Crown TOC-2 User manual
MANUAL 10320 REV 1 (08/22)
$21.00
Direct Steam Table Mounted Jacketed
“Oyster Cooker”
MANUAL SECTION CO
IMPORTANT FOR FUTURE REFERENCE
Please complete this information and retain this
manual for the life of the equipment:
Model #:
___________________________
Serial #:
___________________________
Date Purchased:
_____________________
WARNING
Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury
or death. Read the installation, operating and maintenance instructions thoroughly before installing or
servicing this equipment.
Installation & Operation Manual
Model TOC-2
CROWN FOOD SERVICE EQUIPMENT
A Middleby Company
70 Oakdale Road, Downsview (Toronto) Ontario, Canada, M3N 1V9
Telephone: 919-762-1000 www.crownsteamgroup.com
Direct Steam Table Mounted Jacketed
“Oyster Cooker”
TOC-2
PAGE 2 OF 8 INSTALLATION & OPERATION MANUAL 10320 REV 1 (08/22)
SAFETY PRECAUTIONS
Before installing and operating this equipment, be sure everyone involved in its operation is fully trained and aware of
precautions. Accidents and problems can be caused by failure to follow fundamental rules and precautions.
The following symbols, found throughout this manual, alert you to potentially dangerous conditions to the operator,
service personnel, or to the equipment.
CAUTION
WARNING
NOTICE
This symbol warns of immediate hazards that will result in severe injury or death.
This symbol refers to a potential hazard or unsafe practice that could result in injury or death.
This symbol refers to a potential hazard or unsafe practice that could result in injury, product
damage, or property damage.
This symbol refers to information that needs special attention or must be fully
understood, even though not dangerous.
DANGER
WARNING
Improper installation, operation, adjustment, alteration, service or maintenance can cause property damage, injury
or death. Read the installation, operating and maintenance instructions thoroughly before installing, operating or
servicing this equipment.
NOTICE
This manual should be retained for future reference.
NOTICE
IMPORTANT NOTES FOR INSTALLATION AND OPERATION
WARNING
This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages
that follow this symbol to avoid possible injury or death.
CAUTION
PAGE 3 OF 8
INSTALLATION & OPERATION MANUAL 10320 REV 1 (08/22)
Table of Contents
Important Notes For Installation and Operation.................................................................... 2
............................................................................................................. 4
Introduction ......................................................................................................................... 5
Installation Instructions ......................................................................................................... 5
Operation .............................................................................................................................. 6
Cleaning ............................................................................................................................... 6
Preventive Maintenance ..................................................................................................... 7
TC
PAGE 4 OF 8 INSTALLATION & OPERATION MANUAL 10320 REV 1 (08/22)
DIMENSIONS
SERVICE CONNECTIONS
SI
ABCDEFG
TOC-2 2-Quart
(1.9 liters)
inches
(mm)
(254)
17.88
(454)
(216)
(308)
(67)
(60)
(314)
PAGE 5 OF 8
INSTALLATION & OPERATION MANUAL 10320 REV 1 (08/22)
IMMEDIATELY INSPECT FOR SHIPPING DAMAGE
Immediately after unpacking, check for possible shipping damage. If the appliance is found to be damaged, save the
packaging material and contact the carrier within 15 days of delivery.
We cannot assume responsibility for damage or loss incurred in transit.
I
1. This appliance must be installed on a suitable table or counter top.
appliance.
valve will handle a series of appliances.
working pressure.
eliminate the water.
9. A steam line pressure gauge is also recommended to determine the actual amount of steam coming to the appliance.
10. Install a suitable steam trap in condensate line (left leg) near the appliance and run condensate return line to drain. If
the appliance.
PAGE 6 OF 8 INSTALLATION & OPERATION MANUAL 10320 REV 1 (08/22)
OPERATION
WARNING
3. The water or food should boil 2 - 3 minutes. If it does not, then incoming pressure should be checked to determine
4. Regulate steam control valve depending on type of food being prepared.
cooker bowl surface.
Use of cleaning agents that contain chloride, acids or salts are corrosive and may cause pitting and corrosion when used
over a period of time; this will reduce the life of the appliances.
Follow the recommended cleaning instructions. Use a mild detergent, warm water and rinse thoroughly.
WARNING
Do not use cleaning agents that are corrosive.
1. Ensure that steam supply is OFF.
2. Pre-rinse inside cooker thoroughly and tilt to remove any food particles.
3. Using a nylon brush, clean kettle with a mild detergent and warm water rinse. Never use steel wool or scouring
powder as it will scratch stainless steel.
4. Tilt cooker and rinse thoroughly draining out detergent solution.
PAGE 7 OF 8
INSTALLATION & OPERATION MANUAL 10320 REV 1 (08/22)
No preventive maintenance is required other than adhering to the Cleaning Procedure instructions.
CAUTION
CAUTION
taken to avoid any bodily contact.
CAUTION
two seconds to flush the valve seat free of sediment and debris. Then release lever and permit the valve
to snap shut.
If lift lever does not activate, or there is no evidence of discharge, turn off equipment immediately and
contact a licensed contractor or qualified service personnel.
PAGE 8 OF 8 INSTALLATION & OPERATION MANUAL 10320 REV 1 (08/22)
TOC-2
A product with the Crown name incorporates the best in durability and low maintenance. We all recognize, however,
to the model number, serial number, and type of your appliance.
CROWN FOOD SERVICE EQUIPMENT
A Middleby Company
70 Oakdale Road, Downsview (Toronto) Ontario, Canada, M3N 1V9
Telephone: 919-762-1000 www.crownsteamgroup.com
Table of contents
Other Crown Cooker manuals
Popular Cooker manuals by other brands
Campomatic
Campomatic 90X60 user manual
Indesit
Indesit KN6E52/EX Additional information for the installation and use
La Cornue
La Cornue Chateau series Instructions for use
Smeg
Smeg CS122-6 instruction manual
STOVES
STOVES Newhome SI550DOm User & installation instructions
Ariston
Ariston CP 08S P6 DK Instructions for use and installation
