exposure to
static magnetic elds” concerning health are available at the International Commission on
Non-Ionizing Radiation Protection. Strong magnetic elds can disrupt and destroy magnetic
data carriers, such as credit cards, electronic & mechanical components, and similar devices.
Always wear protective glasses and/or other protective equipment to prevent risk of
injury form splintering and crushing. Avoid impact as sintered magnets are hard and brittle
and will shatter into many sharp fragments.
To avoid crushing the skin, magnets should be handled with great care because of the strong
attractive forces. Allergic reactions might occur to people with known allergies to ceramic or
metallic substances. Always wear protection while handling magnets!
Operating temperatures and radiation
The highest allowed operating temperature of our magnet materials varies between 80C and
450C. Permanent magnets should not be exposed to ionizing radiation for long periods of
time. They will lose their magnetization.
Possible explosion or re
Magnets can emit sparks on impact and must be handled in areas with no risk of explosion!
Grinding dust and shavings are combustible. These processes should be done in an inert gas
environment. Or, always have a constant water ow at the mechanical processing point of Rare
Earth magnets! Even dried-out grinding wheel shavings and debris can combust. In case of
re, to extinguish, only use sand or powder type re extinguisher, equipped with metal re
powder.
CHAT BOARD A/S
Tempovej 10
DK-2750 Ballerup
Tel. [phone]
Fax [phone]
[e-mail]
www.chat-board.dk
Storage and transportation
Rare earth magnets must be stored in a dry environment. For transport, such as air cargo the
regulations for Stray Magnetic Fields apply (International Air Transport Association - Dange-
rous Goods Regulations). Goods that will be sent by air cargo must pack in a suitable man-
ner (by using shielding), which will prevent any magnetic elds from escaping, and any such
emissions are kept below the requirements according IATA regulations. If packaging, received
by air, is untouched and still in place, it does not have to be considered as dangerous goods
during air transport.
Choking hazard:
Not for children under 6 years. This product contains small magnets. Swallowed magnets can
stick together across intestines causing serious infections and death. Seek immediate medical
attention if magnets are swallowed.
If you have any further questions about handling and using our magnet material, please con-
tact us.
CHAT-BOARD® by CHAT BOARD A/S
Tempovej 10 – DK 2750 Ballerup
Denmark
T [phone] [email protected]
Safety precautions
and hazard warnings!
CHAT BOARD A/S
Tempovej 10
DK-2750 Ballerup
Tel. [phone]
Fax [phone]
[email protected]
www.chat-board.dk
Safety precautions
and hazard warnings!