Clarion DB538RMP User manual

- 1 -- 1 -
- 1 -- 1 -
- 1 - DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
NOTE
1. We cannot supply PWB with component parts in
principle. When a circuit on PWB has failure, please
repair it by component parts base. Parts which are
not mentioned in service manual are not
supplied.
SeSe
SeSe
Servrv
rvrv
rvice Manualice Manual
ice Manualice Manual
ice Manual
Published by Clarion (Malaysia)
289-6029-00 JUNE. 2003P
Printed In Malaysia
Clarion ( Malaysia) Sdn. Bhd.Clarion ( Malaysia) Sdn. Bhd.
Clarion ( Malaysia) Sdn. Bhd.Clarion ( Malaysia) Sdn. Bhd.
Clarion ( Malaysia) Sdn. Bhd.
Phase 3, Free Trade Zone One, 11900 Bayan Lepas, Penang, Malaysia
Tel: [phone], Fax: [phone]
Clarion Co. Ltd.Clarion Co. Ltd.
Clarion Co. Ltd.Clarion Co. Ltd.
Clarion Co. Ltd.
Export Division : 50 Kamitoda, Toda-shi, Saitama 335-8511 Japan
Specification and design are subject to change without notice for
further improvement.
AM/FM MP3 CD PlayerAM/FM MP3 CD Player
AM/FM MP3 CD PlayerAM/FM MP3 CD Player
AM/FM MP3 CD Player
ModelModel
ModelModel
Model
DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
(Model : PE-2604E-A: For EUROPE)
Radio sectionRadio section
Radio sectionRadio section
Radio section
Model: PE-2604E-AModel: PE-2604E-A
Model: PE-2604E-AModel: PE-2604E-A
Model: PE-2604E-A
Tuning system: PLL synthesizer tuner
Receiving frequencies:FM 87.0 to 108MHz (0.05 MHz steps)
AM 531 to 1,602kHz (9 kHz steps)
LW 153 to 279kHz (3 kHz steps)
CD/MP3 player sectionCD/MP3 player section
CD/MP3 player sectionCD/MP3 player section
CD/MP3 player section
System: Compact disc audio system
Usable disc: Compact disc
Frequency response: 10Hz to 20kHz (+1dB/-1dB)
Signal to Noise ratio: 100dB (1kHz) IHF-A
Dynamic range: 95dB (1kHz)
Distortion: 0.01%
GeneralGeneral
GeneralGeneral
General
Max. Power Output: 50W x 4
Line Output: 1.7V (with CD 1kHz, 10k ohm)
Bass Control Action: +13dB/-13dB (30Hz)
Treble Control Action: +12dB/-12dB (10 kHz)
Power supply voltage: DC 14.4V (10.8 to 15.6V allowable)
negative ground
Current consumption: Less than 15A
Speaker impedance: 4 ohm (4 ohm to 8 ohm allowable)
Dimensions (mm): 178 (W) x 50 (H) x 152 (D)mm
Weight: 1.1kg
SPECIFICATIONS
PE-2604E-APE-2604E-A
PE-2604E-APE-2604E-A
PE-2604E-A
COMPONENTS
Source unit 1
DCP Case 335-5734-22 1
Mounting bracket 300-7742-20 1
Escutcheon (Outer-Es) 370-6041-00 1
Extension Lead 854-6358-50 1
Part’s bag 1
Removal key 331-2497-20 2
Spacer 345-3653-01 1
Special Screw 716-0726-01 1

- 2 -- 2 -
- 2 -- 2 -
- 2 -
DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
To engineers in charge of repair or
inspection of our products.
Before repair or inspection,make sure to follow the
instructions so that customers and Engineers in charge of
repair or inspection can avoid suffering any risk or injury.
1. Use specified parts.
The system uses parts with special safety features
against fire and voltage. Use only parts with equivalent
characteristics when replacing them.
The use of unspecified parts shall be regarded as re-
modeling for which we shall not be liable.The onus of
product liability (PL) shall not be our responsibility in
cases where an accident or failure is as a result of
unspecified parts being used.
2. Place the parts and wiring back in their original
positions after replacement or re-wiring.
For proper circuit construction, use of insulation tubes,
bonding, gaps to PWB, etc, is involved. The wiring con-
nection and routing to the PWB are specially planned
using clamps to keep away from heated and high volt-
age parts. Ensure that they are placed back in their
original positions after repair or inspection.
If extended damage is caused due to negligence dur-
ing repair, the legal responsibility shall be with the re-
pairing company.
3. Check for safety after repair.
Check that the screws, parts and wires are put back
securely in their original position after repair. Ensure
for safety reasons there is no possibility of secondary
problems around the repaired spots.
If extended damage is caused due to negligence of re-
pair, the legal responsibility shall be with the repairing
company.
4. Caution in removal and making wiring connection to
the parts for the automobile.
Disconnect the battery terminal after turning the igni-
tion key off. If wrong wiring connections are made with
the battery connected, a short circuit and/or fire may
occur. If extensive damage is caused due to negligence
of repair, the legal responsibility shall be with the repair-
ing company.
5. Cautions regarding chips.
Do not reuse removed chips even when no abnormal-
ity is observed in their appearance. Always replace them
with new ones. (The chip parts include resistors, ca-
pacitors, diodes, transistors, etc). The negative pole of
tantalum capacitors is highly susceptible to heat, so
use special care when replacing them and check the
operation afterwards.
6. Cautions in handling flexible PWB.
Before working with a soldering iron, make sure that the
iron tip temperature is around 270-C. Take care not to
apply the iron tip repeatedly (more than three times) to the
same patterns. Also take care not to apply the tip with
force.
7. Turn the unit OFF during disassembly and parts replace-
ment. Recheck all work before you apply power to the
unit.
8. Cautions in checking that the optical pickup lights up.
The laser is focused on the disc reflection surface
through the lens of the optical pickup. When checking
that the laser optical diode lights up, keep your eyes
more than 30cms away from the lens. Prolonged
viewing of the laser within 30cms may damage your
eyesight.
9. Cautions in handling the optical pickup
The laser diode of the optical pickup can be damaged
by electrostatic charge caused by your clothes and body.
Make sure to avoid electrostatic charges on your clothes
or body, or discharge static electricity before handling
the optical pickup.
9-1.Laser diode
The laser diode terminals are shorted for transportation
in order to prevent electrostatic damage. After
replacement, open the shorted circuit. When removing
the pickup from the mechanism, short the terminals by
soldering them to prevent this damage.
9-2.Actuator
The actuator has a powerful magnetic circuit. If a
magnetic material is put close to it. Its characteristics
will change. Ensure that no foreign substances enter
through the ventilation slots in the cover.
9-3.Cleaning the lens
Dust on the optical lens affects performance. To clean
the lens, apply a small amount of isopropyl alcohol to
lens paper and wipe the lens gently.
CAUTIONS
The appliance contains a laser system and is classified as
a “CLASS 1 LASER PRODUCT” . In case of any trouble
with this player, please contact your nearest “authorized
service station”. To prevent direct exposure to the laser
beam, do not try to open the enclosure.
Bottom View of
Main Unit

- 3 -- 3 -
- 3 -- 3 -
- 3 - DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
ERROR DISPLAYS
To protect the system, this unit has been equipped with self diagnostic functions. If a fault arises, a warning is
issued by various error displays. Follow the corrective measures and remove the fault.
This error display indicates that a fault has arisen in the mechanism of the
source unit (for example, the disc cannot be ejected).
-Check the source unit
This error display indicates that the pickup focus is off because of a scratched
disc or some other factor during source unit play.
-Check the compact unit
This indicates that the CD’s TOC (table of contents) cannot be read, because
the selected disc is upside-down.
Error Display Corrective Measure
ER2
ER3
ER3
CauseCause
CauseCause
Cause
ProblemProblem
ProblemProblem
Problem MeasureMeasure
MeasureMeasure
Measure
Power does not turn on.
(No sound is produced).
Fuse is blown. Replace with a fuse of the same amperage. If the
fuse blows again, consult your store of purchase.
Compact disc cannot be
loaded.
Eject the compact disc before loading the new
one.
Another compact disc is already
loaded.
Sound skips or is noisy.
Clean the compact disc with a soft cloth.
Compact disc is dirty.
Replace with a compact disc with no scratches.
Sound is bad directly after
power is turned on.
Water droplets may form on the
internal lens when the car is
parked in a humid place.
Let dry for about 1 hour with the power on.
Compact disc is heavily scratched
or warped.
TROUBLESHOOTING
Nothing happens when button
are pressed.
Display is not accurate.
Microprocessor has
malfunctioned due to noise, etc.
Turn off the power, then press the [RELEASE][RELEASE]
[RELEASE][RELEASE]
[RELEASE]
button and remove the DCP.
Press the reset button for about 2 seconds with a
thin rod.
Incorrect wiring Consul your store of purchase.
DCP or main unit connectors are
dirty.
Wipe the dirt off with a soft cloth moistened with
cleaning alcohol.
ADJUSTMENT
ProcedureProcedure
ProcedureProcedure
ProcedureItem Measuring InstrumentMeasuring Instrument
Measuring InstrumentMeasuring Instrument
Measuring Instrument
S-Meter 1. Input the 98.1MHz/30dB u
(400Hz-MOD 30%) signal.
2. Turn on the power switch.
And press the AF button
and CH6 button at the
same time. (TEST MODE)
3. Adjust the reading of LCD
indicator to [24----00]
(2.4±0.2V) by VR101.
SG

