Cooper VoCALL CFVCC5 User manual

V CALL - CFVCC5
C mpact 5 Line Exchange Unit
User Manual & L g B k

2
VoCALL Compact 5 Line Exchange Unit
Introduction
A VoCALL Emergency Voice Communications System (EVCS) is a fixe , secure, bi- irectional, full uplex
voice communication system to assist fire fighters in an emergency in high rise buil ings or large sites
where Ra io communication may not work, an covers the operation of both fire telephones an
isable refuge systems.
The VoCALL EVCS is esigne to fully comply with BS5839-Part 9 (abb. Pt9) for use as a fire telephone
system, isable refuge call system or as a combine system when both fire telephones an isable
refuge points are require .
Suitability
Fire telephone systems are recommen e for all public buil ings an multi story buil ings over four
floors by BS9999.
Disable refuge systems are require in buil ings where public or isable staff gain access to any floor
other than the groun floor using lifts.
Product Overview
A VoCALL EVCS compact 5 line exchange unit comprises of 2 functional blocks, the compact 5 line
exchange unit an outstations, (Type A, Type B, Jack Points an Emergency Assist Alarm), with the
quantities of these basic units being a juste to suit the application.
The VoCALL EVCS compact has been esigne on a star topology; in the most cases this will re uce
the cable requirements from all ring-base systems. The topology consists of spurs forme from 1 off
two core core 1mm CSA cables (soft skin enhance up to 500m per leg, MICC 200m per leg) to each
outstation.

VoCALL Compact 5 Line Exchange Unit
3
Important Safety Information
This equipment must only be installed and maintained by suitably skilled and competent person. This
equipment is defined as Class 1 in EN60065 (Low Voltage Directive) and must be EARTHED.
Each compact unit requires a 3A spur, returning to a breaker clearly marked EVCS DO NOT TURN OFF. If
the units are distributed around a site it is essential all units are on the same mains phase, as they are
classified TEN 230V, powering from different phases can mean a 440V potential can be present in a unit
during a major fault incident.
ANTI-STATIC HANDLING GUIDELINES
ake sure that electro-static handling precautions are taken immediately before handling PCBs and
other static sensitive components.
Before handling any static-sensitive items, operators should get rid of any electrostatic charge by
touching a sound safety earth, such as a radiator. Always handle PCBs by their sides and avoid touching
any components. PCBs should be stored in a clean, dry place that is free from vibration, dust and
excessive heat.
Storing the PCBs in a suitable cardboard box will also guard them against mechanical damage.
CA TION INDOOR USE ONLY
WARNING SHOCK HAZARD- ISOLATE BEFORE OPENING
WARNING TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK,
DO NOT EXPOSE THIS UNIT IN RAIN OR OISTURE
WARNING THIS UNIT UST BE EARTHED
WARNING NO USER SERVICABLE PARTS

4
VoCALL Compact 5 Line Exchange Unit
Batteries
The VoCALL compact requires one number 12V 4.5AH sealed lead acid batteries to provide backup
power in the event of mains failure as defined in BS5839pt9 for 24 hours standby and 3 hours operation
when powered by normal mains supply.
For 72hour standby and 1 hour operation one number 12V 17AH battery is required, this will need to be
fitted in an external battery enclosure, the monitored charger in the VoCALL compact is capable of
charging and monitoring these batteries.
Safety Information:
Sealed Lead acid batteries contain sulphuric acid which can cause burns if exposed to the skin,
the low internal resistance of these batteries means large currents will flow if they are accidentally
short circuited, causing burns and a risk of fire- exercise caution when handling batteries.
Power p Procedure:
Always apply mains power before connecting batteries, do not commission VoCALL Compact on
batteries, as the high inrush current required by the power supply may rupture the battery fuse.
Always connect the Positive (Red +) terminal first.
Power Down Procedure:
Disconnect the batteries before removing the mains power; always remove the negative
(Black – terminal) first.

VoCALL Compact 5 Line Exchange Unit
5
Operation
All conversations on the VoCALL compact system are under the command of the control handset,
Pt9 envisages the majority of calls to be made by lifting the handset of an outstation (Type A) or pressing
the call button (Type B).
Receiving a Call
Lift the receiver; press the zone key where the Green LED is flashing. When connected the Green
LED will go steady and the outstation will be connected to the handset.
To end hang-up receiver or press the zone key again to place the outstation on HOLD (the zone led
will flash slowly when held).
Making a Call
Lift the receiver; press the zone key for the required outstation, the Green LED on the zone key will
flash. When the outstation answers the call the Green zone LED will go steady and the handset will
connect to the called outstation.
To end the call, hang-up receiver or press the zone key again to place the outstation on HOLD (the zone
led will flash slowly when held).
Conference Call
Up-to five calls can be conference called, by answering the calls or dialling the calls as described above
the master handset must be involved in the call and only one conference group is allowed.
Accepting Faults
Note the fault in the log book, then press the mute buzzer key this will silence the “waterfall” tone, while
the fault exists the fault buzzer will “beep” once every 15 seconds until the fault is rectified. The buzzer
will resound on each new fault.
Panel Test
Press and hold the mute buzzer key for 5 seconds, the fault buzzer will sound and all status LEDs will
Light.

