CNH FM-1000 User manual

Version 1.00
Revision D
September 2010
CABLING GUIDE
FM-1000™Integrated Display

2FM-1000 Integrated Display Cabling Guide
Contact Information
Trimble Navigation Limited
Trimble Agriculture Division
10355 Westmoor Drive
Suite #100
Westminster, CO 80021
USA
[e-mail]
Legal Notices
Copyright and Trademarks
©2009-2010, Trimble Navigation Limited. All rights reserved.
Trimble, the Globe and Triangle logo, AgGPS, EZ-Boom, EZ-Guide,
EZ-Steer, FM-1000, and Tru Count Air Clutch are trademarks of Trimble
Navigation Limited, registered in the United States and in other
countries. Autopilot, Field-IQ, FieldManager, Rawson, TrueGuide,
TrueTracker, and Tru Application Control are trademarks of Trimble
Navigation Limited. GreenSeeker is a registered trademark of NTech
Limited.
All other trademarks are the property of their respective owners.
This product is covered by the following United States Patent Numbers:
5,311,149, 5,369,589, 5,987,383, 6,252,863, 5,402,450, 5,493,588, and
6,463,374. Other patents pending.
Release Notice
This is the September 2010 release (Revision D) of the FM-1000
Integrated Display Cabling Guide. It applies to version 1.00 of the
FM-1000 integrated display firmware.
LIMITED WARRANTY TERMS AND CONDITIONS
Product Limited Warranty
Trimble Navigation Limited (“Trimble”) warrants that this product and
its internal components (the “Product”) shall be free from defects in
materials and workmanship and will substantially conform to Trimble’s
applicable published specifications for the Product for a period of two
(2) years, starting from the earlier of (i) the date of installation, or (ii) six
(6) months from the date of original Product shipment from Trimble.
Product Software
Product software, whether built into hardware circuitry as firmware,
provided as a standalone computer software product, embedded in flash
memory, or stored on magnetic or other media, is licensed solely for use
with or as an integral part of the Product and is not sold. If accompanied
by a separate end user license agreement (“EULA”), use of any such
software will be subject to the terms of such end user license agreement
(including any differing limited warranty terms, exclusions, and
limitations), which shall control over the terms and conditions set forth
in this limited warranty.
Software Fixes
During the limited warranty period you will be entitled to receive such
Fixes to the Product software that Trimble releases and makes
commercially available and for which it does not charge separately,
subject to the procedures for delivery to purchasers of Trimble products
generally. If you have purchased the Product from an authorized Trimble
dealer rather than from Trimble directly, Trimble may, at its option,
forward the software Fix to the Trimble dealer for final distribution to
you. Minor Updates, Major Upgrades, new products, or substantially
new software releases, as identified by Trimble, are expressly excluded
from this update process and limited warranty. Receipt of software Fixes
or other enhancements shall not serve to extend the limited warranty
period.
For purposes of this warranty the following definitions shall apply: (1)
“Fix(es)” means an error correction or other update created to fix a
previous software version that does not substantially conform to its
Trimble specifications; (2) “Minor Update” occurs when enhancements
are made to current features in a software program; and (3) “Major
Upgrade” occurs when significant new features are added to software, or
when a new product containing new features replaces the further
development of a current product line. Trimble reserves the right to
determine, in its sole discretion, what constitutes a Fix, Minor Update,
or Major Upgrade.
Warranty Remedies
If the Trimble Product fails during the warranty period for reasons
covered by this limited warranty and you notify Trimble of such failure
during the warranty period, Trimble will repair OR replace the
nonconforming Product with new, equivalent to new, or reconditioned
parts or Product, OR refund the Product purchase price paid by you, at
Trimble’s option, upon your return of the Product in accordance with
Trimble's product return procedures then in effect.
How to Obtain Warranty Service
To obtain warranty service for the Product, please contact your local
Trimble authorized dealer. Alternatively, you may contact Trimble to
request warranty service at [phone] (24 hours a day) or e-mail
your request to [e-mail]. Please be prepared to
provide:
– your name, address, and telephone numbers
– proof of purchase
– a copy of this Trimble warranty
– a description of the nonconforming Product including the model
number
– an explanation of the problem
The customer service representative may need additional information
from you depending on the nature of the problem.