- 4 -- 4 -
- 4 -- 4 -
- 4 -
DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
MAIN UNIT SECTION

- 5 -- 5 -
- 5 -- 5 -
- 5 - DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
1 RDS_CLK I RDS Clock
2 B/U DET I B/U detecting terminal
3 LCD SI I Serial data communication line to
LCD Control IC
4 LCD SO O Serial data communication line to
LCD Control IC
5 LCD SCK O Serial data communication line to
LCD Control IC
6 LCD CE O Serial data communication line to
LCD Control IC
7 REM_DET I While protecting circuit motion, it
is at ‘HI’
8NC -NC
9NC -NC
10 NC - NC
11 VOL-CW I Use for rotary volume
12 VOL-CCW I Use for rotary volume
13 NC - NC
14 NC - NC
15 RDS_TEST O PULL UP
16 SD/ST_IND I While AM/FM SD in, ST is ‘0’
17 NC - NC
18 AM_DX/LO O AM DX/LO High=DX GND
19 A-ANT_ON O NC
20 RDS_DATA I RDS data in
21 RDS_MUTE O RDS MUTE Active Hi
22 MUTE_SPEED O RDS MUTE Active Low
23 KEY A/D I FUNC/EJECT/DCP detection
terminal for A/D converter
24 TEST I For Test Mode purpose
25 RDS-SMETER I RDS Signal Meter Input
26 RDS-NOISE I RDS Noise Input
27 AVDD - VDD
28 NC - NC
29 NC - NC
30 NC - NC
31 NC - NC
32 AVSS - GND
33 CPU_REG - Regulator terminal for CPU power
supply
34 VDD - Power supply terminal
35 OSC_REG - Power supply regulator terminal
for oscillator
36 X_OUT - X-TAL 4.5MHz
37 X_IN - X-TAL 4.5MHz
38 GND - GND
39 ST O Usually input ‘ST’ lights at ‘LO’;
always at ‘HI’ during seeking
40 GND - GND
41 AM_IF_CNT I AM IF counter
42 FM_IF_CNT I FM IF counter
43 VDD - VDD
44 FM_OSC I FM VCO input terminal
Pin No PIN NAME I/O DESCRIPTION
EXPLANATION OF IC
uPD178078GF-583 052-1936-01
Master Micro computer
Outward Form
100 pins, plastic QFP
Terminal Description
45 AM_OSC I AM VCO input terminal
46 GND - GND
47 FM_EO O FM PLL VT
48 AM_EO O AM PLL VT
49 GND - GND
50 RESET I Reset Port
51 ACC DET I ACC detecting terminal
52 REMOCON I Remote control
53 B/L + B O While ACC is ON, it is at ‘HI’
54 PHONE_AUDIO I NC
55 CS1 I Destination selection setting
56 CS2 I Destination selection setting
57 IF_REQ O During seeking, it is at ‘HI’. While
detecting RDS SD, it is at ‘LO’.
58 NC - NC
59 STANDBY O Power Amp IC control terminal
60 NC - NC
61 REM_ON - While Power on, it is at ‘HI’
62 REM 5V O REM 5V power supply control
terminal. (N-ch open drain port)
63 SYS_MUTE O Output mute. While it is ‘LOW’,
mute is ‘ON’. (N-ch open drain
port)
64 FM ON O While ‘LO’ = AM and ‘HI’ = FM.
(N-ch open drain port)
65 AM ON O While ‘HI’ = AM and ‘LO’ = FM.
(N-ch open drain port)
66 ACC (CD ON) O CDP ACC
67 FM_DX/LO O FM DX/LO High=Local
68 NC - NC
69 NC - NC
70 NC - NC
71 NC - NC
72 NC - NC
73 NC - NC
74 NC - NC
75 VOL_CLK O E-VOL use
76 VOL_DATA O E-VOL use
77 NC - NC
78 KEY_INT I When this terminal turns low, key
A/D terminal detects the key
pushed
79 CDP BUS I/O CDP BUS line
80 PHONE_INT I Phone interrupted
81 OFFSET DET I Offset detect terminal
82 GND - GND
83 NC - NC
84 NC - NC
85 NC - NC
86 NC - NC
87 NC - NC
88 NC - NC
89 NC - NC
Pin No PIN NAME I/O DESCRIPTION

- 6 -- 6 -
- 6 -- 6 -
- 6 -
DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
90 NC - NC
91 NC - NC
92 NC - NC
93 NC - NC
94 NC - NC
95 NC - NC
96 NC - NC
97 NC - NC
98 RDS DISCHG O RDS Noise Off
99 VDD - VDD
100 GND - GND
Pin No Symbol I/O Function

- 7 -- 7 -
- 7 -- 7 -
- 7 - DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
1NC -NC
2 LKFS I Lock status of frame sync
3 SQDT I Subcode-Q data serial output
4 EJ-END I Eject end position of switch
5 ORIGIN I Sled origin position of switch
6 ISTAT I Monitor of the servo power
7 OPTION1 I Interface option
8 OPTION2 I Deck option
9 AVSS - GND
10 FEEDF O Control of the loading motor
11 FEEDR O Control of the loading motor
12 S0S1 I Subcode sync signal ( S0 + S1)
13 BUSIN I Interface signal from headunit
14 CDON I ACC ON/OFF signal from
headunit
15 LSTART I Loading start switch
16 MCK2 O Serial data clock of the MP3
Decoder
17 VDD1 - VDD
18 MDATA O Serial data
19 MP3DIN I Data in of the MP3 Decoder
20 MP3MLAT O Latch signal of the MP3 Decoder
21 MP3INT I Data request of the Mp3 Decoder
22 GND - GND
23 NC - NC
24 NC - NC
25 RESET I Low level active system reset
signal
26 X2 - Crystal resonator for main
system clock oscillation
27 X1 - Crystal resonator for main
system clock oscillation
28 GND - GND
29 VDD - VDD
30 ISTAT2 I Internal status of the servo IC
31 JITB - NC
32 RESET2 O MP3 Decoder reset
33 OPTION3 I Interface option
34 MLT O Latch signal of the servo IC
35 SQCK O Subcode-Q data Transferring bit
clock
36 POWERON O Power on request for head
headunit
uPD78F9177AY 052-3930-01
Master Micro computer
Outward Form
44 pins, plastic QFP
Terminal Description
37 GND - GND
38 CDPRES O Servo reset
39 BDATA - NC
40 BUSOUT O Interface signal from headunit
41 MUTE O DSP DAC hardware mute
42 MCK1 O Serial data clock of the servo IC
43 AVDD - VDD
44 AVREF - Reference voltage
Pin No PIN NAME I/O DESCRIPTIONPin No PIN NAME I/O DESCRIPTION