6
VoCALL Compact 5 Line Exchange Unit
Indications and Controls
Health Indicators (Green)
Healthy The system is ready for use and fault free.
AC Indicates healthy AC mains available.
DC Indicates the battery supply is available.
Fault Indicators (Yellow)
Zone Fault (Led on each zone key) steady indicated short circuit,
flashing indicated open circuit.
General Fault ( on the mute buzzer key) A fault exists on the system.
CPU Fault The processor, main phone or watchdog timer have tripped,
engineer assistance is required.
Supply Fault Either the AC supply or DC supply is unavailable, or a fuse has ruptured.
VoCALL
EVCS
Compact
5
Mute Buzzer
& Lamp Test
Fault
Supply
Manufactured to BS5839:pt9:2003
CPU
Supply
Making a Call:
Lift the receiver,press the Zone
key for the required phone, the
green LED will flash. When
answered the green LED will go
steady.
Toend Hang-up receiver or
press the Zone key again to
HOLD.
Receiving a Call:
Lift the receiver,press the Zone
key where the green LED is
flashing. When connected the
green LED will go steady.
Toend Hang-up receiver or
press the Zone key again to
HOLD.
Accepting Faults:
Press the Mute Buzzer key,
Buzzer will resound on each new
fault.
Panel Test:
Press and hold the Mute Buzzer
key,Buzzer will sound and all
LEDs Light
1
2
3
4
Co
EVCS
Vo
mpact
EVCS
CALLVo
1
2
3
4
5
Fault
estT& Lamp
Mute Buzzer
Supply
CPU
Supply
Making a Call:Receiving a Call: Making a Call: Accepting Faults:
.
HOLD
press the Z
o end Hang-up receiv
T
o end Hang-up receiv
.steady
answered the green LED will go
green LED will flash. When
ey for the required phone, thek
Lift the receiv
.
HOLD
ey again toone kpress the Z
er or
o end Hang-up receiv
T
o end Hang-up receiv
.green LED will go steady
flashing. When connected the
ey where the green LED isk
one
,press the Z
er
r
, press the Z
Lift the receiv
Manufactured to BS5839:pt9:2003
ey again toone kpress the Z
er oro end Hang-up receiv
answered the green LED will go
green LED will flash. When
ey for the required phone, the
one
,press the Z
er
r
,
Lift the receiv
LEDs Light
er will sound and all, Buzzeyk
erPress and hold the Mute Buzz
Panel Test:
fault.
er will resound on each newBuzz
,eyer kPress the Mute Buzz
Manufactured to BS5839:pt9:2003

VoCALL Compact 5 Line Exchange Unit
7
Maintenance
It is a requirement of BS5839pt9 that a maintenance agreement be in place for the EVCS, the
maintenance schedule should be as follows.
Weekly: Lift a different handset on the system each week and make a call to the control, repeat
each week until all points are tested, record results in the site log.
Monthly: Test one handset on each exchange by lifting the handset, followed by the master
calling the line, record results in the site log.
Quarterly: Engineer Call to check system operation.
Yearly: Engineer Call to check system operation and check battery health.
5 Yearly: Engineer Call to check system operation and replace the batteries.

8
VoCALL Compact 5 Line Exchange Unit
VoCALL Compact 5 Line Telephone & Disabled Refuge System - Log Book
Site Name:
Address:
Contractor:
Commissioned:

VoCALL Compact 5 Line Exchange Unit
9
Certificate of Commissioning for an Emergency Voice Communication System
(EVCS) to BS5839 pt 9 (2011)
System Design:
In accordance with section 1 of BS 5839 : Part 9 : 2011 sub clause 6 the system design is has in accordance
with the recommendations of this code except for the following:
Installation:
In accordance with section 3 of BS 5839 : Part 9 : 2011, the wiring has been inspected and tested and been
found to be in accordance with the recommendations of this code except for the following:
Commissioning:
In accordance with Section 4 of BS 5839 : Part 9 : 2011: sub clause 21.2C
1. Intelligible conversation is heard at all locations.
2. All controls and indicators operate correctly
The system is accepted in good working order and, in accordance with BS5839: Part 9, 2011, record drawings,
operating instructions and a system log book have been supplied and received.
Attention has been drawn to the recommendations concerning user's responsibilities, particularly those
concerned with routine attention and test procedures in section 5, and an appointed responsible person should
be nominated by the customer in accordance with the recommendations of Section 6 of BS5839 : Part 9 : 2011.
Site Name:
Address:
Customer
Address:
Areas Covered:
Engineer:
Date:
Position:
Signiture:

10
VoCALL Compact 5 Line Exchange Unit
Site Specific Information
Equipment Locations:
Compact Handset:
Outstation Locations
Cable ID Line Area Served
1
2
3
4
5