Warranty Exclusions and Disclaimer
This Product limited warranty shall only apply in the event and to the
extent that (a) the Product is properly and correctly installed,
configured, interfaced, maintained, stored, and operated in accordance
with Trimble's applicable operator's manual and specifications, and; (b)
the Product is not modified or misused. This Product limited warranty
shall not apply to, and Trimble shall not be responsible for, defects or
performance problems resulting from (i) the combination or utilization
of the Product with hardware or software products, information, data,
systems, interfaces, or devices not made, supplied, or specified by
Trimble; (ii) the operation of the Product under any specification other
than, or in addition to, Trimble's standard specifications for its products;
(iii) the unauthorized installation, modification, or use of the Product;
(iv) damage caused by: accident, lightning or other electrical discharge,
fresh or salt water immersion or spray (outside of Product
specifications); or exposure to environmental conditions for which the
Product is not intended; (v) normal wear and tear on consumable parts
(e.g., batteries); or (vi) cosmetic damage. Trimble does not warrant or
guarantee the results obtained through the use of the Product, or that
software components will operate error free.
NOTICE REGARDING PRODUCTS EQUIPPED WITH TECHNOLOGY
CAPABLE OF TRACKING SATELLITE SIGNALS FROM SATELLITE BASED
AUGMENTATION SYSTEMS (SBAS) (WAAS/EGNOS, AND MSAS),
OMNISTAR, GPS, MODERNIZED GPS OR GLONASS SATELLITES, OR
FROM IALA BEACON SOURCES: TRIMBLE IS NOT RESPONSIBLE FOR
THE OPERATION OR FAILURE OF OPERATION OF ANY SATELLITE
BASED POSITIONING SYSTEM OR THE AVAILABILITY OF ANY
SATELLITE BASED POSITIONING SIGNALS.
THE FOREGOING LIMITED WARRANTY TERMS STATE TRIMBLE’SENTIRE
LIABILITY, AND YOUR EXCLUSIVE REMEDIES, RELATING TO THE TRIMBLE
PRODUCT. EXCEPT AS OTHERWISE EXPRESSLY PROVIDED HEREIN, THE
PRODUCT, AND ACCOMPANYING DOCUMENTATION AND MATERIALS
ARE PROVIDED “AS-IS” AND WITHOUT EXPRESS OR IMPLIED WARRANTY
OF ANY KIND, BY EITHER TRIMBLE OR ANYONE WHO HAS BEEN
INVOLVED IN ITS CREATION, PRODUCTION, INSTALLATION, OR
DISTRIBUTION, INCLUDING, BUT NOT LIMITED TO, THE IMPLIED
WARRANTIES OF MERCHANTABILITY AND FITNESS FOR APARTICULAR
PURPOSE, TITLE, AND NONINFRINGEMENT. THE STATED EXPRESS
WARRANTIES ARE IN LIEU OF ALL OBLIGATIONS OR LIABILITIES ON THE
PART OF TRIMBLE ARISING OUT OF, OR IN CONNECTION WITH, ANY
PRODUCT. BECAUSE SOME STATES AND JURISDICTIONS DO NOT ALLOW
LIMITATIONS ON DURATION OR THE EXCLUSION OF AN IMPLIED
WARRANTY, THE ABOVE LIMITATION MAY NOT APPLY OR FULLY APPLY
TO YOU.
Limitation of Liability
TRIMBLE'SENTIRE LIABILITY UNDER ANY PROVISION HEREIN SHALL BE
LIMITED TO THE AMOUNT PAID BY YOU FOR THE PRODUCT. TO THE
MAXIMUM EXTENT PERMITTED BY APPLICABLE LAW, IN NO EVENT
SHALL TRIMBLE OR ITS SUPPLIERS BE LIABLE FOR ANY INDIRECT,
SPECIAL, INCIDENTAL, OR CONSEQUENTIAL DAMAGE WHATSOEVER
UNDER ANY CIRCUMSTANCE OR LEGAL THEORY RELATING IN ANYWAY
TO THE PRODUCTS, SOFTWARE AND ACCOMPANYING DOCUMENTATION
AND MATERIALS, (INCLUDING, WITHOUT LIMITATION, DAMAGES FOR
LOSS OF BUSINESS PROFITS, BUSINESS INTERRUPTION, LOSS OF DATA, OR
ANY OTHER PECUNIARY LOSS), REGARDLESS OF WHETHER TRIMBLE HAS
BEEN ADVISED OF THE POSSIBILITY OF ANY SUCH LOSS AND REGARDLESS
OF THE COURSE OF DEALING WHICH DEVELOPS OR HAS DEVELOPED
BETWEEN YOU AND TRIMBLE. BECAUSE SOME STATES AND
JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR LIMITATION OF
LIABILITY FOR CONSEQUENTIAL OR INCIDENTAL DAMAGES, THE ABOVE
LIMITATION MAY NOT APPLY TO YOU.