- 8 -- 8 -
- 8 -- 8 -
- 8 -
DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
S5L9276 051-6398-00
MP3 Decoder
Outward Form
64 pins, plastic QFP
1 VDD - Digital Power
2 XI I X’tal Oscillator input (16.9344MHz)
3 XO O X’tal Oscillator output
4 XOUT O Buffered Output of XO
5 CLK I System Clock input
6 RESETB I System Reset Active LOW
7 PLL0 VDDA - Analog Power for PLL0
8 PLL0 VSSA - Analog GND for PLL0
9 PLL0 VBBA - Analog GND for PLL0
10 FILTER_0 O External Capacitor port for PLL0
11 PLL1 VDDA - Analog Power for PLL1
12 PLL1 VSSA - Analog GND for PLL1
13 PLL1 VBBA - Analog GND for PLL1
14 FILTER_1 O External Audio Clock source
15 PLL_BYPASS - NC
16 VSS - Digital GND
17 VDD - Digital Power
18 ACLK ET I External Audio Clock source
19 CD CLK O Clock Output for CD DSP IC
20 CD DATA I Data from CD DSP IC
21 CD LRCK I LRCK from CD DSP IC
22 CD BCK I BCK from CD DSP IC
23 CD C2PO I C2PO from CD DSP IC
24 ACLK O Audio clock to DAC clock input
25 BCLK O BCLK to DAC
26 LRCK O LRCK to DAC
27 ADAT O Data to DAC
28 EMP - NC
29 ETYPE - NC
30 A11 O Address Output11 for DRAM
31 A10 O Address Output10 for DRAM
32 VSS - Digital GND
33 VDD - Digital Power
34 MCU_CLK - NC
35 MDAT I Data input pin
36 MCK I Micom Clock pin
37 MLAT I Data Latch input pin
38 MDOUT O Data from CD-MP3 to MCU
39 MINT O Interrupt output to MCU
40 SCAN_EN - NC
41 TEST2 - GND
42 TEST1 - GND
43 TEST0 - GND
44 DDAT0 B Data0 BUS for External DRAM
45 DDAT1 B Data1 BUS for External DRAM
46 WEB O Write Enable for External DRAM
47 RASB O Row Address for External DRAM
48 VSS - Digital GND
49 VDD - Digital Power
50 DDAT2 B Data2 BUS for External DRAM
51 DDAT3 B Data3 BUS for External DRAM
Terminal Description
52 CASB O Column Address for External
DRAM
53 DA08 O Address Output8 for DRAM
54 DA07 O Address Output7 for DRAM
55 DA06 O Address Output6 for DRAM
56 DA05 O Address Output5 for DRAM
57 DA04 O Address Output4 for DRAM
58 DA09 O Address Output9 for DRAM
59 DA00 O Address Output0 for DRAM
60 DA01 O Address Output1 for DRAM
61 DA02 O Address Output2 for DRAM
62 DA03 O Address Output3 for DRAM
63 OEB - GND
64 VSS - Digital GND
Pin No PIN NAME I/O DESCRIPTIONPin No PIN NAME I/O DESCRIPTION

- 9 -- 9 -
- 9 -- 9 -
- 9 - DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
S5L9290 051-6397-00
DSP
Outward Form
48 pins, plastic QFP
1 VSSA_PLL - Analog GND for DPLL
2 VCO1LF O Pump out for VCO1
3 VSSD_PLL - Digital GND Separated Bulk Bias
for DPLL
4 VDDD_PLL - Digital Power Separated Bulk Bias
for DPLL (3V Power)
5 VDDD1-5V - Digital power (5V power, I/O pad)
6 XIN I X’tal oscillator input (16.9344MHz)
7 XOUT - NC
8 VSSD1 - GND
9 EFMI I EFM signal input
10 LOCK O CLV Servo locking status output
11 SMEF O LPF time constant control of the
spindle servo error signal
12 SMDP O Phase control output for Spindle
Motor drive
13 SMDS O Speed control output for Spindle
Motor drive
14 WDCK O Word clock output
(Normal Speed: 88.2kHz,
Double Speed : 176.4kHz)
15 TESTV - GND
16 LKFS O The Lock status output of frame
sync
17 C4M - NC
18 RESETB I System Reset at “L”
19 MLT I Latch signal input from Micom
20 MDAT I Serial data inout from Micom
21 MCK I Serial data receiving clock inout
from Micom
22 ISTAT - NC
23 SOS1 O Subcode sync signal (S0+S1)
output
24 SQCK I Subcode-Q data transferring bit
clock input
25 SQDT I Subcode-Q data serial output
26 MUTE I System mute at “H”
27 VDDD2-3V - Digital Power (3V power, Internal
Logic)
28 VSSD2 - Digital GND (Internal Logic)
29 VDDD3-5V - Digital Power (5V Power, I/O PAD)
30 SBCK I Subcode data transferring bit
clock
31 JITB - NC
32 C2PO O C2 pointer output
33 DATX - NC
34 SADTO O Serial audio data output (48 slot,
MSB first)
35 LRCKO O Channel clock output
36 BCKO O Bit clock output
37 BCKI I Channel clock input
Terminal Description
38 LRCKI I Channel clock input
39 SADTI I Serial audio data input (48 slot,
MSB first)
40 VSSD_DAC - Digital GND for DAC
41 VDDD_DAC - Digital Power for DAC (3V Power)
42 RCHOUT O Right-Channel audio output
through DAC
43 VSSA_DAC - Analog GND for DAC
44 VREF O Reference Voltage output for
bypass
45 VHALF O Reference Voltage output for
bypass
46 VDDA_DAC - Analog Power for DAC (3V Power)
47 LCHOUT O Left-Channel audio output through
DAC
48 VDDA_PLL - Analog Power for PLL (3V Power)
Pin No PIN NAME I/O DESCRIPTIONPin No PIN NAME I/O DESCRIPTION

- 10 -- 10 -
- 10 -- 10 -
- 10 -
DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
S1L9226 051-5712-00
ASP ( RF AMP )
Outward Form
48 pins, plastic QFP
1 RFM I RF summing amp. Inverting input
2 RFO O RF summing amp. Output
3 EQI I RFO DC eliminating input (use by
MIRROR,FOK,AGC & EQ
terminal
4 EQO O RF Equalizer output
5 EFMI I EFM slice input. ( input
impedance 47K )
6VCC -VDD
7 FRSH I Capacitor connection to focus
search
8 FSET I Filter bias for focus, tracking,
spindle
9 FLB I Capacitor connection to make
focus loop rising band
10 FGD I Terminal to change the high
frequency gain of focus loop
11 FSI I Focus servo input
12 TGU I Connect the component to
change the high frequency of
tracking Loop
13 ISTAT O Internal Status output
14 MCK I Micom clock
15 MDATA I Data Input
16 MLT I Data latch input
17 RESET I Reset input
18 CLVI I Input the spindle control output
from DSP
19 WDCK I 88.2KHz input terminal from DSP
20 LOCK I Sled run away inhibit pin (L: sled
off & tracking gain up)
21 EFM O EFM output for RFO slice (to
DSP)
22 ASY I Auto Asymmetry control input
23 SPM I Spindle amp. Inverting input
24 SPO O Spindle amp. Output
25 SLM I Sled servo inverting input
26 SLO O Sled servo output
27 SLP I Sled servo noninverting input
28 TEM I Tracking servo amp. Inverting
input
29 TEO O Tracking servo amp. Output
30 FEM I Internal status of the servo IC
31 FEO - NC
32 GND - GND
33 TZC/SSTOP I Tracking zero crossing input &
Check the position of pick-up
whether inside or not
34 TEIO B Tracking error output & Tracking
servo input
35 LPFT I Tracking error integration input
36 ATSC I Anti-shock input
Terminal Description
37 LD O APC amp. output
38 PD I APC amp. Input
39 PDAC I Photo diode A & C RF I/V
amp.inverting input
40 PDBD I Photo diode B & D RF I/V amp.
Inverting input
41 PDF I Photo diode F& tracking(F) I/V
amp. Inverting input
42 PDE I Photo diode E & tracking(E) I/V
amp. Inverting input
43 DCB I Capacitor connection to limit the
defect detection
44 MCP I Capacitor connection to mirror
hold
45 DCCI O Output pin to connect the
component for defect detect
46 DCCO I Input pin to connect the
component for defect detect
47 VREF O (VCC+GND)/2 Voltage reference
output
48 EQC I AGC_qualize level control
terminal & Capacitor terminal to
input in to VCA
Pin No PIN NAME I/O DESCRIPTIONPin No PIN NAME I/O DESCRIPTION

- 11 -- 11 -
- 11 -- 11 -
- 11 - DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
EXPLODED VIEW • PART LIST
Main Section/DCP Section

- 12 -- 12 -
- 12 -- 12 -
- 12 -
DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
42 335-7014-00 LCD ILLUMI 1
43 001-7046-00 DIODE 1
44 335-6955-00 LCD HOLDER 1
45 016-9900-90 VR W/SHAFT 1
46 345-7148-20 RUBBER PART 4
47 017-0410-00 PILOT LAMP 4
48 013-6305-50 TACT SWITCH 3
49 013-6005-51 TACT SWITCH 12
50 076-0703-12 PLUG 1
51 051-6013-50 IC 1
52 039-2310-01 MAIN PWB (SWITCH) 1
53 060-4008-00 IR-RECEIVER 1
54 039-2310-01 MAIN PWB (WITHOUT COMPONENTS) 1
55 331-3630-00 CONECTOR COVER 1
56 074-1316-12 OUTLET SOCKET (DCP) 1
57 074-9013-11 OUTLET SOCKET 1
58 880-2090-Y TUNER 1
59 816-2628-60 FLAT WIRE 1
60 331-3631-00 RCA BRKY 1
61 075-0388-00 RCA JACK 1
62 074-1214-00 OUTLET SOCKET 1
63 009-9006-60 CHOKE 1
64 331-3367-01 IC HOLDER 1
65 051-2050-01 POWER IC 1
66 092-4000-51 ANT-RECEPT 1
67 313-1878-00 HEAT SINK 1
68
69
70
71 382-6712-00 BUTTON AF/PTY 1
72 313-1873-00 HEAT SINK 1
73 039-2319-01 CD PWB (WITHOUT COMPONENTS) 1
74 716-3502-01 SP SCREW 3
75 750-6742-00 SPRING 1
76 347-6975-00 COPPER TAPE 1
77 347-7026-00 BLACK MATTEE STICKER 1
78 331-1861-21 EARTH PLATE 1
79 331-3677-01 SHEILD CASE 1
80 291-0074-00 SECURITY LABEL 1
81 013-3932-01 TACT SWITCH 1
82 052-3930-01 IC 1
1 DCP-449-700 DCP ASSY 1
2 286-9997-00 SET PLATE 1
3 311-1848-00 LOWER CASE 1
4 310-1781-02 UPPER CASE 1
5 731-2604-81 TAPTIGHT 3
6
7
8 948-0668-00 CD MECHA 1
9
10 714-2012-81 MC SCREW 1
11 731-3008-80 TAPTIGHT 4
12 731-3012-80 TAPTIGHT 2
13 714-3006-81 TAPTIGHT 2
14 716-0872-03 SP SCREW 2
15 371-5745-20 FACE PLATE 1
16 373-1006-00 DIAL COVER 1
17 345-5261-00 RUBBER KNOB 1
18 380-5566-00 KNOB 1
19 370-6042-00 ESCUTCHEON 1
20 382-6711-00 BUTTON ASSY (R) 1
21 335-6952-01 ILLUMI PLATE (R) 1
22 382-6689-00 REMOTE BUTTON 1
23 382-6688-00 BUTTON ASSY (L) 1
24 382-6690-00 RELEASE BUTTON 1
25 335-6953-00 ILLUMI PLATE (L) 1
26 335-6951-00 REAR COVER 1
27 716-0872-11 SP SCREW 4
28 346-0097-00 LEATHER SHEET 1
29
30 370-6922-02 INNER ESC 1
31 382-4078-20 BUTTON P-UP 1
32 750-3173-00 SPRING 2
33 331-3609-00 HOOK PLATE 1
34 716-0778-00 WAVE SCREW 2
35 335-5915-20 HOOK 1
36 341-1627-20 SHAFT 1
37 750-3219-20 SPRING 1
38 331-3608-00 LCD COVER 1
39 379-1267-41 INDICATOR 1
40 347-6924-00 FILM 1
41 347-6923-00 SHADE 1
NO. PART NO. PART NAME Q'TY NO. PART NO. DESCRIPTION Q'TY

- 13 -- 13 -
- 13 -- 13 -
- 13 - DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
EXPLODED VIEW • PARTS LIST
CD mechanism section 948-0668-00

- 14 -- 14 -
- 14 -- 14 -
- 14 -
DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
NO. PART NO. DESCRIPTION Q'TY
73 658-0235-41 LD WIRE ASSY ML 1
74 658-0235-42 SW WIRE ASSY M 1
75 658-0235-43 SP WIRE ASSY M 1
77 658-0235-44 WIRE CLAMPER M 4
78 658-0235-45 WIRE TUBE SPM 2
79 658-0235-46 WIRE TUBE MSW 1
81 658-0235-47 ROLLER SHAFT ASS’Y 1
82 658-0235-48 LOADING GEAR PLATE RIVET 1
83 658-0235-49 LOADING PLATE ASS’Y 1
84 658-0235-50 LOCK ARM RIVET ASS’Y 1
85 658-0235-51 LOADING/FEED MOTOR ASS’Y 1
86 658-0235-52 LOADING GEAR 1 1
87 658-0235-53 LOADING GEAR 2 1
88 658-0235-54 LOADING GEAR 3 1
89 658-0235-55 LOADING GEAR 4 1
90 658-0235-56 LOADING GEAR 5 1
91 658-0235-57 LOADING GEAR 6 1
92 658-0235-58 LOADING GEAR 7 1
93 658-0235-59 ROLLER GUIDE 2
94 658-0235-60 ROLLER GUIDE SPRING 2
95 658-0235-61 DISC STOPPER ARM 1
96 658-0235-62 DISC STOP ARM SPRING 1
97 658-0235-63 LD GEAR BRACKET 1
98 658-0235-64 L SLIDE PLATE 1
99 658-0235-65 LOADING PLATE SPRING 1
100 658-0235-66 LDG ROLLER 2
101 658-0235-67 PK COLLAR SCREW A 1
111 658-0235-68 TAPPING SCREW 2 x 3 5
112 658-0235-69 TAPPING SCREW 2 x 4 2
113 658-0235-70 TAPPING BIND SCREW 2 x 4 1
114 658-0235-71 CAMERA SCREW 1.7 x 1.8 2
115 658-0235-72 CAMERA SCREW 2•~2 1
116 658-0235-73 CAMERA TAPPING 1
SCREW P3
121 658-0235-74 PW 3.5 x 8 x 0.3 1
122 658-0235-75 HLW 1.85 x 5 x 0.13 1
123 658-0235-76 LUMILAR WASHER 1
3.1 x 6 x 0.
124 658-0235-77 E RING S 1.5 1
125 658-0235-78 PW 2.1 x 4 x 0.13 1
NO. PART NO. DESCRIPTION Q'TY
1 658-0235-01 FRAME M 1
2 658-0235-02 TOP COVER M 1
3 658-0235-03 DAMPER F 2
4 658-0235-04 DAMPER R 1
5 658-0235-05 AR SHEET 1
11 658-0235-06 CHASSIS RIVET S ASS’Y (M) 1
12 658-0235-07 CHANGE PLATE RIVET ASS’Y 1
13 658-0235-08 CLAMPER ASS’Y 1
14 658-0235-09 SPINDLE MOTOR (M) ASS’Y1
15 658-0235-10 CLAMPER ARM M 1
16 658-0235-11 CHANGE GEAR SPRING 1
17 658-0235-12 CHANGE GEAR 2 1
18 658-0235-13 FEED GEAR 1
19 658-0235-14 FEED RACK M 1
20 658-0235-15 CHANGE LOCK LEVER M 1
21 658-0235-16 FEED SW HOLDER (M) 1
22 658-0235-17 PU SHAFT HOLDER (M) 2
23 658-0235-18 CLAMPER SUB SPRING 1
24 658-0235-19 FD SUB HOLDER M 1
25 658-0235-20 TOP PLATE S 1
26 658-0235-21 SELECT LOCK ARM 1
27 658-0235-22 TRIGGER ARM M 1
28 658-0235-23 SLIDE HOOK 1
29 658-0235-24 PU SHAFT M 1
30 658-0235-25 CLAMPER ARM SPRING M 1
31 658-0235-26 SELECT LOCK ARM SPRING 1
32 658-0235-27 SUSPENSION SPRING MS 4
33 658-0235-28 SELECT ARM R 1
34 658-0235-29 LINK PLATE 1
35 658-0235-30 LINK PLATE SPRING 1
36 658-0235-31 CUSHION F 1
37 658-0235-32 CUSHION R 2
38 658-0235-33 FEED SPR PLATE M 1
43 658-0235-34 SELECT PLATE L 1
44 658-0235-35 SELECT PLATE R 1
45 658-0235-36 SELECT PIECE L 1
46 658-0235-37 SELECT PIECE R 1
61 658-0235-38 PICK UP RD-DAP005-TN 1
62 658-0235-39 DET SW ESE 22MH55 1
72 658-0235-40 MODE SW 1
CAUTION:CAUTION:
CAUTION:CAUTION:
CAUTION:
PART NO. 3, 4, 45, 46, 77, 87, 88, 89, 90 are reusing prohibition.
Exchange to the new part after remove.