PLEASE NOTE: THE ABOVE TRIMBLE LIMITED WARRANTY PROVISIONS
WILL NOT APPLY TO PRODUCTS PURCHASED IN THOSE
JURISDICTIONS (E.G., MEMBER STATES OF THE EUROPEAN ECONOMIC
AREA) IN WHICH PRODUCT WARRANTIES ARE THE RESPONSIBILITY
OF THE LOCAL TRIMBLE AUTHORIZED DEALER FROM WHOM THE
PRODUCTS ARE ACQUIRED. IN SUCH ACASE, PLEASE CONTACT YOUR
LOCAL TRIMBLE AUTHORIZED DEALER FOR APPLICABLE WARRANTY
INFORMATION.

FM-1000 Integrated Display Cabling Guide 3
Official Language
THE OFFICIAL LANGUAGE OF THESE TERMS AND CONDITIONS IS
ENGLISH. IN THE EVENT OF ACONFLICT BETWEEN ENGLISH AND OTHER
LANGUAGE VERSIONS, THE ENGLISH LANGUAGE SHALL CONTROL.
Registration
To receive information regarding updates and new products, please
contact your local dealer or visit the Trimble website at
www.trimble.com/register. Upon registration you may select the
newsletter, upgrade, or new product information you desire.
Notices
Federal Communications Commission (FCC) Statement
Note: This equipment has been tested and found to comply with the
limits for a Class A digital device, pursuant to Part 15 of the FCC Rules.
These limits are designed to provide reasonable protection against
harmful interference when the equipment is operated in a commercial
environment. This equipment generates, uses, and can radiate radio
frequency energy and, if not installed and used in accordance with the
instruction manual, may cause harmful interference to radio
communications. Operation of this equipment in a residential area is
likely to cause harmful interference, in which case the user will be
required to correct the interference at his own expense.
Properly shielded and grounded cables and connectors must be used in
order to meet FCC emission limits. TRIMBLE is not responsible for any
radio or television interference caused by using other than
recommended cables and connectors or by unauthorized changes or
modifications to this equipment. Unauthorized changes or
modifications could void the user's authority to operate the equipment.
This device complies with Part 15 of the FCC rules. Operation is subject
to the following two conditions: (1) this device may not cause harmful
interference, and (2) this device must accept any interference received,
including interference that may cause undesired operation.
Responsible Party:
Trimble Navigation
935 Stewart Drive
Sunnyvale CA 94085
Telephone: [phone]
Industry Canada Compliance Statement
This Class A digital apparatus meets the requirements of the Canadian
Interference-Causing Equipment Regulations.
Avis de conformité à la réglementation d'Industrie
Canada
Cet appareil numérique de la classe A respecte toutes les exigences du
Règlement sur le matériel brouilleur du Canada.
European Community Compliance Statement
This product is in conformity with the protection requirements of EU
Council Directive 89/336/EEC on the approximation of the laws of the
Member States relating to electromagnetic compatibility. TRIMBLE
cannot accept responsibility for any failure to satisfy the protection
requirements resulting from a non-recommended modification of the
product, including the fitting of non-TRIMBLE option cards.
Australia and New Zealand Class A Statement
Attention: This is a Class A product. In a domestic environment this
product may cause radio interference in which case the user may be
required to take adequate measures.
Notice to Our European Union Customers
For product recycling instructions and more information, please go to
www.trimble.com/ev.shtml.
Recycling in Europe: To recycle Trimble WEEE (Waste Electrical
and Electronic Equipment, products that run on electrical
power.), Call [phone], and ask for the "WEEE Associate".
Or, mail a request for recycling instructions to:
Trimble Europe BV
c/o Menlo Worldwide Logistics
Meerheide 45
5521 DZ Eersel, NL
Restriction of Use of Certain Hazardous Substances in
Electrical and Electronic Equipment (RoHS)
This Trimble product complies in all material respects with DIRECTIVE
2002/95/EC OF THE EUROPEAN PARLIAMENT AND OF THE
COUNCIL of 27 January 2003 on the restriction of the use of certain
hazardous substances in electrical and electronic equipment (RoHS
Directive) and Amendment 2005/618/EC filed under C(2005) 3143, with
exemptions for lead in solder pursuant to Paragraph 7 of the Annex to
the RoHS Directive applied.