- 15 -- 15 -
- 15 -- 15 -
- 15 -
DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
ELECTRICAL PARTS LIST
Main PWB Section (B1) Note:- Several different parts of the same reference number are alternative parts.
One of those parts is used in the set.
ANT 101 092-4000-51 ANT-RECEP
BL 101 880-2090Y AM/FM TUNER
C 101 166-2201-50 50V 22pF
C 102 166-2201-50 50V 22pF
C 103 168-1032-55 50V 0.01uF
C 104 168-1032-55 50V 0.01uF
C 105 168-1022-55 50V 1000pF
C 106 183-1073-25 10V 100uF
C 107 168-1045-56 50V 0.1uF
C 108 168-1032-56 50V 0.01uF
C 109 183-1073-25 10V 100uF
C 110 183-1073-25 10V 100uF
C 111 168-1032-55 50V 0.01uF
C 112 168-6822-55 50V 6800pF
C 113 168-2232-55 50V 0.022uF
C 114 168-2232-55 50V 0.022uF
C 115 168-1022-55 50V 1000pF
C 116 168-4732-78 50V 0.047uF
C 117 183-1053-65 50V 1uF
C 118 168-2232-55 50V 0.022uF
C 120 183-3353-65 50V 3.3uF
C 121 168-1032-55 50V 0.01uF
C 125 183-4753-55 35V 4.7uF
C 126 168-5632-78 50V 0.056uF
C 127 168-1032-55 50V 0.01uF
C 201 168-1032-55 50V 0.01uF
C 204 168-1045-56 50V 0.1uF
C 205 166-2201-50 50V 22pF
C 206 166-2201-50 50V 22pF
C 207 166-3311-50 50V 330pF
C 208 166-1011-50 50V 100pF
C 209 166-1011-50 50V 100pF
C 210 166-1011-50 50V 100pF
C 211 168-1022-55 50V 1000pF
C 212 183-1073-17 6.3V 100uF
C 213 168-4732-78 50V 0.047uF
C 215 183-3353-65 50V 3.3uF
C 216 168-1032-55 50V 0.01uF
C 217 168-1011-50 50V 100pF
C 301 183-2253-65 50V 2.2uF
C 302 166-3311-50 50V 330pF
C 303 166-5611-50 50V 560pF
C 304 166-4701-50 50V 47pF
C 305 166-8201-50 50V 82pF
C 306 168-1045-56 50V 0.1uF
C 307 183-4763-15 6.3V 47uF
C 308 168-2232-55 50V 0.022uF
C 309 168-1032-55 50V 0.01uF
C 310 168-2232-55 50V 0.022uF
C 311 166-1001-50 50V 10pF
C 312 166-8211-50 50V 820pF
C 313 166-6811-50 50V 680pF
C 401 183-1063-35 16V 10uF
C 402 166-4711-50 50V 470pF
Designator PART No. DESCRIPTION Designator PART No. DESCRIPTION Designator PART No. DESCRIPTION
C 411 183-1063-35 16V 10uF
C 412 166-4711-50 50V 470pF
C 413 166-6811-50 50V 680pF
C 501 183-2253-65 50V 2.2uF
C 502 183-2253-65 50V 2.2uF
C 503 183-2253-65 50V 2.2uF
C 504 178-4742-78 25V 0.47uF
C 505 168-1045-56 50V 0.1uF
C 506 168-1045-56 50V 0.1uF
C 507 168-2722-55 50V 2700pF
C 508 166-6811-50 50V 680pF
C 511 183-2253-65 50V 2.2uF
C 512 183-2253-65 50V 2.2uF
C 513 183-2253-65 50V 2.2uF
C 514 178-4742-78 25V 0.47uF
C 515 168-1045-56 50V 0.1uF
C 516 168-1045-56 50V 0.1uF
C 517 168-2722-55 50V 2700pF
C 518 166-6811-50 50V 680pF
C 521 183-2263-35 16V 22uF
C 522 168-1045-56 50V 0.1uF
C 523 168-1045-56 50V 0.1uF
C 524 168-2222-55 50V 2200pF
C 525 168-2222-55 50V 2200pF
C 526 166-1011-50 50V 100pF
C 527 166-1011-50 50V 100pF
C 528 166-1011-50 50V 100pF
C 529 166-1011-50 50V 100pF
C 530 166-1011-50 50V 100pF
C 602 178-4742-78 50V 0.47uF
C 603 178-4742-78 50V 0.47uF
C 604 172-1041-15 50V 0.1uF
C 605 172-1041-15 50V 0.1uF
C 606 172-1041-15 50V 0.1uF
C 607 172-1041-15 50V 0.1uF
C 608 183-1063-35 16V 10uF
C 609 183-1063-35 16V 10uF
C 612 178-4742-78 50V 0.47uF
C 613 178-4742-78 50V 0.47uF
C 614 172-1041-15 16V 0.1uF
C 615 172-1041-15 16V 0.1uF
C 616 172-1041-15 16V 0.1uF
C 617 172-1041-15 16V 0.1uF
C 618 183-1063-35 16V 10uF
C 619 183-1063-35 16V 10uF
C 622 183-4763-35 16V 47uF
C 623 183-2263-35 16V 22uF
C 624 183-3343-65 50V 0.33uF
C 625 166-4711-50 50V 470pF
C 626 166-4711-50 50V 470pF
C 627 166-4711-50 50V 470pF
C 628 166-4711-50 50V 470pF
C 629 166-4711-50 50V 470pF
C 630 166-4711-50 50V 470pF
C 631 166-4711-50 50V 470pF
C 632 166-4711-50 50V 470pF
C 701 166-1011-50 50V 100pF
C 702 166-1011-50 50V 100pF
C 703 168-1032-55 50V 0.01uF
C 705 183-1063-35 16V 10uF
C 706 183-1073-17 6.3V 100uF
C 707 183-1063-35 16V 10uF
C 708 183-1063-35 16V 10uF
C 709 183-1063-35 16V 10uF
C 710 183-2253-65 50V 2.2uF
C 711 182-2273-15 6.3V 220uF
C 802 182-2273-15 6.3V 220uF
C 901 184-2283-32 16V 2200uF
C 902 172-1041-15 50V 0.1uF
C 903 183-1053-65 50V 1uF
C 904 183-4763-35 16V 47uF
C 907 183-1073-25 10V 100uF
C 908 183-1073-25 10V 100uF
C 909 183-1063-35 16V 10uF
C 910 183-1073-25 10V 100uF
C 911 168-1045-56 50V 0.1uF
C 912 183-4743-65 50V 0.47uF
C 915 183-1063-35 16V 10uF
C 920 166-1011-50 50V 100pF
C 921 168-1032-55 50V 0.01uF
C 923 166-1011-50 50V 100pF
C 928 166-1501-50 50V 15pF
D 201 001-0330-90 1SS119
D 301 001-0330-90 1SS119
D 302 001-0330-90 1SS119
D 601 001-0466-90 S5688B
D 602 001-0466-90 S5688B
D 603 001-0466-90 S5688B
D 604 001-0466-90 S5688B
D 605 001-0466-90 S5688B
D 606 001-0466-90 S5688B
D 607 001-0466-90 S5688B
D 608 001-0466-90 S5688B
D 701 001-0330-90 1SS119
D 702 001-0347-32 MA4056M
D 703 001-0466-91 S5688G
D 704 001-0347-43 MA4082L
D 901 001-0592-00 RM4Z
D 902 001-0330-90 1SS119
D 903 001-0466-91 S5688G
D 904 001-0330-90 1SS119
D 905 001-0347-45 MA4082H
D 906 001-0330-90 1SS119
D 907 001-0347-46 MA4091L
D 908 001-0330-90 1SS119
D 909 001-0330-90 1SS119
D 910 001-0347-36 MA4062H
D 911 001-0330-90 1SS119

- 16 -- 16 -
- 16 -- 16 -
- 16 - DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
Q 902 125-3006-90 KTA1281
Q 903 125-3004-90 KTA1504GR
Q 904 125-4010-90 KTC3875GR
Q 905 125-2199-92 KRC102S
Q 906 125-0199-92 KRA102S
Q 907 102-3420-00 2SC3420
Q 909 125-3004-90 KTA1504GR
Q 911 125-2199-93 KRC103S
Q 912 125-3004-90 KTA1504GR
Q 913 125-4011-90 KTD863YAT
Q 914 125-4011-90 KTD863YAT
Q 915 125-4011-90 KTD863YAT
Q 916 125-3004-90 KTA1504GR
Q 917 125-4010-90 KTC3875GR
Q 918 125-0199-92 KRA102S
Q 919 125-4010-90 KTC3875GR
Q 920 125-0199-92 KRA102S
Q 921 125-4010-90 KTC3875GR
Q 922 125-2199-93 KRC103S
Q 923 125-3005-90 KTA1273
Q 924 125-2199-92 KRC102S
Q 925 125-4011-90 KTD863YAT
Q 928 125-3004-90 KTA1504GR
Q 931 125-4010-90 KTC3875GR
Q 932 125-2199-92 KRC102S
R 101 119-1021-15 1/16W 1K ohm
R 102 119-1011-15 1/16W 100 ohm
R 103 119-4721-15 1/16W 4.7K ohm
R 105 119-1021-15 1/16W 1K ohm
R 107 119-1031-15 1/16W 10K ohm
R 108 111-2221-98 1/4W 2.2K ohm
R 109 119-1031-15 1/16W 10K ohm
R 110 111-2221-98 1/4W 2.2K ohm
R 111 119-2221-15 1/16W 2.2K ohm
R 112 119-1021-15 1/16W 1K ohm
R 113 111-1031-98 1/4W 10K ohm
R 122 119-3311-15 1/16W 330 ohm
R 124 119-3311-15 1/16W 330 ohm
R 125 119-2221-15 1/16W 2.2K ohm
R 127 119-5621-15 1/16W 5.6K ohm
R 128 119-1021-15 1/16W 1K ohm
R 129 119-4721-15 1/16W 4.7K ohm
R 130 111-3311-98 1/4W 330 ohm
R 131 119-0000-05 1/16W 0 ohm
R 132 119-0000-05 1/16W 0 ohm
R 134 119-0000-05 1/16W 0 ohm
R 201 119-1041-15 1/16W 100K ohm
R 202 119-2221-15 1/16W 2.2K ohm
R 203 119-2221-15 1/16W 2.2K ohm
R 204 119-1021-15 1/16W 1K ohm
R 205 119-1031-15 1/16W 10K ohm
R 206 119-5631-15 1/16W 56K ohm
R 207 119-4721-15 1/16W 4.7K ohm
R 208 119-1031-15 1/16W 10K ohm
Designator PART No. DESCRIPTION Designator PART No. DESCRIPTION Designator PART No. DESCRIPTION
D 912 001-0330-90 1SS119
D 913 001-0347-40 MA4075L
D 914 001-0347-38 MA4068M
D 915 001-0330-90 1SS119
D 916 001-0330-90 1SS119
D 917 001-0330-90 1SS119
D 918 001-0347-35 MA4062M
D 920 001-0347-46 MA4091L
D 921 001-0466-91 S5688G
D 923 001-0330-90 1SS119
D 925 001-0347-35 MA4062M
D 926 001-0347-40 MA4075L
D 927 001-0529-43 MA8082L
IC 201 052-1937-01 uPD178078
GF-583
IC 301 051-4614-00 PT2579
IC 302 051-0350-93 NJM4558M
IC 501 051-5031-90 PT2313L
IC 601 051-2050-00 LA47532
IC 701 051-0350-93 NJM4558M
JW 1 060-0108-90 1/4W 0 ohm
JW 2 060-0108-90 1/4W 0 ohm
JW 3 060-0108-90 1/4W 0 ohm
JW 4 060-0108-90 1/4W 0 ohm
J 201 074-1316-12 OUTLET
SOCKET
J 501 074-9013-11 OUTLET
SOCKET
J 901 074-1214-00 OUTLET
SOCKET
L 101 010-2003-04 COIL
L 103 010-2230-69 5.6uH
L 301 010-2230-88 220uH
L 601 010-3001-63 5.6uH
L 602 010-3001-63 5.6uH
L 603 010-3001-63 5.6uH
L 604 010-3001-63 5.6uH
Q 101 125-2199-93 KRC103S
Q 102 125-3004-90 KTA1504GR
Q 103 125-3004-90 KTA1504GR
Q 104 125-4010-90 KTC3875GR
Q 105 125-4010-90 KTC3875GR
Q 106 198-0669-00 2SK669
Q 107 125-4010-90 KTC3875GR
Q 108 125-0199-93 KRA103S
Q 302 125-2199-92 KRC102S
Q 401 125-4010-90 KTC3875GR
Q 411 125-4010-90 KTC3875GR
Q 421 125-0199-92 KRA102S
Q 701 125-3004-90 KTA1504GR
Q 702 125-0199-92 KRA102S
Q 703 125-2199-92 KRC102S
Q 704 125-4011-90 KTD863YAT
Q 901 125-2199-93 KRC103S
R 209 119-1031-15 1/16W 10K ohm
R 210 119-2231-15 1/16W 22K ohm
`R 211 119-2231-15 1/16W 22K ohm
R 212 119-1041-15 1/16W 100K ohm
R 213 119-1031-15 1/16W 10K ohm
R 215 119-1031-15 1/16W 10K ohm
R 216 119-1031-15 1/16W 10K ohm
R 218 119-4721-15 1/16W 4.7K ohm
R 219 119-4721-15 1/16W 4.7K ohm
R 220 119-1021-15 1/16W 1K ohm
R 226 119-1031-15 1/16W 10K ohm
R 227 119-1031-15 1/16W 10K ohm
R 228 119-5631-15 1/16W 56K ohm
R 229 119-1031-15 1/16W 10K ohm
R 230 119-1021-15 1/16W 1K ohm
R 231 119-1031-15 1/16W 10K ohm
R 232 119-1021-15 1/16W 1K ohm
R 234 119-1021-15 1/16W 1K ohm
R 235 119-1021-15 1/16W 1K ohm
R 241 119-0000-05 1/16W 0 ohm
R 242 119-0000-05 1/16W 0 ohm
R 301 119-2221-15 1/16W 2.2K ohm
R 302 119-1031-15 1/16W 10K ohm
R 303 119-1231-15 1/16W 12K ohm
R 304 119-1041-15 1/16W 100K ohm
R 305 119-2211-15 1/16W 220 ohm
R 306 119-3331-15 1/16W 33K ohm
R 307 119-3321-15 1/16W 3.3K ohm
R 401 119-1031-15 1/16W 10K ohm
R 402 119-3311-15 1/16W 330 ohm
R 403 119-5621-15 1/16W 5.6K ohm
R 411 119-1031-15 1/16W 10K ohm
R 412 119-3311-15 1/16W 330 ohm
R 413 119-5621-15 1/16W 5.6K ohm
R 421 119-4721-15 1/16W 4.7K ohm
R 422 119-0000-05 1/16W 0 ohm
R 423 119-0000-05 1/16W 0 ohm
R 501 119-2221-15 1/16W 2.2K ohm
R 502 119-1021-15 1/16W 1K ohm
R 503 119-5621-15 1/16W 5.6K ohm
R 511 119-2221-15 1/16W 2.2K ohm
R 512 119-1021-15 1/16W 1K ohm
R 513 119-5621-15 1/16W 5.6K ohm
R 514 119-2231-15 1/16W 22K ohm
R 515 119-2231-15 1/16W 22K ohm
R 518 119-3901-15 1/16W 39 ohm
R 519 119-3901-15 1/16W 39 ohm
R 520 119-3901-15 1/16W 39 ohm
R 521 119-3901-15 1/16W 39 ohm
R 522 119-1531-15 1/16W 15K ohm
R 523 119-1531-15 1/16W 15K ohm
R 601 119-2221-15 1/16W 2.2K ohm
R 602 119-2221-15 1/16W 2.2K ohm
R 603 119-2291-15 1/16W 2.2 ohm