Declaration of Conformity
We, Trimble Navigation Limited,
935 Stewart Drive
PO Box 3642
Sunnyvale, CA 94088-3642
United States
[phone]
declare under sole responsibility that the product:
FM-1000 complies with Part 15
of FCC Rules.
Operation is subject to the following two conditions:
(1) this device may not cause harmful interference, and
(2) this device must accept any interference received,
including interference that may cause undesired operation.

4FM-1000 Integrated Display Cabling Guide

FM-1000 Integrated Display Cabling Guide 5
Contents
1 Cable Configuration Guidelines . . . . . . . . . . . . . . . . . . . . . . . . . 9
Multiple cables on single ports. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Cable/port compatibility table. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Superseded cables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
2 Connecting the Display Only . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Standalone FM-1000 / WAAS / EGNOS / OmniSTAR XP/HP corrections. . . . . . . . . . . . . . 14
Standalone FM-1000 / RTK corrections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
3 Connecting to an Ag GPS EZ-Steer System . . . . . . . . . . . . . . . . . . 17
FM-1000 / EZ-Steer / WAAS / EGNOS corrections using the power bus . . . . . . . . . . . . . . 18
FM-1000 / EZ-Steer / WAAS / EGNOS corrections with external power leads. . . . . . . . . . . 19
4 Connecting to an Ag GPS Autopilot System . . . . . . . . . . . . . . . . . . 21
FM-1000 / Autopilot / WAAS /EGNOS corrections . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
FM-1000 / Autopilot / OmniSTAR XP or HP corrections . . . . . . . . . . . . . . . . . . . . . . . . 23
FM-1000 / Autopilot / RTK corrections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
FM-1000 with external switch / Autopilot / RTK corrections . . . . . . . . . . . . . . . . . . . . . 25
FM-1000 with ignition sensing / Autopilot / RTK corrections . . . . . . . . . . . . . . . . . . . . . 27
FM-1000 / Autopilot / TrueGuide or Implement Monitoring. . . . . . . . . . . . . . . . . . . . . . 28
FM-1000 / Autopilot / TrueGuide or Implement Monitoring
with an AgGPS 252/262 external receiver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
FM-1000 / Autopilot / TrueTracker / RTK corrections. . . . . . . . . . . . . . . . . . . . . . . . . . 32
FM-1000 / Autopilot / AgGPS 252/262 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
FM-1000 / Factory ready CNH vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
FM-1000 / Autopilot / Factory ready CNH vehicle / external receiver . . . . . . . . . . . . . . . . 37
FM-1000 / Autopilot / AGCO Wheeled Tractors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
5 Connecting the Field-IQ Crop Input Control System . . . . . . . . . . . . . 41
FM-1000 / Field-IQ cab kit / Powell hitch connector . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
FM-1000 / Field-IQ cab kit / Powell hitch connector / power relay . . . . . . . . . . . . . . . . . . 43
Field-IQ / Rawson Par 2 drives / Tru Count Air Clutch . . . . . . . . . . . . . . . . . . . . . . . . . 45
FM-1000 / Field-IQ cab kit / Rawson PAR 40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
FM-1000 / Autopilot / Field-IQ cab kit / Rawson PAR 40 / RTK Corrections . . . . . . . . . . . . 48
FM-1000 / Field-IQ Rate and Section control to Raven 4x0 or AgGPS EZ-Boom harness . . . . 50
FM-1000 / Field-IQ Section Control only to the Raven 4x0 . . . . . . . . . . . . . . . . . . . . . . . 51
FM-1000 / Field-IQ Section Control to Raven 4x00 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
FM-1000 / Field-IQ Rate and Section Control to Raven 4x00 . . . . . . . . . . . . . . . . . . . . . . 53
FM-1000 / Field-IQ Rate and Section Control for CaseIH SPX
(2009 and later) sprayers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
FM-1000 / Field-IQ Rate and Section Control to AGCO RoGator (2007 and later) . . . . . . . . 56
FM-1000 / Field-IQ cab kit / NH3 and liquid application full harness . . . . . . . . . . . . . . . . 57
FM-1000 / Autopilot / Field-IQ cab kit / Spreader. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59