- 17 -- 17 -
- 17 -- 17 -
- 17 -
DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
R 905 111-1591-98 1/4W 1.5 ohm
R 906 111-1591-98 1/4W 1.5 ohm
R 907 111-1591-98 1/4W 1.5 ohm
R 908 119-1031-15 1/16W 10K ohm
R 909 119-3321-15 1/16W 3.3K ohm
R 910 119-3321-15 1/16W 3.3K ohm
R 911 119-2231-15 1/16W 22K ohm
R 912 111-4711-98 1/4W 470 ohm
R 913 111-4711-98 1/4W 470 ohm
R 914 119-1031-15 1/16W 10K ohm
R 915 119-1021-15 1/16W 1K ohm
R 917 119-1031-15 1/16W 10K ohm
R 918 111-3921-98 1/4W 3.9K ohm
R 919 111-8211-98 1/4W 820 ohm
R 920 111-8211-98 1/4W 820 ohm
R 921 111-2291-98 1/4W 2.2 ohm
R 922 111-2291-98 1/4W 2.2 ohm
R 923 111-1021-98 1/4W 1K ohm
R 924 119-1231-15 1/16W 12K ohm
R 925 119-1031-15 1/16W 10K ohm
R 926 119-1021-15 1/16W 1K ohm
R 927 119-4721-15 1/16W 4.7K ohm
R 928 119-1031-15 1/16W 10K ohm
R 929 119-1231-15 1/16W 12K ohm
R 930 119-1031-15 1/16W 10K ohm
R 931 119-4721-15 1/16W 4.7K ohm
Designator PART No. DESCRIPTION Designator PART No. DESCRIPTION Designator PART No. DESCRIPTION
R 604 119-2291-15 1/16W 2.2 ohm
R 605 119-2291-15 1/16W 2.2 ohm
R 606 119-2291-15 1/16W 2.2 ohm
R 611 119-2221-15 1/16W 2.2K ohm
R 612 119-2221-15 1/16W 2.2K ohm
R 613 119-2291-15 1/16W 2.2 ohm
R 614 119-2291-15 1/16W 2.2 ohm
R 615 119-2291-15 1/16W 2.2 ohm
R 616 119-2291-15 1/16W 2.2 ohm
R 621 119-1231-15 1/16W 12K ohm
R 622 119-1031-15 1/16W 10K ohm
R 701 119-4721-15 1/16W 47K ohm
R 702 119-4721-15 1/16W 47K ohm
R 703 119-2231-15 1/16W 22K ohm
R 704 119-1231-15 1/16W 12K ohm
R 705 119-1031-15 1/16W 10K ohm
R 706 119-3331-15 1/16W 33K ohm
R 707 119-3331-15 1/16W 33K ohm
R 708 119-4721-15 1/16W 47K ohm
R 710 119-4721-15 1/16W 47K ohm
R 713 111-1001-98 1/4W 10 ohm
R 714 111-1221-98 1/4W 1.2K ohm
R 715 111-1021-98 1/4W 1K ohm
R 902 111-1221-98 1/4W 1.2K ohm
R 903 119-1031-15 1/16W 10K ohm
R 904 111-1591-98 1/4W 1.5 ohm
R 932 119-2231-15 1/16W 22K ohm
R 933 111-2231-98 1/4W 22K ohm
R 934 119-4721-15 1/16W 47K ohm
R 935 111-1021-98 1/4W 1K ohm
R 936 119-1031-15 1/16W 10K ohm
R 937 111-4711-98 1/4W 470 ohm
R 938 119-1031-15 1/16W 10K ohm
R 939 119-2231-15 1/16W 22K ohm
R 940 111-3321-98 1/4W 3.3K ohm
R 943 119-1021-15 1/16W 1K ohm
R 944 119-2231-15 1/16W 22K ohm
R 945 119-1031-15 1/16W 10K ohm
R 946 111-1021-98 1/4W 1K ohm
R 947 111-1021-98 1/4W 1K ohm
R 949 119-0000-05 1/16W 0 ohm
R 950 119-0000-05 1/16W 0 ohm
RCA 401 075-0388-00 RCA JACK
S 901 013-3932-01 SKHHLMA01
SUP 101 060-0122-20 DSP-141
N-S00B
T 901 009-9006-60 CHOKE
VR 101 012-4738-13 470K
X 201 061-1053-00 4.5MHz
X 301 061-3013-00 4.33MHz
C 1 168-1022-55 50V 1000pF
C 2 168-4732-78 50V 0.047uF
C 3 168-4732-78 50V 0.047uF
C 4 168-4732-78 50V 0.047uF
C 5 042-0416-51 6.3V 10uF
C 6 042-0416-51 6.3V 10uF
D 1 001-0529-41 MA8075M
D 2 001-7046-00 NSPW310BS(LED)
D 3 001-0529-29 MA8051M
D 4 001-0529-14 MA8030L
D 5 001-0529-41 MA8075M
D 6 001-0529-41 MA8075M
D 7 001-0529-41 MA8075M
D 8 001-0529-41 MA8075M
D 9 001-0529-41 MA8075M
D 10 001-0529-41 MA8075M
D 11 001-0529-41 MA8075M
D 12 001-0529-29 MA8051M
IC 1 051-6013-50 PT6554LQ
IR 1 060-4008-00 RS-171
Designator PART No. DESCRIPTION
J 1 076-0703-12 PLUG
LCD 1 379-1267-41 INDICATOR
PL 1 017-0410-00 14V 40mA
PL 2 017-0410-00 14V 40mA
PL 3 017-0410-00 14V 40mA
PL 4 017-0410-00 14V 40mA
Q 1 125-3007-90 KTA1298
R 1 119-2221-15 1/16W 2.2K ohm
R 2 119-2221-15 1/16W 2.2K ohm
R 3 119-2221-15 1/16W 2.2K ohm
R 4 119-3921-15 1/16W 3.9K ohm
R 5 119-1241-15 1/16W 120K ohm
R 7 119-1031-15 1/16W 10K ohm
R 8 119-4731-15 1/16W 47K ohm
R 9 119-3311-15 1/16W 330 ohm
R 10 119-3311-15 1/16W 330 ohm
R 11 119-1011-15 1/16W 100 ohm
R 12 119-1011-15 1/16W 100 ohm
R 13 119-2731-15 1/16W 27K ohm
R 14 119-3311-15 1/16W 330 ohm
R 15 119-1011-15 1/16W 100 ohm
R 16 119-1021-15 1/16W 1K ohm
S 1 013-6305-51 TACT SWITCH
S 2 013-6305-51 TACT SWITCH
S 3 013-6305-51 TACT SWITCH
S 4 013-6305-51 TACT SWITCH
S 5 013-6305-51 TACT SWITCH
S 6 013-6305-51 TACT SWITCH
S 7 013-6305-50 TACT SWITCH
S 8 013-6305-51 TACT SWITCH
S 9 013-6305-51 TACT SWITCH
S 10 013-6305-51 TACT SWITCH
S 11 013-6305-51 TACT SWITCH
S 12 013-6305-50 TACT SWITCH
S 13 013-6305-51 TACT SWITCH
S 14 013-6305-51 TACT SWITCH
S 15 013-6305-50 TACT SWITCH
S 16 013-6305-51 TACT SWITCH
S 17 013-6305-51 TACT SWITCH
VR 1 016-9900-90 VR W/SHAFT
Designator PART No. DESCRIPTION Designator PART No. DESCRIPTION
Main PWB (Switch) (B2)

- 18 -- 18 -
- 18 -- 18 -
- 18 - DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
Designator PART No. DESCRIPTION
R 19 119-1541-15 1/16W 150K ohm
R 20 119-1001-15 1/16W 10 ohm
R 22 119-4721-15 1/16W 4.7K ohm
R 23 119-1051-15 1/16W 1M ohm
R 24 119-1531-15 1/16W 15K ohm
R 25 119-2221-15 1/16W 2.2K ohm
R 27 119-1041-15 1/16W 100K ohm
R 28 119-1021-15 1/16W 1K ohm
R 29 119-1021-15 1/16W 1K ohm
R 31 119-4731-15 1/16W 47K ohm
R 33 119-5621-15 1/16W 5.6K ohm
R 34 119-9121-15 1/16W 9.1K ohm
R 36 119-1021-15 1/16W 1K ohm
R 37 119-1831-15 1/16W 18K ohm
R 41 119-2431-15 1/16W 24K ohm
R 43 119-1021-15 1/16W 1K ohm
R 47 119-2431-15 1/16W 24K ohm
R 48 119-4721-15 1/16W 4.7K ohm
R 51 119-1591-15 1/16W 1.5ohm
R 61 119-1591-15 1/16W 1.5ohm
R 71 119-0000-05 1/16W 0 ohm
R 72 119-0000-05 1/16W 0 ohm
R 73 119-1591-15 1/16W 1.5 ohm
R 74 119-1591-15 1/16W 1.5 ohm
R 75 119-4711-15 1/16W 470 ohm
R 110 119-2241-15 1/16W 220K ohm
R 111 119-1241-15 1/16W 120K ohm
R 112 119-5631-15 1/16W 56K ohm
R 113 119-0000-05 1/16W 0 ohm
R 114 119-3331-15 1/16W 33K ohm
R 115 119-1531-15 1/16W 15K ohm
R 116 119-1531-15 1/16W 15K ohm
R 117 119-2241-15 1/16W 220K ohm
R 118 119-2741-15 1/16W 270K ohm
R 119 119-1031-15 1/16W 10K ohm
R 120 119-6831-15 1/16W 68K ohm
R 121 119-1031-15 1/16W 10K ohm
R 122 119-1031-15 1/16W 10K ohm
R 123 119-1031-15 1/16W 10K ohm
R 124 119-2241-15 1/16W 220K ohm
R 125 119-2231-15 1/16W 22K ohm
R 126 119-2221-15 1/16W 2.2K ohm
R 127 119-1031-15 1/16W 10K ohm
R 210 119-1041-15 1/16W 100K ohm
R 211 119-2031-15 1/16W 20K ohm
R 212 119-8221-15 1/16W 8.2K ohm
R 213 119-2221-15 1/16W 2.2K ohm
R 410 119-4731-15 1/16W 47K ohm
R 411 119-4731-15 1/16W 47K ohm
R 413 119-7531-15 1/16W 75K ohm
R 414 119-7531-15 1/16W 75K ohm
R 415 119-4731-15 1/16W 47K ohm
R 417 119-4731-15 1/16W 47K ohm
R 418 119-1531-15 1/16W 15K ohm
R 419 119-2221-15 1/16W 2.2K ohm
R 432 119-0000-05 1/16W 0 ohm
C 11 168-1045-56 50V 0.1uF
C 12 168-1032-55 50V 0.01uF
C 13 168-1045-56 50V 0.1uF
C 14 166-3911-50 50V 390pF
C 15 168-1032-55 50V 0.1uF
C 16 168-1045-56 50V 0.1uF
C 17 168-1045-56 50V 0.1uF
C 19 168-2222-55 50V 2200pF
C 23 168-2222-55 50V 2200pF
C 24 168-1045-56 50V 0.1uF
C 28 168-1045-56 50V 0.1uF
C 29 168-1045-56 50V 0.1uF
C 31 168-1045-56 50V 0.1uF
C 32 168-1045-56 50V 0.1uF
C 41 166-2201-50 50V 22pF
C 42 166-2201-50 50V 22pF
C 43 168-4745-79 50V 0.47pF
C 51 168-1045-56 50V 0.1uF
C 52 168-1045-56 50V 0.1uF
C 53 168-1045-56 50V 0.1uF
C 54 168-1045-56 50V 0.1uF
C 55 166-3301-50 50V 33pF
C 56 166-3301-50 50V 33pF
C 57 168-1032-55 50V 0.01uF
C 58 168-1045-56 50V 0.1uF
C 59 168-8212-55 50V 820uF
C 61 168-1045-56 50V 0.1uF
C 62 168-1045-56 50V 0.1uF
C 63 168-1045-56 50V 0.1uF
C 64 168-1045-56 50V 0.1uF
C 71 168-2232-55 50V 0.022uF
C 73 168-1045-56 50V 0.1uF
C 74 168-1045-56 50V 0.1uF
C 75 168-1045-56 50V 0.1uF
C 76 168-1045-56 50V 0.1pF
C 110 166-3911-50 50V 390pF
C 111 168-6832-55 50V 0.068uF
C 112 168-1032-55 50V 0.01uF
C 113 168-1045-56 50V 0.1uF
C 114 168-1032-55 50V 0.01uF
C 115 168-1045-56 50V 0.1uF
C 116 168-1045-56 50V 0.1uF
C 117 168-1045-56 50V 0.1uF
C 118 168-1045-56 50V 0.1uF
C 119 166-8097-50 50V 8pF
C 120 168-1032-55 50V 0.01uF
C 121 168-1032-55 50V 0.01uF
C 122 168-1532-55 50V 0.01uF
C 123 168-1045-56 50V 0.1uF
C 124 168-4722-55 50V 4700pF
C 125 166-2096-50 50V 2pF
C 126 168-1032-55 50V 0.01uF
C 127 168-1022-55 50V 1000pF
C 128 168-1045-56 50V 0.1uF
C 129 168-1045-56 50V 0.1uF
C 130 168-1022-55 50V 1000pF
Designator PART No. DESCRIPTION
C 131 168-1045-56 50V 0.1uF
C 132 168-1045-56 50V 0.1uF
C 133 168-1045-56 50V 0.1uF
C 134 168-1032-55 50V 0.01uF
C 210 168-1032-55 50V 0.01uF
C 212 168-1045-56 50V 0.1uF
C 213 168-1045-56 50V 0.1uF
C 214 168-1045-56 50V 0.1uF
C 217 168-1522-55 50V 1500pF
C 218 168-1522-55 50V 1500pF
C 219 168-3332-78 50V 0.033uF
C 220 168-4745-79 50V 0.47uF
C 221 166-1011-50 50V 100pF
C 311 042-0652-53 10V 10uF
C 311 042-0652-53 10V 10uF
C 312 042-0652-53 10V 10uF
C 313 042-0652-53 10V 10uF
C 314 042-0652-53 10V 10uF
C 315 042-0423-94 10v 4.7uF
C 321 042-0652-53 10V 10uF
C 323 042-0652-53 10V 10uF
C 324 042-0652-53 10V 10uF
C 351 163-1073-35 16V 100uF
C 361 163-1073-35 16V 100uF
C 373 163-1073-35 16V 100uF
C 374 163-1073-35 16V 100uF
C 375 163-1073-35 16V 100uF
C 378 163-1073-35 16V 100uF
C 510 168-1045-56 50V 0.1uF
C 511 168-1022-55 50V 1000pF
C 710 168-1045-56 50V 0.1uF
IC 1 051-5712-00 S1L9226
IC 2 051-6397-00 S5L9290
IC 3 051-6067-08 IP4011
IC 4 052-3930-01 D78F9177AY
IC 5 051-6398-00 S5L9276
IC 6 051-9323-10 MSM51
V17405D-60
J 1 074-9015-66 OUTLET
SOCKET
J 2 076-0488-02 PLUG
J 3 076-0488-04 PLUG
J 4 076-0488-03 PLUG
J 6 074-9014-11 OUTLET
SOCKET
Q 1 125-3004-90 KTA1504GR
Q 2 125-4013-90 KTC4375
R 2 119-9121-15 1/16W 9.1K ohm
R 3 119-9121-15 1/16W 9.1K ohm
R 11 119-1841-15 1/16W 9.1K ohm
R 12 119-1841-15 1/16W 9.1K ohm
R 13 119-6831-15 1/16W 9.1K ohm
R 14 119-0000-05 1/16W 0 ohm
R 15 119-1001-15 1/16W 10 ohm
R 16 119-4731-15 1/16W 47K ohm
R 18 119-5131-15 1/16W 51K ohm
Note: Several different parts of the same reference number are alternative parts.
One of those parts is used in the set.
CD PWB (B3)
Designator PART No. DESCRIPTION

- 19 -- 19 -
- 19 -- 19 -
- 19 -
DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
R 433 119-0000-05 1/16W 0 ohm
SEL 2 119-2731-15 1/16W 27K ohm
SEL 3 119-4731-15 1/16W 47K ohm
SEL 4 119-3331-15 1/16W 33K ohm
X 2 061-9200-90 5MHz
X 3 061-9201-90 16.9344MHz
ZD 1 001-4307-00 2.0V
ZD 2 001-4308-00 3.6V
Designator PART No. DESCRIPTION
figure 1
No Part Number Part Name QTY
A 311-1848-00 LOWER CASE 1
B 039-2310-01 MAIN PWB 1
C 816-2628-60 FLAT WIRE 1
D 731-2604-81 TAPTIGHT 3
E 948-0668-00 MECHANISM 1
F 313-1878-00 HEAT SINK 1
G 731-3012-80 TAPTIGHT 2
H 714-3006-81 MACHINE SCREW 2
I 731-3008-80 TAPTIGHT 4
J 714-2012-81 MACHINE SCREW 1
K 370-6922-00 INNER ESC 1
REMOVING MAIN PWB FOR REPAIR
Step 1
Remove Lower Case (A) screw for Heat Sink, (F)
Step 2
Remove Lower Case, (A)
Step 3
Remove all screw fom Heat Sink
Step 4
Remove Heat Sink, (F)
Step 5
Remove Inner Escutcheon, (K)
Step 6
Unsolder 3 point on the main PWB, (B) figure 1
Step 7
After unsolder Main PWB remember to remove flat
wire (C) between main PWB (B), and Mechanism, (E)
Step 8
Remove Main PWB, (B)
Step 9
Unscrew the mechanism from the upper case, (D)

- 20 -- 20 -
- 20 -- 20 -
- 20 - DB538RMPDB538RMP
DB538RMPDB538RMP
DB538RMP
See from the BOTTOM SIDE